Safety Data Sheet GLOW FOAM LOW PH (WX-300)

Transcription

1 Safety Data Sheet GLOW FOAM LOW PH (WX-300) Section 1. Identification Product Identifier Synonyms Manufacturer Stock Numbers GLOW FOAM LOW PH (WX-300) Recommended use Uses advised against Presoak, Friction Lubricator, Liquid Foaming Detergent Manufacturer Contact Address JBS INDUSTRIES 2550 HENKLE DR LEBANON, OHIO, USA Phone (513) Emergency Phone (800) CHEMTREC Fax (513) Section 2. Hazards Identification Classification Signal Word Pictogram Hazard Statements Precautionary Statements Response EYE DAMAGE/IRRITATION - Category 2B SKIN CORROSION/IRRITATION - Category 2 Warning Causes eye irritation Causes skin irritation If eye irritation persists: Get medical advice/attention. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, Page 1 of 5

2 Prevention Storage Disposal if present and easy to do. Continue rinsing. If on skin: Wash with plenty of soapy water and rinse skin thoroughly. If skin irritation occurs: Get medical advice/attention. Take off contaminated clothing and wash it before reuse. Wash hands and any exposed skin thoroughly after handling. Wear eye protection/face protection. Wear protective gloves. Store in a closed container Dispose of contents/container per federal, state, and local laws. Ingredients of unknown toxicity Hazards not Otherwise Classified 0% Section 3. Ingredients CAS Ingredient Name Weight % PROPRIETARY SUFACTANT BLEND 10% - 20% Benzenesulfonic acid, dodecyl- 5% - 10% Occupational exposure limits, if available, are listed in Section 8. Section 4. First-Aid Measures EYE CONTACT: SKIN CONTACT: INGESTION: Inhalation Immediately flush with clean water for 15 minutes. Seek medical attention. Wash thoroughly with soap and water; remove soiled clothing and wash before reuse. DO NOT INDUCE VOMITING! Seek medical attention. If exposed to excessive levels of dusts or fumes, remove to fresh air and get medical attention if cough or other symptoms develop. Section 5. Fire Fighting Measures Suitable Extinguishing Media Unsuitable Extinguishing Media Carbon dioxide, dry chemical, or foam. Do not use water. Section 6. Accidental Release Measures Clean-up Small spills may be diluted and rinsed to sanitary sewer. Large spills should be contained and offered for disposal per state and/or local laws. Page 2 of 5

3 Section 7. Handling and Storage Storage Store in original container at temperatures below 120 degrees F. Product is best if used within 6mths of purchase. Spills may cause floor to become slippery Do not store in metal containers Section 8. Exposure Controls/Personal Protection Occupational Exposure Limits Personal Protective Equipment Other clothing Engineering controls Ingredient Name ACGIH TLV OSHA PEL STEL PROPRIETARY SUFACTANT BLEND Benzenesulfonic acid, dodecyl- Goggles, Gloves Where contact is likely, wear chemical-resistant gloves, a chemical suit, rubber boots, and chemical safety goggles plus a face shield. Wear safety glasses with side shields (or goggles) and a face shield. Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Good general ventilation should be sufficient to control airborne levels. Page 3 of 5

4 Section 9. Physical and Chemical Properties Physical State LIQUID Color VARIES, CLEAR, BLUE, PINK, ORANGE Odor Slight Characteristic Odor Odor Threshold Solubility Complete Partition coefficient Water/n-octanol VOC% Viscosity Specific Gravity 1.06 Density lbs/gal Pounds per Cubic Foot Flash Point FP Method Ph a Concentration 120 to 1 Melting Point Boiling Point Boiling Range LEL UEL Evaporation Rate Flammability Decomposition Temperature Auto-ignition Temperature Vapor Pressure Vapor Density Section 10. Stability and Reactivity STABILITY: HAZARDOUS POLYMERIZATION: INCOMPATIBLE MATERIALS: STABLE WILL NOT OCCUR Strong Alkalis, Oxidizers. Section 11. Toxicological Information Page 4 of 5

5 Section 12. Ecological Information Section 13. Disposal Waste Disposal Section 14. Transport Information UN Number 2586 UN Proper Shipping Name Alkyl Sulfonic Acids,liquids DOT Classification 8 Packing Group PGIII FREIGHT CLASS 55 Section 15. Regulatory Information Offer surplus and non-recyclable solutions to a licensed disposal company. Contact a licensed professional waste disposal service to dispose of this material. Empty containers should be disposed of as unused product. Regulatory DODECYLBENZENE SULFONIC ACID New Jersey - Workplace Hazard New Jersey - Special Hazard Pennyslvania - Workplace Hazard Pennsylvania - Enviromental Hazard New York City - Hazardous Substance Section 16. Other Information Revision Date 2/11/2015 NFPA Health: 3 Fire: 0 Reactivity: 0 HMIS Health: 3 Fire: 0 Reactivity: 0 Personal Protection: B DISCLAIMER: The information contained herein is believed to be accurate and is offered in good faith. This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process. Mixing this product with any other materials may change the characteristics such as flash point, flammability or health effects. Because product use is beyond our control, no warranty is given, expressed or implied. Page 5 of 5