Material Safety Data Sheet

Transcription

1 MSDS Date: Revised 02/07/2008 Product Name: CIDETRAK CM MD Manufacturer: Trécé, Incorporated I. Product and Company Description Trécé, Incorporated P.O. Box 129 Adair, OK Emergency Phone Number: (918) For Product Information: (918) (8E,10E)-8,10-Dodecadien-1-ol, Technical Grade Synonym (s): 8,10-Dodecadien-1-ol (E,E)-Technical CM pheromone Codlure II. Chemical Composition / Information on ingredients Active ingredient prepared in a PVC matrix (8E,10E)-8,10-Dodecadien-1-ol CAS# MF: C 12 H 22 0 EC NO:

2 III. Hazards Identification HMIS Hazard Classifications Health = 1 Flammability = 1 Reactivity = 0 Protection = B NFPA Hazard Classifications Health = 1 Flammability = 1 Reactivity = 0 Label Precautionary Statements U.S. Hazard Labeling Keep under nitrogen. May be irritating to skin and eyes. European R Phrases Irritating to skin. IV. First Aid Measures First Aid Measures for Accidental: Special Measures: No special first aid measures Eye Exposure: Flush with copious amounts of water for at least 15 minutes. Seek medical help if necessary. Skin Exposure: Wash area well with soap and copious amounts of water. Seek medical help if necessary. Inhalation: Remove to fresh air. Give oxygen and call a physician. Ingestion: Administer water and call a physician or poison control center immediately. Do not induce vomiting. Clothing: Wash contaminated clothing before reused. 2

3 V. Fire Fighting Measures Fire Hazard Data: Flash Point: Autoignition Temperature: Not Determined Not Determined Flammability Limits (vol/vol%): Lower: ND Upper: ND Extinguishing Media: Water spray, Carbon dioxide (CO 2 ), foam, dry chemical powder. Special Fire Fighting Procedures: Use standard fire fighting procedures. Fire fighters should use self-contained breathing equipment and protective clothing. Unusual Fire and Explosion Hazards: Under Hazardous Decomposition Materials (Under Fire Conditions): NA VI. Accidental Release Measures Cleanup and Disposal of Spill: Standard absorbents can be used. Absorb on sand or vermiculite and place in close container for disposal. Ventilate area and wash spill site after material pickup is completed. If small spill, mop up, wipe up or soak up immediately Waste Disposal: Place in suitable container for waste disposal. Incineration or sanitary landfill in accordance with local, state, and federal regulations. VII. Handling and Storage Handling: Avoid contact with eyes, skin and clothes. Use with adequate ventilation. Wash thoroughly after handling. Keep container closed. Avoid open flame, heat and sparks. Avoid contact to acid, peroxides and other oxidizing materials. Avoid grinding, welding, drilling and smoking near this substance. Avoid reuse of the empty container to other purpose. 3

4 Storage: Store tightly sealed under inert gas below 0 degrees C. Keep away from heat and sunlight. When storing, follow all the regulations in regard of this substance in your country or region. Fire Protection: Keep away from ignition sources and naked flame. VIII. Exposure Controls / Personal Protection Ventilation: Used with local exhaust ventilation. Respiratory Protection: Usually not required. Eye / Face Protection: Wear splash-proof safety glasses Skin Protection: Wear rubber gloves. Wear body-covering clothing. Other Protective Equipment: Make available emergency shower and eye wash in the work area. IX. Physical and Chemical Properties (8E, 10E)-8,10-Dodecadien-1-ol Physical Appearance: Colorless or light yellow transparent liquid. Solid when frozen Odor: waxy, fatty Melting Point: ºC Specific Gravity at 25 ºC (water=1): Water Solubility: Insoluble in water, soluble in alcohol Boiling Point: ºC at 2.0 mm Hg Vapor Pressure (25 ºC, mm Hg): x 10-2 Vapor Density (Air=1): Not applicable Flash point (Pensky-Martens): 196 ºF, 91 ºC 4

5 X. Stability and Reactivity Chemical Stability: Stable under normal temperatures and pressures. Conditions to avoid: Avoid contact with strong oxidizers, excessive heat, sparks or open flame. Materials / Chemicals to be Avoided: Acids, peroxides and other oxidizing agents. Hazardous Decomposition Products: Thermal decomposition products may include toxic oxides of carbon such as CO and CO 2. Hazardous Polymerization: It has not been reported to occur under normal temperatures and pressures. XI. Toxicological Information (8E, 10E)-8,10-Dodecadien-1-ol General: Most likely route of entry is through the skin. Ames: non-mutagenic with and without microsomal activation. Full strength may be irritating to eyes and skin. Irritation Data: Skin Irritation (Rabbits) Eye Irritation (Rabbits) Sub acute and chronic: Toxicity Data: LD 50 Acute Oral (Rats) LD 50 Acute Dermal (rats) LD 50 Acute Inhalation (Rats, 4 hours) LD 50 Intratracheal (per animal) Slight to moderate Slight to moderate Not available > 5,000 mg/kg > 2,000 mg/kg Non toxic 2.5 ml/animal Threshold Limit Value: (TLV): Not established OSHA Permissible Exposure Limit (PEL): Not established Listed as Carcinogen by NTP, IARC, or OSHA?: No 5

6 XII. Ecological Information General: Prevent contamination of soil, ground and surface water Ecotoxicity: Birds LD 50 (14 days): Fish LD 50 (96 hours): Daphinia LD 50 (48 hours): Algae LOEC (72 hours): Bee: >2,150 mg/day >120 mg/liter >1.3 mg/liter Not available Not available Persistence and Degradability: Easily decompose to carbon dioxide (CO 2 ) and water. No residue in soil. Other adverse effects: Not known. XIII. Disposal Consideration Waste Disposal Method: Incineration or sanitary landfill in accordance with local, state, and federal regulations XIV. Transportation Information Class Pack Group Sub. Risk UN No. IMDG Page Road (U.S. DOT): not regulated Air (IATA): Not regulated Sea (IMDG): Not regulated XV. Regulatory Information European Information Based on toxicological studies in the published literature, there are no risk and safety phrases to assign for this product. R38:Irritating to skin and eyes Reviews, Standards, and Regulations This chemical is listed on the following inventories: TSCA, AICS, CHINA DSL, ECL EINECS, PICCS Listed as carcinogen by NTP, IARC, or OSHA?: NO 6

7 XVI: Other Information Disclaimer of warranties and limitation of liability. The information in this MSDS was obtained from sources, which we believe, are reliable. However, the information is provided without any warranty, expressed or implied regarding its correctness. Trécé, Inc. makes no representations or warranties, either expressed or implied, of merchantability, fitness for a particular purpose or of any other nature with respect to the information or the product to which the information refers. Trécé sole and exclusive liability with respect to products provided to Trécé s satisfaction to be defective or nonconforming shall be the replacement of such products in accordance with Trécé s instructions. This remedy, in the manner provided herein, shall constitute fulfillment of all liabilities of Trécé, whether based on contract, tort or otherwise with respect to or arising out of the products. Trécé shall not be liable for any incidental, consequential, contingent or special damages. TRECE INC: 7569 HWY 28W, PO BOX 129, ADAIR, OK PHONE: ~ FAX: ~ CUSTSERV@TRECE.COM 7