Replacement Parts List No. 057114400 Revision M 10/2013 McQuay AAF Enersaver Packaged Terminal Air Conditioner ENC 000 Vintage B ENR 009-015 Vintage B PNES, PREN 009-015 Design A(1) & B(2) To find your Daikin Applied parts distributor, call 1-800-377-2787 or visit www.daikinapplied.com
Contents About the Model Changes...2 Parts List Revision History...3, 4 Nomenclature Serial...5 Model - ENC, ENR...6 Model - PNES, PREN...7 Chassis Diagram...8 Components...9 Compressor Section Diagrams...10 Components... 11 Condenser (Outside Air) Fan Section...12 Evaporator (Room Air) Fan Section...13 Control Box Diagrams...14 Wall Mounted Thermostats- ENR Only...15 Unit Mounted Thermostats...16 Electric Heat Section...17 Damper Section Manual...18 Motorized- ENR until 11/97...19 Motorized- ENR, PNES 11/97 & later...20 Power Cords...21 Wall Sleeve Cabinet Assembly Diagrams...22 Short Cabinet Components...23 Long Cabinet Components...24 Field Installed Accessories Receptacles...25 Optional Room Cabinet Front Panel...25 Replacement Filter...25 Outdoor Stamped Louvers...25 Condensate Drain Kit...25 Sensor- Wall Mounted...25 Installation Kits and Accessories...26 Hydronic Valves...27 Critical Parts List...CPL1 About the Model Changes In 1999 the model numbering nomenclature for the Enersaver PTAC changed: The ENR "B" Vintage unit is now either the: PNES Design "A" unit (the AAF Enersaver PTAC) or PNES Design"B" unit (the Type 45 retrofit chassis). The unit's components did not change when the nomenclature did (a few engineering changes have taken place since this RPL was last issued, and the part number changes are noted). The complete model number nomenclature currently used has been added to this revision. Unless otherwise noted, all components listed in this revision apply to both the current and the original model numbered units. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 2
Parts List Revision History Rev. Date NEW 9/97 A 1/99 Pages 18 & 19 - Corrected description of Ref.# 150 to say "Assy, Wall Sleeve". B 12/99 Page 6 - Added Bubble 8A. Page 7 - Corrected description for Bub. #5 and Bub. #8. Added information for Drain Pan (Bub.#8A). Page 10 - Added Capacitor (Bub. # 38) for size 015,. Page 11 - Added Fan Board (Bub. #8). Corrected description and updated p/n for Motor, (Bub. #57). Corrected Capacitor designation (Bub. #58) for size 015,. Added Motor Mount. Page 13 - Added Receptacle Assy, Plug Assy, Receptacle, Plug, Terminal Pin and Terminal Socket. Page 14 - Updated part number for Freezestat. Page 16 - Added "Before 11/10/97" to title. Page 17 - Added new page 17, "ENR Damper Section - After 11/10/97", re-numbering all pages. C 5/00 Page 9 - Bub #20 Compressor/Rotary 208/230V & Btu's changed to 13200 (was 15000 Btu). D 5/00 Page 12 - Added arrow for bub #92 to drawing. Page 13 - Delete bub #94 (Knob), added "Remote Only' to bub # 95. Add Escutcheon Plate pn 066793601. Page 14 - Made note that bub #92 goes with bub #94. Page 20 - Valve, Complete w/wire Harness' voltages were corrected. (not shown on diagram). E 11/00 Page 11- Added bub #57, pn 06303230, Motor, 1/12 HP double shaft, size 009,, M1. Deleted size 009 from listing of motor, 1/8 HP, double shaft, M1. F 8/02 Page 18 - Part num. 063042801 (Cord set); qty for size 012 changed to qty. of 1 for & qty. of 0 for. G 3/03 Added nomenclature for PNES Designs A & B. Page 4- Added second page to Parts Revision History. Page 5- Ref # 4 added serial number nomenclature for units built 2/99 and later. Page 7- Added new (subsequent pages are re-numbered). Page 8- Removed ref. # 3, 31, 49. Added ref# 14, 15, 16. Added view of PNES2 baffle and ref # 63. Page 9- Ref # 3 removed. Ref # 1 standard construction added p/n for units built after 7/99. Ref # 4 remove astersisk and note. Ref # 5 added p/n 105547501 for units built 7/99 & later. Ref # 13 p/n changed to 073374301.Ref # 14, 15, 16, 63 added. Ref # 30-32 moved from compressor section. Gasket p/n 063110403 moved to condenser fan section. Page 10- Removed ref# 30-32. Page 11- Ref# 30-32 moved to chassis page. Page 12- Ref # 35 added p/n 059024601 for size 015. Ref # 38 removed 015 application for 067291529 and added 067291502 in its place. Page 13- Ref # 54 added new. Ref # 56 added fan wheel hub clamp. Ref # 57 p/n 063032201 removed for sizes 012/015. 073374501 added for 012/015. Ref # 62 removed 063127901 and added 009 usage to 057918301. Page 15- Added note in headline. Added circuit breakers. Page 16- Added note designating parts used only in ENR. Removed wall sleeve footnotes (did not apply to data on page). Added hydronic heat freezestat. Added terminal board, control box top panel and cover. Added circuit breakers. Page 17- Added columns specific to PNES. separated common parts into separate chart. Page 18- Moved motorized components to next page. Subsequent pages are re-numbered. Added ref # 140, 141 to drawing. Page 19 - Separated motorized damper (pre 11/10/97). Page 20 - Added note regarding usage. Page 21 - Added cords for PNES1 & PNES2. Pages 22 thru 24 - reformatted. Pages 25 thru 27 - added new. H 3/05 Page 9 -Bub #32; 80" cap tube part number change from 059031001 to 063090701. continued on next page Daikin Applied, 13600 Industrial Park Blvd., P.O. Box 1551, Minneapolis, MN 55440 (763) 553-5330 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 3
Parts List Revision History Rev. Date J 1/06 Page 15 - Bubbles #85 & 86: pn change from # 067180401 to # 066803901. Bub. #97 Transformer -size 009, pn change from 063042601 to 060630802. Transformer - for change from pn 063042601 to 060630802. Page 21 - ENR Power Cord (Electric heat only) - 250V Hydronic p/n change from 063108601 to 062218131; 2.4 kw p/n change from 063095701 to 062218135; 3.2 kw p/n change from 063042801 to 062218131; 4.3kW p/n change from 063043001 to 062218136. ENR Power Cord (Long Cord) - Wet Heat, 20 amp, p/n change from 06319804 to 062218137; 20 amp 60" long p/n change from 06304801 to 062218131. PNES1 (Design A) Power Cords - Cord Set, Hydronic Heat Units, p/n change from 063042801 to 062218131. PNES2 (Design B) Power Cords - Cord Set, Electric Heat Units, p/n change from 063108701 to 062218136. K 12/09 Page 13 - Ref #57 change Evaporator Fan Motor p/n from 073374501 to 073374502. L 5/12 Rebrand to Daikin Mcquay. Formatted to CS5.5. Page 5- Updated Serial - 2/99 to present. CPL1- Add Critical Parts List. M 10/13 Daikin Rebranding. Add model PREN to title page and nomenclature on pg 7. Drawings were reformatted & numerous changes were done. Page 9- Sheet metal deleted and added footnote1. Added filter p/n 105537401. Deleted Touch-up Paint p/ns 061174723 (antique Ivory) & 061174724 (oxford brown). Page 11- Add new capacitor p/ns 669450001, 910120049 & 910120048. Page 12- Add new capacitor p/ns 669241401, 669241501 & 910120041. Page 13- Add new capacitor p/ns 910120042 & 910120041. Pages 18-19 Ref # 138 Filter change to Screen, Fiberglass. Page 22- Delete ENC000B (ordered with ENR "B") PNES1 Field installed Acc.(not used w/des B). Pages 23-24 Deleted Touch-up Paint p/ns 061174723 (antique Ivory) & 061174724 (oxford brown). Page 25- Added Condensate Kits p/ns 105542401 & 105542410. Added Sensor p/n 668375301 & 107096001. Page 26- Added retrofit kit p/n 063028801 to Installation Kits from pg 26 Rev L. CPL1- Add PREN to title header and delete ENC. Added Fan Housings ASSY for Evaporator & Condenser. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 4
Nomenclature Serial (until 2/99) 7 6A 12345 010 Factory 7 = Auburn, NY Engineering Revision Serial Year and Month of Manufacture: Year Month Z= 1994 A= Jan. 5= 1995 B= Feb. 6= 1996 C= Mar. 7= 1997 D= Apr. 8= 1998 E= May 9= 1999 F= Jun G= Jul H= Aug J= Sep. K= Oct. L= Nov. M= Dec. Serial - 2/99 & later AUB U 99 05 34048 Plant Identification AUB= Auburn U= Unit Serial (build sequence) Week of Manufacture Year of Manufacture 99= 1999 00= 2000 01= 2001 etc. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 5
Nomenclature Model - ENC, ENR ENR 009B 03 18 CC Y UEYM 1 Y Code 01 02 03 04 05 06 07 08 25 01 Unit Type ENR= Enersaver Packaged Terminal Air Conditioner ENC= Wall Sleeve Cabinet Assembly Only 02 Unit Size 009B= Nominal 9000 BTUH Unit 012B= Nominal 12000 BTUH Unit 015B= Nominal 15000 BTUH Unit 000B= Wall Sleeve Cabinet Only 03 Voltage 11= 115/60/1 39= 240/60/1 03= 208/60/1 40= 277/60/1 YY= No Requirement (Wall Sleeve Cabinet Only) 04 Heater YY= None HH= Hydronic (Hot Water or Steam) 18= 1.8 KW Electric 24= 2.4 KW Electric 32= 3.2 KW Electric 43= 4.3 KW Electric 48= 4.8 KW Electric 05 Chassis Type CC= Commercial SG= SG45 Option Wiring YY= No Requirement (Wall Sleeve Cabinet Only) 06 Not an ENR or ENC Item Y= No Requirement 07 Control Type T-Stat Heat Setback Changeover Location Type Control Type UCYY Unit Cool Only None None UCRY Unit Cool Only Remote None UEYM Unit Elect. None Manual UEYA Unit Elect. None Auto UEUM Unit Elect. Unit Manual UEUA Unit Elect. Unit Auto UERM Unit Elect. Remote Manual UERA Unit Elect. Remote Auto UHYM Unit Hydro. None Manual UHYA Unit Hydro. None Auto UHUM Unit Hydro. Unit Manual UHUA Unit Hydro. Unit Auto UHRM Unit Hydro. Remote Manual UHRA Unit Hydro. Remote Auto WEYM Wall Elect. None Manual WEYA Wall Elect. None Auto WEUM Wall Elect. Unit Manual WEUA Wall Elect. Unit Auto WERM Wall Elect. Remote Manual WERA Wall Elect. Remote Auto WHYM Wall Hydro. None Manual WHYA Wall Hydro. None Auto WHUM Wall Hydro. Unit Manual WHUA Wall Hydro. Unit Auto WHRM Wall Hydro. Remote Manual WHRA Wall Hydro. Remote Auto YYYY No Requirement (Wall Sleeve Cabinet Only) 08 Damper 1= Manual Fresh Air Damper 2= Motorized Fresh Air Damper Y= None (Wall Sleeve Cabinet Only) 25 Miscellaneous X= Special Y= No Requirement PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 6
Nomenclature Model - PNES, PREN Code PNES 1 009 C Z 35 Z 12 AR 14 C I C 1 01 & 02 03 04 05 06 07 08 09 10 11 12 13 14 15 01 Unit Type & PNES= Enersaver Packaged Terminal Air Conditioner 02 PREN= Enersaver Packaged Terminal Air Conditioner 03 Unit Design (Vintage) 1= Design A (AAF Enersaver version) 2= Design B (45 replacement chassis) 04 Size (1000's BTUH) 009 012 015 05 Voltage C= 208/60/1 J= 265/277/60/1 06 Coil Options Z= None 07 Heat Options 35= 2.5 KW Electric Heat 41= 3.5 KW Electric Heat 44= 4.0 KW Electric Heat 62= Hydronic Heat w/ Normally Open Valve 63= Hydronic Heat w/ Normally Closed Valve 08 Hand Application Z= Not Applicable 09 Controls 12= Unit Mounted Manual Changeover 24= Unit Mounted MCO + Night Setback (Des. A w/hydronic Heat Only) 10 Discharge AR= Flat Top 11 Return Air/ OA 14= Bottom 12 Power Connection C= Cord 13 Color I= Antique Ivory 14 SKU Type A= Stock B= Standard Leadtime C= Extended Leadtime 15 Product Style 1= 1st Product Style Change PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 7
Chassis Diagram See Compressor Section 29 28 62 27 26 4 7 12 14 10 11 40 41 38 39 See Condenser Fan Section 35 See Condenser Fan Section 2 9 8A 8 36 See Condenser Fan Section 15 5 1 30 13 16 13 31 See Compressor Section 20 6 23 24 25 32 See Compressor Section PNES2 (Design B) Baffle 63 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 8
Chassis Components Ref Part Unit Size No. 009 012 015 1 Panel - End, RH 1 1 1 1 Panel - End, RH, Cold Climate ENR only 1 1 1 1 2 Panel, End, LH 1 1 1 1 Panel, End, LH, Cold Climate ENR only 1 1 1 1 4 Blockoff, Evaporator, Front 1 1 1 1 5 Drain Pan Blockoff, Evaporator 1 1 1 1 6 Pan, Chassis 057919701 1 1 1 7 Bulkhead 1 1 1 1 Bulkhead, Cold Climate ENR only 1 1 1 1 8 Fanboard/Evap. Motor Mount/Drain Pan Assy 063109801 1 1 1 8A Drain Pan only 106228201 1 1 1 9 Blockoff, Evaporator, End RH 1 1 1 1 10 Blockoff, Evaporator, End LH 1 1 1 1 11 Gasket, Bulkhead Top 063110402 1 1 1 12 Gasket, Evaporator Top 063110401 1 1 1 13 Gasket, Condenser Side 2 063050201 2 2 2 14 Gasket 063092701 1 1 1 15 Gasket, Baffle 063110404 1 1 1 16 Baffle, Condensate 1 1 1 1 30 Coil, Condenser 057935201 1 Coil, Condenser 073379501 1 Coil, Condenser 059031001 1 31 Strainer 056303301 1 1 1 32 Cap Tube 52" Long 063061701 1 Cap Tube 40" Long 060634734 1 Cap Tube 80" Long 063090701 1 62 Coil, Evaporator (Room Air) 3 Row 057918301 1 1 Coil, Evaporator (Room Air) 4 Row 059016601 1 63 Baffle, SG45 Chassis PNES2 only 063121101 1 1 1 N/S Screen, Filter Access 063067401 1 1 1 N/S Filter, Throwaway until 3/99 063093501 1 1 1 N/S Filter, Cleanable until 3/99 063081701 1 1 1 Filter, Cleanable 3/99 & later 105537401 1 1 1 N/S= Not Shown on Diagram. 1 Please contact Daikin Applied with unit model and serial number for part numbers on Chassis components. 2 Does not apply to the PNES2 (Design B) units. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 9
Compressor Section Diagrams Sizes 009, 015 20 23 24 25 Size 012 Only 20 23 24 25 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 10
009 012 015 Ref. Part No. 20 Compressor 061086003 1 Compressor 061086002 1 1 Compressor 061086001 1 Compressor 067281302 1 1 Compressor 067281301 1 Compressor 060626701 1 1 Compressor 060626702 1 N/S Compressor Overload 066819603 1 Compressor Overload 066819602 1 1 Compressor Overload 066819601 1 Compressor Overload 057479501 1 1 Compressor Overload 067282801 1 Compressor Overload 300009405 1 1 Compressor Overload 300009404 1 23 Grommet 060623301 3 3 3 3 3 3 3 3 3 3 24 Sleeve 060623401 3 3 3 3 3 3 3 3 3 3 25 Flange Nut 802012035 3 3 3 3 3 3 3 3 3 3 N/S Terminal Cover- Compressor 067280501 1 1 1 N/S Nut- Compressor 066536501 1 1 1 N/S Spring- Compressor 066536301 1 1 1 N/S Gasket- Compressor 066536601 1 1 1 N/S Gasket- Compressor 066536201 1 1 1 26 3 Capacitor, 25 MFD 370V until 3/09 067291512 1 1 1 1 1 1 Capacitor, 25 MFD 370V 3/09 & later 669450001 1 1 1 1 1 1 Capacitor, 20 MFD 370V until 4/12 067291518 1 1 Capacitor, 20 MFD 370V 4/12 & later 910120049 1 1 Capacitor, 25 MFD 440V until 4/12 067291517 1 1 Capacitor, 25 MFD 440V 4/12 & later 910120048 1 1 27 3 Cover - Capacitor 067291601 1 1 1 1 1 1 1 1 1 1 28 3 Bracket - Capacitor 850010570 1 1 1 1 1 1 1 1 1 1 29 3 Screw 040501415 2 2 2 2 2 2 2 2 2 2 N/S= Not Shown on Diagram. * and units apply only to the ENR. 3 Shown on the Chassis Diagram. Compressor Section Components PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 11
Condenser (Outside Air) Fan Section Diagram & Components 35 46 44 45 37 43 35 Detail B 42 36 009 012 015 Ref. Part No. 35 Fan Housing 063065901 1 1 1 1 1 1 1 Fan Housing 059024601 1 1 1 36 Fan Prop 063067901 1 1 1 1 1 1 1 1 1 1 37 Motor, 1/8 HP 073396001 1 Motor, 1/10 HP 073392301 1 1 Motor, 1/10 HP 073392601 1 Motor, 1/6 HP 073392101 1 1 Motor, 1/6 HP 073392401 1 Motor, 1/6 HP 059016401 1 1 Motor, 1/6 HP 059016501 1 38 3 Capacitor, 3 MFD 370V until 3/09 067291501 1 1 1 1 1 1 1 1 Capacitor, 3 MFD 370V 3/09 & later 669241401 1 1 1 1 1 1 1 1 Capacitor, 4 MFD 370V until 6/09 067291502 1 Capacitor, 4 MFD 370V 6/09 & later 669241501 1 Capacitor, 4 MFD 440V until 4/12 067291525 1 Capacitor, 4 MFD 440V 4/12 & later 910120041 1 39 3 Cover, Capacitor, Std. 067291602 1 1 1 1 1 1 1 1 1 1 40 3 Bracket, Capacitor 850010570 1 1 1 1 1 1 1 1 1 1 41 3 Screw 040501415 2 2 2 2 2 2 2 2 2 2 42 Motor Mount 063030001 1 1 1 1 1 1 1 1 1 1 43 Spacer 063077101 3 3 3 3 3 3 3 3 3 3 44 Grommet, Tube 035928100 3 3 3 3 3 3 3 3 3 3 45 Grommet, Washer 035928000 3 3 3 3 3 3 3 3 3 3 46 Nut 063060601 3 3 3 3 3 3 3 3 3 3 * and units apply only to the ENR. 3 Shown on the Chassis Diagram. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 12
Evaporator (Room Air) Fan Section Diagram & Components 54 8 8 57 55 56 55 57 55 8 56 61 59 58 60 Day Stat (REF. Unit Mounted Thermostat Cap Tube) 009 012 015 Ref. Part No. 8 Fan Board 063109801 1 1 1 1 1 1 1 1 1 1 1 1 54 Gasket- Fan Board 063110403 1 1 1 1 1 1 1 1 1 1 1 1 55 Fan Housing 063030701 2 2 2 2 Fan Housing 063030702 2 2 2 2 2 2 56 Fan Wheel 063050401 2 2 2 2 2 2 2 2 2 2 N/S Clamp- Wheel Hub 066534601 2 2 2 2 2 2 2 2 2 2 57 Motor 1/12 HP 063032101 1 Motor 1/12 HP 063032201 1 1 Motor 1/12 HP 063032301 1 Motor 1/8 HP 073374502 1 1 1 1 Motor 1/8 HP 073374601 1 1 58 Capacitor, 5 MFD 370V until 4/12 063031701 1 1 Capacitor, 5 MFD 370V 4/12 & later 910120042 1 1 Capacitor, 4 MFD 370V until 4/12 063031601 1 1 1 1 1 1 1 1 Capacitor, 4 MFD 370V 4/12 & later 910120041 1 1 1 1 1 1 1 1 59 Bracket, Cover-Capacitor 063067801 1 1 1 1 1 1 1 1 1 1 60 Screw 040501415 4 4 4 4 4 4 4 4 4 4 61 Clamp-Motor Mounting 063048201 2 2 2 2 2 2 2 2 2 2 N/S Motor Mount 063110302 1 1 1 1 1 1 1 1 1 1 62 3 Coil- Evaporator (Room Air) 3 Row, 3/8" Tube 057918301 1 1 1 1 1 1 1 Coil- Evaporator (Room Air) 4 Row, 3/8" Tube 059016601 1 1 1 N/S= Not Shown on diagram. * and units apply only to the ENR. 3 Shown on the Chassis Diagram. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 13
Control Box Diagrams PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 14
Control Box Wall Mounted Thermostats- ENR Only Components 009 012 015 Ref. Part No. 85 Relay-Cool R2 067180401 1 1 1 1 1 1 1 1 1 1 86 Relay-Heat, Wet Heat R3 061019403 1 1 1 1 1 1 1 1 1 1 Relay-Heat, Electric Heat R3 067180401 1 1 1 1 1 1 1 1 1 1 87 Relay-Fan R4 063097101 1 1 1 1 1 1 1 1 1 1 88 Relay-Setback R5 803005121 1 1 1 1 1 1 Relay-Setback R5 803005120 1 1 1 90 Relay-Remote Setback TDR 073386101 1 1 1 1 1 1 1 1 1 1 91 Switch-Push Button (3) PB 063039601 1 1 1 1 1 1 1 1 1 1 92 Thermostat-Manual Changeover TH1 063040701 1 1 1 1 1 1 1 1 1 1 Thermostat-Man.Changeover+Fan SW TH1 063041001 1 1 1 1 1 1 1 1 1 1 Thermostat-Auto Changeover TH1 063040401 1 1 1 1 1 1 1 1 1 1 N/S Subbase-Auto Changeover Stat 063049001 1 1 1 1 1 1 1 1 1 1 93 Thermostat-Setback TH2 073394201 1 1 1 1 1 1 1 1 1 1 95 Thermostat-Low Limit, Remote Only TH3 057930001 1 1 1 1 1 1 1 1 1 1 97 Transformer X1 063042601 1 Transformer X1 063042401 1 1 1 1 1 1 Transformer X1 060630701 1 1 1 146 Circuit Breaker 15 Amp 063096101 1 1 1 1 Circuit Breaker 20 Amp 063096102 1 1 1 Circuit Breaker 15 Amp 063096201 1 1 1 1 1 1 Circuit Breaker 20 Amp 063096202 1 1 1 1 1 1 Circuit Breaker 30 Amp 063096203 1 1 1 1 1 1 N/S Thermostat-Low Ambient TH9 073385301 1 1 1 1 1 1 1 1 1 1 N/S Escutcheon Plate 066793601 1 1 1 1 1 1 1 1 1 1 N/S Receptacle Assembly 063105303 1 1 1 1 1 1 1 1 1 1 N/S Plug Assembly 107174152 1 1 1 1 1 1 1 1 1 1 N/S Receptacle 047934204 1 1 1 1 1 1 1 1 1 1 N/S Plug 802007736 1 1 1 1 1 1 1 1 1 1 N/S Terminal Pin 034247401 6 6 6 6 6 6 6 6 6 6 N/S Terminal Socket 802007741 6 6 6 6 6 6 6 6 6 6 N/S= Not Shown on diagram. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 15
Control Box Unit Mounted Thermostats Components 009 012 015 Ref. Part No. 88 Relay, Setback 4 R5 803005121 1 1 1 1 1 1 Relay, Setback 4 R5 803005120 1 1 1 90 Relay, Remote Setback, Wet Heat 4 TDR 073386101 1 1 1 1 1 1 1 1 1 1 Relay, Remote Setback Cool 4 TDR 063041701 1 1 1 1 1 1 1 1 1 1 Relay, Remote Setback Elec. Heat 4 TDR 063041901 1 1 1 1 1 1 1 1 1 1 91 Switch, Push Button,(5) Man. Changeover PB 063039801 1 1 1 1 1 1 1 1 1 1 Switch, Push Button, (3) Auto Changeover 4 PB 063039601 1 1 1 1 1 1 1 1 1 1 92 Thermostat, Manual Changeover TH1 073394101 1 1 1 1 1 1 1 1 1 1 Thermostat, Auto Changeover 4 TH1 073398001 1 1 1 1 1 1 1 1 1 1 93 Thermostat, Setback TH2 073394201 1 1 1 1 1 1 1 1 1 1 94 Knob- Changeover Thermostat 073397001 1 1 1 1 1 1 1 1 1 1 N/S Thermostat, Low Ambient TH9 073385301 1 1 1 1 1 1 1 1 1 1 146 Circuit Breaker 4 15 Amp 063096101 1 1 1 1 Circuit Breaker 4 20 Amp 063096102 1 1 1 Circuit Breaker 4 15 Amp 063096201 1 1 1 1 1 1 Circuit Breaker 4 20 Amp 063096202 1 1 1 1 1 1 Circuit Breaker 4 30 Amp 063096203 1 1 1 1 1 1 N/S Terminal Board Electric Heat Units 802007090 2 2 2 2 2 2 2 2 2 Hydronic Heat Units 802007090 1 1 1 1 1 1 1 1 1 1 N/S Freezestat- Electric Heat Units TC5 106229401 1 1 1 1 1 1 1 1 1 N/S Freezestat- Hydronic Heat Units TC5 073380001 1 1 1 1 1 1 1 1 1 1 N/S Panel- Control Box Top 056931301 1 1 1 1 1 1 1 1 1 1 N/S Panel- Control Box Cover 056929001 1 1 1 1 1 1 1 1 1 1 N/S= Not shown on diagram. * and units apply only to the ENR. 4 Used only on ENR units. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 16
Electric Heat Section Diagram & Components 120 124 120 121 125 122 or 123 Fan Board Common Parts Ref. Part Qty. No. 121 Clamp-Element 063022101 4 4 4 122 Mount-Heater Right-Hand 063050001 2 2 2 123 Mount-Heater Left-Hand 063050002 2 2 2 124 Wire Harness 056936401 1 1 1 125 Overheat Stat-Disc+150F OH 063040901 1 1 1 Heaters Volt. Ref. ENR PNES Heater Part No. Code 04= Code 07= Position 120 18 N/A Both 063079705 2 24 35 Right-hand 063079701 1 24 35 Left-hand 063079705 1 32 41 Right-hand 063079702 1 32 41 Left-hand 063079701 1 43 44 Right-hand 063079703 1 43 44 Left-hand 063079702 1 48 N/A Both 063079703 2 18 N/A Both 063079704 2 24 N/A Both 063079705 2 32 N/A Right-hand 063079701 1 32 N/A Left-hand 063079705 1 43 N/A Right-hand 063079702 1 43 N/A Left-hand 063079701 1 48 N/A Both 063079702 2 24 35 Both 063079704 2 32 41 Both 063079705 2 43 44 Right-hand 063079701 1 43 44 Left-hand 063079705 1 N/A= Not applicable. * units apply only to the ENR. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 17
Damper Section- Manual Diagram & Components 140 132 141 131 138 130 Ref. Part Qty. No. 130 Damper 063018801 1 131 Lever, Damper Operator 063018901 1 132 Angle, Lever 063018401 1 138 Screen, Fiberglass 063118801 1 140 Gasket 063092702 2 141 Gasket 063092703 2 N/S Tap Screw 106083702 4 N/S= Not shown on diagram. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 18
Damper Section- Motorized ENR- until 11/97 Diagram & Components 137 138 137 136 135 135 134 133 134 009 012 015 Ref. Part No. 133 Damper 063018301 1 1 1 1 1 1 1 1 1 1 134 Shaft, Damper 063089401 1 1 1 1 1 1 1 1 1 1 135 Spring, Damper 063089501 1 1 1 1 1 1 1 1 1 1 136 Toggle Switch, SPST SW2 802005045 1 1 1 1 1 1 1 1 1 1 137 Motor 063078801 1 137 Motor 063078901 1 1 1 1 1 1 137 Motor 063079001 1 1 1 138 Screen, Fiberglass 063118801 1 1 1 1 1 1 1 1 1 1 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 19
Damper Section- Motorized ENR/PNES- 11/97 & later Diagram & Components 9 8 Detail A 10 12 11 6 4 2 5 3 7 Detail A 24 1 Detail B Detail B 009 012 015 Ref. Part No. 1 Support, Damper Motor 105904901 1 1 1 1 1 1 1 1 1 1 2 Damper Lever 105905001 1 1 1 1 1 1 1 1 1 1 3 Channel Operating Arm 062968001 1 1 1 1 1 1 1 1 1 1 4 Spring Nut 802017023 1 1 1 1 1 1 1 1 1 1 5 Spring, Extension 105905401 1 1 1 1 1 1 1 1 1 1 6 Screw, Tap, 8-18 x.38 106083702 4 4 4 4 4 4 4 4 4 4 7 Washer 040500301 2 2 2 2 2 2 2 2 2 2 8 Damper 063018801 1 1 1 1 1 1 1 1 1 1 9 Gasket 063092702 2 2 2 2 2 2 2 2 2 2 10 Gasket 063092703 2 2 2 2 2 2 2 2 2 2 11 Screen, Fiberglass 063118801 1 1 1 1 1 1 1 1 1 1 12 Bushing, Snap-in 105905601 1 1 1 1 1 1 1 1 1 1 24 Motor 802024015 1 1 1 24 Motor 802024037 1 1 1 24 Motor 802024016 1 1 1 N/S Switch, Rocker, SPDT 047357307 1 1 1 1 1 1 1 1 1 1 N/S= Not shown on diagram. * and units apply only to the ENR. PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 20
Power Cords Components ENR Power Cords for Building Receptacles Installed by Others- Electric Heat Only 009 012 015 Part Cord Set, 250V - Hydronic 062218131 1 1 1 Cord Set, 125V - UCYY, UCRY 063110001 1 Cord Set, (2.4 kw) 15 amp, 60" Lg. 062218135 1 1 1 1 1 1 Cord Set, (3.2 kw) 20 amp, 60" Lg. 062218131 1 1 1 1 1 1 Cord Set, (4.3/4.8 kw) 30 amp, 60" Lg. 062218136 1 1 1 1 1 1 ENR Power Cords Permanently Connected to AAF Wall Sleeve- Short Cabinet 009 012 015 Part Cord Set, 20 amp, 20" Lg. 063042701 1 1 1 1 1 1 Cord Set, 20 amp, 20" Lg. 063043101 1 1 1 Receptacle, 20 amp 047139805 1 1 1 1 1 1 Receptacle, 20 amp 047139802 1 1 1 ENR Power Cords Permanently Connected to AAF Wall Sleeve- Long Cabinet 009 012 015 Part Cord Set, Wet Heat, 20 amp 062218137 1 Cord Set, 20 amp, 60" Lg. 062218131 1 1 1 1 1 1 Cord Set, (2.4 kw) 15 amp, 60" Lg. 063043201 1 1 1 Receptacle, 20 amp 047139808 1 Receptacle, 20 amp 047139805 1 1 1 1 1 1 Receptacle, 20 amp 047139802 1 1 1 PNES1 (Design A) Power Cords 009 012 015 Part Cord Set- Electric Heat Units 063042701 1 1 1 Cord Set- Electric Heat Units 063043101 1 1 1 Cord Set- Hydronic Heat Units 062218131 1 1 1 Cord Set- Hydronic Heat Units 063043201 1 1 1 PNES2 (Design B) Power Cords 009 012 015 Part Cord Set- Electric Heat Units 062218136 1 1 1 Cord Set- Electric Heat Units 057041801 1 1 1 Cord Set- Hydronic Heat Units 063108601 1 1 1 Cord Set- Hydronic Heat Units 057041801 1 1 1 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 21
Wall Sleeve Cabinet Assembly Diagrams 165 Short Cabinet- 37.5" Long (Electric Heat Units) 172 173 150 174 163 164 171 166 170 165 172 160 173 150 174 163 164 Long Cabinet- 41.50" Long (Hydronic Heat Units) 162 171 162 160 161 168 169 166 170 167 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 22
Wall Sleeve Cabinet Assembly Ref. Part Qty. No. 150 Wall Sleeve Assembly- Short Cabinet Standard 063099202 1 Sea Coast ENR Only 063099208 1 Cold Climate ENR Only 063099214 1 163 Access Door Standard Construction 063010390 1 Sea Coast ENR Only 063010380 1 164 Access Door w/ Lock Standard Construction ENR Only 063086001 1 Sea Coast ENR Only 063086002 1 165 Lock and Keys Only ENR Only 063050101 1 166 Clip - Hinge 063060801 1 167 Hinge Pin 063099001 1 168 Junction Box ENR Only 4EQB33 1 169 Cover-Junction Box ENR Only 802007355 1 170 Gasket 063092901 1 171 Gasket 063110405 1 172 Bracket-Chassis Support 063010601 2 173 Nut until 5/99 040499901 2 Nut 5/99 & later 105915801 2 174 Discharge Grille 5 063130190 1 N/S Subbase- 5" 063099520 1 N/S Front Panel-Solid Standard 063017290 1 Sea Coast ENR Only 063017280 1 Cold Climate ENR Only 063101701 1 N/S Front Panel-Louver 063101601 1 N/S Screw-Front Panel 038990701 6 N/S Exterior Louver Stamped ENR Only 063021901 1 Extruded 063031401 1 N/S= Not shown on diagram. 5 Spotwelded into wall sleeve assembly. Short Cabinet Components PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 23
Wall Sleeve Cabinet Assembly Ref. Part Qty. No. 150 Wall Sleeve Assembly- Long Cabinet Standard- Hydronic Heat 063099201 1 Sea Coast- Hydronic Heat ENR Only 063099207 1 Cold Climate- Hydronic Heat ENR Only 063099213 1 Standard- Electric Heat ENR Only 063099203 1 Sea Coast ENR Only 063099209 1 Cold Climate ENR Only 063099215 1 160 Blockoff- Hydronic Coil 063010490 1 161 Hydronic Heat Coil YRF26A 1 162 Screw- Hydronic Coil 038990701 6 163 Access Door Standard Construction 063010390 1 Sea Coast ENR Only 063010380 1 164 Access Door w/ Lock Standard Construction ENR Only 063086001 1 Sea Coast ENR Only 063086002 1 165 Lock and Keys Only ENR Only 063050101 1 166 Clip - Hinge 063060801 1 167 Hinge Pin 063099001 1 168 Junction Box ENR Only 4EQB33 1 169 Cover-Junction Box ENR Only 802007355 1 170 Gasket 063092901 1 171 Gasket 063110405 1 172 Bracket-Chassis Support 063010601 2 173 Nut until 5/99 040499901 2 Nut 5/99 & later 105915801 2 174 Discharge Grille 5 063130190 1 N/S Subbase- 5" 063099502 1 N/S Front Panel-Solid Standard 063017390 1 Sea Coast ENR Only 063017380 1 Cold Climate ENR Only 063101702 1 N/S Front Panel-Louvered Standard Only ENR Only 063101602 1 N/S Screw-Front Panel 038990701 6 N/S Exterior Louvered Stamped ENR Only 063022001 1 Extruded 063031301 1 N/S= Not shown on diagram. 5 Spotwelded into wall sleeve assembly. Long Cabinet Components PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 24
Field Installed Accessories Receptacles (field installed in short cabinet subbase or long cabinet end compartment) Part Receptacle- 20 Amp- Units 047139805 Receptacle- 20 Amp- 265V Units 047139802 Optional Room Cabinet Front Panel (used when unit is floor mounted WITHOUT electrical subbase) Part Louvered Front Panel Short Cabinet 063018090 Long Cabinet 056952190 Angle, Blockoff- either size 063018190 Gasket- either size 063091808 Replacement Filter Part Filter, Permanent- Cleanable 30.38" x 7.06" x.25" 063081701 Outdoor Stamped Louvers (clear anodized aluminum flanged to cover oversized outdoor opening) Part Short Cabinet 107322501 Long Cabinet 107322502 Condensate Drain Kit Part Tube Drain Kit for Heat Pumps 1 Pack 105542401 Tube Drain Kit for Heat Pumps 10 Pack 105542410 Sensor- Wall Mounted Part TStat- AC/DC, ACO, 7-Day Programmable, 2 Heat/2 Cool 668375301 Remote Sensor for TSat 668375301 107096001 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 25
Field Installed Accessories Installation Kits and Accessories Part Deflector- Discharge Air 063085401 Front Panel- Louvered Short Cabinet 063017701 Long Cabinet 063017801 Intake Collar- 1½" Outdoor Short Cabinet 063021103 Long Cabinet 063021104 Intake Collar- 4½" Outdoor Short Cabinet 063021102 Long Cabinet 063021101 Wall Guard Flange- 3 Sided, Indoor Short Cabinet 063016701 Long Cabinet 063016702 Thermostat Limiter 063029501 Retrofit Kit for Type SG45 PNES2 only 063028801 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 26
Field Installed Accessories Hydronic Valves- ENR Units Part Valve w/harness 063102301 Valve w/harness 063102302 Valve w/harness 230V 063102303 Valve w/harness 063102304 Hydronic Valves- PNES1 (Design A) Units Part Normally Open 2 Way Valve w/actuator until 4/00 Assembly- 063049103 Assembly- 063049104 Assembly- 063049105 Normally Open 2 Way Valve 4/00 & later Valve Body 106233501 Actuator- 106233903 Actuator- 106233904 Actuator- 106233905 Hydronic Valves- PNES2 (Design B) Units Part Normally Closed 3 Way Valve w/actuator until 4/00 Assembly- 802026113 Assembly- 802026112 Assembly- 802026114 Normally Closed 3 Way Valve 4/00 & later Valve Body 106233601 Actuator- 106233803 Actuator- 106233804 Actuator- 106233805 PTAC; ENC 000 Vint. B / ENR 009-015 Vint. B / PNES, PREN 009-015 Des. A & B Rev. M 10/13 RPL 571144 / Page 27
Critical Daikin Applied OEM Parts Are What Your Daikin Applied HVAC Unit Needs! McQuay Packaged Terminal Heat Pump AAF Packaged Terminal Heat Pump ENR, Unit Sizes 009-015, Vintage B PNES, PREN Unit Sizes 009-015, Designs A & B CRITICAL COMPONENTS MODEL UNIT SIZE VOLTAGE PART NUMBER COMPRESSOR 9100 BTUH ALL 009 115/60/1 061086003 9100 BTUH ALL 009 208-230/60/1 061086002 9100 BTUH ALL 009 265/60/1 061086001 11350 BTUH ALL 012 208-230/60/1 067281302 11350 BTUH ALL 012 265/60/1 067281301 13200 BTUH ALL 015 208-230/60/1 060626701 13200 BTUH ALL 015 265/60/1 060626702 CONDENSER MOTOR Motor, 1/8 HP ALL 009 115/60/1 073396001 Motor, 1/10 HP ALL 009 208-230/60/1 073392301 Motor, 1/10 HP ALL 009 265/60/1 073392601 Motor, 1/6 HP ALL 012 208-230/60/1 073392101 Motor, 1/6 HP ALL 012 265/60/1 073392401 Motor, 1/6 HP ALL 015 208-230/60/1 059016401 Motor, 1/6 HP ALL 015 265/60/1 059016501 EVAPORATOR MOTOR Motor, 1/12 HP ALL 009 115/60/1 063032101 Motor, 1/12 HP ALL 009 208-230/60/1 063032201 Motor, 1/12 HP ALL 009 265/60/1 063032301 Motor, 1/8 HP ALL 012, 015 208-230/60/1 073374502 Motor, 1/8 HP ALL 012, 015 265/60/1 073374601 DAMPER MOTOR Motor ALL ALL 115V 063078801 Motor ALL ALL 208/230V 063078901 Motor ALL ALL 265V 063079001 FAN HOUSING ASSY & WHEEL Fan Housing Assy- Condenser ALL 009, 012 N/A 063065901 Fan Housing Assy- Condenser ALL 015 N/A 059024601 Fan Prop- Condenser ALL ALL N/A 063067901 Fan Housing Assy- Evaporator ALL 009 N/A 063030701 Fan Housing Assy- Evaporator ALL 012, 015 N/A 063030702 Wheel- Evaporator ALL ALL N/A 063050401 Call Your Local Daikin Applied Parts Distributor For All Your Parts Needs. To Locate A Distributor, Go To www.daikinapplied.com or Call 1-800-37PARTS 571144 Rev. M 10/2013 CPL Page 1 of 1