Purchase SilcoNert or Silcolloy treated parts directly from the manufacturer.
|
|
- Marcia Banks
- 6 years ago
- Views:
Transcription
1
2 Tubing Accurate feedstock or process sampling the first time, every time with SilcoNert 2000 tubing. Adsorption problems in sample pathways often can be traced to the tubing and fittings transferring the sample to the analytical instrument. Always use SilcoNert 2000 treated tubing and fittings for applications involving active compounds at ppm and ppb levels. To ensure maximum inertness and minimal surface area, use SilcoNert 2000 treated electropolished tubing. Figure 1 shows uptake and release curves for 500ppbv of methyl mercaptan, an active sulfur compound, in a gas stream passing through a variety of tubing substrates. SilcoNert 2000 treated tubing reduces uptake by orders of magnitude, relative to untreated stainless steel tubing. 1 In corrosive environments, Silcolloy 1000 treated tubing is an excellent alternative to expensive alloys. Silcolloy 1000 extends the lifetime of tubing by 10X, reducing the frequency of preventive maintenance and ensures the purity of the process or sample stream. SilcoNert 2000 will significantly prevent corrosive attack. However, Sicolloy 1000 was specifically optimized by increasing the coating depth to provide the best protection against corrosion. Figure 2 shows the results of ASTM G48 Method B2, crevice corrosion testing. Silcolloy 1000 treated and untreated stainless steel coupons were immersed in ferric chloride for 72 hours. Results show the Silcolloy 1000 treated coupon demonstrates a dramatic improvement in corrosion resistance. 2 Figure1: SilcoNert 2000 treated electropolished seamless stainless steel tubing does not adsorb methyl mercaptan at 500ppbv concentrations. 2 Figure2: Silcolloy 1000 treated 316L stainless steel coupons show no crevice corrosion and only slight pitting corrosion; untreated coupons exhibit severe crevice corrosion. Testing courtesy of Matco Asscociates. Purchase SilcoNert or Silcolloy treated parts directly from the SilcoTek coated products. Give them a call and ask about purchasing their Silco d parts directly from the part SilcoTek partners offer the finest in treated tubing. SilcoNert and Silcolloy treated tubing is available in 304 and 316 grades. O Brien Corporation Contact your O Brien representative and ask for EPS tubing. Restek offers Siltek /Sulfinert and Silcosteel -CR coated tubing. Thermon The Heat Tracing Specialists Contact your Thermon representative and ask for Silcosteel or Sulfinert coating. Silcolloy 1000 Treated Untreated
3 Fittings Tube fittings can be a source of sulfur and mercury adsorption and sample loss. Exposed fitting surfaces will react with active compounds at ppb and ppm levels like sulfur, H2S, NOx and mercury resulting in sample loss, inaccurate readings, delayed response and false positive readings due to memory effects in tubing and fittings. Figure 3 shows how memory of adsorbed active compounds (such as sulfur, hydrogen sulfide (H2S), and mercury) can cause long delays in equilibrating a sample stream. Figure 3 demonstrates the memory effects of electropolished (EPS), standard, and SilcoNert 2000 treated electropolished stainless steel tubing. The SilcoNert 2000 treated tubing shows less retention of sulfur compounds by several orders of magnitude, indicating very high inertness. While the EPS and standard tubing show significant methyl mercaptan spikes several minutes after shutting off methyl mercaptan flow. This demonstrates significant adsorption and desorption of untreated stainless steel while SilcoNert 2000 shows minimal adsorption/desorption of sulfur compounds. 1 Purchase SilcoNert or Silcolloy treated parts directly from the SilcoTek coated products. Swagelok Company Go to Swagelok s website to find a distributor near you. For SilcoNert 2000 (Siltek /Sulfinert ) treated fittings, ask your local Swagelok distributor to add the following suffix to your part number: Fittings: add -JA Valco Ask your Valco distributor for SilcoNert 2000 (Siltek / Sulfinert ) treated fittings and valves. Parker Ask your Parker distributor for SilcoNert 2000 (Siltek / Sulfinert ) treated fittings and valves. Find everything you need for your laboratory or life sciences application. Ask your Restek representative for Siltek / Sulfinert treated fittings. Figure 3: Sulfur memory is a concern in raw commercial grade stainless steel tubing and fittings. SilcoNert 2000 treated tubing and fittings show no memory effects (500ppbv methyl mercaptan in helium) Data courtesy of Shell Corp. and O Brien Corp.
4 Valves &Regulators Sample flow paths through valves and regulators can be tortuous, prolonging contact between the sample stream and the valve/regulator components. SilcoTek treatments have been applied to many valve and regulator geometries; eliminating sulfur and mercury adsorption in bodies, stems, diaphragms, or other wetted components. Purchase SilcoNert or Silcolloy treated parts directly from the SilcoTek coated products. Swagelok Company Go to Swagelok s website to find a distributor near you. For SilcoNert 2000 (Siltek /Sulfinert ) treated fittings, ask your local Swagelok distributor to add the following suffix to your part number: Valves and sample cylinders: add Concoa Ask your Concoa representative for SilcoNert 2000 (Siltek /Sulfinert ) treated regulators. Emerson/Tescom Ask your Emerson/Tescom representative for SilcoNert 2000 (Siltek /Sulfinert ) treated regulators. Parker Ask your Parker distributor for SilcoNert 2000 (Siltek /Sulfinert ) treated fittings and valves. Porter Mass Flow Controllers Ask your Parker representative to specify a J to the body/component material designator to signify stainless steel with Silcosteel coating. Restek offers SilcoTek treated tubing, fittings, NIOSH air sampling equipment, sample cylinders, and valves. Restek also offers a large selection of SilcoTek treated gas chromatographic instrument parts such as FID jets, inlet seals, inlet liners, and injection ports. Spectra Gasses Ask your Spectra Gases representative for SilcoNert 2000 (Sulfinert ) coated regulators. Alta-Robbins Offering SilcoNert 2000 (Siltek /Sulfinert ) and Silcolloy 1000(Silcosteel -CR) treated valves. Ask you Alta- Robbins representative for suffix SN2 for SilcoNert 2000 and -SL1 for Silcolloy 1000 Filters Frits and other filtering devices trap particles and prevent them from entering the analytical instrument, but they also very effectively adsorb active components in sample streams. Their large surface areas can increase sample/system contact by orders of magnitude. SilcoNert 2000 treated frits and filters create an inert flowpath. Our chemical vapor deposition technology ensures the treatment penetrates even the smallest pores in sintered metal frits. Purchase SilcoNert or Silcolloy treated parts directly from the The following list of partners and OEM s supply SilcoTek coated products. Find everything you need for your laboratory or life sciences application. Restek offers SilcoTek treated tubing, fittings, NIOSH air sampling equipment, sample cylinders, and valves. Restek also offers a large selection of SilcoTek treated gas chromatographic instrument parts such as FID jets, inlet seals, inlet liners, and injection ports. Thermo Fisher Ask for SilcoNert 2000 (Sulfinert ) coated filters. Perma Pure LLC. Ask for SilcoNert 2000 (Siltek /Sulfinert ) coated filters. Mott Corporation Ask for SilcoNert 2000 (Sulfinert ) coated filters. Your service was excellent and allowed me to help a customer out of a jam. Tom Lago Sr. Application Engineer Armstrong International, Inc
5 Sample Vessel Equipment When samples are taken from a process stream and are transported to the laboratory for evaluation, it is critical to use SilcoNert 2000 treated sampling containers, to prevent active components from adsorbing to vessel, valve or outage tube surfaces. The data demonstrates that SilcoNert 2000 treated stainless steel surfaces provide superior mercury inertness performance compared to untreated stainless steel. Results show that SilcoNert 2000 treatment is ideal for components and tubing exposed to mercury samples in CMMS and sorbent tube mercury sampling systems. SilcoNert 2000 Untreated Purchase SilcoNert or Silcolloy treated parts directly from the The following list of partners and OEM s supply SilcoTek coated products. Swagelok Company Go to Swagelok s website to find a distributor near you. For SilcoNert 2000 (Siltek /Sulfinert ) treated fittings, ask your local Swagelok distributor to add the following suffix to your part number: Valves and sample cylinders: add Welker Engineering Sampling natural gas streams or other pressure sensitive chemicals? Welker Engineering offers SilcoNert 2000 treated sample systems to insure complete inertness. Parker Ask your Parker distributor for SilcoNert 2000 (Siltek /Sulfinert ) treated fittings and valves. Ask your Restek representative for SilcoNert 2000 (Sulfinert ) coated sample cylinders. Probes Sampling probes are used in a variety of applications, including sampling natural gas, stack, flare, or other process streams. Probes are often exposed to severe conditions involving corrosive gasses, high temperatures, and active compounds such as hydrogen sulfide and sulfur. An untreated probe contributes to the active surface area in the system and may experience severe corrosion which further contributes to system activity. SilcoNert 2000 treated or Silcolloy 1000 treated probes can improve probe life while eliminating potential sources of activity. Purchase SilcoNert or Silcolloy treated parts directly from the The following list of partners and OEM s supply SilcoTek coated products. M&C Corp Ask your M&C representative for SilcoNert 2000 (Sulfinert ) coated probes Welker Engineering Ask your Welker representative for SilcoNert 2000 (Sulfinert ) coated sampling products. Thermo Fisher Ask your Thermo Fisher representative for SilcoNert 2000 (Sulfinert ) coated probes and sampling systems. I cannot express enough how I greatly appreciate the job well done in getting these parts finished in an expedited manner. Thank you all! Marty Mazurkiewicz Purchasing Manager Conax Technologies, LLC
6 Heated Lines A heated trace line consists of standard grade or electropolished tubing that has been insulated and bundled with heating devices to ensure the sample is transferred at a consistent temperature. Heated trace lines are used in many gas stacks and other remote sampling points. Active compounds in the sample quickly can be adsorbed into the hot tubing resulting in false or poor analytical results. Purchase SilcoNert or Silcolloy treated parts directly from the SilcoTek coated products. SilcoTek partners offer the finest in Sample Transport Bundles for CEMS (Continuous Emissions Monitoring Systems) and Process Analytical Applications. SilcoNert treated tubing and tube bundles are available from these SilcoTek supply chain partners. O Brien Corporation Ask your O Brien representative for SilcoNert 2000 (Sulfinert ) coated tubing. Thermon The Heat Tracing Specialists Ask your Thermon representative for SilcoNert 2000 coated tubing. You always deliver what you promised and in a timely manner. I appreciate the s that keep me informed of the progress of my order. Thanks again. Patricia Hooks Research Associate SABIC Technology Center Summary Surface treatments from SilcoTek prevent adsorption of active compounds (such as sulfur, hydrogen sulfide, and mercury) and reduce corrosion in delivery systems. SilcoNert 2000 and Silcolloy 1000 treatments should be considered in applications in which corrosive or active streams are to be sampled, transferred, and analyzed. To learn more about enrolling in SilcoTek s Direct Line, us at silcod@silcotek.com The communication with the performance coatings group is always excellent, and the turnaround time is always outstanding. Thanks for being such a great partner. Edward Pfannkoch Gerstel, Inc. Lit Cat # ST013 To learn more about SilcoTek, go to our website or call us! (814)
SELECTION GUIDE Sample Transport Tubing
SELECTION GUIDE Sample Transport Tubing A guide for the selection of sample transport tubing. Tube Selection for Analyzer Sample Systems Selecting the optimum process tube for use in analyzer sample transport
More informationPerformance Update and Review of Coatings Used to Improve Reliability and Accuracy of Sulfur, Mercury and NO x Sampling and Analysis Equipment.
Performance Update and Review of Coatings Used to Improve Reliability and Accuracy of Sulfur, Mercury and NO x Sampling and Analysis Equipment. Gary Barone SilcoTek Corporation 225 Penntech Drive Bellefonte,
More informationPassivation of Components used for Sample Transfer and Holding
Passivation of Components used for Sample Transfer and Holding Presented by: Dave Pearse Restek Corporation 110 Benner Circle Bellefonte, PA, 16823 (800) 356-1688 http://www.restekcorp restekcorp.com C
More informationPassivation of Components used for Sample Transfer and Holding
Passivation of Components used for Sample Transfer and Holding Gary A. Barone,, David Smith, David Shelow Restek Corporation www.restekcorp restekcorp.com Components That Benefit from Inert Coatings Sample-holding
More informationSELECTION GUIDE Sample Transport Tubing
SELECTION GUIDE Sample Transport Tubing A guide for the selection of sample transport tubing. Tube Selection for Analyzer Sample Systems Selecting the optimum process tube for use in analyzer sample transport
More informationSilcoTek Coatings 101
Game-Changing Coatings SilcoTek Coatings 101 SilcoTek Corporation - All rights reserved. Hard copies are uncontrolled. 1 Key Facts Year founded: 2009 Employees: 50 Mission: To create Game-Changing Coatings
More informationPerformance Update and Review of Coatings Used to Improve Reliability and Accuracy of Mercury and Sulfur Sampling Systems
Performance Update and Review of Coatings Used to Improve Reliability and Accuracy of Mercury and Sulfur Sampling Systems Gary Barone and Marty Higgins SilcoTek Corporation 225 Penntech Drive Bellefonte,
More information40% savings SS /8" SS nut (20) SS /4" SS nut (20) SS /8" SS front ferrule (20) SS
Swagelok Brass & Stainless Sl Fitting Kits Save more than 40% by purchasing a new Restek Swagelok Fittings Kit, compared to prices for the individual parts! Includes the most common assortment of /8" and
More informationSilcoTek s Inert CVD Coatings for Analytical Applications
SilcoTek s Inert CVD Coatings for Analytical Applications SilcoTek Corporation 225 PennTech Dr. Bellefonte, PA 16823 +1 (814) 353-1778 www.silcotek.com 1 Coating Common Applications Ultimate chemical inertness
More informationAlumina BOND/MAPD PLOT Columns!
Restek Refined Analyze Trace Polar Hydrocarbons More Accurately and Reliably With Alumina BOND/MAPD PLOT Columns! Reproducible, predictable responses for reduced calibration frequency. Exceptional sample
More informationNew Developments in Thermal Desorption (TD) Tube & Canister Technologies for Collection & Analysis of Soil Gas
New Developments in Thermal Desorption (TD) Tube & Canister Technologies for Collection & Analysis of Soil Gas Presented by Roy Smith, M.Sc., MBA, C.Chem. Why Use TD Tube or Canister Sampling For Collection
More informationA Single Analyzer Solution for Refinery Flare Emissions Monitoring (40 CFR 60 Subpart Ja) Using Mass Spectrometry
A Single Analyzer Solution for Refinery Flare Emissions Monitoring (40 CFR 60 Subpart Ja) Using Mass Spectrometry Introduction New environmental regulations have recently prompted many oil refineries and
More informationASI MODEL DM 100 SERIES DILUTING MODULES
ASI MODEL DM 100 SERIES DILUTING MODULES The ASI Model DM 100 Series Diluting Modules have been developed to meet the requirements of some of our more specialized applications, where our standard in situ
More informationMATERIALS OF CONSTRUCTION
HIGH PRESSURE PURIFIER (MODEL SG6140) Model SG6140 purifier is designed to remove water and/or oil from gas or liquid streams. In the laboratory, it protects delicate or sensitive instruments, prolongs
More informationImproving the Performance of Time Integrated Sampling of. Steel Canisters. Application Note: 902. Authors. Introduction. Abstract
Improving the Performance of Time Integrated Sampling of TO14 Compounds into Stainless Steel Canisters Application Note: 902 Authors Dan Cardin Ken Langford Vinay Shetty Entech Instrurments, Inc Simi Valley,
More informationSorbents Evaluation Testing Facilities. 95% removal efficiency or an emission standard of lbs/gw h by 2012, while
Sorbents Evaluation Testing Facilities Several states have enacted Hg emission regulations that are more stringent than the CAMR milestones. For example, Massachusetts will require power plants to achieve
More informationSuper Clean Gas Filters Simply the best
Super Clean Gas Filters TM Simply the best Cartridge Type rev. 1.4 Features EP-B-0606960 U.S. Patent 5.478.378 Ultra-high capacity High-purity output ensures 99.9999% Pure gas Quick connect fittings for
More informationCONFIGURABLE. LOCAL. RELIABLE.
Grab Sampling Systems LOCAL, GLOBAL Chicago Fluid System Technologies is bringing new solutions to grab sampling CONFIGURABLE. LOCAL. RELIABLE. ENGINEERED TO PERFORM UNDER PRESSURE Learn how Swagelok is
More informationAnalytical Instrumentation & Maintenance Systems (AIMS)
Analytical Instrumentation & Maintenance Systems (AIMS) ANALYZER IMPORTANCE IN AMINE Presenter: Mr. Zaheer Juddy PROCESS INSTRUMENTS BUSINESS UNIT 1 OVERALL AGRP, SRU & TGTU PROCESS INSTRUMENTS AMINE TREATING
More informationSystem Solutions For. Process Analysis. Your Resource for Process Analysis Components, Systems and Solutions
System Solutions For Process Analysis Your Resource for Process Analysis Components, Systems and Solutions Process Analysis: A Focus Parker means components and systems that work To accurately monitor
More informationHydrocarbon Processing Industry Gas Chromatographs. Standard GC Analyzer Solutions
Hydrocarbon Processing Industry Gas Chromatographs Standard GC Analyzer Solutions Scion Instrument s GC Analyzer specialists have the knowledge and experience to provide pre-configured gas chromatographic
More informationGas and Liquid Sampling
Gas and Liquid Sampling Training Goal Review basic terminology and standards Provide basic understanding and offerings of the low emissions (Low-E) manual samplers Understand the Low-E competitors Understand
More informationSuper Clean Gas Filters Simply the best
Super Clean Gas Filters TM Simply the best Cartridge Type rev. 1.4 Features EP-B-0606960 U.S. Patent 5.478.378 Ultra-high capacity High-purity output ensures 99.9999% Pure gas Quick connect fittings for
More informationTTE N TTE N
All in One Purifiers Metronics gas purifiers dramatically reduce contaminant levels and absorb a greater variety of contaminants than other gas purification products. Advanced materials and design features
More informationOlefin Analyzer Solutions for Polymer Grade Ethylene and Propylene
Olefin Analyzer Solutions for Polymer Grade Ethylene and Propylene Angela Smith Henry Kelly Beard George Gonzalez 1 Impurity Monitoring in Olefin Production Analysis of contaminants in ethylene and propylene
More informationSampling Technology for Extractive CEMS & Maintenance Issues of CEMS Sanjeev Rai Perma Pure Aug 9, 2016
Continuous Emission Monitoring System From Understanding to Implementation Sampling Technology for Extractive CEMS & Maintenance Issues of CEMS Sanjeev Rai Perma Pure Aug 9, 2016 INDEX Different Application
More informationC146-E096 TD-20. Shimadzu Thermal Desorption System
C146-E096 TD-20 Shimadzu Thermal Desorption System Thermal Desorption Thermal desorption systems trap target substances carried in mobile phase by adsorption in a sample tube packed with adsorbent. Then,
More informationA LOW PRESSURE DROP SINTERED METAL FILTER FOR ULTRA-HIGH PURITY GAS SYSTEMS
A LOW PRESSURE DROP SINTERED METAL FILTER FOR ULTRA-HIGH PURITY GAS SYSTEMS Dr. Kenneth L. Rubow Donna S. Prause, Mark Eisenmann Mott Corporation Presented at the 3 rd Annual Technical Meeting Institute
More informationMach-RGA. The Fast Refinery Gas Analyzer. Analyzer
Mach-RGA The Fast JAS Mach-RGA Refinery gas is used as a fuel gas or as feedstock for further chemical processing. US EPA Title V Permit requires operators to monitor and report the composition of refinery
More informationPROCESS ANALYZERS FOR PURIFIED BULK GAS QC/QA: ENTERING THE PPT RANGE
JPACSM 27 PROCESS ANALYZERS FOR PURIFIED BULK GAS QC/QA: ENTERING THE PPT RANGE Marco Succi SAES Getters S.p.A. Milano, Italy James G. Moncur and William L. Robinson Independent Consultants KEYWORDS: TRACE
More informationDifficult CEMS Applications at Refineries & Chemical Plants
Difficult CEMS Applications at Refineries & Chemical Plants Bart Leininger, P.E. Principal Ashworth Leininger Group Camarillo, CA 4/3/18 Page 1 Objectives Discussion of CEMS and Process Measurement Sample
More informationOperating the SRI RGD ( Reduction Gas Detector )
The SRI RGD detector is mounted on the right side of the column oven on a 8610C or 310 gas chromatograph. The RGD detector can also be mounted on a Model 110 stand-alone chassis ( not shown ). RGD detector
More informationCORROSION IN ACID GAS INJECTION SYSTEMS - PROJECT 101
CORROSION IN ACID GAS INJECTION SYSTEMS - PROJECT 101 Kevin S. Fisher, P.E. and Kenneth E. McIntush, P.E. Trimeric Corporation Buda, Texas, U.S.A. Peter F. Ellis Honeywell Corrosion Solutions Houston,
More informationAgilent MetaCarb 87H Organic Acids Column H + Form User Manual Part No. A5214
Agilent MetaCarb 87H Organic Acids Column H + Form User Manual Part No. A5214 Warning: The Agilent MetaCarb 87H organic acids column is packed with a polymeric material that requires special care. Introduction
More informationDemonstration of Fuel Cells to Recover Energy from Landfill Gas Phase III. Demonstration Tests, and Phase IV. Guidelines and Recommendations
United States National Risk Management Environmental Protection Research Laboratory Agency Cincinnati, OH 45268 Research and Development EPA/600/SR-98/002 March 1998 Project Summary Demonstration of Fuel
More informationHeat Treatment of Tubes for Condenser, Feedwater Heater, and Shell & Tube Heat Exchangers
Heat Treatment of Tubes for Condenser, Feedwater Heater, and Shell & Tube Heat Exchangers 1. SCOPE 1.1 The purpose of this document is to provide an overview of the different types of heat treatment processes
More informationJOINT EUROPEAN SUMMER SCHOOL FOR FUEL CELL AND HYDROGEN TECHNOLOGY
JOINT EUROPEAN SUMMER SCHOOL FOR FUEL CELL AND HYDROGEN TECHNOLOGY August 22-24, 2011 Hervé Barthélémy HYDROGEN STORAGE TECHNOLOGIES: COMPATIBILITY OF MATERIALS WITH HYDROGEN 1. GENERALITIES 1.1. Compatibility
More informationEquipment. Description. Features. Ordering Information. indicating oxygen trap Series 6200
indicating oxygen trap Series 6200 This unit is a step above other indicating oxygen traps. The unit comes to you completely assembled and ready for installation. It is ideal for use in-line directly after
More informationAccelerated Crevice Corrosion of Duplex Stainless Steels in Wet Limestone FGD Environments. Deba Maitra, Special Metals Corporation PCC Energy Group
Accelerated Crevice Corrosion of Duplex Stainless Steels in Wet Limestone FGD Environments Deba Maitra, Special Metals Corporation PCC Energy Group Outline General comments on alloy crevice corrosion and
More informationFactors Influencing Materials Selection in Condensing Economizers
Materials Selection for Condensing Economizers Gary M. Carinci, Ph.D. Outokumpu Stainless Outokumpu Stainless Factors Influencing Materials Selection in Condensing Economizers Temperature ph control Sulfur
More informationABB MEASUREMENT & ANALYTICS DATA SHEET. PGC5007 Total sulfur analyzer
ABB MEASUREMENT & ANALYTICS DATA SHEET PGC5007 Total sulfur analyzer 2 P G C 5 0 0 7 TOTA L S U L F U R A N A LY Z E R D S/ P G C 5 0 0 7- E N R E V. A Measurement made easy Online ASTM method D7041-04
More informationVE Technology Sampling System for the (Manual) Measurement of Trace levels of Mercury in Natural Gas. The Background
VE Technology Sampling System for the (Manual) Measurement of Trace levels of Mercury in Natural Gas The Background The measurement of trace levels of mercury in natural gas is a complex subject and the
More informationFully Extractive Vs. Dilution Extractive CEMS
Fully Extractive Vs. Dilution Extractive CEMS Cemtek Environmental Emissions Seminar & Training Session Santa Ana, CA a technical solution to meet every need CEMTEK Environmental Inc. 3041 S. Orange Ave.
More informationChambers and Instrumentation CHAMBERS. STORA: 22 m 3 chamber
Chambers and Instrumentation CHAMBERS STORA: 22 m 3 chamber The chamber is made of electropolished stainless steel with inner dimensions 3.2 x 2.9 x 2.4 meters (breadth x length x height). The volume of
More informationTUV Certified FTIR CEM and Ultra Low Level HCl CEM for Combustion Facilities
TUV Certified FTIR CEM and Ultra Low Level HCl CEM for Combustion Facilities CEM 2014 May 15-17, 2014 Istanbul, Turkey Peter G. Zemek MultiGas FT-IR Automated HCl CEM Systems MKS Instruments On-Line Product
More informationValve Nest Filter with Time Clock Control Installation and Operation Manual
Valve Nest Filter with Time Clock Control Installation and Operation Manual Effective 5/24/12 Effective 5/24/12 Table of Contents Operating Data. 1 Pre-Installation Data... 2 Filter Parameters Installation
More informationA New Look at Impurities in CO 2 for EOR and their Consequences
A New Look at Impurities in CO 2 for EOR and their Consequences Ray McKaskle, P.E. Trimeric Corporation Presented at the 20 th Annual CO 2 Flooding Conference December 11-12, 2014 Midland, Texas Example
More informationUltrahigh-Purity (UHP) and High-Purity Stainless Steel Tubing
Ultrahigh-Purity (UHP) and High-Purity Stainless Steel Tubing Fractional, Metric, and 1 www.swagelok.com Ultrahigh-Purity (UHP) and High-Purity Stainless Steel Tubing Fractional, Metric, and 316L stainless
More informationDräger Gas Filtration SUPER CLEAN GAS FILTERS. Dräger: Technology for Life
Dräger Gas Filtration SUPER CLEAN GAS FILTERS Dräger: Technology for Life 2 DRäGER GAS FILTRATION About Super Clean Gas Filters Cartridge systems make changing gas filters quick and easy. A base plate
More informationFor highest levels of purity
For highest levels of purity Gas purification systems www.airliquide.de Individual gas purification... versatile, quick and clean Proven technology For several decades, Air Liquide has been offering you
More informationSWAGELOK CUSTOM SOLUTIONS
SWAGELOK CUSTOM SOLUTIONS PROVIDED BY SAN DIEGO FLUID SYSTEM TECHNOLOGIES sandiego.swagelok.com UNIQUE CHALLENGES REQUIRE THE RIGHT SOLUTIONS You need a solution uniquely tailored to your needs, and you
More informationSampling and Analysis in Vapor Intrusion Investigations. Andy Rezendes, Technical Sales-Air Analysis
Sampling and Analysis in Vapor Intrusion Investigations Andy Rezendes, Technical Sales-Air Analysis Introduction General Principles Introduction to Measurement Techniques for VOCs in Air Principles of
More informationThe types of industrial exhaust streams that present particular pollution-control challenges include:
Choosing the Right Emissions Control Option Steve Blocki, P.E, Durr Systems, Inc. Determining the most economical option to control airborne emissions during chemical process operations presents several
More informationSuper Clean TM Gas Filters
Super Clean TM Gas Filters BASEPLATE FILTER 2014 C ATA L O G W W W. S G T- N L. C O M Overview About Super Clean TM Gas Filters Cartridge systems make changing gas filters quick and easy. A base plate
More informationThe MIDAC Low Moisture in Corrosive Gases Process Analyzer for Continuous On-Line Applications
AP-156 The MIDAC Low Moisture in Corrosive Gases Process Analyzer for Continuous On-Line Applications Dr. Peter G. Zemek MIDAC Corporation 17911 Fitch Avenue Irvine, California USA 92614 Email: sales@midac.com
More informationStainless Steels for Desalination Plants
Stainless Steels for Desalination Plants Tersainox in Olive Oil Production The 3CR12 in Different Applications and Equipment Transport Equipment, Designed According to Customer Requirements Tersainox -
More informationETHYLENE PLANT DRY CRACKED GAS Product Code 54801
SS2100 WATER IN ETHYLENE PLANT DRY CRACKED GAS Product Code 54801 KEY FEATURES Extremely fast analysis time 1 second updates possible Non-contact laser and detector - Reliable Tunable Diode Laser lasts
More informationCASE STUDY : chroma S SULFUR COMPOUNDS ANALYSIS (H2S and CS 2, 0/300ppm) FOR EMISSION APPLICATION IN A PAPER MILL
EUROPE AIRMOTEC ag SA 15 rue d'artiguelongue F-33240 SAINT-ANTOINE (BORDEAUX) Tel : +33 (0)557 940 626 Fax : +33 (0)557 940 620 AMERICA CHROMATOTEC Inc. 1833 Egret Bay Blvd, Suite 270, HOUSTON TX 77058
More informationMarch 2016 ARM, Inc. white paper: Safe Approach to Gas Purification. Abstract
March 2016 ARM, Inc. white paper: Safe Approach to Gas Purification Abstract Ultra-high purity gases are a necessity in many industries, including fabrication of electronics, photovoltaic, and lighting
More informationEuroFID Total Hydrocarbon Analyzer
Product information EuroFID Total Hydrocarbon Analyzer Precise Determination of Total Hydrocarbons in Air for Corrosive as well as Condensing Gases Analyzers and Process Instrumentation Proven Analyzer
More informationGhost Peaks in Gas Chromatography Part 2: The Injection Port
Cd The Chrom Doctor Ghost Peaks in Gas Chromatography Part 2: The Injection Port Jaap de Zeeuw, Restek Corporation, Middelburg, The Netherlands. In the last issue we discussed possible sources for ghost
More informationSSENTIALS RESTEK. Must-Have Solutions for Your Lab Leverage 3-in-1 Technology for Outstanding Inertness Low Bleed High Reproducibility
RESTEK SSENTIALS Must-Have Solutions for Your Lab 2014.2 Leverage 3-in-1 Technology for Outstanding Inertness Low Bleed High Reproducibility ALSO IN THIS ISSUE: Raptor Columns: Biphenyl & ARC-18 Sky Inlet
More informationAre You Really Ready for a RATA? August 5, 2015 CIBO Portland Maine Bob Davis Project Director TRC Environmental
Are You Really Ready for a RATA? August 5, 2015 CIBO Portland Maine Bob Davis Project Director TRC Environmental So What is a RATA? R Relative A Accuracy T Test A Audit It compares data from a facility
More informationSulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard
Sulfur Tail Gas Thermal Oxidizer Systems By Peter Pickard Introduction SRU s (Sulfur Recovery Units) are critical pieces of equipment in refineries and gas plants. SRUs remove sulfur compounds from certain
More informationCorrosion in GASCO Habshan CBA Units and its mitigation
Corrosion in GASCO Habshan CBA Units and its mitigation Orlando de Matos Inspection Department Head MESPON 2016 - Abu Dhabi 9 th to 11 th October 2016 AGENDA Introduction Process Description for CBA Units
More informationGas Sampling Bags. Cost-Effective Alternatives for Air Sampling. Restek Air
Restek Air Gas Sampling Bags Cost-Effective Alternatives for Air Sampling Ideal for whole air sampling at ppb-ppm levels. Select from Tedlar, ALTEF, and multi-layer foil bags in a wide range of sizes.
More informationStephen M. Patera, Sales Manager, LHI Metals. October 6-9, 2013 Caesars Palace, Las Vegas, Nevada, USA
TITANIUM USED IN REFINERIES Presented by Stephen M. Patera LHI Metals Titanium Grades Most Commonly Grade 2 Grade 7 Grade 12 Grade 16 Used in Refineries Corrosive Environments HCl Hydrochloric acid NH₄Cl
More informationTubing Data. Contents. Tubing Selection. Tubing Handling. Tubing Material. Tubing Outside Diameter Hardness. Tubing Wall Thickness
Tubing Data 1 www.swagelok.com Tubing Data Contents Tubing Selection... 1 Tubing Handling.... 1 Gas Service... 2 Tubing Installation.... 2 Suggested Allowable Working Pressure Tables Carbon Steel Tubing...
More informationmott corporation Process Systems Safe, reliable, fully automated catalyst recovery. The Mott solution.
mott corporation Process Systems Safe, reliable, fully automated catalyst recovery. The Mott solution. Maximizing catalyst retention. Introduction. Process operations involving catalysts have traditionally
More informationCORROSION & ITS CONTROL -Content. Introduction Classification Galvanic series Factors affecting Protection methods Summary
CORROSION & ITS CONTROL -Content Introduction Classification Galvanic series Factors affecting Protection methods Summary 3 Learning Objectives At the end of the chapter the learner will be able to; 1.
More informationAnalysis campaign for measurement of oxy-combustion flue gas from Coal Fired Plants
Analysis campaign for measurement of oxy-combustion flue gas from Coal Fired Plants 15 May 2014 Morgane Rivière, Daniel Missault, Patrick Mauvais, Samuel Daeden, Grégoire Béasse, Claire Bourhy-Weber, Jean-Marc
More informationSchunk Innovative Insulation Materials. Schunk Kohlenstofftechnik GmbH
Schunk Innovative Insulation Materials Schunk Kohlenstofftechnik GmbH Thermal Insulation at High Temperatures Carbon and Graphite Felt As a manufacturer of graphite felt for insulation in high-temperature
More informationThe CDS 7000 E Purge & Trap Concentrator
Leaders In Sample Introduction Technology The CDS 7000 E Purge & Trap Concentrator PROVEN, RELIABLE PERFORMER EASY OPERATION HIGHLY COMPETITIVE PRICE BEST VALUE/PERFORMANCE AVAILABLE WATERS ONLY OR SOIL/WATER
More informationGas Generators. Parker Balston
Gas Generators Parker Balston Zero Air Generators Ultra High Purity Hydrogen Generators for Fuel and Carrier Gas Hydrogen Generators for Fuel Gas Self Contained Membrane Nitrogen Generators Membrane Nitrogen
More informationThomas G. Braga Manager, Research and Development. SulfaTreat, a Business Unit of M I L.L.C. A Smith/Schlumberger Company
Thomas G. Braga Manager, Research and Development SulfaTreat, a Business Unit of M I L.L.C. A Smith/Schlumberger Company Who is SulfaTreat? A World Leader in H 2 S Removal for More than a Decade Today
More informationStraightway Valves. Sec 2: Products. Dia-Flo Diaphragm Valves /15
Features and Benefits Ideal for slurry, abrasive and corrosive applications, the Dia-Flo Straightway Diaphragm Valve provides the following benefits: Slurry Applications Due to the streamlined fluidpassage,
More informationOUR MISSION TRANSPORTATION
OIL AND GAS UPSTREAM SECTOR Onshore Oil and Gas Production Bitumen Production and Processing Coal-Bed Methane Offshore Oil and Gas Production Mining MIDSTREAM SECTOR LNG Liquefaction LNG Receiving Terminal
More informationExtending Valve Life: The Art of Heat Treating and Ceramic Coatings
Extending Valve Life: The Art of Heat Treating and Ceramic Coatings By Chris Johnson & Kevin Tackett Bodycote Presented at the Today s Valve Industry Today s industrial valve industry within the oil &
More informationABB Measurement & Analytics Monitoring cement plant stack emissions using FTIR
White paper WP/ANALYTICAL/002 EN ABB Measurement & Analytics Monitoring cement plant stack emissions using FTIR ABB FTIR CEMS analyzer successfully monitors cement plant stack emissions in extensive field
More informationCorrosion and Performance Issues for Immersion Service Shell and Tube Heat Exchangers
Corrosion and Performance Issues for Immersion Service Shell and Tube Heat Exchangers Condenser & Heat Exchanger Applications Tubesheet coatings Tube-end ID coatings Full-length tube coatings Waterbox
More informationLD8000. DESIGN REPORT v2. Trace Nitrogen in Argon or Helium analyzer
LD8000 Trace Nitrogen in Argon or Helium analyzer DESIGN REPORT v2 The need of trace nitrogen in argon or helium analysis in the industry is not something new. Many instruments have been and still are
More informationAgilent MetaCarb Ca PLUS Carbohydrate Column Ca ++ Form User Manual Part No. A5205
Agilent MetaCarb Ca PLUS Carbohydrate Column Ca ++ Form User Manual Part No. A5205 WARNING: The Agilent MetaCarb Ca PLUS calcium column is packed with a polymeric material that requires special care. Introduction
More informationCLARIFYING MATERIAL SELECTION: UNDERSTANDING THE CORROSION MECHANISMS FOR CLARIFIER MECHANISMS
CLARIFYING MATERIAL SELECTION: UNDERSTANDING THE CORROSION MECHANISMS FOR CLARIFIER MECHANISMS DOUG SHERMAN, P.E. PRINCIPAL CONSULTANT, CORROSION PROBE, INC. RANDY NIXON, PRINCIPAL CONSULTANT, CORROSION
More informationLOCAL SOLUTIONS, GLOBAL SUPPORT
Grab Sampling Systems LOCAL SOLUTIONS, GLOBAL SUPPORT Swagelok has developed standard Grab Sampling System designs to meet the needs of customers in a variety of applications around the world. The designs
More informationAuthor: Donald Pretty, Project Manager, Presenter: John Downs, Environmental Manager, B&W PGG, KVB-Enertec Products January 29, 2015
Author: Donald Pretty, Project Manager, Presenter: John Downs, Environmental Manager, B&W PGG, KVB-Enertec Products January 29, 2015 May 2007 Rule was proposed as an amendment to the NSPS Subpart J Rule
More informationHamilton PRP Polymeric Columns
Hamilton PRP Polymeric Columns Hamilton s Polymeric Reversed Phase (PRP) columns combine the characteristics of silica based and polymeric columns for improved versatility and longer life. With PRP columns,
More informationMAX300-AIR PRODUCT NOTE. Ambient Air Monitoring Flare Gas Analysis Industrial Health and Safety. Environmental Mass Spectrometer
MAX300-AIR Environmental Mass Spectrometer PRODUCT NOTE Ambient Air Monitoring Flare Gas Analysis Industrial Health and Safety Introducing the MAX300-AIR Be Safe, Be Clean, Be Compliant Mass spectrometry
More informationZircadyne 702/705 - in Chloride Solutions
Zircadyne 702/705 - in Chloride Solutions INTRODUCTION Chloride salt solutions, such as seawater, present a challenging environment for selecting materials with acceptable corrosion resistance. When exposed
More informationmott corporation High Purity Products IGS Porous Metal Filters and Flow Restrictors.
mott corporation High Purity Products IGS Porous Metal Filters and Flow Restrictors. IGS Porous Metal Filters and Flow Restrictors. Integrating the best of high flow rates, material range and configuration
More informationDesign of Mercury Storage Containers
Design of Mercury Storage Containers Adam J. Carroll Remote Systems Group / Nuclear Science and Technology Division Oak Ridge National Laboratory October 13, 2009 Email: carrollaj@ornl.gov Phone: 1-865-576-7505
More informationStack Sampling. requires airflow through the sampling probe to be at the same rate as that flowing in the waste gas stream isokinetic
Stack Sampling emissions associated with combustion, velocity and temperature may be much higher than ambient conditions - measure to correct to standard conditions Velocity data determined from pressure
More informationModular Oil & Gas Equipment Onshore & Offshore
Modular Oil & Gas Equipment Onshore & Offshore Separators & Desalters AI Energy Solutions onshore and offshore oil process solutions offer innovative technologies packaged with global project management
More informationWhat Does the Future Hold for Ambient Air Monitoring Regulations?
An Executive Summary What Does the Future Hold for Ambient Air Monitoring Regulations? A PAMS Site Instrumentation Evaluation for VOC Monitoring Nicola Watson Sales Support Manager - Americas Markes International
More informationHydrogen Sulphide and Mercaptan Removal
Natural Gas The significance of natural gas as an energy source is increasing rapidly. Yet its discovery and exploitation are far more recent than those of oil as gas projects have begun to develop since
More informationOn-Line Gas Analysis In Air Separation Plants
Application Data Sheet ADS 103-2815A.A01 March, 2008 Application Data On-Line Gas Analysis In Air Separation Plants APPLICATION Emerson provides several Rosemount Analytical gas analyzer technologies to
More informationCondensate System Troubleshooting andoptimization
Condensate System Troubleshooting andoptimization One of the prime considerations in the operation of a boiler is feedwater quality. The better the feedwater, the less likely that water-related problems
More informationResearch on tubing material selection for preventing corrosion in high sour gas well under existence of bacteria corrosion
ISSN : 0974-7435 Volume 8 Issue 9 BTAIJ, 8(9), 2013 [1258-1263] Research on tubing material selection for preventing corrosion in high sour gas well under existence of bacteria corrosion Lingfeng LI 1
More informationNew Developments in Measuring Low Silicon in Process Piping Using Handheld X-ray Fluorescence (XRF)
New Developments in Measuring Low Silicon in Process Piping Using Handheld X-ray Fluorescence (XRF) Presented by: Mark Lessard Business Development Manager Thermo Fisher Scientific mark.lessard@thermofisher.com
More informationContinuous Emissions Monitoring in Support of the Cement MACT
Continuous Emissions Monitoring in Support of the Cement MACT McIlvaine Webinar on Cement MACT March 30, 2011 Topics Covered Overview of Portland Cement MACT Mercury monitoring on cement kilns PM CEMS
More informationfrom concept to reality setting a new course from concept to reality setting a new course
setting a new course setting a new course Since 1983 Cardinal UHP has been supplying the semiconductor industry with piping components that help increase manufacturing efficiency. We introduced many practices
More information