Safety Data Sheet acc. to OSHA HCS

Transcription

1 Page 1/7 * 1 Identification Product identifier Relevant identified uses of the substance or mixture and uses advised against No further relevant information available. Application of the substance / the mixture Corrosion inhibitors Details of the supplier of the safety data sheet Manufacturer/Supplier: Cortec Corporation 4119 White Bear Parkway St. Paul, MN Phone (651) Fax (651) Information department: Product safety department. info@cortecvci.com Emergency telephone number: Spill, Leak, Fire, Exposure, or Accident 24 hour CHEMTREC contact: and Canada International (collect calls accepted) * 2 Hazard(s) identification Classification of the substance or mixture The product is not classified according to the Globally Harmonized System (GHS). Classification according to Directive 67/548/EEC or Directive 1999/45/EC Void Information concerning particular hazards for human and environment: Harmful if swallowed. Label elements GHS label elements Void Hazard pictograms Void Signal word Void Hazard statements Void Classification system NFPA ratings (scale 0-4) Health = 1 Fire = 1 Reactivity = 0 HMIS rating system (0-4) HEALTH FIRE REACTIVITY Health = 1 Flammability = 1 Reactivity = 0 Other hazards Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. (Contd. on page 2)

2 Page 2/7 (Contd. of page 1) * 3 Composition/information on ingredients Chemical characterization: Mixtures Description: Mixture of the substances listed below with nonhazardous additions. Dangerous components: Void Additional information This product contains mineral oil CAS no , which meets EU requirement of less than 3%(w/w) DMSO extract for total polycyclic aromatic compound (PAC) using IP346. For the wording of the listed risk phrases refer to section 16. * 4 First-aid measures Description of first aid measures General information No special measures required. After inhalation Supply fresh air; consult doctor in case of complaints. After skin contact Immediately wash with water and soap and rinse thoroughly. After eye contact Rinse opened eye for several minutes under running water. After swallowing If symptoms persist consult doctor. Most important symptoms and effects, both acute and delayed No further relevant information available. Indication of any immediate medical attention and special treatment needed No further relevant information available. * 5 Fire-fighting measures Extinguishing media Suitable extinguishing agents Use fire fighting measures that suit the environment. Special hazards arising from the substance or mixture In certain fire conditions, traces of other toxic gases cannot be excluded. In case of fire, the following can be released: Sulphur dioxide (SO2) Nitrogen oxides (NOx) Carbon monoxide (CO) Advice for firefighters Protective equipment: Wear self-contained respiratory protective device. * 6 Accidental release measures Personal precautions, protective equipment and emergency procedures Not required. Environmental precautions: Do not allow product to reach sewage system or any water course. Methods and material for containment and cleaning up: Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust). Reference to other sections See Section 7 for information on safe handling See Section 8 for information on personal protection equipment. See Section 13 for disposal information. * 7 Handling and storage Precautions for safe handling Keep receptacles tightly sealed. (Contd. on page 3)

3 Page 3/7 Information about protection against explosions and fires: No special measures required. Conditions for safe storage, including any incompatibilities Storage Requirements to be met by storerooms and receptacles: Use only receptacles specifically permitted for this substance/product. Information about storage in one common storage facility: Store away from foodstuffs. Further information about storage conditions: None. Specific end use(s) No further relevant information available. (Contd. of page 2) * 8 Exposure controls/personal protection Additional information about design of technical systems: No further data; see item 7. Control parameters Components with limit values that require monitoring at the workplace: calcium carbonate ( 2.5%) PEL Long-term value: 15* 5** mg/m³ *total dust **respirable fraction REL Long-term value: 10* 5** mg/m³ *total dust **respirable fraction TLV TLV withdrawn Additional information: The lists that were valid during the creation were used as basis. Exposure controls Personal protective equipment General protective and hygienic measures The usual precautionary measures for handling chemicals should be followed. Breathing equipment: Not required. Protection of hands: Protective gloves The glove material has to be impermeable and resistant to the product/ the substance/ the preparation. Selection of the glove material on consideration of the penetration times, rates of diffusion and the degradation Penetration time of glove material The exact break through time has to be found out by the manufacturer of the protective gloves and has to be observed. Eye protection: Goggles recommended during refilling. Body protection: Protective work clothing. * 9 Physical and chemical properties Information on basic physical and chemical properties General Information Appearance: Form: Liquid Color: Beige Odor: Characteristic Odour threshold: Not determined. ph-value: Not determined. (Contd. on page 4)

4 Page 4/7 Change in condition Melting point/melting range: Boiling point/boiling range: undetermined undetermined Flash point: 146 C (295 F) Flammability (solid, gaseous) Not applicable. Ignition temperature: 315 C (599 F) Decomposition temperature: Not determined. Auto igniting: Product is not selfigniting. Danger of explosion: Product does not present an explosion hazard. Explosion limits: Lower: Upper: Not determined. Not determined. Vapor pressure: Not determined. Density at 20 C (68 F): g/cm³ ( lbs/gal) Relative density Not determined. Vapour density Not determined. Evaporation rate Not determined. Solubility in / Miscibility with Water: Not miscible or difficult to mix Partition coefficient (n-octanol/water): Not determined. Viscosity: dynamic: Not determined. kinematic at 40 C (104 F): cst (ASTM D ) Solvent content: Organic solvents: 0.0 % (Contd. of page 3) Solids content: % Other information The above data are typical values and do not constitute a specification. * 10 Stability and reactivity Reactivity Not reactive Chemical stability This product is stable and not subject to hazardous polymerization Thermal decomposition / conditions to be avoided: No decomposition if used according to specifications. Possibility of hazardous reactions No dangerous reactions known Conditions to avoid Strong acid Incompatible materials: Strong acid Hazardous decomposition products: Carbon monoxide and carbon dioxide Calcium oxide Sulfur oxides (SOx) (Contd. on page 5)

5 Page 5/7 (Contd. of page 4) * 11 Toxicological information Information on toxicological effects Acute toxicity: Primary irritant effect: on the skin: Repeated or prolonged skin contact with this product may produce skin irritation. on the eye: May be irritating. Sensitization: No sensitizing effects known. Additional toxicological information: Carcinogenic categories IARC (International Agency for Research on Cancer) NTP (National Toxicology Program) OSHA-Ca (Occupational Safety & Health Administration) * 12 Ecological information Toxicity Aquatic toxicity: (similar products) 96 h Fathead Minnow, LC50 30,000 mg/l Persistence and degradability A part of the components is biodegradable. Bioaccumulative potential No further relevant information available. Mobility in soil No further relevant information available. Results of PBT and vpvb assessment PBT: Not applicable. vpvb: Not applicable. Other adverse effects No further relevant information available. * 13 Disposal considerations Waste treatment methods Recommendation Delivery of waste oil to offically authorized collectors only. Must not be disposed of together with household garbage. Do not allow product to reach sewage system. Uncleaned packagings: Recommendation: Disposal must be made according to official regulations. * 14 Transport information UN-Number DOT, ADR, ADN, IMDG, IATA Void (Contd. on page 6)

6 Page 6/7 UN proper shipping name DOT, ADR, ADN, IMDG, IATA Void Transport hazard class(es) DOT, ADR, ADN, IMDG, IATA Class Void Packing group DOT, ADR, IMDG, IATA Void Environmental hazards: Marine pollutant: No Special precautions for user Not applicable. Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code UN "Model Regulation": - Not applicable. (Contd. of page 5) * 15 Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture SARA Section 355 (extremely hazardous substances) SARA Section 313 (specific toxic chemical listings) TSCA (Toxic Substances Control Act) All ingredients are listed. Prop 65 - Chemicals known to cause cancer Cancerogenity categories EPA (Environmental Protection Agency) NIOSH-Ca (National Institute for Occupational Safety and Health) GHS label elements GHS label elements Hazard pictograms Void Signal word Void Hazard statements Void Chemical safety assessment: A Chemical Safety Assessment has not been carried out. * 16 Other information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Cortec Corporation does not warranty any translation of this SDS not created by Cortec Corporation. Date of preparation / last revision 09/23/2014 / - (Contd. on page 7)

7 Page 7/7 (Contd. of page 6) Abbreviations and acronyms: RID: Règlement international concernant le transport des marchandises dangereuses par chemin de fer (Regulations Concerning the International Transport of Dangerous Goods by Rail) ICAO: International Civil Aviation Organization ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) IMDG: International Maritime Code for Dangerous Goods DOT: US Department of Transportation IATA: International Air Transport Association EINECS: European Inventory of Existing Commercial Chemical Substances ELINCS: European List of Notified Chemical Substances CAS: Chemical Abstracts Service (division of the American Chemical Society) NFPA: National Fire Protection Association () HMIS: Hazardous Materials Identification System () * Data compared to the previous version altered.