Safety Data Sheet (#52) acc. to OSHA HCS

Transcription

1 (#52) Page 1/7 1 Identification Product identifier Trade name: ST AIA-PACK PROG II: Relevant identified uses of the substance or mixture and uses advised against No further relevant information available. Application of the substance / the mixture In Vitro Diagnostics. Details of the supplier of the safety data sheet Manufacturer / Supplier: TOSOH CORPORATION TOSOH BIOSCIENCE, INC Shiba, Minato-ku 6000 Shoreline Ct.; Suite 101 Tokyo South San Francisco, CA94080 JAPAN Tel. : Phone : or (800) Fax : Fax : or (800) Information department: QA-RA: susan.koss@tosoh.com Emergency telephone number: Poison Control Center: Hazard(s) identification Classification of the substance or mixture The product is not classified according to the Globally Harmonized System (GHS). Classification according to Directive 67/548/EEC or Directive 1999/45/EC Harmful Harmful if swallowed. Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment. Information concerning particular hazards for human and environment: The product has to be labeled due to the calculation procedure of international guidelines. Classification system: The classification was made according to the latest editions of international substances lists, and expanded upon from company and literature data. Label elements GHS label elements Void Hazard pictograms Void Signal word Void Hazard statements Void Classification system: NFPA ratings (scale 0-4) Health = 0 Fire = 0 Reactivity = 0 HMIS-ratings (scale 0-4) HEALTH FIRE REACTIVITY Health = 1 Fire = 0 Reactivity = 0 Other hazards Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. 3 Composition/information on ingredients Chemical characterization: Mixtures Description: Mixture of the substances listed below with nonhazardous additions. (Contd. on page 2)

2 Page 2/7 (Contd. of page 1) Dangerous components: sucrose, pure 10-25% sodium salicylate % 2.5% zinc chloride 2.5% 4 First-aid measures Description of first aid measures General information: Symptoms of poisoning may even occur after several hours; therefore medical observation for at least 48 hours after the accident. After inhalation: Supply fresh air; consult doctor in case of complaints. After skin contact: Generally the product does not irritate the skin. After eye contact: Rinse opened eye for several minutes under running water. After swallowing: Immediately call a doctor. Most important symptoms and effects, both acute and delayed No further relevant information available. Indication of any immediate medical attention and special treatment needed No further relevant information available. 5 Fire-fighting measures Extinguishing media Suitable extinguishing agents: CO2, extinguishing powder or water spray. Fight larger fires with water spray or alcohol resistant foam. Special hazards arising from the substance or mixture No further relevant information available. Advice for firefighters Protective equipment: No special measures required. 6 Accidental release measures Personal precautions, protective equipment and emergency procedures Not required. Environmental precautions: Do not allow product to reach sewage system or any water course. Inform respective authorities in case of seepage into water course or sewage system. Do not allow to enter sewers/ surface or ground water. Methods and material for containment and cleaning up: Dispose contaminated material as waste according to item 13. Reference to other sections See Section 7 for information on safe handling. See Section 8 for information on personal protection equipment. See Section 13 for disposal information. 7 Handling and storage Precautions for safe handling Store in cool, dry place in tightly closed receptacles. No special precautions are necessary if used correctly. Information about protection against explosions and fires: No special measures required. Conditions for safe storage, including any incompatibilities Storage: Requirements to be met by storerooms and receptacles: No special requirements. Information about storage in one common storage facility: Not required. Further information about storage conditions: None. (Contd. on page 3)

3 Page 3/7 Specific end use(s) No further relevant information available. (Contd. of page 2) 8 Exposure controls/personal protection Additional information about design of technical systems: No further data; see item 7. Control parameters Components with limit values that require monitoring at the workplace: sucrose, pure PEL Long-term value: 15* 5** mg/m³ *total dust **respirable fraction REL Long-term value: 10* 5** mg/m³ *total dust **respirable fraction TLV Long-term value: 10 mg/m³ REL Ceiling limit value: 0.3** mg/m³, 0.1* ppm *as HN3; **as NaN3; Skin TLV Ceiling limit value: 0.29** mg/m³, 0.11* ppm *as HN3 vapor **as NaN3 Additional information: The lists that were valid during the creation were used as basis. Exposure controls Personal protective equipment: General protective and hygienic measures: Keep away from foodstuffs, beverages and feed. Wash hands before breaks and at the end of work. Breathing equipment: Not required. Protection of hands: The glove material has to be impermeable and resistant to the product/ the substance/ the preparation. Due to missing tests no recommendation to the glove material can be given for the product/ the preparation/ the chemical mixture. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation Material of gloves The selection of the suitable gloves does not only depend on the material, but also on further marks of quality and varies from manufacturer to manufacturer. As the product is a preparation of several substances, the resistance of the glove material can not be calculated in advance and has therefore to be checked prior to the application. Penetration time of glove material The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed. Eye protection: Not required. 9 Physical and chemical properties Information on basic physical and chemical properties General Information Appearance: Form: Spray dried powder Color: Light beige Odor: Odorless Odour threshold: Not determined. ph-value: Not applicable. Change in condition Melting point/melting range: Boiling point/boiling range: Undetermined. Undetermined. Flash point: Not applicable. Flammability (solid, gaseous): Not determined. (Contd. on page 4)

4 Page 4/7 Ignition temperature: Decomposition temperature: Not determined. Auto igniting: Product is not selfigniting. (Contd. of page 3) Danger of explosion: Product does not present an explosion hazard. Explosion limits: Lower: Upper: Not determined. Not determined. Vapor pressure: Not applicable. Density: Not determined. Relative density Not determined. Vapour density Not applicable. Evaporation rate Not applicable. Solubility in / Miscibility with Water: Soluble. Partition coefficient (n-octanol/water): Not determined. Viscosity: Dynamic: Kinematic: Solvent content: Organic solvents: 0.0 % Not applicable. Not applicable. Solids content: % Other information No further relevant information available. 10 Stability and reactivity Reactivity Chemical stability Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications. Possibility of hazardous reactions No dangerous reactions known. Conditions to avoid No further relevant information available. Incompatible materials: No further relevant information available. Hazardous decomposition products: No dangerous decomposition products known. 11 Toxicological information Information on toxicological effects Acute toxicity: LD/LC50 values that are relevant for classification: Oral LD50 27 mg/kg (rat) Dermal LD50 20 mg/kg (rabbit) zinc chloride Oral LD mg/kg (rat) Primary irritant effect: on the skin: No irritant effect. on the eye: No irritating effect. Sensitization: No sensitizing effects known. Additional toxicological information: The product shows the following dangers according to internally approved calculation methods for preparations: Harmful (Contd. on page 5)

5 Page 5/7 Carcinogenic categories IARC (International Agency for Research on Cancer) NTP (National Toxicology Program) OSHA-Ca (Occupational Safety & Health Administration) (Contd. of page 4) 12 Ecological information Toxicity Aquatic toxicity: No further relevant information available. Persistence and degradability No further relevant information available. Bioaccumulative potential No further relevant information available. Mobility in soil No further relevant information available. Ecotoxical effects: Remark: Harmful to fish Additional ecological information: General notes: Water hazard class 2 (Self-assessment): hazardous for water Do not allow product to reach ground water, water course or sewage system. Danger to drinking water if even small quantities leak into the ground. Harmful to aquatic organisms Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. Other adverse effects No further relevant information available. 13 Disposal considerations Waste treatment methods Recommendation: Must not be disposed of together with household garbage. Do not allow product to reach sewage system. Uncleaned packagings: Recommendation: Disposal must be made according to official regulations. Recommended cleansing agent: Water, if necessary with cleansing agents. 14 Transport information UN-Number DOT, ADR, ADN, IMDG, IATA Void UN proper shipping name DOT, ADR, ADN, IMDG, IATA Void Transport hazard class(es) DOT, ADR, ADN, IMDG, IATA Class Void Packing group DOT, ADR, IMDG, IATA Void Environmental hazards: Marine pollutant: No (Contd. on page 6)

6 Page 6/7 Special precautions for user Not applicable. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Not applicable. UN "Model Regulation": - (Contd. of page 5) 15 Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture Sara Section 355 (extremely hazardous substances): Section 313 (Specific toxic chemical listings): zinc chloride TSCA (Toxic Substances Control Act): All ingredients are listed. Proposition 65 Chemicals known to cause cancer: Chemicals known to cause reproductive toxicity for females: Chemicals known to cause reproductive toxicity for males: Chemicals known to cause developmental toxicity: Carcinogenic categories EPA (Environmental Protection Agency) zinc chloride D, I, II TLV (Threshold Limit Value established by ACGIH) sucrose, pure A4 A4 NIOSH-Ca (National Institute for Occupational Safety and Health) GHS label elements Void Hazard pictograms Void Signal word Void Hazard statements Void Chemical safety assessment: A Chemical Safety Assessment has not been carried out. 16 Other information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. The information contained herein is prepared based on the available information to Tosoh that is believed to be reliable: however the information is provided by Tosoh WITHOUT ANY REPRESENTATION OR WARRANTY, EXPRESSED OR IMPLIED, AS TO ITS COMPLETENESS, COMPREHENSIVENESS AND ACCURACY. Since the conditions of handling, storage and disposal of this material are beyond our control, it is the responsibility of the user to determine whether the material is fit for a particular purpose and/or suitable for the user s method of use or application, and to determine safe conditions for use of the material, and to assume full responsibility for loss, injury and expense arising out of or in connection with the use of material. NO REPRESENTATION OR WARRANTY, EXPRESS OR IMPLIED, REGARDING THE MATERIAL DESCRIBED HEREIN SHALL BE CREATED BY OR INFERRED FROM ANY STATEMENT OR OMISSION FROM THIS SDS. (Contd. on page 7)

7 Page 7/7 (Contd. of page 6) Various government agencies and local authorities may have general or specific regulations applicable to the material which may not be covered in this SDS. It is sole responsibility of the user to examine and confirm for its full compliance with any such regulations. When the revision of this SDS is received, please dispose of the old one. Date of preparation / last revision 02/05/2015 / - Abbreviations and acronyms: ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) IMDG: International Maritime Code for Dangerous Goods DOT: US Department of Transportation IATA: International Air Transport Association ACGIH: American Conference of Governmental Industrial Hygienists EINECS: European Inventory of Existing Commercial Chemical Substances ELINCS: European List of Notified Chemical Substances CAS: Chemical Abstracts Service (division of the American Chemical Society) NFPA: National Fire Protection Association () HMIS: Hazardous Materials Identification System () LC50: Lethal concentration, 50 percent LD50: Lethal dose, 50 percent