MSDS Number: CALYPSO 4 FLOWABLE INSECTICIDE MSDS Version 2.0

Transcription

1 Revision Date: 04/25/2007 SECTION 1. CHEMICAL PRODUCT AND COMPANY INFORMATION Product Name CALYPSO 4 FLOWABLE INSECTICIDE MSDS Number EPA Registration No Bayer CropScience 2 T.W. Alexander Drive Research Triangle PK, NC USA For MEDICAL, TRANSPORTATION or other EMERGENCY call: (24 hours/day) For Product Information call: BAYER ( ) SECTION 2. COMPOSITION/INFORMATION ON INGREDIENTS Hazardous Component Name CAS-No. Average % by Weight Thiaclopride Trade Secret Ingredient(s) SECTION 3. HAZARDS IDENTIFICATION NOTE: Please refer to Section 11 for detailed toxicological information. Emergency Overview Warning! May be fatal if swallowed. Harmful if inhaled or absorbed through skin. Prolonged or frequently repeated skin contact may cause allergic reactions in some individuals. Avoid breathing spray mist. Avoid contact with skin, eyes and clothing. Physical State Odor Appearance Routes of Exposure Immediate Effects Eye Skin Ingestion Inhalation viscous liquid very faint white to beige Eye contact, Skin contact, Skin Absorption, Inhalation, Ingestion Avoid contact with eyes. Harmful if absorbed through skin. Avoid contact with skin and clothing. May be fatal if swallowed. Harmful if inhaled. Avoid contact or inhalation of spray mist. Page 1 of 8

2 Potential Environmental Effect Toxic to fish, aquatic invertebrates and marine/estuarine organisms. SECTION 4. FIRST AID MEASURES General Eye Skin Ingestion Inhalation Notes to Physician Treatment When possible, have the product container or label with you when calling a poison control center or doctor or going for treatment. Hold eye open and rinse slowly and gently with water for minutes. Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye. Call a physician or poison control center immediately. Take off contaminated clothing and shoes immediately. Wash off immediately with plenty of water for at least 15 minutes. Call a physician or poison control center immediately. Call a physician or poison control center immediately. Rinse out mouth and give water in small sips to drink. DO NOT induce vomiting unless directed to do so by a physician or poison control center. Never give anything by mouth to an unconscious person. Do not leave victim unattended. Move to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably mouth-to-mouth if possible. Call a physician or poison control center immediately. There is no specific antidote. Appropriate supportive and symptomatic treatment as indicated by the patient's condition is recommended. SECTION 5. FIRE FIGHTING MEASURES Flash point > 100 C / > 212 F Fire and Explosion Hazards Suitable Extinguishing Media In the event of fire the following can be released: hydrogen chloride (HCl) carbon monoxide (CO) nitrogen oxides (NOx) Hydrogen cyanide (hydrocyanic acid) Sulphur oxides Water spray, Foam, Dry powder, Carbon dioxide (CO2), Sand Page 2 of 8

3 Fire Fighting Instructions Avoid contact with spilled product or contaminated surfaces. Keep out of smoke. Fight fire from upwind position. Cool closed containers/ tanks exposed to fire with water spray. Do not allow run-off from fire fighting to enter drains or water courses. Firefighters should wear NIOSH approved self-contained breathing apparatus and full protective clothing. SECTION 6. ACCIDENTAL RELEASE MEASURES Personal Precautions Methods for Cleaning Up Keep unauthorized people away. Avoid contact with spilled product or contaminated surfaces. Use personal protective equipment. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder). Collect and transfer the product into a properly labelled and tightly closed container. Contaminated soil may have to be removed and disposed. Clean contaminated floors and objects thoroughly, observing environmental regulations. Decontaminate tools and equipment following cleanup. Additional Advice Do not allow to enter soil, waterways or waste water canal. Do not allow product to contact vegetation. Information regarding safe handling, see section 7. Information regarding personal protective equipment, see section 8. Information regarding waste disposal, see section 13. SECTION 7. HANDLING AND STORAGE Handling Procedures Handle and open container in a manner as to prevent spillage. Maintain exposure levels below the exposure limit through the use of general and local exhaust ventilation. For personal protection see section 8. Storing Procedures Work/Hygienic Procedures Store in a cool, dry place and in such a manner as to prevent cross contamination with other pesticides, fertilizers, food, and feed. Store in original container and out of the reach of children, preferably in a locked storage area. Handle in accordance with good industrial hygiene and safety practice. Wash hands thoroughly with soap and water after handling and before eating, drinking, chewing gum, using tobacco, using the toilet or applying cosmetics. Remove contaminated clothing immediately and dispose of safely. Wash thoroughly and put on clean clothing. Remove Personal Protective Equipment (PPE) immediately after handling this product. Before removing gloves clean them with soap and water. Wash thoroughly and put on clean clothing. Page 3 of 8

4 Min/Max Storage Temperatures Do not transport or store below -17 C / 1 F Do not transport or store below minimum temperature. SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION General Protection Eye/Face Protection Hand Protection Body Protection Respiratory Protection Exposure Limits Follow all label instructions. Follow manufacturer's instructions for cleaning/maintaining PPE. If no such instructions for washables, use detergent and warm/tepid water. Keep and wash PPE separately from other laundry. Safety glasses with side-shields Chemical resistant nitrile rubber gloves Wear long-sleeved shirt and long pants and shoes plus socks. When respirators are required, select NIOSH approved equipment based on actual or potential airborne concentrations and in accordance with the appropriate regulatory standards and/or industry recommendations. This product contains material which are Trade Secret and may have Occupational Exposure Limits. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Physical State Odor ph white to beige viscous liquid very faint 7-9 (5 %) (as a dispersion) Specific Gravity 1.20 at 20 C Density approx g/cm³ at 20 C Viscosity 126,000 mpa.s at 20 C SECTION 10. STABILITY AND REACTIVITY Conditions to Avoid Hazardous Reactions freezing Stable under normal conditions. Page 4 of 8

5 SECTION 11. TOXICOLOGICAL INFORMATION Only acute studies have been performed on this product as formulated. The non-acute information pertains to the technical-grade active ingredient, thiacloprid. Acute Oral Toxicity Acute Dermal Toxicity Acute Inhalation Toxicity rat: LD50: > < 500 mg/kg rat: LD50: > 4,000 mg/kg female rat: LC50: > < 2.2 mg/l Exposure time: 4 h Determined in the form of liquid aerosol. female rat: LC50: > < 8.8 mg/l Exposure time: 1 h Determined in the form of liquid aerosol. Extrapolated from the 4 hr LC50. male rat: LC50: > 2.2 mg/l Exposure time: 4 h Determined in the form of liquid aerosol. male rat: LC50: > 8.8 mg/l Exposure time: 1 h Determined in the form of liquid aerosol. Extrapolated from the 4 hr LC50. Skin Irritation Eye Irritation Sensitization Chronic Toxicity rabbit: No skin irritation. rabbit: No eye irritation. guinea pig: sensitizing Thiacloprid caused secondary effects due to significant liver enzyme induction in the liver, thyroid, adrenals, uterus and/or ovaries in chronic studies in rats, mice and dogs. Assessment Carcinogenicity Thiacloprid demonstrated evidence of oncogenicity inlifetime feeding studies in rats (thyroid and uterus) and mice (ovary). These effects, however, were observed only at high doses that also significantly induced hepatic enzyme activity. At lower doses, which did not affect hepatic enzymes, there was no evidence of oncogenicity. ACGIH NTP IARC Page 5 of 8

6 OSHA Reproductive & Developmental Toxicity REPRODUCTION: Thiacloprid is not considered a primary reproductive toxicant in rats. Reproductive effects were observed but were considered secondary to maternal toxicity. DEVELOPMENTAL TOXICITY: Thiacloprid is not considered a primary developmental toxicant in rats and rabbits. Developmental effects were observed at doses that caused maternal toxicity. Neurotoxicity Mutagenicity Thiacloprid was not a neurotoxicant in acute, subchronic and developmental neurotoxicity screening studies in rats. Thiacloprid was not mutagenic or genotoxic in a battery of in vitro and in vivo tests. SECTION 12. ECOLOGICAL INFORMATION Toxicity to Fish Bluegill sunfish LC50: 80.7 mg/l Exposure time: 96 h Toxicity to Aquatic Plants Desmodesmus subspicatus IC50: 96.7 mg/l Exposure time: 72 h Selenastrum capricornutum IC50: > 100 mg/l Exposure time: 72 h Acute Toxicity to Aquatic Invertebrates Environmental Precautions Daphnia EC50: >= 85.1 mg/l Exposure time: 48 h Do not apply directly to water, to areas where surface water is present or to intertidal areas below the mean high water mark. Do not contaminate surface or ground water by cleaning equipment or disposal of wastes, including equipment wash water. Page 6 of 8

7 SECTION 13. DISPOSAL CONSIDERATIONS General Disposal Guidance Container Disposal Do not contaminate water, food, or feed by disposal. Follow container label instructions for disposal of wastes generated during use in compliance with the product label. Follow advice on product label and/or leaflet. Triple rinse containers. Do not reuse empty containers. Puncture container to avoid re-use. Then offer for recycling or reconditioning or puncture and dispose of in a sanitary landfill or incineration, or if allowed by State and Local authorities, by burning. If burned, stay out of smoke. SECTION 14. TRANSPORT INFORMATION DOT CLASSIFICATION: Not regulated for Domestic Surface Shipment IMDG CLASSIFICATION: Not regulated for Ocean Shipment FREIGHT CLASSIFICATION: Insecticides or Fungicides, N.O.I.; other than poison TDG (Canada): Not regulated for road or rail. SECTION 15. REGULATORY INFORMATION This product contains material(s) which are Trade Secret and are on various Regulatory Lists. These material(s) are not listed below. EPA Registration No US Federal Regulations TSCA list US. Toxic Substances Control Act (TSCA) Section 12(b) Export Notification (40 CFR 707, Subpt D) SARA Title III - Section Notification and Information SARA Title III - Section Toxic Chemical Release Reporting US States Regulatory Reporting CA Prop65 This product does not contain any substances known to the State of California to cause cancer. Page 7 of 8

8 This product does not contain any substances known to the State of California to cause reproductive harm. US State Right-To-Know Ingredients Canadian Regulations Canadian Domestic Substance List Environmental CERCLA Clean Water Section 307 Priority Pollutants Safe Drinking Water Act Maximum Contaminant Levels SECTION 16. OTHER INFORMATION NFPA 704 (National Fire Protection Association): Health - 2 Flammability - 1 Reactivity - 1 Others - none 0 = minimal hazard, 1 = slight hazard, 2 = moderate hazard, 3 = severe hazard, 4 = extreme hazard Reason to Revise: Updated due to new system and numbering scheme. Updated for general editorial purposes. Revision Date: 04/25/2007 This information is provided in good faith but without express or implied warranty. The customer assumes all responsibility for safety and use not in accordance with label instructions. The product names are registered trademarks of Bayer. Page 8 of 8