CHAPTER -9 EXECUTIVE SUMMARY 1. Basic Information of the Project: i Name & Address of the Project site (Complete details with plot no./survey no., Landmark etc. ) M/s. Aarti Industries Ltd. (Organic Division) Plot 801, 801/23, 806 & 807, Phase-III, GIDC Estate, Pardi, Vapi, Dist.:-Valsad, Gujarat. ii Name of the Applicant Mr. Nimesh Naik, General Manager iii Address for correspondence Plot 801, 801/23, 806 & 807, Phase-III, GIDC Estate, Pardi, Vapi, Dist.:-Valsad, Gujarat. iv Contact no. and e-mail ID of the Applicant Mo. no. :9727782160 e-mail: premnath.r@aarti-industries.com v Aerial distance of nearest Habitat (KM) Vapi around 4.5 KM vi Longitude & Latitude of the Project Site: (4 corners of the site) Latitude 20 21 20.50 N Longitude 72 56 5.25 E Direction Corners Latitude Longitude S 1 st - Gate 20 21'48.49"N 72 56'29.21"E S 2 nd - Gate 20 21'49.28"N 72 56'32.22"E E 3 nd - Gate 20 21'57.68"N 72 56'35.25"E SW 1 st 20 21'48.36"N 72 56'27.75"E E 2 nd 20 21'55.60"N 72 56'35.28"E NE 3 rd 20 22'0.33"N 72 56'34.69"E WN 4 th 20 21'59.95"N 72 56'30.70"E W 5 th 20 21'54.37"N 72 56'27.15"E vii Total cost of Proposed Project (Rs. in Crores): Existing : 401.9 Crores Proposed : 52.85 Crores Total : 454.75 Crores viii (1) Capital cost for EMS (Environmental Management System): 2.18 Crores. (2) Recurring cost towards the environmental protection measures: 2.90 Crores per Annum. ix Total Plot area ( sq. meter) Existing : 45, 705 sq. meter Proposed: 00 Total : 45, 705 sq. meter x Green belt area,/tree Plantation area ( sq. meter) Existing : 9605.22 sq. meter Proposed: 00 Total : 9605.22 sq. meter (21%) (Unit will take care by creating and developing the green belt in near by GIDC notified area. Also, we will carry out plantation of 1000 trees/year for a period of M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 267
xi xii Category as per the Schedule to the EIA Notification 2006 i.e. 1(d), 2(b), 5(f) etc. Applicability of General Conditions of EIA Notification 2006: i.e. Ensure that I. Protected areas notified under the Wildlife (Protection) Act, 1972; II. CEPI areas III. Eco-sensitive areas and IV. Inter-state boundaries and international boundaries; are not located within 5 km or 10 km (as the case may be) area from the boundary of the proposed site. 5 year in nearby villages (Chanod Colony and Karvad, Tal. Pardi, Dist.: Valsad.). 5 (f) Not Applicable 2. Online application proposal no.: IA/GJ/IND2/64790/2017 & File no.: J-11011/248/2017-IA.II (I) 3. Date of application for EC: 4. Date of MoEF&CC, Delhi meeting for TOR: 24 th EAC meeting on 14 th -16 th June,2017 5. Date of TOR issued by MoEF&CC, Delhi: 25 th July, 2017 6. Date of Public Hearing (If applicable): Not Applicable 7. Date of presentation for Appraisal: -- 8. Project status: Expansion 9. Product profile: 1 2 3 4 5 6 7 Name of the Products CAS Quantity Para Nitro Chloro (PNCB) Ortho Nitro Chloro (ONCB) Meta Nitro Chloro (MNCB) 2,5 Dichloro Nitro (2,5 DCNB) 3,4 Dichloro Nitro (3,4 DCNB) 2,3 Dichloro Nitro (2,3 DCNB) 2,4 Dichloro Nitro (2,4 DCNB) 100-00-5 88-73-3 Existing Proposed Total 5000 121-73-3 100 89-61-2 400 99-54-7 600 3209-22-1 100 611-06-3 400 3900 0 9000 (Either/Or) 1500 (Either/Or) End-use of product M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 268
8 9 10 11 12 13 14 15 16 17 18 19 Quantity Name of the Products CAS Existing Proposed Total 2,6 Dichloro Nitro (2,6 DCNB) 601-88-7 0 2,3,4 Trichloro Nitro (2,3,4 TCNB) 17700-09-3 0 2,4,5 Trichloro Nitro (2,4,5 TCNB) 89-69-0 0 2,4 Dichloro 3 Fluoro Nitro 393-79-3 0 2,4 Dinitro Chloro 1500 97-00-7 200 1300 (DNCB) (Either/Or) Mono Chloro (MCB) 108-90-7 3800 Ortho Dichloro 95-50-1 (ODCB) 500 Para Dichloro (PDCB) 106-46-7 500 Meta Dichloro 106-46-7 0 (MDCB) 8000* 3000 (Either/Or) 1,2,4 Tri Chloro (1,2,4 TCB) 1,2,3 Tri Chloro (1,2,3 TCB) Trichloroaniline (TCAN) 120-82-1 87-61-6 636-30-6 634-93-5 20 Ortho Anisidine 90-04-0 30 0 30 21 Para Anisidine 104-94-9 20 0 20 22 Dichloro Aniline 95-76-1 50 0 50 23 2,5 Dichloro Aniline 95-82-9 35 0 35 24 3,4 Dichloro Aniline 95-76-1 15 0 15 25 Ortho Chloro Aniline 95-51-2 10 0 10 26 P-Phenylene diamine 106-50-3 25 0 25 27 O-Phenylene diamine 95-54-5 225 0 225 28 OCPNA/PCONA 121-87-9 100 0 100 29 Ortho Nitro Aniline (ONA) / Para Nitro 88-74-4/ 100-01-6 200 0 150 0 150 End-use of product M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 269
Name of the Products CAS Quantity Existing Proposed Total End-use of product Aniline (PNA) 30 ONCB Para sulphonic 17691-19-9 25 0 25 acid 31 3,3 Dichloro benzidine sulphate 74332-73-3 10 0 10 32 Dilute Sulphuric Acid 7665-93-9 1441 0 1441 Basic Chemical Total 13,936 8,200 22, 136 By-Product 1. Sulphuric Acid 70% 7665-93-9 3627 3027 6654 Basic Chemical 2. Hydrochloric Acid 30% 7647-01- 0 6165 7038 13203 Basic Chemical 3. Aq. Sodium Thio sulphate 7772-98-7 136.5 0 136.5 Basic Chemical Total 9,928.5 10,065 19, 993.5 *NOTE: As such either/or any product will be 8000, but 1, 2, 4 TCB, 1, 2, 3 TCB, TCAN not more than 3000. The project falls under Category B of project activity 5(f) as per the schedule of EIA Notification 2006. 10. Product wise Raw material consumption: 1. 2. Name of the Product Para Nitro Chloro (PNCB)/ Ortho Nitro Chloro (ONCB) 3. Meta Nitro Chloro (MNCB) 4. 2,5 Dichloro Nitro (2,5 DCNB) 5. 3,4 Di Chloro Nitro (3,4 DCNB) Name of the Raw materials CAS of Raw Total Raw Consumption in Chloro 108-90-7 4630.41 Nitric Acid 7697-37-5 2618.31 Sulphuric Acid 7664-93-9 2076.59 Spent acid 7664-93-9 3869.43 Total 13194.75 Chloro 108-90-7 50.02 Nitric Acid 7697-37-5 28.28 Sulphuric Acid 7664-93-9 22.43 Spent acid 7664-93-9 41.80 Total 142.54 2,5 Di chloro 89-61-2 88.27 Conc. Nitric Acid 7697-37-5 39.04 Sulphuric Acid 7664-93-9 32.69 Spent acid 7664-93-9 142.99 Total 302.99 2,5 Di chloro 89-61-2 22.07 Conc. Nitric Acid 7697-37-5 9.76 Sulphuric Acid 7664-93-9 8.17 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 270
Name of the Product 6. 2,3 Dichloro Nitro (2,3 DCNB) 7. 2,4 Dichloro Nitro (2,4 DCNB) 8. 2,4 Di nitro Chloro (DNCB) 9. 2,6 Di nitro Chloro 10. 2,3,4 Tri chloro Nitro (2,3,4 TCNB) 11. 2,4,5 Tri chloro Nitro (2,4,5 TCNB) Name of the Raw materials CAS of Raw Total Raw Consumption in Spent acid 7664-93-9 35.75 Total 75.75 2,5 Di chloro 89-61-2 4.41 Conc. Nitric Acid 7697-37-5 1.95 Sulphuric Acid 7664-93-9 1.63 Spent acid 7664-93-9 7.15 Total 15.15 2,5 Di chloro 89-61-2 176.54 Conc. Nitric Acid 7697-37-5 78.08 Sulphuric Acid 7664-93-9 65.38 Spent acid 7664-93-9 285.99 Total 605.99 PNCB 100-00-5 700.20 98% Conc. Nitric Acid 7697-37-5 306.00 98% Conc. Sulphuric 7664-93-9 266.40 Acid Recovered spent acid 7664-93-9 200.52 Total 1473.12 PNCB 100-00-5 15.56 98% Conc. Nitric Acid 7697-37-5 6.80 98% Conc. Sulphuric 7664-93-9 5.92 Acid Recovered spent acid 7664-93-9 4.46 Total 32.74 1,2,4/1,2,3 TCB 87-61-6 201.86 Nitric Acid 7697-37-5 70.11 Sulphuric Acid 7664-93-9 81.21 Spent Acid 7664-93-9 38.82 Soda Ash 497-19-8 1.94 Total 393.94 1,2,4/1,2,3 TCB 87-61-6 20.19 Nitric Acid 7697-37-5 7.01 Sulphuric Acid 7664-93-9 8.12 Spent Acid 7664-93-9 3.88 Soda Ash 497-19-8 0.19 Total 39.39 12. Crude TCNB 1,2,4/1,2,3 TCB 87-61-6 141.30 Nitric Acid 7697-37-5 49.08 Sulphuric Acid 7664-93-9 56.85 Spent Acid 7664-93-9 27.17 Soda Ash 497-19-8 1.36 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 271
Name of the Product 13. 2,4 Di chloro 3 fluoro Name of the Raw materials CAS of Raw Total Raw Consumption in Total 275.76 1,2,4/1,2,3 TCB 87-61-6 79.73 Nitric Acid 7697-37-5 32.01 Sulphuric Acid 7664-93-9 38.41 Soda Ash 497-19-8 0.33 Total 150.49 14. Crude DCNB 2,5 Di chloro 89-61-2 132.40 Conc. Nitric Acid 7697-37-5 58.56 Sulphuric Acid 7664-93-9 49.04 Spent acid 7664-93-9 214.49 Total 454.49 15. Mono Chloro Fresh benzene 71-43-2 693.39 Recovered benzene 71-43-2 847.95 Chlorine 782-50-5 630.84 Total 2172.18 16. Ortho Di chloro Fresh benzene 71-43-2 401.40 Recovered benzene 71-43-2 707.70 Chlorine 782-50-5 730.80 Total 1839.90 17. Para Di chloro Fresh benzene 71-43-2 401.40 Recovered benzene 71-43-2 707.70 Chlorine 782-50-5 730.80 Total 1839.90 18. 1,2,4/1,2,3 Tri chloro ODCB 95-50-1 302.97 Recovered Ortho Di- 95-50-1 1060.19 Chloro Chlorine 782-50-5 827.09 Total 2190.25 19. Trichloroaniline (TCAN) Aniline 62-53-3 47.54 Mono Chlorobenzene 108-90-7 0.23 Rec. Mono 108-90-7 138.46 Chlorobenzene Hydrogen chloride gas 7647-01-0 18.62 Chlorine 7782-50-5 108.77 Sodium hydroxide 1310-73-2 6.38 Total 320.00 20. Ortho Anisidine o-nitroanisole 91-23-6 37.32 Hydrogen 1333-74-0 1.53 Rec. 30% OA Crude 91-23-6 9.00 Total 47.85 21. Para Anisidine p-nitroanisole 100-17-4 24.88 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 272
Name of the Product Name of the Raw materials CAS of Raw Total Raw Consumption in Hydrogen 1333-74-0 1.02 Rec. 30% OA Crude 91-23-6 6.00 Total 31.90 22. Di chloro Aniline Mixture of 2,5 DCNB & 2,6 DCNB Hydrogen 1333-74-0 1.94 Fresh Solvent 67-56-1 0.43 (Methanol) Recovered solvent 67-56-1 37.90 Total 99.90 23. 2,5 Di Chloro Aniline Mixture of 2,5DCNB & 89-61-2 41.74 2,6 DCNB Hydrogen 1333-74-0 1.36 Fresh Solvent (Methanol) 67-56-1 0.30 Recovered solvent 67-56-1 26.53 Total 69.93 24. 3,4 Di Chloro Aniline Mixture of 2,5DCNB & 89-61-2 17.89 2,6 DCNB Hydrogen 1333-74-0 0.58 Fresh Solvent 67-56-1 0.13 (Methanol) Recovered solvent 67-56-1 11.37 Total -- 29.97 25. Ortho Chloro Aniline ONCB 100-00-5 12.37 Hydrogen 1333-74-0 0.47 Fresh Solvent 67-56-1 0.31 (Methanol) Recovered solvent 67-56-1 7.32 Total 20.47 26. PPDA ONA 65996-98-7 31.90 Caustic 1310-73-2 18.50 Sulphur 7704-34-9 14.80 Total 65.20 27. OPDA Ortho Nitro aniline 65996-98-7 287.10 Caustic 1310-73-2 166.50 Sulphur 7704-34-9 133.20 Total 586.80 28. OCPNA/PCONA 3:4DCNB/2:5DCNB 611-06-3 115.20 Anhydrous Ammonia 7664-41-7 12.70 Ammonia Solution (32%) 7664-41-7 252.30 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 273
Name of the Product Name of the Raw materials CAS of Raw Total Raw Consumption in Total 380.20 29. ONA/PNA ONCB/ PNCB 88-73-3 172.80 Anhydrous Ammonia 7664-41-7 19.05 Ammonia Solution 7664-41-7 378.45 (32%) Total 570.30 30. ONCB Para Sulfonic Acid MCBPSA -- 23.80 Sulphuric acid 7664-93-9 23.80 Nitric acid 7697-37-5 10.20 Potassium chloride Mix 7447-40-7 7.63 Sodium chloride 7647-14-5 17.73 Total 83.14 31. 3:3 Di chloro Benzdine ONCB 88-73-3 18.52 Sulphate Dichlone 117-80-6 0.11 Emulsifier 107-98-2 0.04 Caustic Lye 48% 1310-73-2 2.82 Hydrogen 1333-74-0 0.60 Fresh Toluene 108-88-3 0.65 Recovered Toluene 108-88-3 20.89 Hydrochloric acid (3%) -- 57.62 Spent Acid (62%) 7664-93-9 36.63 Thiourea -- 0.10 Total -- 137.98 Total -- 27642.95 11. Compliance status of the existing project: Particulars Brief Information/Details Remarks 1 Earlier EC details Unit was established in the year 2003 before EIA - notification issued. Hence, EC is not applicable. Unit has applied EC for the first time. 2 Compliance of EC Not Applicable -- 3 Status of inspection by Not Applicable -- RO-MoEFCC, Bhopal. 4 Status of submission of -- -- half yearly return to concern authorities. 5 Compliance of existing CC&A Unit has valid CCA : AWH- 88120, Date of issue: 06/09/2017 and its compliance report is -- 6 Legal actions/closure directions/scn etc. issued by GPCB. attached as Annexure-III in EIA report. SCN and its reply are attached as an Annexure- XXI in EIA report. -- M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 274
7 Any Public Complaints No public complaints -- 8 Is there any litigation pending before any court of Law against the Project? No litigation pending -- 12. Water, Air and Hazardous waste management: Particulars Details no. A Water i Source of Water Supply (GIDC, Bore well, Surface water etc...) GIDC, Vapi Status of permission from the concern authority: Water permission letter from GIDC, Vapi is attached as annexure-ix-a on EIA report. ii Water consumption (KL/day) Category Existing Proposed Total after Remarks KL/day (Additional) KL/day Expansion KL/day (A) Domestic 55 0 55 (B) Gardening 0 0 0 (C) Industrial Process 146 263 409 iii iv Washing 10 0 10 Boiler 0 0 0 Cooling 334 90 424 Others 0 0 0 Total (A+B+C) 898 Note: - Waste water generation (KL/day) Category Existing KL/Day Proposed (Additional) KL/day Total after Expansion KL/day Remarks (A) Domestic 50 0 50 To STP Plant (B) Industrial Process 61 81 142 42 KLD sent to primary treatment. Washing 10 0 10 Sent to ETP Boiler Cooling 79 41 120 60 KLD recycle to CT + 60 KLD send to ETP Others 0 0 0 Total Industrial waste water Treatment facility with capacity (ETP, CETP, MEE, STP etc). 200 122 322 ETP : 212 KLD (212 KLD to ETP + 60 KLD Recycle from SSF) v Mode of Disposal & Final meeting point Domestic: STP to Gardening Industrial: CETP, Vapi (VGEL) vi Reuse/Recycle details (KL/day) Recycle from SSF : 60 KL/day M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 275
B i ii Water going with HCl: 308 KL/Day Air [Existing & Proposed] Flue gas emission details: of Boilers/TFH/Furnaces/DG sets etc. with capacities viz. TPH, Kcal/hr, MT/hr, KVA etc. Source of NAAQS Quantity emission Stack Nam Type of (National of Fuel SR. With Height e of emissions Ambient MT/hr APCM no. Capacity (meter the i.e. Air Air Quality & e.g. Boiler ) fuel Pollutants Standards) MT/Day (8 TPH) Existing 1 2 D.G. set (1 no. 625KVA) D.G. set (1 no. 750 KVA) 11 11 Dies el Dies el 0.1 MT/hr 0.125 MT/hr PM SO 2 NO X PM SO 2 NO X Adequate stack height & acoustic enclosure Proposed D.G. set PM (1 no. Dies 0.15 3. 11 SO 1100 el MT/hr 2 Adequate NO KVA) X stack height Thermo & acoustic PM pack Dies 0.20MT/ enclosure 4. 11 SO 1,00,000 el hr 2 NO K Cal X Note: DG sets will be run only in case of electricity failure. Process gas i.e. Type of pollutant gases (SO 2, HCl, NH 3, Cl 2, NO x etc.) [Existing & Proposed] no. Existing 1 2 Source of emission Chlorinator for MCB plant Nitrator of NCB plant Type of emission HCl Cl 2 18 NO X 12 Stack/ Vent Height (meter) APCM Two stage water scrubber + Caustic scrubber Two Stage Caustic scrubber 150mg/ Nm 3 100 ppm 50ppm 150mg/ Nm 3 100 ppm 50ppm 150mg/ Nm 3 100 ppm 50ppm 150mg/ Nm 3 100 ppm 50ppm NAAQS (National Ambient Air Quality Standards) 20 mg/nm 3 9 mg/nm 3 25 mg/nm 3 Proposed 3. Connected to HCl Two stage water HCl 11 storage tank scrubber 20 mg/nm 3 4. Connected to GLV 25 mg/nm 3 NO NCB X 11 Caustic scrubber 5. Spent acid 25 mg/nm 3 NO Concentration plant X 11 Caustic scrubber 6. Batch Nitration plant NO X 11 Caustic scrubber 25 mg/nm 3 7. DNCB Plant NO X 11 Water scrubber 25 mg/nm 3 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 276
v C i followed by Caustic scrubber Fugitive emission details with its mitigation measures. [Existing & Proposed] Details are provided in chapter-8 in table no: 8.3 from page no.:237 to 239. Hazardous waste (as per the Hazardous and Other Wastes (Management and Transboundary Movement) Rules 2016. [Existing & Proposed] Disposal Method no. Type/ Name of Hazardou s waste Source of generatio n Category and Schedule as per HW Rules. Quantit y (MT/ Annum) 1. ETP waste ETP 35.3 2220 Collection, Storage, Transportation, disposal to TSDF site. 2. MEE salt Effluent 35.5 1080 Collection, Storage, Transportation, disposal to TSDF site. 3. Distillation Residue 4. Spent carbon 5. Discarded (plastic bags, Drums) Process 26.1 6732 Collection, Storage, Transportation, disposal to CHWIF. Process 36.2 12 Collection, Storage, Transportation disposal to CHWIF. Raw 33.1 What so ever 6. Used Oil Plant 5.1 1000 Lit/year 7. a. Dilute H 2 SO 4 b. Dilute H 2 SO 4 8. Sulfuric Acid Process B15 a. 21600 b. 7500 Collection, Storage, Transportation disposal entire quantity reuse for filling the sludge and drums for filling residue & ETP waste/ Sale to authorized recycler. Collection, Storage, Transportation disposal by reuse in plant & machinery for lubricating purpose. M/s. Aarti Industries Ltd. (Alchemie organic Div.) & M/s. Apex Pharma Chem Pvt. Ltd.) Reception/ collection/ Storage/ Reuse. Process B15 79, 848 Collection, storage, Transportation and sale to authorized industry having permission under rule-9 of Hazardous & other wastes (Management & M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 277
ii ii D i ii 9. Hydrochlor ic Acid 10. Aq. Sodium Thio sulphate (Thio Liquor) Process B15 1, 58, 436 Transbouandry Movement) rule-2016 OR inhouse treatment. Collection, storage, Transportation and sale to authorized industry having permission under rule-9 of Hazardous & other wastes (Management & Transbouandry Movement) rule-2016 OR inhouse treatment. Process -- 1638 Collection, storage, Transportation and sale to authorized industry having permission under rule-9 of Hazardous & other wastes (Management & Transbouandry Movement) rule-2016 OR inhouse treatment. NON- HAZARDOUS WASTE GENERATION 8. Insulation waste Plant -- 84 Collection, Storage, Transportation and disposal to TSDF, Vapi. Quantity of discarded containers must be in MT/Annum. Membership details of CETP, TSDF, Membership Certificates are attached as annexure CHWIF, Common MEE etc. XIII-A-B-C in EIA report. Details of Non-Hazardous waste & its Insulation waste : 7 disposal [Collection, Storage, Transportation and disposal (MSW and others) to TSDF, Vapi.] Solvent management (If any) Details of Solvent recovery (As per respective ToR) VOC emission sources and its mitigation measures Details of solvent recovery are given in chapter-2 in section 2.6. Details are provided in chapter-8 in table no: 8.3. 13. Details of Environmental Consultants: Particulars Details no. i Name of the Consultant Jyoti Om Chemical Research Centre Pvt. Ltd. ii Validity of Certificate of High court stay order accreditation issued by the NABET, QCI iii Accreditation for the categories -- iv Any other details -- M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 278
14. Details regarding EIA report: no. a b c d e f g Particulars Details Page no. of EIA report Ensure that there is no 1) Page no.: change in EIA report 2. compared to ToR application i.e. Form-1 & PFR. Baseline environmental monitoring period Baseline study area (5 km or 10 km) of AAQM stations including project site Parameters considered for AAQM & ensure that project specific parameters are considered. Conclusion of the Monitoring (Baseline study) Air, Water & Land Parameters considered for AAQM including project specific parameters. Parameters no. 1. PM 2.5 31.1 54.1 2. PM 10 75.5-97.2 3. SO 2 11.4-19.9 4. NOx 18.2-38.7 5. CO 0.61-0.99 6. Cl 2 BDL 7. HCl BDL 8. VOCs 0-6.3 1) As per TOR application, Existing plot area of the unit is 45, 477 sq. meters. But actual GIDC plot allotment letter plot area of the unit is 45, 705 sq. meters. 2) As per ToR application, Total water requirement will be 958 KLD. Now, In EC application, Total water requirement will be reducing to 898 KLD. 3) As per ToR application, Total waste water generation will be 272 KLD (Industrial). Now, In EC application, Waste water generation will be reducing to 212 KLD (Industrial). Installing side stream filter. So, the water consumption & waste water generation will be reducing by 6.3% compare to the Terms of Reference. March-2017 to May-2017 92 5 KM -- 2) Page no:78 3) Page no: 9 of AAQM stations 94-98 PM 2.5, PM 10, SO 2, NO X, CO, Cl 2, HCl and VOC Acceptable -- PM 2.5, PM 10, SO 2, NO X, CO, Cl 2, HCl and VOC. Range of Concentrations (μg/m 3 ) Remarks 94-98 94-98 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 279
h i j k Whether the results of AAQM are within the norms prescribed in NAAQS? Comments for AAQM results w.r.t. NAAQS Software used for the mathematical Modeling for anticipated incremental GLCs (Ground Level Concentrations) The resultant concentrations w.r.t. NAAQS and its conclusion. l Suggested mitigation measures w.r.t. Air m Conclusion of the Monitoring during baseline study of water n Suggested mitigation measures w.r.t. Water o Conclusion of the Monitoring during baseline study of Land p Suggested mitigation measures w.r.t. Land q Conclusion of the Monitoring during baseline study of Noise Yes -- -- -- Industrial Source Complex Short Term (ISC-ST3) 145 From the dispersion modeling 153 studies conducted, it was observed that the maximum ground level concentration occurs in the East direction. The maximum incremental increase in concentration for PM, SO 2 and NO x is 0.52 µg/m 3, 0.4 µg/m 3 and 0.31 µg/m 3 respectively at a distance of about 1 km in the East direction, whereas, the maximum incremental increase in concentration for HCl and Cl 2 is 0.004 µg/m 3 and 0.002 µg/m 3 respectively at a distance of about 1 km in the East direction. Details are covered under Chapter- 136-162 4. Details are covered under Chapter- 99 & 102 3. -- -- -- -- -- -- The noise levels during daytime varied from 45-52 db (A) Leq to 53-72 db (A) Leq in the study area. The noise level in the study area is within the permissible Limits as per Noise rules 2000. The night time noise level in the study area is in the range of 38-46 db (A) Leq to 46-51 db (A) Leq. The night time noise was also 104 M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 280
r Suggested mitigation measures w.r.t. Noise s Main issues in Public hearing (If applicable) t Brief description of Public hearing Main Issues raised by stake holders within stipulated standards of CPCB. -- -- Not applicable -- Commitments by Project proponent and action plan. -- -- u Major hazardous chemicals and worst Details are covered under Chapter- 169- case scenario considered in Risk 6. 224 Analysis report. Comments/Suggestions/mitigation measures in brief. v An undertaking by the Project Proponent Undertaking from project -- on the ownership of the EIA report as per proponent is attached as an the OM of MoEF&CC dated 05/10/2011 Annexure-XXIV in EIA and an undertaking by the Consultant report. regarding the prescribed TORs have been complied with and the data submitted is factually correct as per the OM of Undertaking from consultant is attached as an Annexure- XXIII in EIA report. MoEF&CC dated 04/08/2009. w Any other details: -- -- M/s. JYOTI OM CHEMICAL RESEARCH CENTRE PVT. LIMITED, ANKLESHWAR. 281