SAFETY DATA SHEET. 1. Identification. 2. Hazard(s) identification. 3. Composition/information on ingredients

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier STREETBOND SB150 PAVEMENT COATING PART B Other means of identification Product Code Recommended use Manufacturer/Importer/Supplier/Distributor information Manufacturer Company name GAF 1 Campus Drive Parsippany, NJ USA Telephone Emergency phone number CHEMTREC [DAY OR NIGHT] Within USA and CANADA Outside USA and Canada: Hazard(s) identification Physical hazards Health hazards Environmental hazards OSHA defined hazards Label elements Skin corrosion/irritation Serious eye damage/eye irritation Sensitization, skin Hazardous to the aquatic environment, long-term hazard Category 2 Category 2 Category 1 Category 2 Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) Supplemental information Warning If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. In case of fire: Use appropriate media to extinguish. Store in a well-ventilated place. Keep cool. None known. None. 3. Composition/information on ingredients Mixtures 1 / 8

2 Chemical name Common name and synonyms CAS number % Water to <60 4,4'-Isopropylidenediphenol-Epichlo to <40 rohydrin Copolymer Non-Hazardous Ingredients 20 to <30 4. First-aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms/effects, acute and delayed General information 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Call a physician if symptoms develop or persist. Rinse skin with water/shower. Get medical attention if irritation develops and persists. Remove contact lenses, if present and easy to do. Get medical attention if irritation develops and persists. Rinse mouth. Get medical attention if symptoms occur. Exposed individuals may experience eye tearing, redness, and discomfort. Take off all contaminated clothing immediately. Wash contaminated clothing before reuse. Not applicable. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Wear appropriate protective equipment and clothing during clean-up. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. Dike the spilled material, where this is possible. Following product recovery, flush area with water. Absorb with earth, sand or other non-combustible material and transfer to containers for later disposal. Clean surface thoroughly to remove residual contamination. Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Avoid discharge into drains, water courses or onto the ground. Wear appropriate personal protective equipment. Observe good industrial hygiene practices. Store in a cool, dry place out of direct sunlight. Store in original tightly closed container. Store in a well-ventilated place. 8. Exposure controls/personal protection Occupational exposure limits Biological limit values Appropriate engineering controls No exposure limits noted for ingredient(s). No biological exposure limits noted for the ingredient(s). Individual protection measures, such as personal protective equipment Eye/face protection Skin protection Hand protection Wear protective gloves. Other Respiratory protection Thermal hazards Wear suitable protective clothing. None known. 9. Physical and chemical properties Appearance 2 / 6

3 Odor Physical state Form Color Odor threshold ph > 6 Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) Liquid. Liquid. Not applicable. Upper/lower flammability or explosive limits Flammability limit - lower (%) Flammability limit - upper (%) Explosive limit - lower (%) Explosive limit - upper (%) Vapor pressure Vapor density Relative density Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity Other information Density Specific gravity VOC CELCIUS 9.18 lbs/gal estimated 0 g/l Material estimated 0 g/l Regulatory estimated 0 lbs/gal Material estimated 0 lbs/gal Regulatory estimated 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products The product is stable and non-reactive under normal conditions of use, storage and transport. Material is stable under normal conditions. No dangerous reaction known under conditions of normal use. No special precautions are necessary beyond normal good hygiene practices. See Section 8 of the SDS for additional personal protection advice when handling this product. Strong oxidizing agents. No hazardous decomposition products are known. 11. Toxicological information Information on likely routes of exposure Inhalation No adverse effects due to inhalation are expected. Skin contact Eye contact Causes skin irritation. Direct contact with eyes may cause temporary irritation. 3 / 6

4 Ingestion Symptoms related to the physical, chemical and toxicological characteristics Expected to be a low ingestion hazard. Direct contact with eyes may cause temporary irritation. Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/eye irritation Prolonged skin contact may cause temporary irritation. Direct contact with eyes may cause temporary irritation. Respiratory or skin sensitization Respiratory sensitization Not a respiratory sensitizer. Skin sensitization Germ cell mutagenicity Carcinogenicity This product is not expected to cause skin sensitization. No data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. OSHA Specifically Regulated Substances (29 CFR ) Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure This product is not expected to cause reproductive or developmental effects. Aspiration hazard Not an aspiration hazard. 12. Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. No data is available on the degradability of this product. No data available. No data available. No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. 13. Disposal considerations Disposal instructions Local disposal regulations Hazardous waste code Waste from residues / unused products Contaminated packaging Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Dispose of contents/container in accordance with local/regional/national/international regulations. Dispose in accordance with all applicable regulations. The waste code should be assigned in discussion between the user, the producer and the waste disposal company. Dispose of in accordance with local regulations. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe manner (see: Disposal instructions). Since emptied containers may retain product residue, follow label warnings even after container is emptied. Empty containers should be taken to an approved waste handling site for recycling or disposal. 14. Transport information DOT Not regulated as dangerous goods. IATA Not regulated as dangerous goods. IMDG Not regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Not established. 4 / 6

5 15. Regulatory information US federal regulations All components are on the U.S. EPA TSCA Inventory List. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) CERCLA Hazardous Substance List (40 CFR 302.4) SARA 304 Emergency release notification OSHA Specifically Regulated Substances (29 CFR ) Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Delayed Hazard - No Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance SARA 311/312 Hazardous chemical SARA 313 (TRI reporting) Other federal regulations No Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) Safe Drinking Water Act (SDWA) US state regulations US. California Controlled Substances. CA Department of Justice (California Health and Safety Code Section 11100) US. Massachusetts RTK - Substance List US. New Jersey Worker and Community Right-to-Know Act US. Pennsylvania Worker and Community Right-to-Know Law US. Rhode Island RTK US. California Proposition 65 California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. International Inventories Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Canada China Europe Europe Japan Korea Domestic Substances List (DSL) Non-Domestic Substances List (NDSL) Inventory of Existing Chemical Substances in China (IECSC) European Inventory of Existing Commercial Chemical Substances (EINECS) European List of Notified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) No No 5 / 6

6 Country(s) or region Inventory name On inventory (yes/no)* New Zealand New Zealand Inventory Philippines United States & Puerto Rico Philippine Inventory of Chemicals and Chemical Substances (PICCS) Toxic Substances Control Act (TSCA) Inventory *A "" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision Issue date Revision date Version # 10 HMIS ratings Health: 2 Flammability: 0 Physical hazard: 0 Personal protection: D NFPA ratings Health: 2 Flammability: 0 Instability: 0 Disclaimer This information relates to the specific material designated and may not be valid for such material used on combination with any other materials or in any process. Such information is to the best of our knowledge and belief accurate and reliable as of the date compiled. However, no representation, warranty or guarantee, expressed or implied, is made as to its accuracy, reliability, or completeness. GAF cannot anticipate all conditions under which this information and product, or the products of other manufacturers in combination with this product, may be used. It is the user s responsibility to satisfy himself as to the suitability and completeness of such information for his particular use. The information given is designed only as guidance for safe handling, use, processing, storage, transportation, disposal and release. We do not accept liability for any loss or damage that may occur from the use of this information. Nothing herein shall be construed as a recommendation for uses which infringe valid patents or as extending a license of valid patents. Revision Information Product and Company Identification: Converted to GAF SDS 6 / 6