1 Preparation of a 18-Classroom School BoQ for constructing a 18-Classroom School - Najaf Site Preparation:Works for leveling the site and remove the garbage to authorized location according to supervisor engineer instructions, clean soil should be sprinkled and well compacted M 2 2,600 2 3 4 5 Filling ground by sub-base with appropriate grade, well compacted by layer not exceed 20cm, percentage of compaction not less than 95% (Lab tests required), as per the instructions of super visor engineer Provision of materials and works to cast the floor for walkways, school yard and CFS floor with Patterned paving tiles, (kerbstone) and the joints with sand and ensure fine face as per the instructions of super visor engineer Provision of materials and work to connect the manholes with new 4 inches PVC pipes (10 Bar pressure) with the level to increase the slope (interior and exterior pipes) (20m.l) including all necessary fittings needed and Provision of install water storage tank with steel tower I section 4m high fixed on the ground with 50 cm concrete deep with over flow drain and control valve, inlet and outlet ¾ inch pipe with all necessary needed (2 no.) Cesspool: Provide materials & erecting cesspool 120 cm inner diameter for black water, 2 m depth clear dimension. the work includes excavation and drilling the cesspool 1.2 m diameter, put cylinder concrete pipes 15 cm clear diameter with at least 4 holes in concrete cylinder sides,12cm thick, concrete pipes Joints to be filled with cement mortar 1:3, casting the roof by reinforced concrete 15 cm thick. Steel bars 14 mm @ 15 cm c/c,other work required, heavy duty cast iron/gpr type manholes cover 15x15 cm. The Price includes provide crushed stone, gravel to the base of concrete pipes (15 cm) thickness with surrounding areas, with all requirements of work and according to specifications and instructions of site engineer. M 2 750 M 2 750 Page 1 of 5
6 Septic tank: Excavate and built septic tank 2.0x3x2m high (interior dimension) with clay brick walls 24 cm width and cement mortar (1:3). Work includes laying broken brick well compacted layer under reinforced concrete 15 cm in thickness floor, reinforced concrete lab 20 cm thick ( reinforcement ½ inch @ 15 cm top and bottom, 2 cast iron covers 60x60 cm for the tank openings ), building 1.5 m high brick wall in the No 2 middle of septic tank, all interior walls should be cement plaster 1:3. all the exterior walls paints with bitumen 20/30. work includes supply and install maintenance ladder. work may need to disposed groundwater within the implementation of this item and whatever treatment needed. 7 8 9 Supply, and connect galvanized water pipes under required pressure according to international specifications, price include all necessary fitting needed with good work(30m.l). Shade: Supply materials and labours of construction shade Area using best type corrougated sheet with reasonable thick having 2.5 m in front of classrooms, 0.5 m behind, the work includes painting the frame of steel structure by anti rust & oil paint two layers lead colour & the last layer to be after completion with all work requirements according to specifications and instructions of site engineer. Fence:provision of material and works for (BRC)wire 3mm fence with all its requirements to make it complete such as digging around the columns, the foundation of concrete 40*40*60 cm over lyer of brick,using (S.R.C),,clips,etc.the price including provision and supply two gates of same type of 4 m width of 2 leafs with reinforcement columns (30*30*200)cm using reinforcement 16mm diameter with 12 mm stirrups every 20 cm, the foundations (100*100*50)cm using steel reinforcement diameter 16mm every 15 cm for both directions with two layers, over a well compacted brick layer M 2 420 ML 215 10 Supply and install high quality brand new water cooler of capacity of 100 litre with four taps,with purification filters, with all required fittings and connections, and power supply, electrical wiring and circuit breaker, according to the supervising engineer directions Page 2 of 5
11 12 13 Water Tanks base: Provide materials & labours for construction the base of tanks. the work includes excavation the foundation 2.0*6.5m, 60cm depth at least, reinforced concrete 1:2:4 for foundation 40cm depth over a layer of thick nylon or crushed stone or lean concrete, steel bar 16mm thickness, 20cm c/c double net, building the base wall by solid concrete block (15*20*40)cm, 40cm width of wall, 3m height, 4.6m length of wall in cross section, plastering work by using cement mortar (1:3), painting by emulsion Turkish type, supply and installation galvanized steel tank circular capacity of 21m3. the plate thickness of 5mm for the base and cylinder and the plate thickness of 4mm for the roof with good welding so as to prevent leakage of water and the work includes painting by epoxy inside and oil paint outside the steel water tank, the work includes installaing water pump and all fittings, galvanizd pipes 1" inlet, 2.5 " outlet, washing 3", airflow to tank and source, valve, tap, other fittings and accessories with connecting 3 galvanized steel tank (1.5m3 each gauge 16) according to specifications and instructions of site engineer. Supply, install and operate 30 KVA Electrical Generator, Western made, with silencer, work includes all needed suitable cables, concrete base, fuel tank with tower, steel shade with fence and door (BRC), Electrical Board and Automatic Change Over, with all that required to get a complete work as per the instructions of supervisor engineer required to installation of electrical power meter, including the connection of power meter to the main power source and the work include making steel box for the power meter and circuit breakers. work includes Provision of materials, labors, equipments and all that required for laying of reinforced cable 4 x 5 mm of Jordanian origin, from the main source to the main circuit breaker. instructions and Provision of materials, labors, equipments and all that required to connect circuit breaker of 18 lines Clipsal type. The work includes all that is required to complete the work in every detail and according to the supervisor engineer's instructions. L.S 1 No 1 ML 50 Page 3 of 5
Provision of materials, labour, equipments and all that required to connecting fluorescent lamps 2*49 watt under the shading area, IP 45 on the Pre-fab school self in 2.5 m height in front and back side of every 14 unite of these units, and all what is required to complete the work according to the supervisor engineer s instructions. 2 15 16 17 required to establish water piping system by laying and connecting pipes of 1 inches diameter and connection between the main source and the reservoir(water storage tank) and the price includes installation of the 8 taps of the good type. the work include all that is required to complete the work according to the supervisor engineer's instructions. required to installation of plastic water-storage tank, Rayyan type and Jordanian origin, capacity 5000 liter with making concrete's base for lifting the tank from the ground. The thickness of 30 cm work includeall of the necessary connections, and all that is required to complete the work in every detail and according to the supervisor agricultural engineer's instructions. Supplying and install Visibility metal plaques -with German Flag and UNICEF logo and messages in English& Arabic with dimensions of 90 cm height and 120 cm width and I mm thickness, the plagues shoud be fixed on aluminum fram (photos attached) and should be installed in suitable location in coordination with UNICEF Provide & install main distribution board formed from including labour cost and fabricating a suitable PVC room with all work requirements and accessories like door lock and other accessories No 1 19 20 main circuit breaker (400 ) three phase Legrand or ABB type no(1) circuit breaker (250 )three phase Legrand or ABB type bus bar (200) Ampere.. No (4) R,S,T,N + E voltmeter (0-500)v with selector switch no(1) ammeter (0-200)A.no (3) indicator lamp no (3) change over 250 Ampere no(1) 3x120+70mm2 the best jordanian type available in market LS 1 ML 25 Page 4 of 5
21 4x35mm2 the best jordanian type available in market ML 30 22 4x4mm2 the best jordanian type available in market ML 450 23 Supply materials and install available earth system for the building according to the specifications with all necessary work in earth copper 3 no. and wires 1*50mm2 with excavation (depth 1.7m), backfilling, adding salt and coal and connected with main board by wire 50mm2. ML 400 24 Supply materials and install available earth system for the building according to the specifications with all necessary work in earth copper 3 no. and wires 1*50mm 2 with excavation (depth 1.7m), backfilling, adding salt and coal and connected with main board by wire 50mm2. ML 500 22 Grand Total Page 5 of 5