MATERIAL SAFETY DATA SHEET

Transcription

1 MATERIAL SAFETY DATA SHEET 1. Product and Company Identification Identification of the preparation Product use Version # 11 Revision date Company identification HP LaserJet Q7553A-X-XC-XD Print Cartridge This product is a toner preparation that is used in HP LaserJet P2014/P2015/M2727mfp series printers. 21-Jul-2010 Hewlett-Packard Company 3000 Hanover Street Palo Alto, CA United States Telephone Hewlett-Packard health effects line (Toll-free within the US) (Direct) HP Customer Care Line (Toll-free within the US) (Direct) hpcustomer.inquiries@hp.com 2. Hazards Identification Acute health effects Skin contact Eye contact Inhalation Ingestion Potential health effects Routes of exposure Unlikely to cause skin irritation. May cause transient slight irritation Minimal respiratory tract irritation may occur with exposure to large amounts of toner dust. Low acute toxicity. Ingestion is a minor route of entry for intended use of this product. Potential routes of exposure under normal use conditions are skin, eye contact and inhalation. Ingestion is not expected to be a primary route of exposure for this product under normal use conditions. Chronic health effects Carcinogenicity Prolonged inhalation of excessive amounts of any dust may cause lung damage. Use of this product as intended does not result in inhalation of excessive amounts of dust. ne of the other ingredients in this preparation are classified as carcinogens according to ACGIH, EU, IARC, MAK, NTP or OSHA. This product is not classified as hazardous according to OSHA CFR or EU Directive 1999/45/EC, as amended. 3. Composition / Information on Ingredients This preparation contains no component classified as Persistent, Bioaccumulative, and Toxic (PBT) or very Persistent and very Bioaccumulative (vpvb) as defined under Regulation (EC) 1907/2006. Components CAS # Percent Styrene acrylate copolymer Ferrite including zinc Amorphous silica 4. First Aid Measures First aid procedures Eye contact Trade Secret < 55 Trade Secret < < 3 Do not rub eyes. Immediately flush with large amounts of clean, warm water (low pressure) for at least 15 minutes or until particles are removed. If irritation persists, consult a physician. 1 / 5

2 Skin contact Inhalation Ingestion Wash affected areas thoroughly with mild soap and water. Get medical attention if irritation develops or persists. Move person to fresh air immediately. If irritation persists, consult a physician. Rinse mouth out with water. Drink one to two glasses of water. If symptoms occur, consult a physician. 5. Fire Fighting Measures Flammable properties Extinguishing media Suitable extinguishing media Unsuitable extinguishing media Protection of firefighters Protective equipment and precautions for firefighters Specific methods Hazardous combustion products Like most organic material in powder form, toner can form explosive dust-air mixtures when finely dispersed in air. CO2, water, or dry chemical ne known. 6. Accidental Release Measures Personal precautions Environmental precautions If fire occurs in the printer, treat as an electrical fire. ne established. Carbon monoxide and carbon dioxide. Minimize dust generation and accumulation. Do not flush into surface water or sanitary sewer system. See also section 13 Disposal considerations. Slowly vacuum or sweep the material into a bag or other sealed container. Clean remainder with a damp cloth or vacuum cleaner. If a vacuum is used, the motor must be rated as dust explosion-proof. Fine powder can form explosive dust-air mixtures. Dispose of in compliance with federal, state, and local regulations. 7. Handling and Storage Handling Storage Keep out of the reach of children. Avoid inhalation of dust and contact with skin and eyes. Use with adequate ventilation. Keep away from excessive heat, sparks, and open flames. Keep out of the reach of children. Keep tightly closed and dry. Store away from strong oxidizers. Store at room temperature. 8. Exposure Controls / Personal Protection Exposure guidelines USA OSHA (TWA/PEL): 15 mg/m3 (Total Dust), 5 mg/m3 (Respirable Fraction) ACGIH (TWA/TLV): 10 mg/m3 (Inhalable Particulate), 3 mg/m3 (Respirable Particulate) Amorphous silica: USA OSHA (TWA/PEL): 20 mppcf 80 (mg/m3)/%sio2, ACGIH (TWA/TLV): 10 mg/m3 Engineering controls Personal protective equipment General Use in a well ventilated area. personal respiratory protective equipment required under normal conditions of use. 9. Physical & Chemical Properties Appearance Fine powder Color Black. Odor Slight plastic odor Odor threshold Physical state Solid Form solid ph Melting point 2 / 5

3 Freezing point Boiling point Flash point Evaporation rate Flammability limits in air, upper, % by volume Flammability limits in air, lower, % by volume Vapor pressure Vapor density t flammable Specific gravity 1.4 (H2O = 1) Relative density Solubility (water) Auto-ignition temperature Decomposition temperature Softening point Viscosity Percent volatile VOC Negligible in water. Partially soluble in toluene and xylene F ( C) Negligible Decomposition temperature: > 200 C 10. Chemical Stability & Reactivity Information Chemical stability Conditions to avoid Incompatible materials Hazardous decomposition products Possibility of hazardous reactions 11. Toxicological Information Oral toxicity Carcinogenicity Inhalation toxicity Serious eye damage/eye irritation Skin sensitization Chronic toxicity Sensitization Mutagenicity Stable under normal storage conditions. Imaging Drum: Exposure to light Strong oxidizers Carbon monoxide and carbon dioxide. Will not occur. LD50/oral/rat >2000 mg/kg; t harmful. (OECD 401). t classified for acute oral toxicity according to EU Directive 67/548/EEC and 1999/45/EC. ne of the other ingredients in this preparation are classified as carcinogens according to ACGIH, EU, IARC, MAK, NTP or OSHA. information available. t classified for acute inhalation toxicity according to EU Directive 67/548/EEC and 1999/45/EC. t classified as irritant, according to OSHA Hazard Communication Standard (HCS) and EU Directive 67/548/EEC and as amended. t classified as irritant, according to OSHA Hazard Communication Standard (HCS) and EU Directive 67/548/EEC and as amended. information available. t classified as a sensitizer according to EU Directive 67/548/EEC and as amended, and OSHA HCS (US). Negative, does not indicate mutagenic potential (Ames Test: Salmonella typhimurium) Reproductivity t classified as toxic according to EU Directive 67/548/EEC and as amended, California Prop. 65, and DFG (Germany). Further information 12. Ecological Information Ecotoxicity Persistence and degradability Complete toxicity data are not available for this specific formulation Refer to Section 2 for potential health effects and Section 4 for first aid measures. LL50: 1000 mg/l, Rainbow Trout, Hours 3 / 5

4 13. Disposal Considerations Disposal instructions 14. Transport Information Further information DOT t regulated as dangerous goods. IATA IMDG Basic shipping requirements: Proper shipping name UN number t regulated as dangerous goods. RID t regulated as dangerous goods. 15. Regulatory Information US federal regulations Do not shred toner cartridge, unless dust-explosion prevention measures are taken. Finely dispersed particles may form explosive mixtures in air. Dispose of in compliance with federal, state, and local regulations. HP's Planet Partners (trademark) supplies recycling program enables simple, convenient recycling of HP original inkjet and LaserJet supplies. For more information and to determine if this service is available in your location, please visit 9 or more of these cartridges shipped together in a single package (e.g., box, container), by air, are regulated as a magnetized material. These requirements do not apply to single or dual pack cartridges contained in an original HP package and shrink wrapped on a pallet for shipment by air. Magnetized Material 2807 CERCLA (Superfund) reportable quantity ne Occupational Safety and Health Administration (OSHA) 29 CFR hazardous chemical US EPA TSCA Inventory: All chemical substances in this product comply with all rules or orders under TSCA. Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Section 302 extremely hazardous substance Section 311 hazardous chemical State regulations Regulatory information 16. Other Information Immediate Hazard - Delayed Hazard - Fire Hazard - Pressure Hazard - Reactivity Hazard -. All chemical substances in this HP product have been notified or are exempt from notification under chemical substances notification laws in the following countries: US (TSCA), EU (EINECS/ELINCS), Switzerland, Canada (DSL/NDSL), Australia, Japan, Philippines, South Korea, New Zealand, and China. This MSDS was prepared in accordance with USA OSHA Hazard Communications regulation (29 CFR ). HMIS ratings Health: 1 Flammability: 1 Physical hazard: 0 4 / 5

5 NFPA ratings Health: 1 Flammability: 1 Instability: 0 Disclaimer Issue date This data sheet contains changes from the previous version in section(s): Manufacturer information Explanation of abbreviations This Safety Data Sheet document is provided without charge to customers of Hewlett-Packard Company. Data is the most current known to Hewlett-Packard Company at the time of preparation of this document and is believed to be accurate. It should not be construed as guaranteeing specific properties of the products as described or suitability for a particular application. This document was prepared to the requirements of the jurisdiction specified in Section 1 above and may not meet regulatory requirements in other countries. 21-Jul-2010 Transport Information: Agency Name and Packaging Type/Transport Mode Selection 14. Transport Information: Further information Hewlett-Packard Company Chinden Boulevard Boise, ID USA (Direct) (Toll-free within the US) ACGIH CAS CERCLA CFR COC DOT EPCRA IARC NIOSH NTP OSHA PEL RCRA REC REL SARA STEL TCLP TLV TSCA VOC American Conference of Governmental Industrial Hygienists Chemical Abstracts Service Comprehensive Environmental Response Compensation and Liability Act Code of Federal Regulations Cleveland Open Cup Department of Transportation Emergency Planning and Community Right-to-Know Act (aka SARA) International Agency for Research on Cancer National Institute for Occupational Safety and Health National Toxicology Program Occupational Safety and Health Administration Permissible Exposure Limit Resource Conservation and Recovery Act Recommended Recommended Exposure Limit Superfund Amendments and Reauthorization Act of 1986 Short-Term Exposure Limit Toxicity Characteristics Leaching Procedure Threshold Limit Value Toxic Substances Control Act Volatile Organic Compounds 5 / 5