Material Safety Data Sheet according to 31 REACH

Transcription

1 Material Safety Data Sheet according to 31 REACH Natural Control Silicon for Validity Print date Last revision Version 01 IDENTIFICATION OF THE SUBSTANCE/MIXTURE AND OF THE COMPANY/UNDERTAKING EU, CH V13 EN 1.1 Product identifier Natural Control Silicon for Item number: 1.2 Relevant identified uses of the substance or mixture and uses advised against , , , , , , , , , , , , , , , , , , , , Fixing of in outdoor areas 1.3 Details of the supplier of the safety data sheet Telephone Fax 1.4 Emergency telephone number SWISSINNO SOLUTIONS AG Rosenbergstrasse St. Gallen Switzerland (0) (UK) 02 HAZARDS IDENTIFICATION 2.1 Classification of the substance or mixture The classification corresponds to the actual EG lists, and has been supplemented by informations from specific literature and by company informations 2.2 Label elements corresponding to directive 1999/45/EC: Label elements Product is not hazardous corresponding to EC regulation 1999/45 Risk phrases Safety phrases corresponding to regulation (EC 1272/2008) (CPL): Signal Word - Hazard statements - Precautionary statements Other hazards This product does not contain any PBT or vpvb substances. SWISSINNO SOLUTIONS AG Page 1 of 6,

2 03 COMPOSITION/INFORMATION ON INGREDIENTS 3.2 Mixtures Dangerous Ingredients Description Distillate (petroleum), treated with hydrogen Silicium dioxide Oximsiloxan CAS-No. EG-No. R-phrases Concentration Xn, R65 Xn, 48/ % 1-10% 1-10% The full text of all R-phrases is displayed in section FIRST AID MEASURES 4.1 Description of first aid measures Inhalation Remove to fresh air. Seek medical help if irritation develops. Skin contact Rinse immediately and abundantly with water and soap. Seek medical advise if irritation develops. Eye contact Rinse immediately and abundantly with water for a few minutes. Consult a doctor. Ingestion Do not induce vomiting, do not drink. Consult a doctor immediatly. 4.2 Most important symptoms and effects, both acute and delayed Treat symptomatically. 4.3 Indication of any immediate medical attention and special treatment needed no special measures required 05 FIRE-FIGHTING MEASURES 5.1 Extinguishing media Suitable extinguishing media Unsuitable extinguishing media 5.2 Special exposure hazards arising from the substance or mixture Foam, sprayed water, water mist. Carbon Dioxide (CO2) and Dry powder only for small incidents. Straight water jet. When heating or in case of fire, formation of toxic or flammable gases possible. 5.3 Advice for firefighters Before taking any action, wear protective clothing. Wear a self-sufficient respiratory apparatus (enclosed premises). 06 ACCIDENTAL RELEASE MEASURES 6.1 Personal precautions, protective equipment and emergency procedures 6.2 Environmental precautions Before taking any action, wear appropriate protective equipment (see 8) Avoid skin and eye contact, have sufficient ventilation. Avoid ignition sources. Do not let reach canalisation, drains, groundwater. SWISSINNO SOLUTIONS AG Page 2 of 6,

3 6.3 Methods and material for containment and cleaning up Take up mechanically. Clean contaminated surfaces thoroughly. Contaminated materials have to be treated as given in section Reference to other sections 07 HANDLING AND STORAGE 7.1 Precautions for safe handling Have good ventilation at working place. Avoid skin and eye conatct and respiration of vapours. See point Conditions for safe storage, including any incompatibilities Store tightly in a closed container in a cool, dry and frost free area. Protect from heat or direkt sun radiation. 7.3 Specific end use(s) Fixing of in outdoor areas. 08 EXPOSURE CONTROLS/PERSONAL PROTECTION 8.1 Control parameters 8.2 Exposure controls Appropriate engineering controls Respiratory protection Hand protection Eye / face protection Skin protection In case of insufficient ventilation, wear mask with combined filter for organic vapours and particles. Protective gloves (solvent proof) Protective goggles Protective work clothing Environmental exposure controls Do not let reach canalisation, drains, groundwater. 09 PHYSICAL AND CHEMICAL PROPERTIES 9.1 Information on basic physical and chemical properties Appearance Odour Odour threshold ph Melting point/freezing point Initial boiling point and boiling range Plastic cartridge with transparent paste characteristic paste Flash point 93 oc (PMCC) Evaporation rate Flammability (solid, gas) When submit to heat can produce flammable vapours. SWISSINNO SOLUTIONS AG Page 3 of 6,

4 Vapour pressure Vapour density Relative density Solubility Partition coefficient: n- octanol/water Auto-ignition temperature ca. 1,03 g/ml not water soluble unknown Decomposition temperature not soluble Viscosity Explosive properties Oxidising properties 9.2 Other information - 10 STABILITY AND REACTIVITY 10.1 Reactivity Unused product hand over to special disposal dump Chemical stability Can be disposed in household garbage dump Possibility of hazardous reactions 10.4 Conditions to avoid Take notice of the national and regional regulations for disposal. Avoid damp conditions, high temperatures, open fire Materials to avoid 10.6 Hazardous decomposition products strong oxidants, water 2-Butanonoxim, see point TOXICOLOGICAL INFORMATION 11.1 Information on toxicological effects Acute toxicity Sensitisation Skin contact may cause irritation. Ingestion followed by vommitting and aspiration into lungs may cause suffocation or toxic lung damage. Oral LD50 estimated > 2000mg/kg; Sensitation effects by skin contact. General information This statement is based on the properties of the single ingredients. 12 ECOLOGICAL INFORMATION Ecological information on ingredients Ecotoxicity water pollutant class Toxicity - SWISSINNO SOLUTIONS AG Page 4 of 6,

5 12.2 Persistence and degradability 12.3 Bioaccumulative potential 12.4 Mobility in soil 12.5 Results of PBT and vpvb assessment 12.6 Other adverse effects none 13 DISPOSAL CONSIDERATIONS 13.1 Waste treatment methods 14 TRANSPORT INFORMATION Empty cartridges can be disposed in household garbage dump. Unused product hand over to special disposal dump. Special precautions for user Transport by road. ADR/RID Transport by rail. RID Transport by sea. IMDG Transport by air. ICAO 14.1 UN number 14.2 Proper shipping name none 14.3 Transport hazard class No hazardous good 14.4 Packing group 14.5 Environmental hazards 14.6 Special precautions for user 14.7 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code SWISSINNO SOLUTIONS AG Page 5 of 6,

6 15 REGULATORY INFORMATION 15.1 Safety, health and environmental regulations/ legislation specific for the substance or mixture EU Legislation: Regulation (EC) No 1907/2006 of the European Parliament and of the Council of 18 December 2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH), establishing a European Chemicals Agency, amending Directive 1999/45/EC and repealing Council Regulation (EEC) No 793/93 and Commission Regulation (EC) No 1488/94 as well as Council Directive 76/769/EEC and Commission Directives 91/155/EEC, 93/67/EEC, 93/105/EC and 2000/21/EC, including amendments Chemical safety assessment Contains Butan-2-on-O,O,O-(methylsilylidyn)trioxim N-(2-Aminoethyl-3aminopropyl)- trimethylsiloxan 2-Butanonoxim, may cause allergic reactions. 16 OTHER INFORMATION R phrases in full Hazard statements in full These R-phrases are mentioned in section 3 for the ingredients: R65 Harmful: may cause lung damage if swallowed. R48/22 Harmful: danger of serious damage to health by prolonged exposure if swallowed. R53 May cause long-term adverse effects in the aquatic environment. S phrases Precautionary statements - Training advice not necessary Recommended restrictions on use Not for use in living quarters Further information - All information, which has been added, deleted or revised is indicated by * on the right side of the page SWISSINNO SOLUTIONS AG Page 6 of 6,