Safety Data Sheet: TERRASAFE FOAMING DEGREASER Supercedes Date Not applicable Issuing Date 01/20/ PRODUCT AND COMPANY IDENTIFICATION

Transcription

1 Safety Data Sheet: TERRASAFE FOAMING DEGREASER Supercedes Date t applicable Issuing Date 01/20/ PRODUCT AND COMPANY IDENTIFICATION Product Name TERRASAFE FOAMING DEGREASER Product Code PMC60413 Recommended use Water based degreaser Chemical nature Aqueous solution Aerosol Information on Manufacturer Emergency Telephone Number Partsmaster, Div of NCH Corp. CHEMTREC P.O. Box Dallas, TX Telephone inquiry HAZARD IDENTIFICATION Color White Physical State Aerosol Odor Citrus GHS Classification Physical Hazards Gases under pressure R36/37/38 - Irritating to eyes, respiratory system and skin Health Hazard Skin Corrosion/Irritation Category 3 Skin Sensitization Category 1 Other hazards ne Labeling Signal Word WARNING Hazard Statements H280 - Contains gas under pressure; may explode if heated H316 - Causes mild skin irritation H317 - May cause an allergic skin reaction Precautionary Statements P261 - Avoid breathing mist or gas P280 - Wear protective gloves, protective clothing and eye protection. P272 - Contaminated work clothing should not be allowed out of the workplace P321 - Specific treatment (see supplemental first aid instructions on this label) P302+ P352 - IF ON SKIN: Wash with plenty of soap and water P333 + P313 - If skin irritation or rash occurs, get medical attention P363 - Wash contaminated clothing before reuse P410 + P403 - Protect from sunlight. Store in a well-ventilated place P391 - Collect spillage P273 - Avoid release to the environment P501 - Dispose of contents and container to an approved waste disposal plant. 23 % of the mixture consists of ingredient(s) of unknown toxicity 3. COMPOSITION / INFORMATION ON INGREDIENTS Component CAS- Weight % Water Methyl esters from soy oil Petroleum gases, liquified, D-Limonene Mineral spirits Sodium lauryl sulfate Sodium carbonate FIRST AID MEASURES Page 1 / 6

2 General advice Eye Contact Skin Contact Inhalation Ingestion tes to physician Do not get in eyes, on skin or on clothing. Avoid prolonged or repeated contact with skin. Wash thoroughly after handling. Do not take internally. Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician Wash affected areas with large amounts of soap and water for 15 minutes. Remove contaminated clothing and shoes. Seek medical attention if irritation persists. Wash clothing and clean shoes before re-use. Move to fresh air If swallowed, contact a poison control center or physician immediately. Do NOT induce vomiting unless directed to do so by medical personnel. Never give anything by mouth to an unconscious person. Get medical attention. Treat symptomatically 5. FIRE-FIGHTING MEASURES Flash Point t applicable Method Seta closed cup Upper data available Lower data available Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment Specific hazards arising from the chemical Flame extension: 0 inches / 0 cm and Burnback: 0 inch / 0 cm. Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear Aerosol Level (NFPA 30B) - 1 NFPA Health 2 Flammability 1 Instability 0 Other HMIS Health 2 Flammability 1 Instability 0 6. ACCIDENTAL RELEASE MEASURES Personal Precautions Environmental Precautions Methods for Containment Methods for Cleaning Up Neutralizing Agent Use personal protective equipment. Prevent further leakage or spillage if safe to do so. Do not allow material to contaminate ground water system. Prevent product from entering drains. Local authorities should be advised if significant spillages cannot be contained. Do not flush into surface water or sanitary sewer system. Contain spillage, soak up with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and transfer to a container for disposal according to local / national regulations (see section 13). Clean contaminated surface thoroughly. t applicable. 7. HANDLING AND STORAGE Handling Avoid contact with skin, eyes and clothing. Keep away from clothing and other combustible materials. Wear personal protective equipment. Ensure adequate ventilation. Storage Store in original container. Keep from freezing. Store in a cool, dry area away from potential sources of heat, open flames, sunlight or other chemicals. Storage Temperature Minimum 32 0 Maximum Storage Conditions Indoor X Outdoor Heated Refrigerated 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Exposure Guidelines This product does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies. Component ACGIH TLV OSHA PEL NIOSH Water data available data available data available Methyl esters from soy oil data available data available data available Petroleum gases, liquified, data available data available data available D-Limonene data available data available data available Mineral spirits data available data available data available Sodium lauryl sulfate data available data available data available Sodium carbonate data available data available data available Engineering Measures Ensure adequate ventilation, especially in confined areas Personal Protective Equipment Eye/Face Protection Chemical goggles should be worn when handling. Skin Protection Wear suitable protective clothing, Impervious gloves. Respiratory Protection In case of insufficient ventilation wear suitable respiratory equipment General Hygiene Considerations Remove and wash contaminated clothing before re-use. When using, do not eat, drink, or smoke. Page 2 / 6

3 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Aerosol Viscosity t applicable Color White Odor Citrus Odor Threshold t applicable Appearance ph Specific Gravity = 0.99 Evaporation Rate 0.1 Percent Volatile (Volume) VOC Content (%) 9.5 Vapor Pressure F Vapor Density 1 (air = 1) Solubility Completely soluble n-octanol/water Partition data available Melting Point/Range data available Decomposition Temperature data available Boiling Point/Range data available Flammability (solid, gas) data available Flash Point t applicable Method Seta closed cup Autoignition Temperature Upper data available Lower data available 10. STABILITY AND REACTIVITY Chemical Stability Conditions to Avoid Incompatible Products Hazardous Decomposition Products Possibility of Hazardous Reactions Stable under normal conditions ne known materials to be especially mentioned ne under normal use ne under normal processing 11. TOXICOLOGICAL INFORMATION Product Information The following values are calculated based on chapter 3.1 of the GHS document (Rev. 3, 2009): Oral LD50 Dermal LD50 Inhalation LC50 Gas Mist Vapor Principle Route of Exposure Skin contact, Inhalation. Primary Routes of Entry ne known Acute Effects Eyes Causes eye irritation. Skin May cause allergic skin reaction. Inhalation May cause irritation of respiratory tract Ingestion Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea Chronic Toxicity May cause sensitization by skin contact. Target Organ Effects Immune system Aggravated Medical Conditions Skin disorders Component Information Acute Toxicity ne known Component LD50 Oral LD50 Dermal LC50 Inhalation Draize Test Other Water no data available no data available no data available no data available no data available Methyl esters from soy oil no data available no data available no data available no data available no data available Petroleum gases, liquified, no data available no data available no data available no data available no data available D-Limonene no data available > 5 g/kg ( Rabbit ) no data available no data available no data available Mineral spirits > 5000 mg/kg ( Rat ) > 2000 mg/kg ( Rabbit ) > 5.2 mg/l ( Rat ) 4 h no data available no data available Sodium lauryl sulfate = 1288 mg/kg ( Rat ) = 580 mg/kg ( Rabbit ) > 3900 mg/m 3 ( Rat ) 1 h no data available no data available Sodium carbonate = 4090 mg/kg ( Rat ) no data available = 2300 mg/m 3 ( Rat ) 2 h no data available no data available Component Mutagenicity Sensitization Developmental Toxicity Reproductive Toxicity Target Organ Effects Water no data available no data available no data available no data available no data available Methyl esters from soy oil no data available no data available no data available no data available no data available Petroleum gases, liquified, no data available no data available no data available no data available no data available D-Limonene no data available Skin sensitization, no data available no data available Immune system Respiratory sensitization Mineral spirits no data available no data available no data available no data available no data available Sodium lauryl sulfate no data available skin sensitization no data available no data available immune system Sodium carbonate no data available no data available no data available no data available no data available Page 3 / 6

4 Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. Component ACGIH IARC NTP OSHA Other Water not applicable not applicable not applicable not applicable not applicable Methyl esters from soy oil not applicable not applicable not applicable not applicable not applicable Petroleum gases, liquified, not applicable not applicable not applicable not applicable not applicable D-Limonene not applicable not applicable not applicable not applicable not applicable Mineral spirits not applicable not applicable not applicable not applicable not applicable Sodium lauryl sulfate not applicable not applicable not applicable not applicable not applicable Sodium carbonate not applicable not applicable not applicable not applicable not applicable 12. ECOLOGICAL INFORMATION Product Information Component Information Component Toxicity to Algae Toxicity to Fish Microtox Water Flea log Pow Water no data available no data available no data available no data available N/A Methyl esters from soy oil no data available no data available no data available no data available N/A Petroleum gases, liquified, no data available no data available no data available no data available <=2.8 D-Limonene no data available LC mg/l Pimephales no data available no data available N/A LC50 = 35 mg/l Oncorhynchus Mineral spirits no data available LC50 = 45 mg/l Pimephales no data available LC50= 4720 mg/l 96 h N/A LC50 = 2.2 mg/l Lepomis LC50 = 2.4 mg/l Oncorhynchus Sodium lauryl sulfate EC50 = 53 mg/l Desmodesmus subspicatus 72 h EC mg/l Desmodesmus subspicatus 96 h EC50 = 117 mg/l Pseudokirchneriella subcapitata 96 h EC mg/l Pseudokirchneriella subcapitata 96 h LC mg/l Pimephales LC mg/l Pimephales LC mg/l Pimephales LC mg/l Oncorhynchus LC50 = 4.62 mg/l Oncorhynchus LC50 = 4.2 mg/l Oncorhynchus LC50 = 7.97 mg/l Brachydanio rerio 96 h LC mg/l Brachydanio rerio 96 h LC mg/l Lepomis LC mg/l Lepomis LC50 = 4.5 mg/l Lepomis LC mg/l Pimephales LC mg/l Pimephales LC mg/l Pimephales LC mg/l Poecilia reticulata 96 h LC mg/l Poecilia reticulata 96 h LC50 = 1.31 mg/l Cyprinus carpio 96 h EC50 = 0.46 mg/l 30 min EC50 = 0.72 mg/l 15 min EC50 = 1.19 mg/l 5 min EC50= 1.8 mg/l 48 h 1.6 Sodium carbonate EC50 = 242 mg/l Nitzschia 120 h LC50 = 300 mg/l Lepomis LC mg/l Pimephales no data available EC50= 265 mg/l 48 h N/A Persistence and Degradability Bioaccumulation Mobility Page 4 / 6

5 13. DISPOSAL CONSIDERATIONS Product Disposal Container Disposal Dispose of in accordance with local regulations. Empty containers should be taken for local recycling, recovery, or waste disposal DOT TDG 14. TRANSPORT INFORMATION Consumer Commodity, ORM-D ICAO IATA UN- UN1950 Aerosols, non-flammable Hazard Class 2.2 Shipping Description UN1950, Aerosols, non-flammable, 2.2, LTD QTY UN- UN1950 Aerosols, non-flammable Hazard Class 2.2 Shipping Description UN1950, Aerosols, non-flammable, 2.2, LTD QTY IMDG/IMO Aerosols Hazard Class 2 UN- UN1950 Shipping Description UN1950, Aerosols, 2, LTD QTY 15. REGULATORY INFORMATION Inventories TSCA Complies DSL Complies U.S. Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and and Title 40 of the Code of Federal Regulations, Part 372. SARA 311/312 Hazardous Categorization Acute Health Hazard Chronic Health Hazard CERCLA Yes Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Component Hazardous Substances RQs CERCLA EHS RQs Water t applicable t applicable Methyl esters from soy oil t applicable t applicable Petroleum gases, liquified, t applicable t applicable D-Limonene t applicable t applicable Mineral spirits t applicable t applicable Sodium lauryl sulfate t applicable t applicable Sodium carbonate t applicable t applicable 16. OTHER INFORMATION Prepared By Christopher Drogin Supercedes Date t applicable Issuing Date 01/20/2014 Reason for Revision Glossary List of References. Partsmaster, Div of NCH Corp. assumes no responsibility for personal injury or property damage caused by the use, storage, or disposal of the product in a manner not recommended on the product label. Users assume all risks associated with such unrecommended use, storage or disposal of the product. The information provided on this document is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, Page 5 / 6

6 processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. Page 6 / 6