SAFETY DATA SHEET. Creation Date 09-Dec-2009 Revision Date 29-Oct-2014 Revision Number Identification

Transcription

1 SAFETY DATA SHEET Creation Date 09-Dec-2009 Revision Number 1 Product Name Cat. : Synonyms Recommended Use 1. Identification Buffer solution ph 7, Phosphate buffer SB108-1; SB108-10; SB108-20; SB ne Laboratory chemicals. Uses advised against Information available Details of the supplier of the safety data sheet Company Fisher Scientific One Reagent Lane Fair Lawn, NJ Tel: (201) Emergency Telephone Number CHEMTRECÒ, Inside the USA: CHEMTRECÒ, Outside the USA: Hazard(s) identification Classification Classification under 2012 OSHA Hazard Communication Standard (29 CFR ) Based on available data, the classification criteria are not met Label Elements ne required Hazards not otherwise classified (HNOC) ne identified 3. Composition / information on ingredients Component CAS- Weight % Buffer solution ph 7, Phosphate buffer NA 100 Water Sodium phosphate dibasic Dihydrogen potassium phosphate Page 1 / 6

2 4. First-aid measures Eye Contact Skin Contact Inhalation Ingestion Most important symptoms/effects tes to Physician Suitable Extinguishing Media Unsuitable Extinguishing Media Flash Point Method - Flush eyes with water as a precaution. Get medical attention if symptoms occur. Rinse with plenty of water. Get medical attention if symptoms occur. Move to fresh air. If breathing is difficult, give oxygen. Get medical attention if symptoms occur. Do not induce vomiting. Obtain medical attention.. Treat symptomatically 5. Fire-fighting measures Substance is nonflammable; use agent most appropriate to extinguish surrounding fire. Autoignition Temperature Explosion Limits Upper Lower Sensitivity to Mechanical Impact Sensitivity to Static Discharge Specific Hazards Arising from the Chemical ne known. Hazardous Combustion Products ne known Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. NFPA Health 0 Flammability 0 Instability 0 Physical hazards N/A Personal Precautions Environmental Precautions 6. Accidental release measures special precautions required. special environmental precautions required. Methods for Containment and Clean Soak up with inert absorbent material. Keep in suitable, closed containers for disposal. Up Handling Storage 7. Handling and storage Wear personal protective equipment. Handle in accordance with good industrial hygiene and safety practice. Avoid contact with skin and eyes. Avoid ingestion and inhalation. Keep containers tightly closed in a dry, cool and well-ventilated place. 8. Exposure controls / personal protection Page 2 / 6

3 Exposure Guidelines This product does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies. NIOSH IDLH: The National Institute for Occupational Safety and Health Immediately Dangerous to Life or Health Engineering Measures Personal Protective Equipment Eye/face Protection Skin and body protection Respiratory Protection Hygiene Measures Ensure that eyewash stations and safety showers are close to the workstation location. Ensure adequate ventilation, especially in confined areas. Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR or European Standard EN166. Wear appropriate protective gloves and clothing to prevent skin exposure. Follow the OSHA respirator regulations found in 29 CFR or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced. Handle in accordance with good industrial hygiene and safety practice. 9. Physical and chemical properties Physical State Liquid Appearance Colorless Odor Odorless Odor Threshold ph 7.00 Melting Point/Range 0 C / 32 F Boiling Point/Range C Flash Point Evaporation Rate Flammability (solid,gas) Flammability or explosive limits Upper Lower Vapor Pressure C Vapor Density Relative Density Solubility Soluble in water Partition coefficient; n-octanol/water Autoignition Temperature Decomposition Temperature Viscosity 10. Stability and reactivity Reactive Hazard Stability Conditions to Avoid Incompatible Materials ne known, based on information available Stable under normal conditions. ne known. ne known Hazardous Decomposition Products ne known Hazardous Polymerization Hazardous Reactions Acute Toxicity Hazardous polymerization does not occur. ne under normal processing. 11. Toxicological information Page 3 / 6

4 Product Information acute toxicity information is available for this product Component Information Component LD50 Oral LD50 Dermal LC50 Inhalation Dihydrogen potassium phosphate t listed >4640 mg/kg ( Rabbit ) t listed Toxicologically Synergistic Products Delayed and immediate effects as well as chronic effects from short and long-term exposure Irritation Sensitization Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Component CAS- IARC NTP ACGIH OSHA Mexico Buffer solution ph 7, NA t listed t listed t listed t listed t listed Phosphate buffer Water t listed t listed t listed t listed t listed Sodium phosphate t listed t listed t listed t listed t listed dibasic Dihydrogen potassium phosphate t listed t listed t listed t listed t listed Mutagenic Effects Reproductive Effects Developmental Effects Teratogenicity STOT - single exposure STOT - repeated exposure Aspiration hazard Symptoms / effects,both acute and delayed Endocrine Disruptor Information Other Adverse Effects... ne known ne known The toxicological properties have not been fully investigated. See actual entry in RTECS for complete information. 12. Ecological information Ecotoxicity Contains no substances known to be hazardous to the environment or that are not degradable in waste water treatment plants. Persistence and Degradability Bioaccumulation/ Accumulation Mobility Waste Disposal Methods Disposal considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. Chemical waste generators must also consult local, regional, and national hazardous waste regulations to ensure complete and accurate classification. Page 4 / 6

5 DOT TDG IATA IMDG/IMO 14. Transport information t regulated t regulated t regulated t regulated 15. Regulatory information International Inventories Component TSCA DSL NDSL EINECS ELINCS NLP PICCS ENCS AICS IECSC KECL Water X X X - X X X Sodium phosphate dibasic X X X X X X X Dihydrogen potassium X X X X X X X phosphate Legend: X - Listed E - Indicates a substance that is the subject of a Section 5(e) Consent order under TSCA. F - Indicates a substance that is the subject of a Section 5(f) Rule under TSCA. N - Indicates a polymeric substance containing no free-radical initiator in its inventory name but is considered to cover the designated polymer made with any free-radical initiator regardless of the amount used. P - Indicates a commenced PMN substance R - Indicates a substance that is the subject of a Section 6 risk management rule under TSCA. S - Indicates a substance that is identified in a proposed or final Significant New Use Rule T - Indicates a substance that is the subject of a Section 4 test rule under TSCA. XU - Indicates a substance exempt from reporting under the Inventory Update Rule, i.e. Partial Updating of the TSCA Inventory Data Base Production and Site Reports (40 CFR 710(B). Y1 - Indicates an exempt polymer that has a number-average molecular weight of 1,000 or greater. Y2 - Indicates an exempt polymer that is a polyester and is made only from reactants included in a specified list of low concern reactants that comprises one of the eligibility criteria for the exemption rule. U.S. Federal Regulations TSCA 12(b) SARA 313 SARA 311/312 Hazardous Categorization Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Clean Water Act Component CWA - Hazardous CWA - Reportable CWA - Toxic Pollutants CWA - Priority Pollutants Substances Quantities Sodium phosphate dibasic X 5000 lb - - Clean Air Act OSHA Occupational Safety and Health Administration CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Component Hazardous Substances RQs Sodium phosphate dibasic 5000 lb California Proposition 65 This product does not contain any Proposition 65 chemicals CERCLA EHS RQs - Page 5 / 6

6 State Right-to-Know Component Massachusetts New Jersey Pennsylvania Illinois Rhode Island Sodium phosphate dibasic X X X - - U.S. Department of Transportation Reportable Quantity (RQ): DOT Marine Pollutant DOT Severe Marine Pollutant Y N N U.S. Department of Homeland Security This product does not contain any DHS chemicals. Other International Regulations Mexico - Grade Canada This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all the information required by the CPR WHMIS Hazard Class Prepared By Creation Date Revision Date Print Date Revision Summary n-controlled 16. Other information Regulatory Affairs Thermo Fisher Scientific EMSDS.RA@thermofisher.com 09-Dec Oct Oct-2014 This document has been updated to comply with the US OSHA HazCom 2012 Standard replacing the current legislation under 29 CFR to align with the Globally Harmonized System of Classification and Labeling of Chemicals (GHS) Disclaimer The information provided on this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of SDS Page 6 / 6