Material Safety Data Sheet

Transcription

1 Product Reference : Page 1 / 7 1. IDENTIFICATION OF THE SUBSTANCE Product Name: Product Type and Use: Supplier Name and Address: Wastewater Treatment Compound COVENTYA Inc Van Epps Road, Brooklyn Heights, OH Supplier Phone Number: (216) Emergency Contact Phone Number: 1 (800) CHEMTREC 24hrs 2. HAZARD INDENTIFICATION Classification: Skin irritation, Category 3 Symbol: Symbol Signal Word: Warning, Irritant Hazard Statement: Causes eye and skin irritation. May cause nausea, vomiting and abdominal pain. Precautionary Statement: Keep container tightly closed. Wear protective gloves and eye/face protection. Avoid breathing aspirated liquids. 3. COMPOSITION / INFORMATION ON INGREDIENTS Chemical Identity CAS# Max. Conc. (wt %) This product does not contain material(s) listed as hazardous materials within the meaning of the following: SARA Title III (Section 313), OSHA 29CFR , Dangerous Substance Directive 67/248/EEC or the Hazardous Products Act. 4. FIRST AID MEASURES Contact with eyes: Contact with skin: Inhalation: Swallowing: Flush with clean water for 15 minutes. Contact a Physician. Washing eyes within 1 minute after contact is essential to achieve maximum effectiveness. Immediately wash skin with soap and plenty of water for 15 minutes. Remove contaminated clothing and do not re-use until laundered. Remove victim to fresh air. Seek medical attention. If breathing has stopped, start artificial respirations. If breathing difficult, give oxygen. Do not induce vomiting. Give large amounts of milk and/or water. Seek medical attention if symptoms persist.

2 Product Reference : Page 2 / 7 5. FIREFIGHTING MEASURES Suitable Extinguishing Media: Unsuitable Extinguishing Media: Specific Hazards in Case of Fire: Protective Equipment / Precautions: Water Fog, Dry Chemical, Alcohol Foam, and CO 2 High flow water jet 6. ACCIDENTAL RELEASE MEASURES Personal Precautions: Environmental Precautions: Methods / Materials for Containment and Clean up: 7. HANDLING AND STORAGE Safe Handling Procedures: Safe Storage Procedures w/ Incompatibles: Containers exposed to fire or extremely elevated temperatures can rupture violently. Positive pressure, self-contained respiratory protection and protective clothing should be worn by firefighters in areas where product is stored. Depending on the extent of release, consider the need for firefighters/emergency responders with adequate personal protective equipment for cleaning up. Do not eat, drink or smoke while cleaning up. See section 8 for personal protective equipment. See section 7 for handling instructions. Prevent spills from entering storm sewers or drains and contact with soil. Contain spill. Cover with an absorbent material (treated sawdust, diatomaceous earth, sand). Shovel up and dispose of at an appropriate waste facility in accordance with current applicable laws and regulations. Avoid contact with eyes. Avoid prolonged or repeated skin contact. Avoid breathing mists or vapors. Avoid spilling material. Keep container tightly closed when not in use. Protect from freezing. Spills of this material are extremely slippery. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Exposure Limits Component Name CAS # t applicable TWA STEL ppm mg/m3 ppm mg/m3 Ventilation: Respiratory Protection: Eye Protection: Skin Protection: Exhaust ventilation to maintain air contamination below TLV. Mechanical ventilation recommended. Use appropriate NIOSH approved respiratory equipment for dust and mists. Face shield, chemical splash goggles Rubber or other suitable material

3 Product Reference : Page 3 / 7 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State: Color: Odor: Liquid Clear to light amber Mild odor Relative Density: o F (20 o C) ph: Melting Point: Freezing Point: 32 o F (0 o C) Initial Boiling Point: Flash Point: Evaporation Rate: Flammability (solid, gas): Explosive Limits: Vapor Pressure: Vapor Density: Solubility: Partition Coefficient: Auto-ignition Temp: Decomposition Temp: Slower than ether t applicable t applicable Heavier than air Complete 10. STABILITY AND REACTIVITY Chemical Stability: Possibility of Hazardous Reaction: Conditions to Avoid: Materials to Avoid: Hazardous Decomposition: Stable Will not occur Freezing Temperatures. This material will corrode metals and cause product degradation. Oxidizing agents Oxides of Carbon and Nitrogen, Ammonia, and/or Hydrogen Chloride

4 Product Reference : Page 4 / TOXICOLOGICAL INFORMATION Signs / Symptoms of Overexposure: Eye and nasal irritation. Prolonged exposure may cause irritation to the skin, respiratory and digestive tracts. Stomach distress, nausea, vomiting. Acute Effects Eye Contact: Skin Contact: Inhalation: Ingestions: Chronic Effects: Mild irritant. Prolonged or repeated contact may cause redness and irritation. Mild irritant. Prolonged or repeated exposure may cause redness and irritation. Inhalation of liquids or airborne concentrations of mists or vapors may be irritating to the mucous membranes of the respiratory tract. Industrial chemicals should never be taken internally. Irritating to the mucous membranes of the digestive tract. May cause stomach distress, nausea, and vomiting. ne known Medical Conditions Aggravated by Exp.: Acute Toxicity Values Oral LD 50 (Rat) = Dermal LD 50 (Rabbit) = Inhalation LC 50 (Rat) = ne known t Known t Known t Known 12. ECOLOGICAL INFORMATION Persistence and Degradability: Bio-Accumulative Potential: Mobility: The total of the organic components contained in the product is not classified as readily biodegradable (OECD-301 A-F). However, this product is expected to be inherently biodegradable. There is no evidence to suggest bioaccumulation will occur. Accidental spillage may lead to penetration on the soil and groundwater. However, there is no evidence that this would cause adverse ecological effects Ecological Toxicity Values LC 50 (Fish) = t Known 13. DISPOSAL CONSIDERATIONS Waste Disposal: Dispose of in accordance with Federal, State and Local regulations. Recommended European Waste Code (EWC):

5 Product : Product Reference : Page 5 / TRANSPORT INFORMATION U.S. DOT (Land) Department of Transportation Proper Shipping Name: t Regulated Hazard Class: UN / NA Number: Packing Group: Labels Required: Marine Pollutant: I.A.T.A. / I.C.A.O. (Air) Proper Shipping Name: Hazard Class: UN / NA Number: Packing Group: Labels Required: Marine Pollutant: I.M.D.G. (Sea) Proper Shipping Name: Hazard Class: UN / NA Number: Packing Group: Labels Required: Marine Pollutant: International Air Transportation Authority / International Civil Aviation Organization t Regulated International Maritime Organization t Regulated 15. REGULATORY INFORMATION CERCLA Act of 1980: TCSA Inventory: Clean Water Act (CWA): Clean Air Act (CAA): U.S. Federal Regulations This material does not have a reportable quantity. Follow instructions for clean up and disposal in sections 6 & 13. All components of this product are included on the TSCA inventory. This material is not listed as a hazardous substance under the Clean Water Act. This material is not listed as a hazardous substance under the Clean Air Act. SARA Section 311/312 Immediate Hazard: Delayed Hazard: Fire Hazard: Superfund Amendments and Reauthorization Act (SARA) Title III Information (40CFR 370) Hazard Categories

6 Product : Product Reference : Page 6 / 7 Pressure Hazard: Reactivity Hazard: SARA Section 313 (40CFR 372) Reportable Toxic Chemical(s) Component CAS Number Maximum % Carcinogen Status State Regulations Component CAS Number Maximum % State Codes Canadian Environmental Protection Act: Canadian (WHMIS) Class International Regulations All the components of this product are included on the Canadian Domestic Substance List (DSL) Workplace Hazardous Materials Information System Description t controlled under WHMIS This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations and the MSDS contains all the information required by the Controlled Products Regulations. European Inventory of Existing Chemicals (EINECS): EU Classification: All of the components of this product are included on EINECS EU Risk(R) and Safety(S) Phrases: Xi Irritant R36/37/38: Irritating eyes, respiratory system and skin S7: Keep container tightly closed S18: Handle and open with care S20/21: When using do not eat, drink or smoke S24/25: Avoid contact with skin and eyes S36/37/39: Wear suitable protective clothing, gloves and eye/face protection

7 Product : Product Reference : Page 7 / OTHER INFORMATION National Fire Protection Assoc. (NFPA) Ratings: This information is intended solely for the use of individuals trained in the NFPA System. Health: 1 Flammability: 0 Reactivity: 0 Hazardous Material Identification System (HMIS) Rating: This information is intended for the use as a compliance aid for the OSHA Hazard Communication Standard (29CFR ). Health: 1 Flammability: 0 Reactivity: 0 Personal Protection: B <Safety Glasses, Gloves> MSDS Preparation Date: October 1, 2009 MSDS Prepared By: Disclaimer: Pete J. Dolowy II, EHS Coordinator The information presented herein has been compiled from sources considered to be dependable and is accurate to the best of the seller s knowledge. However, seller makes no warranty whatsoever, expresses, implied, or of merchantability regarding the accuracy of such data or the results to be obtained from the use thereof. Seller assumes no responsibility for injury or to third persons or for any damage to any property and buyer assumes all such risks.