Section 1 Chemical Product and Company Identification Product Name: Manufacturer: Barton International 6 Warren St. Glens Falls, NY 12801 Telephone: 518.798.5462 Emergency Telephone: 800.741.7756 Section 2 Hazard Identification Physical State: Emergency Overview: Potential Acute Health Effects Eyes: Skin: Potential Chronic Health Effects Solid, granular Due to the low toxicity of this product, it is not expected to pose a risk of acute or chronic health effects of released or spilled. However, spills should be immediately cleaned by sweeping or vacuuming. May cause respiratory irritation upon exposure to high airborne concentrations. May cause eye irritation if material contacts eye. May cause irritation to eyes May cause irritation or abrasion May cause irritation upon exposure to high airborne concentrations May cause digestive irritation, but not expected to cause adverse systemic effects Not likely to cause chronic effects to any target organs or systems Medical Conditions Potentially Aggravated by Overexposure: expected GHS Health Hazard Classification: GHS Physical Hazard Classification: GHS Signal Word(s): Required GHS Hazard Statement(s): Required GHS Precautionary Statement(s): Required GHS Pictograms: Required NFPA Hazard Classification: Health: 0, Fire: 0, Reactivity: 0 HMIS Hazard Classification Health: 0, Fire: 0, Reactivity: 0, Protection: K Section 3 Composition / Mixture Ingredient Information Ingredient (Component) CAS Number %wt. SiO2 (Silicates - Amorphous) * MgO (Magnesium Oxide) Fe2O3 (Iron Oxide) Al2O3 (Aluminum Oxide) CaO (Calcium Oxide) Ni (Nickel) and NiO (Nickel Oxide) Cr2O3 (Chromium Oxide) Trace Elements and Compounds 112926-00-8 1309-48-4 1309-37-1 1344-28-1 1305-78-8 7440-02-0 1308-38-9 50.2 31.4 15.9 1.6 0.7 <0.1 0.1 1.5 * Contains no free crystalline silica Page 1 of 5
Section 4 First Aid Measures Eye Contact: Skin Contact: Remove from exposure situation and move to fresh air. Seek medical attention if symptoms persist. Flush eyes with large amounts of water for 15 minutes. Remove contact lenses, hold eyelids open to ensure thorough flushing. Seek medical attention if eye damage is suspected. Wash or brush material off skin. If irritation occurs, seek medical attention. If person is conscious, give large quantity of water and induce vomiting; however, never attempt to make an unconscious person drink or vomit. Get immediate medical attention. Section 5 Fire-Fighting Measures Flammability: Flash Point: Flash Point Method: Auto-ignition Temperature: LEL: UEL: Extinguishing Media: Products of Combustion: Fire-Fighting Instructions: Fire-Fighting Equipment: Non-Flammable, Non-Combustible Not Established Section 6 Accidental Release Measures Spill and Leak Procedure: Containment: Regulatory Requirements: Clean spills with broom, vacuum cleaner, shovel or scoop. Although the toxicity of this product is extremely low, it is advisable to minimize the creation of airborne dust. Contain spilled material in an appropriate container. Dispose of waste material in accordance with federal, state and local solid waste disposal regulations and requirements. Section 7 Handling and Storage Handling Precautions: Storage Requirements: Avoid generating excessive airborne dust. No special storage requirements. Page 2 of 5
Section 8 Exposure Controls / Personal Protection Occupational Exposure Limits* OSHA PEL ACGIH TLV NIOSH REL NIOSH Ingredient TWA STEL TWA STEL TWA STEL IDLH Amorphous Silica 1 10 mg/m 3 10 mg/m 3 6 mg/m3 3000 mg/m 3 Magnesium Oxide 15 mg/m 3 10 mg/m 3 750 mg/m 3 Iron Oxide (Dust) 10 mg/m 3 5 mg/m 3 mg/m 3 2500 mg/m 3 Aluminum Oxide 2 10 mg/m 3 Aluminum Oxide 3 5 mg/m 3 1 mg/m 3 Calcium Oxide 5 mg/m 3 2 mg/m 3 2 mg/m 3 25 mg/m 3 Nickel 1 mg/m 3 1.5 mg/m 3 0.015 mg/m 3 10 mg/m 3 Chromium Oxide 0.5 mg/m 3 0.5 mg/m 3 1 As amorphous silica and non-crystalline silicates 2 As total dust 3 As respirable dust *Refer to federal, state and local occupational exposure limits. Some jurisdictions have published limits that are different from those listed. Exposure Controls and Personal Protection Engineering Controls: Respiratory Protection: Protective Clothing: Hygiene Practices: Provide general or local exhaust ventilation systems in order to maintain airborne concentrations below occupational exposure limits. Local exhaust ventilation should be used whenever possible to prevent the dispersal of airborne contaminants into the work area. Obtain professional assistance in selecting the appropriate and adequate respiratory protection. If necessary, use the appropriate MSHA/NIOSH approved respirator when engineering controls are not feasible. Chemical protective clothing should not be required under normal circumstances when using this material. Never eat, drink, use tobacco products or apply cosmetics in areas where hazardous chemicals are used. Employees should wash their hands thoroughly prior to engaging in any of these activities. Section 9 Physical and Chemical Properties Appearance and Odor: Grey, green granular solid Boiling Point: Vapor Pressure (mm Hg): Vapor Density (Air = 1): Specific Gravity (Water = 1): 3.0 Melting Point: 2650 deg. F Evaporation Rate: Water Solubility: Not soluble in water Page 3 of 5
Section 10 Stability and Reactivity Stability: Conditions to Avoid: Incompatibility (Materials to Avoid): Hazardous Decomposition or By-Products: Hazardous Polymerization: Conditions to Avoid: Stable Will Not Occur Section 11 Toxicological Information Toxicity Data: * Toxicity Carcinogenicity Ingredient (LD50) NTP IARC OSHA SiO2 (Silicates - Amorphous) >10000 mg/kg No No No MgO (Magnesium Oxide) Not Available No No No Fe2O3 (Iron Oxide) 5500 mg/kg No No No CaO (Calcium Oxide) 7340 mg/kg No No No Ni (Nickel) and NiO (Nickel Oxide) >9000 mg/kg No No No Cr2O3 (Chromium Oxide) >10000 mg.kg No No No Potential Acute Health Effects Eyes: Skin: Potential Chronic Health Effects Medical Conditions Potentially Aggravated by Overexposure: May cause respiratory irritation upon exposure to high airborne concentrations. May cause eye irritation if material contacts eye. May cause irritation to eyes May cause irritation or abrasion May cause irritation upon exposure to high airborne concentrations May cause digestive irritation, but not expected to cause adverse systemic effects Not likely to cause chronic effects to any target organs or systems expected * See NIOSH for additional toxicity data. Section 12 Ecological Information Ecotoxicity: Environmental Fate: Environmental Transport: Environmental Degradation: No ecotoxicity effects known or anticipated Page 4 of 5
Section 13 Disposal Considerations Refer to federal, state and local waste disposal rules and requirements for proper disposal method. Section 14 Transport Information DOT Transportation Data (49 CFR 172.101): This product, as produced and offered, is not listed as a Hazardous Material by the Department of Transportation in 49 CFR 172. Section 15 Additional Regulatory Information This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right to Know Act of 1986 (EPCRA 40 CFR 372): Ni (Nickel) and NiO (Nickel Oxide) 7440-02-0 <0.1% Note: Refer to your federal, state and local environmental, safety and health regulatory agencies for specific additional regulatory requirements in your location. Section 16 Other Information Revision Date: July 31 st, 2017 Disclaimer: While the information included in this SDS has been obtained from reliable sources, this information is furnished without any warranty (expressed or implied), representation, inducement, or license except that it is accurate to the best of Barton International s knowledge. This information is offered solely for your consideration, investigation, and verification. Any use of this information must be determined by the user to be in accordance with applicable federal, state, and local laws and regulations. Furthermore, the conditions or methods of handling, storage, use and disposal of the product are beyond the control and knowledge of Barton International. Barton International does not assume responsibility and expressly disclaim liability for any loss, damage, or expense arising out of or in any way connected with the handling, storage, use, or disposal of the product. Buyer assumes all risks in its use of the product. Page 5 of 5