M A T E R I A L S A F E T Y D A T A S H E E T SECTION I - PRODUCT IDENTIFICATION

Transcription

1 SECTION I - PRODUCT IDENTIFICATION Product Code: 8290 Product Name/Synonyms: Chix* Plus Foodservice Towel with Microban* Chemical Description: Rayon/Polyester Based Nonwoven Fabric SECTION II - COMPOSITION, INFORMATION ON INGREDIENTS ***Exposure Limits*** Percent TWA Short Term Components by Weight C A S No. (8 Hour) (15 Min.) The composition of this material is proprietary. This material as sold is not hazardous per 29 CFR criteria. SECTION III - HAZARDS IDENTIFICATION Health Effects: Eyes: Skin: Inhalation: Ingestion: None known. None known. Page 1 of 8

2 SECTION IV - FIRST AID MEASURES First Aid Procedures: Eyes: Skin: Inhalation: Ingestion: If irritation occurs, flush eyes immediately with large amounts of water for at least 15 minutes and continue flushing until irritation subsides. If redness or irritation persists, contact a physician. Use good personal hygiene and wash thoroughly after handling. If redness or irritation persist, contact a physician. SECTION V - FIRE FIGHTING MEASURES Flammable (Explosive) Limits (Percent by Volume) Flash Point(Specify Method): Lower Explosive Limit: Flammability Class: Upper Explosive Limit: Fire Extinguishing Media: Water, Carbon Dioxide, Dry Chemical Special Fire Fighting Procedures: None Unusual Fire & Explosion Hazards: None known; expected to be similar to ordinary combustible SECTION VI - ACCIDENTAL RELEASE Steps to be taken in case material is released or spilled: Page 2 of 8

3 SECTION VII - HANDLING AND STORAGE Handling: Storage: None Avoid storing near strong oxidizers. Avoid sources of ignition. Use caution when stacking to avoid unstable conditions. Store at temperatures below 140 o F Store in a sprinklered warehouse. SECTION VIII - EXPOSURE CONTROLS, PERSONAL PROTECTION Eye Protection: Gloves: Respiratory: Ventilation: Other: None required when used as intended. None required when used as intended. None required. None required. SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES Appearance and Odor: White fabric Odor Threshold: Boiling Point: Specific Gravity (Water=1): Freezing Point: Vapor Density (Air=1): ph: Vapor Pressure(mm of mercury): Solubility in Water: N.A Evaporation Rate: Page 3 of 8

4 SECTION X - STABILITY AND REACTIVITY General Reactivity: Stable Incompatibility (Materials to Avoid): Hazardous Decomposition Products: Not tested; expected to be similar to ordinary combustion. Hazardous Polymerization:..X.. Will Not Occur... Will Occur Conditions to Avoid: SECTION XI - TOXICOLOGICAL INFORMATION Reported Human Effects: Based on primary dermal irritation human patch tests on similar product, this fabric indicates a negligible potential for dermal irritation. Reported Animal Effects: No animal toxicity studies have been carried out with this product. Carcinogenicity Information: Not classifiable as a Human Carcinogen by ACGIH, IARC, EPA or NTP. SECTION XII - ECOLOGICAL INFORMATION Ecotoxicity: No ecological studies have been carried out on this product. Page 4 of 8

5 SECTION XIII - DISPOSAL CONSIDERATION Waste Disposal Methods: Dispose in accordance with Federal, State and local regulations. Be aware that state and local requirements may differ widely depending on location and may in many cases be different from federal rules. When a decision is made to discard this material as supplied, it does not meet RCRA s (Resource Conservation and Recovery Act) characteristic definition of ignitability, corrosivity, or reactivity, and is not listed in 40 CFR The toxicity characteristic (TC), however, has not been evaluated by the Toxicity Characteristic Leaching Procedure (TCLP). SECTION XIV - TRANSPORTATION INFORMATION Shipping Information: Shipments of Chix* Plus Foodservice Towel with Microban* are not regulated by the U.S. Department of Transportation (DOT). There is no identification number. No special labels are required. SECTION XV - REGULATORY INFORMATION U.S. Federal Regulations OSHA: This MSDS is provided to comply with provisions of the Hazard Communication Standard (29 CFR ). Page 5 of 8

6 EPA: FDA: TSCA: All components of this product are in compliance with the inventory listing requirements of the U.S. Toxic Substances Control Act (TSCA) Chemical Substance Inventory, 8(b). CERCLA Information (40CFR 302.4): Releases of this material to land or water are not reportable to the National Response Center under the Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA) or to state and local emergency planning committees under the Superfund Amendments and Reauthorization Act (SARA) Title III Section 304. SARA TITLE III, Section 313 Information (40CFR 372): This product does not contain a chemical which is listed in Section 313 at or above de minimis concentrations. CLEAN AIR ACT AMENDMENTS OF 1990: This product and its packaging do not contain, nor are they manufactured with, any of the ozone-depleting substances listed in either Class I chlorofluorocarbons, halons, carbon tetrachloride, and methyl chloroform) or Class II (hydrochlorofluorocarbons) of the Clean Air Act Amendments of FIFRA: This product contains Microban TM EPA Registration No This product is not registered with the FDA. Therefore, it is not approved for use as articles or components of articles intended for repeated contact with food. USDA: This product has not been evaluated by USDA for use in packaging material in direct contact with meat or poultry food products prepared under federal inspection. Page 6 of 8

7 State Regulations California s Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This product contains trace levels of Acetaldehyde CAS # , Ethyl Acrylate CAS# and Formaldehyde CAS # known to the State of California to cause cancer, contributed by the additives and binder. Massachusetts Right-to-Know, Hazardous Substance List (MSL): Hazardous Substances and Extraordinarily Hazardous Substances on the MSL must be identified when present in products. This product contains trace levels of Acetaldehyde CAS # , Ethyl Acrylate CAS# , Formaldehyde CAS # , Vinyl Acetate CAS # , Silica, amorphous CAS # , and Isopropanol CAS # known to cause cancer, contributed by binder and the additives. New Jersey Right-to-Know Hazardous Substance List: Hazardous Substances and Extraordinarily Hazardous Substances on the MSL must be identified when present in products. This product contains trace levels of Acetaldehyde CAS # , Ethyl Acrylate CAS# , Formaldehyde CAS # , Vinyl Acetate CAS # , Silica, amorphous CAS # , and Isopropanol CAS # known to cause cancer, contributed by binder and the additives. SECTION XVI - OTHER INFORMATION PGI Nonwovens (Chicopee, Inc.) Hazard Rating Health 1 Fire 1 Reactivity 0 Special --- Scale 4 = Extreme 3 = High 2 = Moderate 1 = Slight 0 = Insignificant Ratings are based on PGI guidelines, and are intended for internal use. Page 7 of 8

8 References Documentation: Component MSDS(s) 2001 ACGIH Guide To Occupational Exposure Values The Book of Chemical Lists on CD-ROM, August 2001 Important Notice: All statements, technical information and recommendations set forth herein are based on information or tests which PGI Nonwovens - Chicopee, Inc. believes to be reliable as of the date of this material safety data sheet. However, nothing contained in this information is to be taken as a representation, guarantee, or warranty, for which PGI Nonwovens - Chicopee, Inc. bears legal responsibility. PGI Nonwovens - Chicopee, Inc. urges persons receiving this information to make their own determination as to the information s suitability and completeness for their particular application(s). The data in this Material Safety Data Sheet relates only to the specific material designated herein and does not relate to use in combination with any other material or in any process. Abbreviations: ACGIH = American Conference of Governmental Industrial Hygienists OSHA = Occupational Safety and Health Administration TLV = Threshold Limit Value PEL = Permissible Exposure Limit TWA = Time Weighted Average STEL = Short-Term Exposure Limit EPA = Environmental Protection Agency IARC = International Agency for Research on Cancer NTP = National Toxicology Program FDA = Food & Drug Administration USDA = United States Department of Agriculture Responsibility For This MSDS: Elizabeth Howard, Assistant Director, Regulatory Affairs 1301 E. 8 th Street North Little Rock, AR Phone Number: (501) Fax Number: (501) Internet Address: HowardB@PGINW.COM Page 8 of 8