1. Product and Manufacturer Identification Product Name: Manufacturer: Tetrapotassium Pyrophosphate Apollo Technologies, Inc. 31441 Santa Margarita Parkway, Suite A-219 Rancho Santa Margarita, Ca. 92688 For more information call: (949) 888-0573 In case of emergency call: (24 hours per day, 7 days per week) Chem-Tel (800) 255-3924 2. Composition- Ingredients INGREDIENT NAME CAS NUMBER Tetrapotassium Pyrophosphate 7320-34-5 Sodium Sulfate 7757-82-6 3. Hazards Identification Potential Health Hazards Dust may cause skin and/or eye irritation after prolonged contact. Mist and solutions will cause skin and/or eye irritation. Inhalation: May cause irritation to the respiratory tract. Ingestion: May irritate the gastrointestinal tract with nausea, vomiting and diarrhea. Moderately toxic. 4. First Aid Measures Skin: Immediately wash skin with soap and water. Prolonged contact with dry powder may cause drying or chapped skin. Eyes: Flush eyes immediately with water for at least 15 minutes. Hold the lids back and allow water to thoroughly irrigate the eye. Seek prompt medical attention. Inhalation: May cause coughing and sneezing. Remove to fresh air immediately. Ingestion: Do NOT induce vomiting. If the person is conscious, give plenty of milk or water. Get immediate medical attention. No significant health effects are expected with ingestion of small amounts. 1 of 5
5. Fire Fighting Measures Flammable Properties Flash Point: Not Flammable Auto ignition temperature Not Applicable Extinguishing Media: Material is not flammable. Use extinguishing media appropriate for surrounding fire. Unusual Fire and Explosion Hazards: None Special Fire Fighting Measures: Wear NIOSH approved breathing apparatus. Use water spray to keep containers cool. 6. Accidental Release Measures In case of spill or other material release: Promptly sweep up or vacuum while minimizing dusting. Wear appropriate personal protective equipment. Avoid unnecessary exposure. 7. Handling and Storage Normal Handling: Avoid contact with eyes, skin and clothing. Do not breathe dust. Minimize dusting while handling. Do not eat or drink in the material handling and storage area. Practice good personal hygiene and housekeeping. Wear goggles while handling material. Storage Recommendations: Store in a cool, well ventilated area away from moisture. Material is hygroscopic. Keep in a tightly closed container. 8. Exposure Controls/ Personal Protective Equipment Engineering Controls: Use local exhaust if dusty conditions exist. Do not handle within an unventilated space. OSHA and the ACGIH have not established an exposure limit for this material. However the least stringent exposure limit for particulates which are not 2 of 5
otherwise regulated or classified are listed below. These limits should be followed in the absence of more stringent levels. Occupational Exposure Limits: ACGIH TLV OSHA PEL 10 mg/m 3 (inhalable) 8 hr. TWA, 3 mg/m 3 (respirable) 8 hr TWA 15 mg/m 3 (total dust) 8 hr. TWA, 5 mg/m 3 (respirable) 8 hr TWA Personal Protective Equipment Skin Protection: To handle dry material, wear a class D work uniform including cotton gloves, long sleeve shirt and trousers. Eye Protection: Wear a head covering and chemical safety goggles. Do not wear contact lenses or impact resistant safety glasses. Respiratory Protection: breathing dust. Use a NIOSH approved respirator for dusts and mists. Avoid An eye wash and safety shower is also recommended. 9. Physical and Chemical Properties Appearance: White granules or powder Physical State: Solid Odor: Odorless Solubility in Water: 187g/100g H 2 O (at 25 C) ph: 1% solution = 10.2-10.7 Bulk Density 0.96-1.2 g/cc 10. Stability and Reactivity Normally Stable. Store in a cool, dry place. Incompatibilities: Strong Oxidizers, Ammonia, moisture, Magnesium, Sodium and Calcium. Solutions are corrosive to Aluminum. Avoid strong mineral acids and bases. Hazardous Decomposition Products: Oxides of Phosphorous. 3 of 5
11. Toxicological Information Oral rat LD 50 Dermal- rabbit LD 50 Eye irritation-rabbit Skin irritation >2980 mg/kg; slightly toxic >7940 mg/kg; practically nontoxic moderately irritating practically nonirritating This material is a hazardous chemical as defined under the Hazard Communication Standard (29 CFR 1910.1200). 12. Disposal Considerations RCRA: This material is not a listed hazardous waste. Dispose of in accordance with federal, state and local regulations. 13. Transport Information US DOT: Not regulated Proper Shipping Name: Not applicable 14. Regulatory Information Toxic Substances Control Act TSCA: This material is listed on the TSCA Inventory of Chemical Substances. 4 of 5
SARA Title III/CERCLA There are no reportable quantities (RQ s) or Threshold Planning Quantities (TPQ s) for this material. SARA Section 302 Extremely Hazardous Substances: None SARA 313 Toxic Chemicals: None State Right to Know Lists No other substances are present in addition to the ingredient listed in section 2. 15. Other Information NFPA Rating: Health Fire Reactivity Additional Information 1 0 1 E= safety glasses, gloves and dust respirator Current Issue Date: November 10, 2005 Revision Date: November 10, 2008 unless otherwise noted 5 of 5