Safety Data Sheet PROPHASE WOUND CLEANSER Section 1. Identification Product Identifier Synonyms Manufacturer Stock Numbers Recommended use Uses advised against Manufacturer Contact Address PROPHASE WOUND CLEANSER MSC8002; MSC8008 ; MSD_SDS0264 MSC8002; MSC8008 Cleanses, moistens, and aids in debridement of wounds. Removes foreign material including microorganisms and debris from wounds including first and second degree burns. Medline Industries, Inc. One Medline Place Mundelein, IL, 60060 USA Section 2. Hazards Identification Phone Emergency Phone Fax (800) 633-5463 (800) 424-9300 CHEMTREC (847) 643-4436 Website www.medline.com Classification Signal Word Pictogram Hazard Statements Precautionary Statements Response Prevention Storage Disposal No OSHA Hazard Classifications Applicable - Category No OSHA Hazard Classifications Applicable Ingredients of unknown 0% Page 1 of 7
toxicity Hazards not Otherwise Classified Acute Effects: Inhalation: Not considered an inhalation irritant. Eyes Avoid contact with eyes. Skin: Based on product history, lack of consumer complaints, and label directions, this product should be safe if used as intended. Medical conditions aggravated by long-term exposure: Chronic Effects: Ingestion: Avoid ingestion. Section 3. Ingredients CAS Ingredient Name Weight % 7647-01-0 Hydrogen chloride Proprietary % 7439-89-6 Iron Proprietary % 7440-66-6 Zinc Proprietary % 7732-18-5 Water Proprietary % 133029-32-0 Polyaminopropyl Biguanide (PHMB) Proprietary % 86438-79-1 Cocamidopropylbetaine Proprietary % Occupational exposure limits, if available, are listed in Section 8. Section 4. First-Aid Measures General Advice: Eye Contact: Skin Contact: Inhalation: Ingestion: Special Precautions/Procedures: Take proper precautions to ensure your own health and safety before attempting rescue and providing first aid. Consult a physician. Show this safety data sheet to the doctor in attendance. Move out of dangerous area. Flush eyes with large amounts of water for at least 15 minutes. Remove contact lenses, if worn. If irritation persists, seek medical attention. If irritation develops wash area with water. Get medical attention if irritation persists. Not a hazard. In event of symptom consult a physician. Page 2 of 7
Section 5. Fire Fighting Measures Suitable Extinguishing Media Unsuitable Extinguishing Media Flash Point: Burning Rate: Auto Ignition Temperature: Unusual Fire and Explosive Hazards: Hazardous combustion products: Fire fighting equipment/instructions: In case of fire, use Water, Carbon Dioxide (CO2), Foam, Dry Chemical Do not enter enclosed or confined space without proper protective equipment including respiratory protection. Products of combustion may contain carbon monoxide, carbon dioxide, and other toxic materials. Self contained breathing apparatus and protective clothing should be worn. Section 6. Accidental Release Measures Spill/Leak Procedures: Small Spills Large Spills Contain all spill and leaks to prevent discharge into environment. Soak up with absorbent, shovel into waste container, flush area with water. Soak up with absorbent, shovel into waste container, flush area with water. Section 7. Handling and Storage Handling Storage: Regulatory Requirements: This product is considered to be an article which does not release or otherwise result in exposure to a hazardous chemical under normal use conditions. Store at room temperature, between 41 F (5 C) and 77 F (25 C). Avoid overheating and freezing. Store in a dry and cool area at temperatures not over 77 F (25 C). Page 3 of 7
Section 8. Exposure Controls/Personal Protection Occupational Exposure Limits Personal Protective Equipment Engineering Controls: Ventilation: Respiratory Protection: Protective Clothing/Equipment: Work/hygienic practices: Comments: Ingredient Name ACGIH TLV OSHA PEL STEL Hydrogen chloride 0 Iron 0 Zinc Water Polyaminopropyl Biguanide (PHMB) Cocamidopropylbetaine None required under normal use conditions. General ventilation recommended. None required under normal use conditions. None required for normal use. For prolonged exposure, use appropriate goggles, protective clothing and gloves. Handle in accordance with good industrial hygiene and safety practice. Wash thoroughly with soap and water after handling and before eating, drinking, or using tobacco. Safety shower and eye wash should be available close to work areas. Never eat, drink, or smoke, in work areas. Practice good personal hygiene after using this material, especially before eating, drinking, smoking, using the toilet, or applying cosmetics. Page 4 of 7
Section 9. Physical and Chemical Properties Physical State Liquid Color Colorless Odor Neutral Odor Threshold Solubility Water mixable Partition coefficient Water/n-octanol N.D VOC% Viscosity Specific Gravity 1 Density lbs/gal Pounds per Cubic Foot Flash Point FP Method Ph 2.9 Melting Point Boiling Point 100 C Boiling Range LEL UEL Evaporation Rate Flammability Non flammable Decomposition Temperature N.D Auto-ignition Temperature Vapor Pressure Vapor Density Density: 1.0 Section 10. Stability and Reactivity Stability: Reactivity: Incompatibility (Materials to Avoid): Hazardous Decomposition or Byproducts: Hazardous Polymerization Conditions to avoid: Stable. No reactivity expected under normal conditions Extreme/high temperatures. Section 11. Toxicological Information Eye Effects: Skin Effects: Acute Inhalation Effects: Acute Oral Effects: Chronic Effects: Not considered to be hazardous but avoid contact with eyes. Not considered an irritant. Not considered an irritant. Not considered an irritant. Page 5 of 7
Section 12. Ecological Information Ecotoxicity: Not considered an environmental hazard. Environmental Fate: Not considered an environmental hazard. Environmental Degradation: Not considered an environmental hazard. Soil Absorption/Mobility: Not considered an environmental hazard. Additional Information: Ecological data of the complete product are not available. Section 13. Disposal Disposal: Uncleaned packaging: Waste Code: Disposal Regulatory Requirements: Section 14. Transport Information Contact your supplier or a licensed contractor for detailed recommendations. Follow applicable federal, state, and local regulations. Recyclable. No hazardous goods. Check local, state and federal requirements. UN Number UN Proper Shipping Name DOT Classification Packing Group Not Regulated Not Regulated Not Regulated Section 15. Regulatory Information SARA 311/312: SARA 302: SARA 313: TSCA: CERCLA Hazardous Substance List: Clean Air Act (CAA) Section 112, 112 (r): New Jersey Right to Know Components: Massachusetts Right to Know Components: Pennsylvania Right to Know Components: Rhode Island Right to Know Components: Hydrochloric acid. HYDROGEN CHLORIDE. HYDROCHLORIC ACID. HYDROCHLORIC ACID. Hydrochloric acid. Page 6 of 7
Section 16. Other Information Revision Date 4/29/2016 Legend - Not Applicable N.E. - Not Established - Not Determined HMIS (U.S.A.): Health O Hazard HMIS (U.S.A.): Flammability O HMIS (U.S.A.): Reactivity O National Fire Protection O Association (U.S.A): Health Hazard National Fire Protection O Association (U.S.A): Flammability National Fire Protection O Association (U.S.A): Instability Hazard Additional Information The information contained herein is furnished without warranty or legal responsibility of any kind. Employers should use this information only as a supplement to other information gathered by them and must make independent determination of suitability and completeness of information from all sources to assure proper use of these materials and the safety and health of employees Page 7 of 7