SAFETY DATA SHEET. None. None. The mixture does not meet the criteria for classification.

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Other means of identification Recommended use Recommended restrictions Flow Improver. Manufacturer/Importer/Supplier/Distributor information Manufacturer Address Other uses are not recommended unless an assessment demonstrates potential exposures will be controlled. LiquidPower Specialty Products Inc. One BriarLake Plaza 2000 W Sam Houston Pkwy S Suite 400 Houston, TX Telephone or Website SDS@LiquidPower.com Emergency telephone Hazard(s) identification Physical hazards Health hazards OSHA defined hazards Not classified. Not classified. Not classified. Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) Supplemental information The mixture does not meet the criteria for classification. Observe good industrial hygiene practices. Wash hands after handling. Store away from incompatible materials. Dispose of waste and residues in accordance with local authority requirements. None known. 3. Composition/information on ingredients Mixtures The manufacturer lists no ingredients as hazardous according to OSHA 29 CFR First-aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms/effects, acute and delayed Move to fresh air. Call a physician if symptoms develop or persist. Wash off with soap and water. Get medical attention if irritation develops and persists. Rinse with water. Get medical attention if irritation develops and persists. Rinse mouth. Get medical attention if symptoms occur. Direct contact with eyes may cause temporary irritation Version #: 02 Revision date: 19-April-2017 Issue date: 19-April / 6

2 Indication of immediate medical attention and special treatment needed General information 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment/instructions Specific methods General fire hazards 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Treat symptomatically. 8. Exposure controls/personal protection Occupational exposure limits Biological limit values Exposure guidelines Appropriate engineering controls Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2). Do not use water jet as an extinguisher, as this will spread the fire. During fire, gases hazardous to health may be formed. Self-contained breathing apparatus and full protective clothing must be worn in case of fire. Move containers from fire area if you can do so without risk. Use standard firefighting procedures and consider the hazards of other involved materials. No unusual fire or explosion hazards noted. Keep unnecessary personnel away. For personal protection, see section 8 of the SDS. Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is possible. Absorb in vermiculite, dry sand or earth and place into containers. Following product recovery, flush area with water. Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Avoid discharge into drains, water courses or onto the ground. Avoid prolonged exposure. Ensure adequate ventilation. Observe good industrial hygiene practices. Store in original tightly closed container. Store away from incompatible materials (see Section 10 of the SDS). No exposure limits noted for ingredient(s). No biological exposure limits noted for the ingredient(s). Follow standard monitoring procedures. Use process enclosures, local exhaust ventilation, or other engineering controls to control airborne levels below recommended exposure limits. Individual protection measures, such as personal protective equipment Risk of contact: Wear approved safety goggles. Eye/face protection Skin protection Hand protection Other Respiratory protection Thermal hazards General hygiene considerations 9. Physical and chemical properties Appearance Use suitable protective gloves if risk of skin contact. Suitable gloves can be recommended by the glove supplier. If prolonged or repeated contact is likely, chemical resistant clothing is recommended. In case of inadequate ventilation, use respiratory protection. Wear appropriate thermal protective clothing, when necessary. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. Discard contaminated clothing and footwear that cannot be cleaned Version #: 02 Revision date: 19-April-2017 Issue date: 19-April / 6

3 Odor Physical state Form Color Odor threshold Liquid. Liquid. White. Mild. ph Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) 32 F (0 C) 212 F (100 C) Not applicable. Same as water. Not applicable. Upper/lower flammability or explosive limits Flammability limit - lower Not applicable. (%) Flammability limit - upper (%) Vapor pressure Vapor density Relative density Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity Other information Explosive properties Oxidizing properties 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products 11. Toxicological information Not applicable mmhg (25 C) < 1 ( Air=1) (15.6 C) Disperses completely. 350 cp 511s-1 (Non-Newtonian) (25 C) Not explosive. Not oxidizing. The product is stable and non-reactive under normal conditions of use, storage and transport. Material is stable under normal conditions. No dangerous reaction known under conditions of normal use. Contact with incompatible materials. Strong oxidizing agents. No hazardous decomposition products are known. Information on likely routes of exposure Inhalation No adverse effects due to inhalation are expected. Skin contact Eye contact Ingestion Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Acute toxicity No adverse effects due to skin contact are expected. Direct contact with eyes may cause temporary irritation. Expected to be a low ingestion hazard. Direct contact with eyes may cause temporary irritation. Not expected to be acutely toxic Version #: 02 Revision date: 19-April-2017 Issue date: 19-April / 6

4 Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity IARC Monographs. Overall Evaluation of Carcinogenicity NTP Report on Carcinogens OSHA Specifically Regulated Substances (29 CFR ) Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard Chronic effects Further information 12. Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects 13. Disposal considerations Disposal instructions Local disposal regulations Hazardous waste code Waste from residues / unused products Contaminated packaging Not an aspiration hazard. None known. None known. The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. No data available. No data available. No data available. No other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. Waste material from this product should not be exposed to waste streams or sumps containing any concentration of hydrocarbon. This will cause formation of gelled substances that may plug pipes. Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Dispose in accordance with all applicable regulations. The waste code should be assigned in discussion between the user, the producer and the waste disposal company. Dispose of in accordance with local regulations. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe manner (see: Disposal instructions). Since emptied containers may retain product residue, follow label warnings even after container is emptied. Empty containers should be taken to an approved waste handling site for recycling or disposal Version #: 02 Revision date: 19-April-2017 Issue date: 19-April / 6

5 14. Transport information DOT Not regulated as dangerous goods. IATA Not regulated as dangerous goods. IMDG Not regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code 15. Regulatory information US federal regulations Not established. This product is not known to be a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR All ingredients are on the TSCA inventory, or are not required to be listed on the TSCA inventory. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) OSHA Specifically Regulated Substances (29 CFR ) CERCLA Hazardous Substance List (40 CFR 302.4) Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - No Delayed Hazard - No Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance SARA 311/312 Hazardous chemical SARA 313 (TRI reporting) Other federal regulations No Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) Safe Drinking Water Act (SDWA) US state regulations US. Massachusetts RTK - Substance List California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65): This material is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. US. New Jersey Worker and Community Right-to-Know Act US. Pennsylvania Worker and Community Right-to-Know Law US. Rhode Island RTK International Inventories Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Canada Domestic Substances List (DSL) Non-Domestic Substances List (NDSL) Version #: 02 Revision date: 19-April-2017 Issue date: 19-April / 6

6 Country(s) or region Inventory name On inventory (yes/no)* China Inventory of Existing Chemical Substances in China (IECSC) Europe Europe Japan Korea New Zealand Philippines United States & Puerto Rico European Inventory of Existing Commercial Chemical Substances (EINECS) European List of Notified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances (PICCS) Toxic Substances Control Act (TSCA) Inventory *A "" indicates this product complies with the inventory requirements administered by the governing country(s). A "No" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision Issue date Revision date Version # 02 Further information NFPA ratings 19-April April-2017 NFPA Hazard Scale: 0 = Minimal 1 = Slight 2 = Moderate 3 = Serious 4 = Severe No List of abbreviations LD50: Lethal Dose, 50%. LC50: Lethal Concentration, 50%. PBT: Persistent, bioaccumulative, toxic. vpvb: very Persistent, very Bioaccumulative. TWA: Time weighted average. STEL: Short term exposure limit. TLV: Threshold Limit Value. References Disclaimer HSDB - Hazardous Substances Data Bank IARC Monographs. Overall Evaluation of Carcinogenicity LiquidPower Specialty Products Inc. cannot anticipate all conditions under which this information and its product, or the products of other manufacturers in combination with its product, may be used. It is the user s responsibility to ensure safe conditions for handling, storage and disposal of the product, and to assume liability for loss, injury, damage or expense due to improper use. The information in the sheet was written based on the best knowledge and experience currently available Version #: 02 Revision date: 19-April-2017 Issue date: 19-April / 6