Section 1 - Identification of Product. Health: 2 Least 0 Flammability: 3 Slight 1 Reactivity: 0 Moderate 2 High 3 Extreme 4

Transcription

1 MATERIAL SAFETY DATA SHEET Complies with OSHA Hazard Communication Standard 29 CFR Product Type Conductive Paint Emergency Contact: Chemtrec Phone (24 hours): (800) Part Number(s): HMIS RATINGS Section 1 - Identification of Product Health: 2 Least 0 Flammability: 3 Slight 1 Reactivity: 0 Moderate 2 High 3 Extreme 4 Section 2 - Hazardous Ingredients Wgt Carcinogenicity ACGIH TLV/OSHA PEL Hazardous Ingredients CAS # % NTP IARC OSHA Nickel** >40 Y Y Y 1.00 mg/m 3 Proprietary Acrylic Resin N/A <16 N N N None Estb. Toluene** <16 N N N PPM n-butyl Acetate <16 N N N PPM n-amyl Acetate <16 N N N PPM Isopropanol** <10 N N N PPM Isopropyl Acetate >10 N N N PPM Xylene** <4 N N N PPM Ethanol <4 N N N PPM n-butyl Alcohol** <4 N N N 50.00/ PPM **Subject to the reporting requirements of Section 313 of Sara Title III, See Section 10-Regulatory Information. All components of this product are listed on the TSCA registry. Warning: This product contains Toluene, known to the State of California to cause birth defects or other reproductive harm. Part Number(s): Page 1 of 5

2 Physical Form: Viscous Liquid Color: Nickel-Gray Volatile Organic Compound (VOC): 760 g/liter Specific Gravity 1.9 Boiling Point 103 C Solubility in Water Negligible Evaporation Rate >n-buac N/A Vapor Density >Air N/A % Volatile by Volume N/A Section 3 - Physical Data Section 4 - Fire & Explosion Hazard Data Flash Point: General Hazard: Extinguishing Media: Special Fire Fighting Procedures: Hazardous Combustion or Decomposition Products: 42 F Flammable, combustible material. Do not expose to heat, sparks, or flames.vapor and/or runoff may explode or ignite indoors, outdoors, or in sewers. Dry chemical, CO2, water spray or alcohol-resistant foam. Do NOT use dry chemical extinguishers to control fires involving nitromethane or nitroethane. Full protective equipment including self-contained breathing apparatus should be used. Water spray may be used to cool fire-exposed container to prevent pressure build-up and possible auto-ignition or rupture. Oxides of Carbon, Oxides of Nickel Section 5 - Health Hazard Data Primary Routes of Exposure: _ Skin _ Inhalation X Eye contact X Ingestion Effects of acute exposure: Eye contact: Skin contact: Inhalation: Ingestion: Medical Conditions Aggravated by Exposure: Causes severe eye irritation. May cause moderate skin irritation. May be absorbed through skin and cause allergic reaction. Vapors and mists irritate eyes, nose, and throat. Harmful or fatal if swallowed, even in dry form. None known. Part Number(s): Page 2 of 5

3 Chronic Health Effects: This product contains a nickel compound that has been classified as carcinogenic by both NTP and IARC. Since no dust of this nickel compound should be generated during the use of this product, exposure potential for humans is limited. Emergency and First Aid procedures: Skin: Eye: Inhalation: Ingestion: Remove contaminated clothing. Wash skin thoroughly with soap and water. Immediately flush eyes with running water while holding eyelids open. Get medical attention if irritation persists. Remove to fresh air, Seek medical guidance or attention promptly. Do not induce vomiting, Seek medical attention promptly. Section 6 - Reactivity Data Stability: Conditions to Avoid: Materials to Avoid: Hazardous Polymerization Stable Heat Strong oxidizers. Will not occur. Section 7 - Spill or Leak Procedures Spills: Waste Disposal Method: Shut off ignition sources. Isolate area until vapors have dispersed. Contain and remove with sand or other noncombustible absorbent material. For large spills, dike ahead of liquid spill for later disposal. Disposal should be done in accordance with Federal (40 CFR Part 261), State and local regulations. Before attempting clean-up, refer to hazard caution information in other sections of the MSDS form. Use only licensed hazardous waste disposal companies. Section 8 - Special Protection Information Respiratory Protection: Ventilation: Protective Clothing: Eye Protection: Approved NIOSH respirator may be used to reduce exposures. Ventilation controls, local exhaust and/or fresh air entry suggested. Chemical resistant gloves and impermeable clothing are suggested. Vapor tight chemical-type splash goggles when splashing or spraying of product. Section 9 Special Precautions Handling and Storage: Keep container closed and away from heat, sparks, flame, and direct sunlight. Ground all containers. Empty containers may retain hazardous properties. Part Number(s): Page 3 of 5

4 Section 10-Regulatory Information SARA TITLE III: Section 313 Information (40 CFR 372) Acheson Colloids Company Electrodag 440 contains a chemical which is listed in Section 313 at or above DE MINIMIS concentrations. The following listed chemicals are present: CAS # % Component Name <20 Toluene >50 Nickel <5 Xylene Acheson Colloids Company's SB-8 contains a chemical which is listed in Section 313 at or above DE MINIMIS concentrations. The following listed chemicals are present: CAS # % Component Name <50 Isopropanol <20 N-Butyl Alcohol TSCA-All components of these products are listed or are excluded from listing on the U. S. Toxic Substance Control Act (TSCA) Chemical Substance Inventory: Proposition 65 Substances are: (component(s) known to the State of California to cause cancer and/or reproductive toxicity and subject to warning and discharge requirements under the "Safe Drinking Water and Toxic Enforcement Act of 1986) CAS# Component Name Toluene Nickel Section 11 - Other Information DOT Proper Shipping Name: Paint Hazard Class or Division: 3 Packing Group Number: II UN Number: 1263 (49 CFR ) Exceptions for Class 3 (flammable) and combustible liquids Labeling: Flammable Liquid label required on gallons Label: ORM-D TSCA Status: All components of this product are listed on, or exempted from the requirement to be listed on, the TSCA Inventory of Chemical Substances. Part Number(s): Page 4 of 5

5 Disclaimer GC Electronics believes that the information contained herein is accurate and reliable as of the date of this material safety data sheet, but no representation guarantee or warranty, express or implied, is made as to the accuracy, reliability, or completeness of the information. Persons receiving this information are encouraged to make their own determination as to the information s suitability and completeness for their particular application. NO INFORMATION CONTAINED HEREIN CONSTITUTES A PRODUCT WARRANTY OF ANY KIND, WHETHER EXPRESS OR IMPLIED; AND ALL IMPLIED WARRANTIES OF MERCHANT ABILITY AND OF FITNESS FOR A PARTICULAR PURPOSE ARE HEREBY DISCLAIMED BY GC ELECTRONICS. Part Number(s): Page 5 of 5