Safety Data Sheet (SDS)

Transcription

1 Section 1: Product and Company Identification Safety Data Sheet (SDS) Revision Date: 03/2015 Printed Date: 03/2015 Product Name: Product Use Description: Company: Terroxy Resin Systems Terrazzo Primer, Part A Resin Compound, Epoxy Resin Systems Terrazzo & Marble Supply Companies 77 South Wheeling Road Wheeling, Illinois Telephone: Emergency Telephone: USA International Section 2: Hazards Identification Classification of the mixture: Skin irritation Category 2 Skin sensitization Category 1 Eye irritation Category 2 Respiratory tract irritation Category 3 Classification according to Regulation (EC) No 1272/2008 GHS Label elements: Hazard Pictogram: Signal Word: Hazard Statements: Precautionary Statements: Other hazards not classified: Warning H315 Causes skin irritation H317 May cause an allergic skin reaction H319 Causes serious eye irritation H335 May cause respiratory irritation P261 Avoid breathing mist/vapors/spray P264 Wash hands and skin contact areas thoroughly after handling P272 Contaminated work clothing should not be allowed out of the workplace P273 Avoid release to the environment P280 Wear protective gloves/eye/face protection P302, P352 IF ON SKIN: Wash with plenty of soap and water P305, P351, P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do, continue rinsing P333, P313 If skin irritation or rash occurs: Get medical advice/attention P337, P313 If eye irritation persists: Get medical advice/attention P362 Take off contaminated clothing and wash before reuse P391 Collect spillage P501 Dispose of content/container through a waste management company authorized by the local government None Known Page 1

2 Section 3: Composition / Information on Ingredients This product is a mixture. Component CAS# Amount Epoxy Resin % Nonylphenol % % Glycidyl Ether % % Benzyl Alcohol % % N/E - ALL ingredients are registered on TSCA The remaining components are trade secret. Substances listed are present in concentration of 1% or greater, or 0.1% if cited as a potential Carcinogen in the OSHA Hazards communication Standard. Where proprietary ingredient is listed, the identity is available as provided in 29 CFR Section 4: First Aid Measures General advice: Eye contact: Skin contact: Ingestion: Inhalation: Seek medical advice. If breathing has stopped or is labored, give assisted respirations. Supplemental oxygen may be indicated. If the heart has stopped,trained personnel should begin cardiopulmonary resuscitation immediately. Flush eyes with plenty of water for at least 15 minutes retracting eyelids often. Tilt the head to prevent chemical from transferring to the uncontaminated eye. Get immediate medical attention. Wash with soap and water. Remove contaminated clothing and launder. Get immediate medical attention if irritation develops or persists. Do not induce vomiting. Seek medical attention immediately. Drink two glasses of water of milk to dilute. do not give anything by mouth to an unconscious person. Induced vomiting may lead to aspiration of material into the lungs potentially causing chemical pneumonitis that may be fatal. Move to fresh air. Call a physician if symptoms persist. Section 5: Fire Fighting Measures Flash Point : Not Applicable Autoignition Temperature : Lower Explosive Limit (% in air) : Upper Explosive Limit (% in air) : Extinguishing Media : Use water spray, foam, dry chemical or carbon dioxide Unusual Fire & Explosion Hazards: Material will burn in a fire. Special Fire Fighting Instructions: Hazardous Combustion Products: Persons exposed to products of combustion should wear self-containing breathing apparatus and full protective equipment. Carbon dioxode, Carbon monoxide Page 2

3 Section 6: Accidental Release Measures Special Protection: Clean-up: Exposure to the spilled material may be irritating or harmful. Follow personal protective equipment recommendations found in Section 8 of this MSDS. Additional precautions may be necessary based on special circumstances created by the spill including; the material spilled, the quantity of the spill, the area in which the spill occurred. Dike if necessary, contain material with inert absorbent and transfer to containers for disposal. Keep spilled product out of sewers, watersheds, or water systems. Transport Emergency Phone Number: (CHEMTREC) Section 7: Handling and Storage Handling: Storage: Avoid contact with eyes. Avoid contact with skin and eyes. Adhere to work practice rules established by government regulations. Use personal protective equipment. When using, do not eat, drink or smoke. Store in a cool dry place Section 8: Exposure Controls / Personal Protection Personal Protective Equipment: Respiratory Protection: Ventilation: Hand Protection: Eye Protection: Skin and Body Protection: Exposure Limit: Not required for properly ventilated areas. If vapor or mist is generated and the occupational exposure limit is exceeded, use appropriate NIOSH/MSHA approved self contained breathing equipment or a full face respirator. Respirators should be selected by and used following requirements found in OSHA s respirator standards (29 CFR ). Not required for properly ventilated areas. Mechanical ventilation required if TLV is expected to be exceeded in confined areas. Recommend wearing disposable latex or nitrile gloves when mixing to protect against incidental contact. If continuous contact is expected, recommend butyl rubber gloves be worn. Wear safety glasses with side shields or safety goggles when handling this product. Additionally, wear a face shield when the possibility of splashing liquid exists. Do not wear contact lens. Have an eye wash station available. Prevent contact with this product. Long sleeve shirts and trouser without cuffs and/or apron is recommended if splashing liquids exists. Other protective equipment may be needed depending on condition use. Chemical Name OSHA PEL ACGIH TLV Epoxy Resin Phenol, 4-nonyl, branched Benzyl Alcohol Glycidyl Ether Page 3

4 Section 9: Physical and Chemical Properties Physical State: Liquid Color: Amber Odor: Neutral Odor Threshold: Not established Weight Per Gallon: 8.99 lbs. Specific Gravity: 1.08 Solids (% by weight): V.O.C. 0 g/l ph: Boiling point/range: >350 F (176.6 C) Vapor pressure: <1 mmhg at 100 F (37.8 C) Vapor density: Approximately 3.5 (Air = 1) Evaporator Rate: Slower than N-Butyl Acetate Octanol/Water Coefficient: Freezing/Melting Point: Solubility in Water: Very Slight Section 10: Reactivity Data Stability : Stable under normal conditions. Chemical Incompatibility: Water. Hazardous Polymerization: Will not occur. Hazardous Decomposition Products: Carbon monoxide, carbon dioxide (CO2). Section 11: Toxicological Information Chemical Name Epoxy Resin Phenol, 4-nonyl, branched Benzyl Alcohol LD50 / LC50 Oral LD50 Rat = 1300mg/kg Toxicology Summary : No additional health information available. Section 12: Ecological Information Overview: No ecological information available. Page 4

5 Section 13: Disposal Considerations To the best of our knowledge, this product does not meet the definition of hazardous waste under the U.S. EPA Hazardous Waste Regulations 40 CFR 261. Disposal via incineration at an approved facility is recommended. Consult state, local or provincial authorities for more restrictive requirements. Consult Bill of Lading for transportation information DOT: Not Regulated IATA: Not Regulated Section 14: Transport Information Country USA EU Regulatory List TSCA EINECS Notification This product is in compliance with the Toxic Substances Control Act s Inventory requirements. This product is in compliance with the European Inventory of Notified and Existing Chemical Substances requirements. Canada DSL This product is in compliance with the Canadian Domestic Substance List requirements. Australia AICS Included on Inventory Japan ENCS Included on Inventory South Korea ECL Included on Inventory China SEPA Included on Inventory Philippines PICCS Included on Inventory Chemical Name CAS # Percent Epichlorohydrin (Carcinogen) <10ppm Toluene (Developmental Toxin) <10ppm Epichlorohydrin (Male Reproductive Toxin) Section 15: Regulatory Information OSHA Hazard Communication Standard (29 CFR ) Hazard Class(es)Corrosive. Sensitizer. This product may contain substances that are regulated for export by various government agencies (such as the Environmental Protection Agency,the Bureau of Industry and Security, or the Drug Enforcement Administration, among others). Federal Reporting EPA SARA Title III Section 313 Unless listed below, this product does not contain toxic chemical(s) subject to the reporting requirements of section 313 of Tile III of the Super-fund Amendments and Reauthorization Act of 1986 (SARA) and 40 CFR part 372. EPA has advised that when a percentage range is listed the midpoint may be used to fulfill reporting obligations. WHMIS STATUS: Unless listed below, This product is not controlled under the Canadian Workplace Hazardous Materials Information System. D2B D2A STATE REPORTING Proposition 65, The Safe Drinking Water and Toxic Enforcement Act of 1986: Unless listed below, this product does not contain known levels of any chemical known to the State of California to cause cancer or reproductive harm <10ppm Page 5

6 Section 16: Other Information HMIS Rating Health: 3 Flammability: 1 Reactivity: 0 Physical hazard : C This Material Safety Data Sheet, is prepared to comply with the United States Occupational Safety and Health Administration (OSHA) Hazard Communication Standards (29 CFR ) and the Canadian Workplace Hazardous Materials Information System (WHMIS). Prepared by Terrazzo & Marble Supply Companies. Data and recommendations presented herein are based upon ours and other researchers and are believed to be accurate. The products discussed are distributed without warranty (expressed or implied) and the customer shall make his own determination of suitability for his particular purpose. Page 6