Page 1 / 7 Safety Data Sheet. Manometer Fluid. Issuing Date Revision Date Version 1 058E00230, 058E00240

Transcription

1 Page 1 / 7 Safety Data Sheet SDS # : D-4007 Issuing Date Revision Date Version 1 1. Product and Company Identification Active Trade Name Part no. for Xerox Products 058E00230, 058E00240 Color Pure substance/preparation Identified uses Supplier Address Yellow Preparation Gauge fluid Xerox Corporation Rochester, NY Xerox Canada LTD Yonge Street North York, Ontario M2M4G7 Emergency telephone Safety Information US: (800) Chemical Emergency only (Chemtrec) (800) Hazards Identification Emergency Overview The product contains no substances which, in the form utilized and at their given concentrations, are considered to be hazardous to health. Color Yellow Appearance Liquid contained in molded tubing Classification of the substance or mixture Physical state Liquid Odor Characteristic Consumers Not classified GHS Label elements, including precautionary statements Signal Word None Hazard Statements Precautionary Statements None required None required Other hazards which do not result in classification Potential Health Effects Principle Routes of Exposure Ingestion

2 SDS # : D-4007 Page 2 / 7 Acute toxicity Eyes Skin Inhalation Ingestion Chronic effects Main symptoms Aggravated medical conditions Environmental hazard May cause mild eye irritation May produce mild irritation on prolonged contact with skin. No known effect No known effect May cause central nervous system depression None under normal use conditions See Section 12 for additional Ecological Information 3. Composition/Information on Ingredients Chemical Name CAS-No Weight % Water Ethylene glycol First Aid Measures General advice Eye contact Skin contact Inhalation Ingestion Notes to physician Protection of first-aiders When symptoms persist or in all cases of doubt seek medical advice. Show this material safety data sheet to the doctor in attendance. Rinse thoroughly with plenty of water, also under the eyelids Wash skin with soap and water Move to fresh air Clean mouth with water and afterwards drink plenty of water Induce vomiting, but only if victim is fully conscious Treat symptomatically 5. Fire-Fighting Measures Flammable properties May burn if exposed to extreme heat or flame Flash point 111 C / 232 F Suitable extinguishing media Unsuitable extinguishing media Use water fog, alcohol foam, CO 2 or dry chemical. Specific hazards arising from the chemical Hazardous combustion products Explosion Data Sensitivity to Mechanical Impact Sensitivity to Static Discharge Carbon monoxide, Carbon dioxide (CO2) Not impact sensitive Not sensitive Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear.

3 SDS # : D-4007 Page 3 / 7 6. Accidental Release Measures Personal Precautions None required for material as supplied Methods for containment Methods for cleaning up Other Information Contain and collect spillage with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and place in container for disposal according to local / national regulations (see Section 13) Soak up with inert absorbent material. The environmental impact of this product has not been fully investigated. However, this preparation is not expected to present significant adverse environmental effects. 7. Handling and Storage Advice on safe handling Technical measures/storage conditions Hygiene measures Handle in accordance with good industrial hygiene and safety practice Store in a cool, dry area away from potential sources of heat, open flames, sunlight or other chemicals None under normal use condtions 8. Exposure Controls/Personal Protection Exposure guidelines Chemical Name ACGIH TLV OSHA PEL Ethylene glycol Ceiling: 100 mg/m 3 Other Information No hazardous exposure expected under normal use conditions. Occupational Exposure Controls Engineering measures None under normal use conditions. Personal Protective Equipment Consumer use Respiratory protection Eye/Face protection Skin and body protection Hand protection These recommendations apply to the product as supplied 9. Physical and Chemical Properties Values listed are for solvent (ethylene glycol)

4 SDS # : D-4007 Page 4 / 7 Appearance Liquid contained in molded tubing Odor Characteristic Odor threshold Physical state Liquid ph Not determined Color Yellow Flash point 111 C / 232 F Boiling C / >387 F point/range Softening point Not applicable Autoignition temperature 398 C / >748 F Volatility Flammability Limits in Air Negligible Upper >5% Lower >3.2% Vapor pressure ~47 20 C Vapor density Not determined Water solubility Completely soluble Viscosity Partition coefficient Evaporation rate Slower than water Melting point/range Not applicable Freezing point Not applicable Decomposition temperature Not determined Specific gravity ~ 25 C 10. Stability and Reactivity Reactivity Stability Incompatible products Conditions to Avoid No dangerous reaction known under conditions of normal use Stable under normal conditions Strong acids, Strong oxidizing agents Excessive heat Hazardous Decomposition Products May emit toxic fumes under fire conditions Hazardous polymerization Hazardous reactions Hazardous polymerization does not occur None under normal processing 11. Toxicological Information Acute toxicity Product information Irritation Mild eye irritant Chemical Name LD50 Oral LD50 Dermal LC50 Inhalation Ethylene glycol mg/kg ( Rat ) mg/kg ( Rat ) 9530 µl/kg ( Rabbit ) Chronic toxicity Main symptoms May cause central nervous system depression Aggravated medical conditions None under normal use conditions Carcinogenicity Contains no ingredient listed as a carcinogen Other toxic effects Product information Sensitization Not a sensitizer

5 SDS # : D-4007 Page 5 / 7 Mutagenic effects Teratogenicity Target organ effects Aspiration Hazard Other adverse effects Not mutagenic in AMES Test Kidney Not applicable Teratogenic effects 12. Ecological Information Ecotoxicity The environmental impact of this product has not been fully investigated. Chemical Name Toxicity to algae Toxicity to fish Toxicity to microorganisms Ethylene glycol mg/l EC50 96 h (Pseudokirchneriella subcapitata) LC50= mg/l Oncorhynchus mykiss 96 h LC ml/l Oncorhynchus mykiss 96 h LC50= mg/l Lepomis macrochirus 96 h LC50= mg/l Oncorhynchus mykiss 96 h LC mg/l Pimephales promelas 96 h LC50= mg/l Poecilia reticulata 96 h EC50 = 620 mg/l 30 min EC50 = mg/l 16 h EC50 = mg/l 30 min Toxicity to daphnia and other aquatic invertebrates EC50 = mg/l 48 h Persistence and degradability Bioaccumulation Mobility No product level data available No product level data available No product level data available Chemical Name log Pow Ethylene glycol Other adverse effects 13. Disposal Considerations Waste Disposal Methods This material, as supplied, is not a hazardous waste according to Federal regulations (40 CFR 261). This material could become a hazardous waste if it is mixed with or otherwise comes in contact with a hazardous waste, if chemical additions are made to this material, or if the material is processed or otherwise altered. Consult 40 CFR 261 to determine whether the altered material is a hazardous waste. Consult the appropriate state, regional, or local regulations for additional requirements. Contaminated packaging Dispose of in accordance with local regulations. 14. Transport Information Note This material is not subject to regulation as a hazardous material for shipping. 15. Regulatory Information

6 SDS # : D-4007 Page 6 / 7 International Inventories TSCA Complies U.S. Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product contains a chemical or chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372: Chemical Name CAS-No SARA Threshold Values % Ethylene glycol SARA 311/312 Hazard Categories Clean Water Act This product does not contain any substances regulated as pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ). Clean Air Act, Section 112 Hazardous Air Pollutants (HAPs) (see 40 CFR 61) This product contains the following substances which are listed hazardous air pollutants (HAPS) under Section 112 of the Clean Air Act: Chemical Name CAS-No Weight % HAPS data Class 1 Ozone Depletors Class 2 Ozone Depletors Ethylene glycol Present CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302): Chemical Name Hazardous Substances RQs Extremely Hazardous Substances RQs Ethylene glycol 5000 lb TSCA TSCA 12(b) does not apply to this product. U.S. State Regulations California Proposition 65 This product does not contain any Proposition 65 chemicals. U.S. State Right-to-Know Regulations This product is subject to U.S. State Right-to-know regulations as noted below. Chemical Name Massachusetts New Jersey Pennsylvania Illinois Rhode Island Ethylene glycol X X X X X Canada This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the SDS contains all the information required by the CPR. NPRI This product contains the following substances listed on the NPRI for Canada: Chemical Name NPRI Ethylene glycol X 16. Other Information Issuing Date Revision Date Revision Note Updated for OSHA HazCom 2012 and WHMIS 2015

7 SDS # : D-4007 Page 7 / 7 Disclaimer The information provided on this SDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. end