New Pig One Pork Avenue Tipton, PA Chemical Compatibility Guide for: Drum Lid Gasket

Transcription

1 Chemical Compatibility Guide : Drum Lid Gasket The guide on following (s) was provided by supplier. New Pig Corporation assumes no responsibility, obligation, or liability in conjunction with use or misuse inmation. New Pig One Pork Avenue Tipton, PA newpig.com North America: UK: urope: +31 (0) Outside North America: PIG, PIG logo are registered trademarks in USA and or countries. See tm.newpig.com Last revised 3/14/2013

2 CHMICAL RSISTANC Many new materials have been developed to handle wide range modern chemicals being used in industry today. Many se materials are now being used in construction Kuri Tec hose and tubing products. The following guide has been prepared to assist user in selection correct hose application. The recommendations are based on best chemical data available at time printing. This guide will be continuously reviewed and new inmation added as it becomes available. A material s resistance to effects a chemical depends not only upon particular chemical, but also on or factors such as length exposure, service temperature, pressure, fluid velocity, and relative concentration each component in multicomponent mixtures. Theree, no guarantee is expressed or implied. Chemical Resistance Guide The chemical resistance ratings materials are based on pure material samples and may not take into account specific factors related to material when used in a hose or tube. It is always advisable that product be tested under actual conditions. Additionally, Chemical Resistance Guide which follows does not imply conmance to any food handling regulations or federal or state/provincial laws governing hose and tubing applications. Bee using any Kuri Tec hose/tubing product with any chemical substance user must determine suitability product his/her intended use. The user assumes all risk and liability use any Kuri Tec product with any chemical or or substance. Key to Chemical Resistance Guide Ratings = xcellent Little or no effect due to exposure to chemical. G = Good Satisfactory service expected, but some deterioration may occur after lengthy exposure or under extreme conditions. L = Limited Variable resistance depending upon conditions use (e.g. nature chemical, its concentration, service temperature, pressure, etc.). U = Unsuitable Not resistant. Not recommended use under any conditions. C = Cautionary Although chemical resistance material may be good, special factors exist that must be considered in hose applications, such as regulatory issues, permeation vapors, and safety, health or environmental concerns. = No Data refer to back availability products/sizes shown. 66 KKTCA0408

3 Key: =xcellent G=Good L=Limited U=Unsatisfactory C=Cautionary =No Data LLDPVA TPU LLDP VA TPU Acetaldehyde u u u u l u g l g u u u Arylsulfonic Acid L U L U U U Acetate Solvents - Pure U U U U G L G L U L U Asphalt l u l u l u l u u u g l Acetic Acid - Glacial L U L U U U L U U U U U ASTM #1 Oil l u l u G G Acetic Acid 0-10% G G G G G U U ASTM #3 Oil l u l u G G Acetic Acid 10-20% G L G G G L G G U U ASTM Fuel A l u l u G G Acetic Acid Pct G L G L G L G L U U Acetic Acid 30-60% G L G L L L G L L U U U Acetic Acid 80% L L L L U U U U L U U U Acetic Acid Vapors G G G G G L G L G L U U Acetic Anhydride U U U U U U U U L L U U Acetone u u u u l u G L U L U Acetylene Acrylonitrile l u l u Adipic Acid g l g l g l G G U U Alcohol (See Type) Allyl Alcohol 96% U U U U G G G U U Allyl Chloride u u u u g l g l l u u u Alum G Aluminum Chloride G G G G G C G G Aluminum Fluoride G G G G G G G G G L G L Aluminum Hydroxide G G G G G G G L Aluminum Nitrate L L Aluminum Oxychloride G G G G G Aluminum Sulfate g g Ammonia - Aqueous L U L U G G G U U Ammonia - Dry Gas L U L U G U U Ammonia - Liquid U U U U G L L U U U Ammonium Carbonate Ammonium Chloride G L Ammonium Fluoride 25% U U U U G G G G G L U Ammonium Hydroxide 28% L U L U G G L U Ammonium Metaphosphate G G G G G G Ammonium Nitrate G G Ammonium Persulfate G G Ammonium Phosphate G G G G G G G G G Ammonium Phosphate Neutral G G G G G Ammonium Sulfate Ammonium Sulfide Ammonium Thiocyanate G G Amyl Acetate u u u u u u l u u U U Amyl Alcohol l u l u g l g l g l u u Amyl Chloride u u u u u u u u u Aniline Aniline Chlorohydrate Aniline Hydrochloride Animal Oils l u l u u u l u l u g l Anthraquinone Anthraqunonesulfonic Acid U U Antimony Trichloride ASTM Fuel B ASTM Fuel C Barium Carbonate Barium Chloride Barium Hydroxide u u u u G L u u u u G L G L Barium Sulfate Barium Sulfide Beer L L Beet-Sugar Liquor Benzaldehyde U U U U U U G L U U U Benzene u u l u u u L U U L U Benzoic Acid g l g l g g g g g U U Benzol u u l u u u u u u u l u Bismuth Carbonate Black Liquor (Paper industry) Bleach % Active CL Borax Boric Acid Boron Trifluoride Brake Fluid G L G L G L G L G L U G U u u u u U U Brine G U Bromic Acid L L G G G G G U U Bromine - Liquid Bromine - Water Butadiene l u l l u u u u u u Butane Butanol - Primary U U U U G G G L U Butanol - Secondary U U U U G G G L U Butter l l L L Butyl Acetate u u l u u u u u u u l u Butyl Alcohol l u l l G G L U Butyl Cellosolve U U U U G L G Butyl Phenol l u l u u u u u u u Butylene C C C C U U U U C C Butyric Acid 20% L U L U U U U U U U L U Calcium Bisulfite Calcium Carbonate Calcium Chlorate G L Calcium Chloride G Calcium Hydroxide G L Calcium Hypochlorite G G U U Calcium Nitrate Calcium Sulfate Cane Sugar Liquors G G G G G Carbon Bisulfide U U U U U U U U U U Apple (Sauce or Juice) Carbon Dioxide Aqua Regia l u l u u u u u u u u u (Aqueous Solution) Aromatic Hydrocarbons refer to back U U Carbon Dioxide Gas (Wet) availability products/sizes shown. Arsenic Acid 80% G G G G G U U Carbon Monoxide G G G G G CHMICAL RSISTANC KKTCA

4 CHMICAL RSISTANC Key: =xcellent G=Good L=Limited U=Unsatisfactory C=Cautionary =No Data LLDPVA TPU LLDP VA TPU Carbon Tetrachloride U U L U U U L U U U L U Diethylene Glycol G L G L L G G L U U Carbonic Acid l u g g g g g g g g u u Diglycolic Acid G G G Casein L Di-isodecyl Phthalate U U Castor Oil U U L U L U Dimethylamine Catsup G Dioctyl Phthalate U U U U G L G U Caustic Potash Caustic Soda Cellosolve Chloracetic Acid Chloral Hydrate L L L L L L L L L L U l l l l g l l l g L U l u g l g l g l l u g l U U U U G L U U U U U U U U L U G L Chloric Acid 20% U U Chlorinated Hydrocarbons Chlorine Gas (Dry) G G G G U U U U U U U U Chlorine Gas (Moist) L U L L U U U U U U U U Chlorine Water 2% G L G L L U G L G L L U Chlorine Water Saturated L U L U G L Chlorobenzene Chlororm u u u u u u l u u u u u Chlorsulfonic Acid L U L U U U U U U U U U Chrome Alum G G G G Chromic Acid 10% Chromic Acid 25% Chromic Acid 30% Chromic Acid 40% Chromic Acid 50% G L G L G L G L G U U G L G L G L G L G U U L U L U L U L U L U U U L U L U L U L U L U U U L U L U L U L U L U U U Chromic Acid Plating Solution U U Cider L G L Citric Acid U U Coal Tar Coconut Oil g l G G L G L L U Copper Chloride Copper Cyanide Copper Fluoride 2% Copper Nitrate G G G Copper Sulfate G Corn Oils G L U Cottonseed Oil G L G G Creosote u u u u u u u u u u Cresol u u U U U U U U L U Cresylic Acid 50% Crude Oil - Sour Crude Oil - Sweet Cyclohexane Cyclohexanol U U L L U U U U U U U U L U L U U U U U U U L U L U U U U U U U u u u u l u g g l u g l u u u u l u g l L L U Cyclohexanone U U U U U U G L L U U Demineralized Water L Dextrin Dextrose G Di-acetone Alcohol G Disodium Phosphate Distilled Water L rs u u l u u u g l u u g l thyl Acetate u u l u l u G L U L U thyl Acrylate u u u u thyl Alcohol 0-50% thyl Alcohol 50-98% thyl Chloride thyl r thylene Bromide thylene Dichloride thylene Glycol thylene Oxide Fatty Acids Ferric Chloride Ferric Nitrate Ferric Sulfate Ferrous Chloride Ferrous Sulfate Fish Solubles Fluorine Gas - Dry Fluorine Gas - Wet Fluoroboric Acid Fluorosilicic Acid Foric Acid G L G G L G L G L L U G L L U G L U G u u u u u u u u u u g l U U U U U U U U U U U G G G G L G L G L L U G L U G G G L G L G U U L L G G U U Formaldehyde (40% Aqueous) U U G G G L G L G Formic Acid 3% Formic Acid 10% Formic Acid 25% Formic Acid 50% Formic Acid 100% U U Freon-12 l u g l g l g l g Fructose Fruit Pulps and Juices Fuel Oil g l g l u u g u u u G Furfural Furfuryl Alcohol U U Gallic Acid Gas - Coke Oven G G G G G G Gas - Natural (Dry) Gas - Natural (Wet) Gasoline Gasoline - Refined Gasoline - Sour u u u u u u g l G L U G U L U L U U U G L U G U U U U U U U G Diazo Salts G G Gelatine Dichlorobenzene U U U U L U U U Glucose Diesel Oils refer to back l u l u G L Glycerine (Glycerol) availability products/sizes shown. Diethyl r u u u u G L U U G L Glycol G G 68 KKTCA0408

5 Key: =xcellent G=Good L=Limited U=Unsatisfactory C=Cautionary =No Data LLDPVA TPU LLDP VA TPU Glycolic Acid 30% U U Linseed Oil U U L U L U Grease L G G Liquors (Chemical) G G G G Green Liquor (Paper industry) Lubricating Oils Magnesium Carbonate G L G G U U U U U U Heptane l u g u u u u u u u Magnesium Chloride Hexadecanol U U U Hexane l u l u g l Hexanol, Tertiary L U L U G L G L L U G Hydrobromic Acid 20% G G G G G G G U U Hydrochloric Acid 10% G G U U Hydrochloric Acid 48% Hydrluoric Acid 4% Hydrluoric Acid 10% Hydrluoric Acid 48% Hydrluoric Acid 60% G G G G G U U G G G G G G G G U U G L G L G G G G U U G U G L G L G L U U G U G U G L G L U U Hydrluorosilic Acid G L G L U U Hydrogen C C C C C C C C C C C Hydrogen Bromide (Dry) Hydrogen Chloride (Dry) Hydrogen Cyanide C C C C C C C C C C U U Hydrogen Peroxide 3-12% G G G L G L G L G L Hydrogen Peroxide 30% G G G L G L G L G L Hydrogen Peroxide 50% L L L U L U U U L U Hydrogen Peroxide 90% Hydrogen Phosphide L L G G G G Hydrogen Sulfide (Aqueous Solution) G G Hydrogen Sulfide - Dry G G Hydrombromic Acid 20% G G G G G G G U U Hydroquinone Hypochlorous Acid G G L U L U Inks Iodine (In Alcohol) Iso-octane l u l u Isopropyl Acetate U U Isopropylalcohol G G Jelly Jet Fuels JP 3, 4, 5 U U U U U U G L Kerosene u u l u u u l u u u G Ketones u u u u l u G L U G L Kraft Liquor (Paper industry) G G G Lacquer Thinners U U U U G L G L U G Lactic Acid 28% L U Lard Oil G G L G L G L G Lauric Acid L U L U Lauryl Chloride L U L U L G Lauryl Sulfate U U U U U U Lead Acetate Lead Arsenate Lead Nitrate Magnesium Hydroxide G L Magnesium Nitrate Magnesium Sulfate Maleic Acid 25% Aqueous G G G G L U Maleic Acid 50% Maleic Acid Concentrated G G Malic Acid G G G G G L U Mayonnaise Mercuric Chloride G L G G G G G G G G G L Mercuric Cyanide U U U U G G G G G G Mercurous Nitrate G G G G G G G G G G G Mercury g g g g g g g g g l Methyl Acetate U U U U U U Methyl Alcohol L U L U G G G L U Methyl Bromide U U U U U U Methyl Chloride Methyl thyl Ketone U U U U L U G L U L U Methyl lsobutyl Ketone U U U U L U G L U Methyl Sulfate G G G Methyl Sulfuric Acid G G G G U U Methylated Spirit G Methylene Chloride U U L U U U U U U U U U Milk G L Mineral Oils g l L U L U L U Mineral Spirits G Molasses Monochlorobenzene U U U U Naphtha u u l u u u g l u u g u Napthalene u u u u l u l u u u Nickel Acetate Nickel Chloride Nickel Nitrate Nickel Sulphate Nicotine Nicotine Acid Nitric Acid (Anhydrous) Nitric Acid 10% Nitric Acid 25% Nitric Acid 35% Nitric Acid 40% Nitric Acid 50% Nitric Acid 60% Nitric Acid 68% Nitric Acid 70% Nitrobenzene C C G C C G G L G L G G G G U U G L G L G L G G G L U U G L G L L U G U L U U U G L G L L U L U L U U U G U G U L U L U L U U U G U G U U U L U U U U U L U L U U U U U U U U U Lead Tetra-ethyl Nitrous Oxide Lemon Juice G Oils and Fats G G L G L G U Lime Sulfur refer to back G G G G G Oils, Petroleum availability G products/sizes G L G L G U shown. Linoleic Acid L U Oleic Acid g l g l l u l u u u u u CHMICAL RSISTANC KKTCA

6 CHMICAL RSISTANC Key: =xcellent G=Good L=Limited U=Unsatisfactory C=Cautionary =No Data LLDPVA TPU LLDP VA TPU Oleum Potassium Bromide G G Orange Juice G L Potassium Carbonate Oxalic Acid G G G G G G G U U Potassium Chlorate G G Oxygen G G G G L G L Potassium Chloride G Ozone l u l u u u l u u u Potassium Chromate 40% G G Palmitic Acid 10% G L G L G U U Palmitic Acid 70% L U L U G U G U L U U U Paraffin G G G L L U G Pentane l u l u G Peracetic Acid 40% U U U U U U Perchlorethylene U U U U U U Perchloric Acid 10% G L G L G G G G G G U U Perchloric Acid 70% L U L U G L G L G U U Petrol u u u u u u U U Petroleum r L L L L U U Phenol Phenylhydrazine U U U U L U L U Phenylhydrazine Hydrochloride L U L U L U L U Phosgene (Gas) C C C C C U Phosgene (Liquid) U U Phosphoric Acid 0-25% G G G G G U U Phosphoric Acid 25-50% G G G G G U U Phosphoric Acid 50-90% G G G L G L L U U Phosphorus (Yellow) G L G L L L L L U U Phosphorus Pentoxide L U L U L L G L G L Phosphorus Trichloride U U U U L U L U L U Photographic Developers L U L U L Photographic mulsions L U L U Photographic Fixers L U L U Picric Acid u u u u g u g u g l u u Pitch g l g l G Plating Solutions Brass G G G G L Cadmium G G G G L Chromium Copper Gold Judium Lead Nickel Rhodium Silver Tin Zinc g g g g u u u u u u g g G G G G L G G G G L G G G G L G G G G L G G G G L G G G G L G G G G L G G G G L G G G G G L Potable Water G G Potassium Acid Sulfate G G G Potassium Antimonate Potassium Bicarbonate Potassium Bichromate Potassium Cuprocyanide Potassium Cyanide C C C C C C C C C C C C Potassium Dichromate 40% G G Potassium Ferricyanide Potassium Fluoride G Potassium Hydroxide 10% L U Potassium Hydroxide 20% U U Potassium Hydroxide 35% G L G G U U Potassium Hydroxide Conc. L Potassium Hypochlorite G L G L G G G L U U Potassium Nitrate Potassium Perborate Potassium Perchlorite Potassium Permanganate 10% G G G G G L G L G G G G G G L G G U U G L Potassium Persulfate Potassium Phosphate Potassium Sulfate Potassium Sulfide Potassium Thiosulfate Power Steering Fluid L L Propane Propargyl Alcohol G G G G Propyl Alcohol L G L Propylene Dichloride Propylene Glycol Prune Juice Ritchfield A Weed Killer L G Salicylic Acid Salt Water L Selenic Acid G G G L G L G L U U Shortening g l Silicic Acid U U Silicone Fluids Silver Cyanide Silver Nitrate Silver Plating Solutions G G G G Soap Solution G G G G L G L G U Sodium Acetate Sodium Acid Sulfate Sodium Antimonate Sodium Arsenite Sodium Benzoate G Sodium Bicarbonate Sodium Bisulfate Potassium Bisulfite Sodium Bisulfite Potassium Bisulphate G L Sodium Bromide G Potassium refer Borate to 1% back Sodium Carbonate availability products/sizes shown. Potassium Bromate 10% G G (Soda Ash) 70 KKTCA0408

7 Key: =xcellent G=Good L=Limited U=Unsatisfactory C=Cautionary =No Data LLDPVA TPU LLDP VA TPU Sodium Chlorate G L G L G G Titanium Trichloride U U Sodium Chloride G Toluol or Toluene U U L U U U G U U L U Sodium Cyanide Tomato Juice G L L U Sodium Dichromate G G G Transmer Oil U U Sodium Ferricyanide Transmission Fluid L L Sodium Ferrocyanide Sodium Fluoride G Sodium Hydroxide 10% G L Sodium Hydroxide 35% G L U Sodium Hydroxide 50% G L Sodium Hypochlorite Sodium Nitrate Sodium Nitrite Sodium Phosphate-Acid Sodium Silicate U U G G G G U U Sodium Sulfate Sodium Sulfide Sodium Sulfite Sodium Thisulfate (Hypo) G St Drinks G G L Soya Oil G Soybean Oil g l Stannic Chloride G Stannous Chloride G G G Starch Stearic Acid l l l l L U Stoddard Solvent L U G L G L G L L U G U Styrene u u u u Sucrose Sulfur g g g g Sulfuric Acid 0-10% G G G G G U U Sulfuric Acid 10-40% G G G G G G G G U U Sulfuric Acid 50-60% G G G L G L G L U U Sulfuric Acid 70% G G L U L U L U U U Sulfuric Acid 95% Sulfuric Acid 95% to Fuming L L L L U U U U U U U U Sulfurous Acid G L G L L U U U Sulphur Dioxide - Liquid L U L U U U U U U U Sulphur Dioxide Gas - Dry G G G G G Sulphur Dioxide Gas - Wet L U L U G L G L L Sulphur Trioxide G G U U U U U U Sulphurous Acid 10% Sulphurous Acid 30% U U Tallow U Tannic Acid L U Tanning xtracts Tanning Liquors G L G L L Tartaric Acid L U Tea (Brewed) G G G L Tetraethyl Lead G L G G G G Tributyl Phosphate U U U U Trichlorobenzene U U U U U U Trichloroethylene U U L U U U G L U U L U Tricresyl Phosphate U U U U L L L L U U U U Triethanolamine L U G U G L G L L Triethylamine g l g l Trimethyl Propane L U L U Trisodium Phosphate Turpentine l u g l l u g l u G Urea Urine Varnish u u u u g l g l u u G Varsol G Vegetable Oils G L G L U U Vinegar G G G L Vinyl Acetate u u u u l u l u u u u u Vinyl Chloride u u u u Water-Acid Mine Water G U Water-Distilled G U Water-Fresh G U Water-Salt G U Whey G G L G L Whiskey l u L White Gasoline U U U U U U G White Liquor (Paper industry) Wines g l Xylene or Xylol U U L U U U G L U U G L Zinc Chloride Zinc Chromate Zinc Cyanide Zinc Nitrate Zinc Sulfate Mixtures Acids: Nitric 15%, Hydrluoric 4% G G U U Sodium Dichromate 13%, Nitric Acid 16%, Water G G L Tetrahydrurane Thionyl Chloride Tin Chloride refer to back availability products/sizes shown. Titanium Tertachloride U U L U CHMICAL RSISTANC KKTCA