SECTION 1. PRODUCT AND COMPANY IDENTIFICATION Product name Product Use Description Grease Company Manufacturer Anderol Specialty Lubricants, a division of Chemtura Corporation 215 Merry Lane East Hanover, NJ 07936 United States of America Telephone 973-887-7410 Emergency telephone number CHEMTREC (24 hours) 800-424-9300 703-527-3887 For additional emergency telephone numbers see section 16 of the Safety Data Sheet. Prepared by 07/11/2013 Product Safety Department (US) +1 866-430-2775 MSDSRequest@chemtura.com SECTION 2. HAZARDS IDENTIFICATION Emergency Overview WARNING! Form paste Colour dark brown Odour slight Hazard Summary OSHA Hazards Causes eye irritation. Causes skin irritation. May cause cancer. CARCINOGEN Potential Health Effects SAP 6.0 1 / 9 SDS Number 400000001765
Primary Routes of Entry Aggravated Medical Condition Inhalation Skin Eyes Ingestion Chronic Exposure Symptoms of Overexposure Skin contact Eye contact Dermatitis Dust may cause irritation of the respiratory tract. Irritating to skin. Irritating to eyes. May be harmful if swallowed. Limited evidence of a carcinogenic effect. None known. Carcinogenicity IARC OSHA NTP ACGIH Group 2A Probably carcinogenic to humans sodium nitrite 7632-00-0 No component of this product present at levels greater than or equal to 0.1% is identified as a carcinogen or potential carcinogen by OSHA. No component of this product present at levels greater than or equal to 0.1% is identified as a known or anticipated carcinogen by NTP. Suspected human carcinogen quartz (SiO2) (Fr = 100%) 14808-60-7 SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS Hazardous components Component / CAS-No. sodium nitrite 7632-00-0 quartz (SiO2) (Fr = 100%) 14808-60-7 Weight percent >= 1 - < 5 % >= 0.1 - < 1 % SECTION 4. FIRST AID MEASURES First aid procedures Inhalation If inhaled Move to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. In case of bluish discoloration (lips, ear lobes, fingernails), give oxygen as quickly as possible. Get medical attention. SAP 6.0 2 / 9 SDS Number 400000001765
Skin contact Eye contact Ingestion In case of skin contact Wash off with soap and water. Remove contaminated clothing and shoes. Wash contaminated clothing before re-use. Get medical attention if irritation develops and persists. In case of eye contact Flush with plenty of water. If eye irritation persists, consult a specialist. If swallowed, DO NOT induce vomiting. Consult a physician if necessary. Notes to physician Symptoms Treatment None known. For specialist advice physicians should contact the Poisons Information Service. SECTION 5. FIREFIGHTING MEASURES Flammable properties Flash point > 446 F (> 230 C) Method open cup Ignition temperature Lower explosion limit Upper explosion limit Remarks not applicable Remarks no data available Remarks no data available Fire fighting Suitable extinguishing media Unsuitable extinguishing media Carbon dioxide (CO2) Dry powder Foam Alcohol-resistant foam Water mist Water In the event of fire, cool tanks with water spray. Protective equipment and precautions for firefighters Specific hazards during Burning produces noxious and toxic fumes. firefighting Special protective equipment In the event of fire, wear self-contained breathing apparatus. for firefighters Use personal protective equipment. SAP 6.0 3 / 9 SDS Number 400000001765
SECTION 6. ACCIDENTAL RELEASE MEASURES Personal precautions Environmental precautions Methods for containment / Methods for cleaning up Additional advice Use personal protective equipment. Do not contaminate water. Do not flush into surface water or sanitary sewer system. Discharge into the environment must be avoided. Shovel into suitable container for disposal. Remove all sources of ignition. Clean contaminated surface thoroughly. Material can create slippery conditions. SECTION 7. HANDLING AND STORAGE Handling Handling procedures Keep container closed when not in use. Ensure all equipment is electrically grounded before beginning transfer operations. Storage Requirements for storage areas and containers Other data Keep container tightly closed in a dry and well-ventilated place. Stable under recommended storage conditions. SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines Components with workplace control parameters Components / CAS-No. Value / Basis / Update quartz (SiO2) (Fr = 100%) TWA 14808-60-7 ACGIH 2007-01-01 TWA OSHA P0 1989-01-19 TWA NIOSH REL 2005-09-01 Control parameters 0.025 mg/m3 0.1 mg/m3 0.05 mg/m3 SAP 6.0 4 / 9 SDS Number 400000001765
Engineering measures Engineering measures Use with adequate ventilation. Local ventilation is needed in the presence of airborne mists. Ensure that eyewash stations and safety showers are close to the workstation location. Personal protective equipment Eye protection Safety glasses with side-shields Tightly fitting safety goggles Hand protection Neoprene gloves Skin and body protection Respiratory protection Hygiene measures impervious clothing not required under normal use In the case of dust or aerosol formation use respirator with an approved filter. Avoid contact with skin, eyes and clothing. Provide adequate ventilation. Do not breathe dust or spray mist. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Form Colour Odour paste dark brown slight Safety data Flash point > 446 F (> 230 C) Method open cup Ignition temperature Lower explosion limit Upper explosion limit ph Vapour pressure Specific Gravity Remarks not applicable Note no data available Note no data available Note not applicable no data available 0.88 at SAP 6.0 5 / 9 SDS Number 400000001765
SECTION 10. STABILITY AND REACTIVITY Conditions to avoid Materials to avoid Hazardous decomposition products Hazardous reactions Remarks Heat. Contamination Remarks Strong acids and strong bases Note Carbon oxides Hazardous polymerisation does not occur. SECTION 11. TOXICOLOGICAL INFORMATION Acute oral toxicity quartz (SiO2) (Fr = 100%) LD50 500 mg/kg Species rat Skin irritation Remarks Not classified due to lack of data. Eye irritation Remarks Not classified due to lack of data. Sensitisation Remarks Not classified due to lack of data. Aspiration toxicity No aspiration toxicity classification Toxicology Assessment CMR effects Carcinogenicity Not classified due to lack of data. Mutagenicity Not classified due to lack of data. Reproductive toxicity Not classified due to lack of data. No data is available on the product itself. 12. ECOLOGICAL INFORMATION Ecotoxicity effects Toxicity to fish Remarks no data available SAP 6.0 6 / 9 SDS Number 400000001765
Toxicity to daphnia and other aquatic invertebrates Remarks no data available Elimination information (persistence and degradability) Bioaccumulation Remarks no data available Mobility Remarks no data available Biodegradability Result no data available on ecology Ecotoxicology Assessment Results of PBT assessment This mixture contains no substance considered to be persistent, bioaccumulating nor toxic (PBT). Additional ecological There is no data available for this product. information SECTION 13. DISPOSAL CONSIDERATIONS Contaminated packaging Dispose of waste material in compliance with all federal, state, and local regulations. Do not burn, or use a cutting torch on, the empty drum. SECTION 14. TRANSPORT INFORMATION DOT TDG IATA IMDG RID SECTION 15. REGULATORY INFORMATION OSHA Hazards Carcinogen SAP 6.0 7 / 9 SDS Number 400000001765
CERCLA Reportable Quantity sodium nitrite 7632-00-0 100 lbs SARA 302 Reportable Quantity SARA 311/312 Hazards Chronic Health Hazard EPCRA - EMERGENCY PLANNING COMMUNITY RIGHT - TO - KNOW SARA 302 Reportable Quantity SARA 304 Components This material does not contain any components with a section 304 EHS RQ. SARA 313 Components sodium nitrite 7632-00-0 California Prop. 65 Components WARNING! This product contains a chemical known to the State of California to cause cancer. quartz (SiO2) (Fr = 100%) 14808-60-7 quartz (SiO2) (Fr = 100%) The components of this product are reported in the following inventories US.TSCA On TSCA Inventory DSL AICS NZIoC All components of this product are on the Canadian DSL list. On the inventory, or in compliance with the inventory Not in compliance with the inventory ENCS Not in compliance with the inventory KECI PICCS IECSC On the inventory, or in compliance with the inventory On the inventory, or in compliance with the inventory On the inventory, or in compliance with the inventory SECTION 16. OTHER INFORMATION SAP 6.0 8 / 9 SDS Number 400000001765
HMIS Classification Health hazard 1 Chronic Health Hazard * Flammability 1 Reactivity 0 PPIAsk supervisor or safety specialist for handling instructions NFPA Classification Health hazard 1 Fire Hazard 1 Reactivity Hazard 0 1 1 0 Other Emergency Phone Number Latin America Brazil +55 113 711 9144 All other countries +44 (0) 1235 239 670 Mexico +52 555 004 8763 The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. SAP 6.0 9 / 9 SDS Number 400000001765