Experimental / Development Only Safety Data Sheet (SDS) NFPA Rating (US Only) HEALTH 1 FLAMMABILITY 0 REACTIVITY 0 PERSONAL PROTECTION 0 Date of Issue: 1/21/14 Date of Rev: 4/22/14 Date of Review: 4/22/14 SECTION I PRODUCT AND COMPANY IDENTIFICATION Product Name Gap Pad HC 3.0 Manufacturer/Supplier The Bergquist Company Address 18930 West 78th Street Emergency Telephone Information CHEMTREC: (800) 424-9300 Info Telephone: (952) 835-2322 City Chanhassen State MN Zip 55317 Contact Person M-SDSadmin@BergquistCompany.com Recommended Use and Limitations on Use Thermally Conductive Interface Material SECTION II HAZARDS IDENTIFICATION Hazard Classification: Classification according to Directive 67/548/EEC or 1999/45/EC as amended This preparation does not meet the criteria for classification according to Directive 1999/45/EC as amended. Classification according to Regulation (EC) No 1272/2008 as amended This mixture does not meet the criteria for classification according to Regulation (EC) 1272/2008 as amended. Physical Hazards Not classified Health Hazards Not classified Environmental Hazards Not classified Label Elements NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 1 of 7
Symbols None Signal word Hazard Statement None The mixture does not meet the criteria for classification Precautionary Statement Prevention Response Storage Observe good industrial hygiene practices Wash thoroughly after handling Store away from incompatible material Disposal Dispose of contents/container in accordance with local / regional / national / international regulations SECTION III COMPOSITION/INFORMATION ON INGREDIENTS Substance: Mixture: Chemical Name EINECS Number CAS Number CAS Weight % REACh Registration Number The components are not hazardous or are below required disclosure limits. This product is considered an article. First aid measures for different exposure routes SECTION IV FIRST AID MEASURES Inhalation Skin contact Eye contact Ingestion. Most important symptoms and effects Personal protection for first aid responders Wear gloves NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 2 of 7
Notes to physician Not established SECTION V FIRE-FIGHTING MEASURES General fire hazards Material will burn Extinguishing media Suitable extinguishing media Extinguishing media to avoid Specific hazards during fire fighting Special fire fighting procedures Protection of fire-fighters Use water or other media appropriate for surroundings Burns and/or smoke inhalation SECTION VI ACCIDENTAL RELEASE MEASURES Personal precautions Environmental precautions Spill cleanup methods Other information Pick up spilled material SECTION VII HANDLING AND STORAGE Handling Precautions Safe handling advice Storage Technical measures Suitable storage conditions Incompatible materials Wear gloves No special storage hazards Room temperature and humidity SECTION VIII EXPOSURE CONTROLS / PERSONAL PROTECTION Exposure limits Components Type Value Form US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000) NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 3 of 7
Aluminium oxide (1344-28-1) PEL 5 mg/m3 Respirable fraction 15 mg/m3 Total Dust US ACGIH Threshold Limit Values Aluminium oxide (1344-28-1) TWA 1 mg/m3 Respirable fraction Aluminium oxide (1344-28-1) TWA 1mg/m3 Respirable Fraction Engineering Measures Personal protective equipment Respiratory protection Hand protection Eye protection Skin and body protection Wear gloves and personal protective equipment Wear gloves Wear safety glasses Wear lab coat Hygiene measures Wash hands after using material SECTION IX PHYSICAL AND CHEMICAL PROPERTIES Appearance Physical State Solid Form Solid Color Solid Odor No odor Odor threshold ph Melting point/freezing point Boiling point, initial boiling point, and boiling range Flash point Auto-ignition temperature Flammability (solid, gas) Flammability limit lower (%) Flammability limit upper (%) Explosive limit lower (%) Explosive limit upper (%) Vapor Pressure (mm Hg) Evaporation rate Vapor Density (air = 1) Density 3.1 Specific gravity 3.1 Relative density Solubility Decomposition temperature Oxidizing properties Partial Coefficient (n-octanol / water) Explosive properties NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 4 of 7
SECTION X STABILITY AND REACTIVITY Stability Conditions to avoid Incompatible materials Hazardous decomposition products Stable Strong oxidizers Possibility of hazardous reactions SECTION XI TOXICOLOGICAL INFORMATION Acute toxicity Routes of exposure Symptoms Skin corrosion / irritation Serious eye damage/eye irritation Respiratory sensitizer Skin sensitizer Germ cell mutagenicity Carcinogenicity Toxic to reproduction Specific target organ toxicity single exposure Specific target organ toxicity repeated exposure Aspiration hazard Chronic effects SECTION XII ECOLOGICAL INFORMATION Eco-toxicity Bioaccumulation Persistence and degradability Other hazardous effects Mobility in soil SECTION XIII DISPOSAL CONSIDERATIONS Contaminated packaging Local disposal regulations Follow all local, state and federal disposal regulations Follow all local, state and federal disposal regulations International regulations SECTION XIV TRANSPORTATION INFORMATION IATA IMDG TDG The product is not covered by international regulation on the transport of dangerous goods. The product is not covered by international regulation on the transport of dangerous goods. The product is not covered by international regulation on the transport of dangerous goods. Domestic regulations DOT The product is not covered by on the transport of hazardous materials NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 5 of 7
Other regulations None SECTION XV REGULATORY INFORMATION Applicable Regulations (Domestic and International) Safety, health and environmental regulations/legislation specific for the substance or mixture US federal regulations This product is not known to be a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR 1910.1200. All components are on the U.S. EPA TSCA Inventory List. TSCA Section 12(b) Export Notification (40 CFR 707, Subpt. D) Not regulated. US. OSHA Specifically Regulated Substances (29 CFR 1910.1001-1050) Not listed. CERCLA Hazardous Substance List (40 CFR 302.4) Not listed Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - No Delayed Hazard - No Fire Hazard - No Pressure Hazard - No Reactivity Hazard - No SARA 302 Extremely hazardous substance Not listed. SARA 311/312 Hazardous chemical No SARA 313 (TRI reporting) Chemical name CAS number % by wt. Aluminum oxide 1344-28-1 60-90 Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List Not regulated Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR 68.130) Not regulated. Safe Drinking Water Act (SDWA) Not regulated. US state regulations This product does not contain a chemical known to the State of California to cause cancer, birth defects or other reproductive harm. US. Massachusetts RTK - Substance List US. New Jersey Worker and Community Right-to-Know Act US. Pennsylvania Worker and Community Right-to-Know Law US. Rhode Island RTK US. California Proposition 65 US - California Proposition 65 - Carcinogens & Reproductive Toxicity (CRT): Listed substance Not listed. SECTION XVI OTHER INFORMATION List of Abbreviations CLP: Regulation No. 1272/2008. DSD: Directive 67/548/EEC. DNEL: Derived No-Effect Level. PNEC: Predicted No-Effect Concentration. PBT: Persistent, bio-accumulative and toxic. vpvb: Very Persistent and very Bio-accumulative NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 6 of 7
References HSDB - Hazardous Substances Data Bank Registry of Toxic Effects of Chemical Substances (RTECS) Issued by Disclaimer The Bergquist Company, Thermal Interface Materials Division The information contained herein has been developed based upon current available scientific data. New information may be developed from time to time which may render the conclusions of this report obsolete. Therefore, any warranty is extended as to the applicability of this information to the user s intended purpose for the consequences of its use or misuse NA Not Applicable NE Not Established UN Unknown Template Rev: June 2013 7 of 7