ZEP ORANGE HAND CLR HD099 OBS

Transcription

1 SECTION 1. PRODUCT AND COMPANY IDENTIFICATION Material name : Material number : HD99116 Manufacturer or supplier's details Company : Zep Inc. Address : 35 Joe Frank Harris Parkway, SE Emerson, GA 3137 Telephone : Emergency telephone numbers For SDS Information : Compliance Services For a Medical Emergency : Toll Free - All Calls Recorded For a Transportation Emergency : CHEMTREC: All Calls Recorded. In the District of Columbia Recommended use of the chemical and restrictions on use Recommended use : Hand Care Note: This product is labeled as a consumer product in accordance with the United States Consumer Product Safety Commission regulations. The warnings presented below in this Safety Data Sheet (SDS) comply with the 212 OSHA Hazard Communication Standard (GHS - Globally Harmonized System of Classification and Labeling). The requirements for the labeling and warnings of consumer products may differ from those required for GHS based hazard communication. SECTION 2. HAZARDS IDENTIFICATION Emergency Overview Appearance Colour Odour viscous orange pleasant, characteristic GHS Classification Not a hazardous substance or mixture. GHS label elements Not a hazardous substance or mixture. SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS Substance / Mixture : Mixture Hazardous components 1 / 9

2 Chemical name CAS-No. Concentration [%] Alcohols, C12-16, ethoxylated >= 1 - < 3 The exact percentages of disclosed substances are withheld as trade secrets. SECTION 4. FIRST AID MEASURES General advice If inhaled In case of skin contact In case of eye contact If swallowed Most important symptoms and effects, both acute and delayed Notes to physician : Do not leave the victim unattended. Move out of dangerous area. Get medical attention. Show this safety data sheet to the doctor in attendance. : If unconscious, place in recovery position and seek medical advice. If symptoms persist, call a physician. : This product is formulated for use on skin but should always be immediately washed off with plenty of water. Discontinue use if irritation and redness develop. If conditions persist for more than 72 hours, consult a physician. : Flush eyes with water as a precaution. Remove contact lenses. Protect unharmed eye. Keep eye wide open while rinsing. If eye irritation persists, consult a specialist. : Keep respiratory tract clear. Never give anything by mouth to an unconscious person. If symptoms persist, call a physician. DO NOT induce vomiting unless directed to do so by a physician or poison control center. Take victim immediately to hospital. : Effects may be delayed, symptoms may include minor eye or skin irritation. Overexposure may cause mild eye or skin irritation. : Treat symptomatically. Symptoms may be delayed. SECTION 5. FIREFIGHTING MEASURES Suitable extinguishing media Unsuitable extinguishing media Specific hazards during firefighting : Water spray jet Alcohol-resistant foam Carbon dioxide (CO2) Dry chemical : High volume water jet : Do not allow run-off from fire fighting to enter drains or water courses. 2 / 9

3 Hazardous combustion products Specific extinguishing methods Further information Special protective equipment for firefighters : Carbon dioxide (CO2) Carbon monoxide Smoke : Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. : Collect contaminated fire extinguishing water separately. This must not be discharged into drains. Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations. : Wear self-contained breathing apparatus for firefighting if necessary. SECTION 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up : Material can create slippery conditions. Use non-slip safety shoes in areas where spills or leaks can occur. Refer to protective measures listed in sections 7 and 8. : Prevent further leakage or spillage if safe to do so. Prevent product from entering drains. If the product contaminates rivers and lakes or drains inform respective authorities. : Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Keep in suitable, closed containers for disposal. SECTION 7. HANDLING AND STORAGE Advice on safe handling Conditions for safe storage Materials to avoid : Avoid contact with eyes. For personal protection see section 8. Smoking, eating and drinking should be prohibited in the application area. Dispose of rinse water in accordance with local and national regulations. : Keep container tightly closed in a dry and well-ventilated place. Containers which are opened must be carefully resealed and kept upright to prevent leakage. : Oxidizing agents SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Components with workplace control parameters Contains no substances with occupational exposure limit values. 3 / 9

4 Engineering measures : Not applicable Personal protective equipment Respiratory protection : In case of insufficient ventilation, wear suitable respiratory equipment. Hand protection Remarks Eye protection Skin and body protection Hygiene measures : No special protection is required. : Eye protection is not required while washing with this product. In the workplace, the use of safety glasses is recommended to avoid eye exposure during the handling of containers or during spill clean-up. : No special protection is required. : When using do not eat or drink. When using do not smoke. Wash hands before breaks and at the end of workday. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance : viscous Colour Odour Odour Threshold : orange : pleasant, characteristic : ph : Melting point/freezing point Boiling point Flash point : Evaporation rate Upper explosion limit Lower explosion limit Vapour pressure Relative vapour density Density Solubility(ies) Water solubility Partition coefficient: n- octanol/water Auto-ignition temperature : : Not applicable : : Not applicable : Not applicable : : : 1.2 g/cm3 : emulsifiable : : not determined 4 / 9

5 Thermal decomposition Viscosity Viscosity, kinematic : : SECTION 1. STABILITY AND REACTIVITY Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products : Stable : Stable under normal conditions. : No decomposition if stored and applied as directed. : : Oxidizing agents : Carbon oxides SECTION 11. TOXICOLOGICAL INFORMATION Potential Health Effects Aggravated Medical Condition Symptoms of Overexposure : None known. : Effects may be delayed, symptoms may include minor eye or skin irritation. Carcinogenicity: IARC ACGIH OSHA NTP No component of this product present at levels greater than or equal to.1% is identified as probable, possible or confirmed human carcinogen by IARC. No component of this product present at levels greater than or equal to.1% is identified as a carcinogen or potential carcinogen by ACGIH. No component of this product present at levels greater than or equal to.1% is on OSHA s list of regulated carcinogens. No component of this product present at levels greater than or equal to.1% is identified as a known or anticipated carcinogen by NTP. Acute toxicity Skin corrosion/irritation 5 / 9

6 Remarks: May irritate skin. Serious eye damage/eye irritation Remarks: Contact with eyes may cause irritation. Respiratory or skin sensitisation Germ cell mutagenicity Carcinogenicity Reproductive toxicity STOT - single exposure STOT - repeated exposure Aspiration toxicity Further information Remarks: SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability Bioaccumulative potential Partition coefficient: n- octanol/water Mobility in soil : Remarks: 6 / 9

7 Other adverse effects Regulation Remarks Additional ecological information 4 CFR Protection of Environment; Part 82 Protection of Stratospheric Ozone - CAA Section 62 Class I Substances This product neither contains, nor was manufactured with a Class I or Class II ODS as defined by the U.S. Clean Air Act Section 62 (4 CFR 82, Subpt. A, App.A + B). : SECTION 13. DISPOSAL CONSIDERATIONS Disposal methods Waste from residues Contaminated packaging : The product should not be allowed to enter drains, water courses or the soil. Do not contaminate ponds, waterways or ditches with chemical or used container. Dispose of in accordance with local regulations. : Empty remaining contents. Dispose of as unused product. Do not re-use empty containers. SECTION 14. TRANSPORT INFORMATION Transportation Regulation: 49 CFR (USA): Transportation Regulation: IMDG (Vessel): Transportation Regulation: IATA (Cargo Air): Transportation Regulation: IATA (Passenger Air): Transportation Regulation: TDG (Canada): 7 / 9

8 The product as delivered to the customer conforms to packaging requirements for shipment by road under US Department of Transportation (DOT) regulations. Additional transportation classifications noted above are for reference only, and not a certification or warranty of the suitability of the packaging for shipment under these alternative transport regulations. SECTION 15. REGULATORY INFORMATION TSCA list : No substances are subject to a Significant New Use Rule. No substances are subject to TSCA 12(b) export notification requirements. EPCRA - Emergency Planning and Community Right-to-Know Act CERCLA Reportable Quantity Components CAS-No. Component RQ Calculated product RQ (lbs) (lbs) methanol * *: Calculated RQ exceeds reasonably attainable upper limit. CERCLA Reportable Quantity This material does not contain any components with a CERCLA RQ. SARA 34 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 34 EHS RQ. SARA 311/312 Hazards : No SARA Hazards SARA 32 SARA 313 : No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 32. : This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. California Prop. 65 This product contains a chemical that is at or below California Propositions 65 s "safe harbor level" as determined via a risk assessment. Therefore, the chemical is not required to be listed as a Prop 65 chemical on the SDS or label. The components of this product are reported in the following inventories: DSL TSCA This product contains one or more components that are listed on the Canadian NDSL. All other components are on the Canadian DSL. On TSCA Inventory 8 / 9

9 Health Instability SAFETY DATA SHEET For information on the country notification status for other regions please contact the manufacturer s regulatory group. Inventory Acronym and Validity Area Legend: TSCA (USA), DSL (Canada), NDSL (Canada) SECTION 16. OTHER INFORMATION Further information NFPA: Flammability HMIS III: 1 HEALTH FLAMMABILITY PHYSICAL HAZARD Special hazard. = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic OSHA - GHS Label Information: Not a hazardous substance or mixture. Version: 2.3 Revision Date: 5/14/218 Print Date: 9/3/218 We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind. The information in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. Users should make their own investigations to determine the suitability and applicability of the information for their particular purposes. This SDS has been prepared by the Compliance Services organization supporting this manufacturer, supplier or distributor. Zep Inc. markets products under well recognized and established brand names such as Zep, Zep Commercial,Zep Professional, Enforcer, National Chemical, Selig, Misty, Next Dimension, Petro, i-chem, TimeMist, TimeWick, MicrobeMax, Country Vet, Konk, Original Bike Spirits, Blue Coral, Black Magic, Rain-X, Niagara National, FC Forward Chemicals,Rexodan, Mykal, and a number of private labeled brands. 9 / 9