SAFETY DATA SHEET Universalskiva 1201

Transcription

1 Universalskiva 1201 Page 1 of 7 SAFETY DATA SHEET Universalskiva 1201 SDS according to Regulation (EC) No. 1907/2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH), Annex II-EU SECTION 1: Identification of the substance / mixture and of the company / undertaking Date issued Revision date Product identifier Product name Universalskiva Relevant identified uses of the substance or mixture and uses advised against Use of the substance / preparation Fibreboard for fire seal 1.3. Details of the supplier of the safety data sheet Manufacturer Company name ESSVE Produkter AB Office address Esbogatan 14 Postal address P.O. Box 7091 Postcode Kista City Sollentuna Country Sweden Telephone number Fax Website Contact person Dick Johansson (dick.johansson@essve.se) 1.4. Emergency telephone number Emergency telephone Telephone number: 112 Description: Dial for acute emergency SECTION 2: Hazards identification Telephone number: +46 (0) Description: Swedish Poisons Information Centre 2.1. Classification of substance or mixture

2 Universalskiva 1201 Page 2 of 7 Substance / mixture hazardous properties Not regarded as a health or environmental hazard under current legislation Label elements S-phrases Composition on the label Not classified. Risk phrases shall not be stated. Mineral wool, with the exception of those specified elsewhere in this Annex %, Dust, thermoset < 4 %, Oil (dust binder) < 0,50 % 2.3. Other hazards Health effect May cause temporary irritation on skin or eye contact. May cause respiratory irritation. SECTION 3: Composition / information on ingredients 3.2. Mixtures Substance Identification Classification Contents Mineral wool, with the exception of those specified elsewhere in this Annex Index No.: Cancer 3; R40 Carc. 2; H351 Note : A; Q; R % Bakelite < 4 % Oil (dust binder) < 0,50 % Description of the mixture Substance comments SECTION 4: First aid measures 4.1. Description of first aid measures Mineral wool board painted with fireproof paint Universal KS1. The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16. Mineral wool is classified as carcinogenic, category 3, according to the CLP (EG nr 1272/2008). If the fibre complies with one out of four conditions according to note Q in CLP, the fibre will not be classified as carcinogenic. The product contains a mineral wool which fulfils the criteria concerning biological solubility and is because of that not classified as carcinogenic, tested according to an EU record ECB/TM 26:27 rev Inhalation Skin contact Eye contact Ingestion Move the exposed person to fresh air at once. Get medical attention if any discomfort continues. Rinse the skin immediately with lots of water. Wash the skin immediately with soap and water. Do not rub eye. Rinse the eye with water immediately. Get medical attention if any discomfort continues. Rinse mouth thoroughly. Immediately rinse mouth and drink plenty of water ( ml) Most important symptoms and effects, both acute and delayed Information for health personnel Treat Symptomatically Indication of any immediate medical attention and special treatment needed Information on clinical testing No information required. SECTION 5: Firefighting measures 5.1. Extinguishing media

3 Universalskiva 1201 Page 3 of 7 Suitable extinguishing media The product is non-combustible Special hazards arising from the substance or mixture Fire and explosion hazards The product is non-combustible Advice for firefighters Fire fighting procedures SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures General measures Avoid dust formation Environmental precautions Environmental precautionary measures Avoid spreading dust or contaminated materials Methods and material for containment and cleaning up Cleaning method Use a vacuum cleaner. If not possible, moisten dust with water before it is collected with shovel, broom or the like Reference to other sections Other instructions See section 7, 8 and 13. SECTION 7: Handling and storage 7.1. Precautions for safe handling Handling Avoid generating excess dust. Avoid spread of dust. Use mechanical ventilation in case of handling which causes formation of dust Conditions for safe storage, including any incompatibilities Storage Store in a dry place. Store in tightly closed original container Specific end use(s) Specific use(s) The identified uses for this product are detailed in Section 1.2. SECTION 8: Exposure controls / personal protection 8.1. Control parameters Substance Identification Value TWA Year Mineral wool, with the exception of those specified elsewhere in this Annex Bakelite 8.2. Exposure controls Index No.: TWA (8h): 1 fiber/cm3 TWA Year: 2005 TWA (8h): 3 mg/m3 Source: Total dust TWA Year: 1978

4 Universalskiva 1201 Page 4 of 7 Limitation of exposure on workplace Safety signs Well-ventilated area. Provide eyewash, quick drench. Respiratory protection Respiratory protection Use respiratory equipment with combination filter, type A2/P2. Hand protection Hand protection Use protective gloves. Eye / face protection Eye protection Wear dust resistant safety goggles where there is danger of eye contact. Skin protection Skin protection (except hands) Anti-static suit. Hygiene / environmental Specific hygiene measures Provide shower facilities near the work place. Remove contaminated clothing and wash the skin thoroughly with soap and water after work. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state Solid. Colour Grey. Greenish. Odour Odourless. Melting point / melting range Value: > 1000 C Flash point Value: > 1000 C Specific gravity Solubility description Value: 300 kg/m3 Insoluble in water Other information Other physical and chemical properties Physical and chemical properties No information required. SECTION 10: Stability and reactivity Reactivity Reactivity There are no known conditions that are likely to result in a hazardous situation Chemical stability

5 Universalskiva 1201 Page 5 of 7 Stability Stable under normal temperature conditions and recommended use Possibility of hazardous reactions Possibility of hazardous reactions Conditions to avoid Conditions to avoid Toxic gases are generated when heated. (>200 C) Incompatible materials Materials to avoid Not known Hazardous decomposition products Hazardous decomposition products Carbon monoxide (CO). Carbon dioxide (CO2). Nitrogen compounds. SECTION 11: Toxicological information Information on toxicological effects Potential acute effects Inhalation Skin contact Eye contact Ingestion Dust may irritate respiratory system. May cause irritation. May irritate and cause redness and pain. May cause irritation to the mouth and throat. SECTION 12: Ecological information Toxicity Ecotoxicity There are no data on the ecotoxicity of this product Persistence and degradability Bioaccumulative potential Bioaccumulative potential Bioaccumulation: Is not expected to be bioaccumulable Mobility in soil Mobility Not regarded as dangerous for the environment Results of PBT and vpvb assessment PBT assessment results This substance is not classified as PBT or vpvb Other adverse effects Environmental details, summation No information required. SECTION 13: Disposal considerations

6 Universalskiva 1201 Page 6 of Waste treatment methods Product classified as hazardous waste No EWC waste code EWC: insulation materials other than those mentioned in and SECTION 14: Transport information UN number UN proper shipping name Transport hazard class(es) Packing group Environmental hazards Special precautions for user Special safety precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Additional information Additional information The product is not covered by international regulation on the transport of dangerous goods (IMDG, IATA, ADR/RID). SECTION 15: Regulatory information Safety, health and environmental regulations / legislation specific for the substance or mixture Legislation and regulations Regulation (EC) No 1907/2006 of the European Parliament and of the Council of 18 December 2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH), establishing a European Chemicals Agency, amending Directive 1999/45/EC and repealing Council Regulation (EEC) No 793/93 and Commission Regulation (EC) No 1488/94 as well as Council Directive 76/769/EEC and Commission Directives 91/155/EEC, 93/67/EEC, 93/105/EC and 2000/21/EC, including amendments Chemical safety assessment Chemical safety assessment performed No

7 Universalskiva 1201 Page 7 of 7 SECTION 16: Other information List of relevant R-phrases (under headings 2 and 3). List of relevant H-phrases (Section 2 and 3) Key literature references and sources for data Information added, deleted or revised R40 Limited evidence of a carcinogenic effect. H351 Suspected of causing cancer MSDS supplied by the manufacturer Change to Sections: 13.