JOBSITE CHECKLIST Pre-Installation

Transcription

1 JOBSITE CHECKLIST Pre-Installation CUSTOMER INFORMATION Home Owner s Name: Address: City: _ State: Zip Code: Phone Number: Address: Jobsite Visit Date: Time: General Contractor: _ JOB INFORMATION Property Type: Residential New Construction Listing Type: Single Family Apartment/Condo Athletic Store Front/Office EXTERIOR EVALUATION Commercial Remodel Duplex Townhome Restaurant/Bar Occupied: Property Faces: rth Relation of Lot to Street: Relation of Lot to Neighbors: Lot Drainage Away from Foundation: Swimming Pool: Slope Angle Measurement: Nearby Water Source: Gutters: Roof Overhang: Soil Damp at Foundation: Window Wells: Distance from Pool/Water Source to Foundation: Visible Cracks in Foundation: Visible Exterior Damage: Front Entry: Steps Up Steps Down Level Landscaping at Foundation: Number of Levels: Building is Over: Irrigation: Slab Basement Crawlspace

2 INTERIOR EVALUATION SUBSTRATE EVALUATION Temperature: F/C Relative Humidity: % Meter Used: HVAC System Operating: If, Date to be Operating: If, Alternative System Type: Capable of Mimicking Expected Living Conditions: Type of Heating System: Location of Heating: Forced Air Electric Radiant Baseboard Type of Cooling System: Radiator Wood Burning Stove Above Floor Below Floor Baseboard Central A/C Swamp Cooler Exhaust Fan Portable A/C Humidification/Dehumidification System: If, Is it Operating? Humidistat Control Settings: Thermostat Control Settings: Programmable: Data Logger: Large Windows Facing: Window Coverings: Tinted Glass/UV Protection: rth MOISTURE CONTENT OF WOOD AT VARIOUS TEMPERATURE AND RELATIVE HUMIDITY READINGS Relative Humidity (percent) Based on temperature and relative humidity readings. Mark expected wood moisture content and compare with material selection requirements. *See the FLOORING INFORMATION section for comparison. CONCRETE SUBFLOOR WOOD SUBFLOOR Relation of Slab Surface to Exterior Soil Line: inches Type of Subfloor: Maximum Joist Span Requirement: Above Grade Below Grade 19/32 Plywood 16 On Center rmal Weight Concrete (min 3,000 psi): 19/32 OSB 16 On Center (add 15/32 Overlay) Unknown 23/32 Plywood or OSB 19.2 On Center Light Weight Conrete: 7/8 Plywood or OSB 24 On Center Unknown 1 x 6 Solid Board Pre-Tension/Post-Tension Slab: Particle Board Unknown New Slab: Pour Date: Joist Span: Joist Type: Existing Slab: Age: Manufacturer Requirements: Moisture Test(s) Required by Flooring Manufacturer: Overlay Required: RH (ASTM 2170) Meter (ASTM 2659) Loose Subfloor: CaCl (ASTM 1869) Location: Results of Required Tests: Audible Squeaks/ise: Location: Number of Tests: Location of Tests: Peaked Seams: Moisture Test(s) Required by Adhesive Manufacturer: Required Sanding: RH (ASTM 2170) Meter (ASTM 2659) Protruding Nails/Screws: CaCl (ASTM 1869) Location: Results of Required Tests: Results Within 1/4 in 10 or 3/16 in 6 : Stains: Number of Tests: Location of Tests: Rot: Floor Measured for Flatness: Replacement Required: Method Flatness Measured: Total Number of Sheets: Type: MOISTURE TESTING High Spots Grinded: Moisture Meter Type: Name: Low Spots Floated: Model: Meter Setting: Results Within 3/16 in 10 or 1/8 in 6 : Comparison Readings (trim, door, cabinets, etc.): Concrete Surface Profile (CSP) Rating: Presence of Contamination on Surface: Average Reading (sum of readings/20): High Readings (indicate areas): Method of Testing: >> 20 Readings per 1,000 Square Feet << Method of Removal: Presence of Stress Cracks in Concrete: Method to Address: Presence of Expansion Joints in Concrete: Method to Address:

3 BELOW FLOORING SYSTEM FLOORING INFORMATION CRAWL SPACE Open-Air Enclosed Wall-Vented Conditioned Ground is Dirt, Concrete, Gravel, : BASEMENT Walk Out: Side(s) Below Ground Level: Manufacturer: Solid Engineered Strip Plank Unfinished Factory Finished Approved Over Radiant Heat: Approved Below Grade: MOISTURE TESTING Moisture Meter Type: 6 mil Plastic Vapor Retarder Present: rth Width: Species: Name: Model: Parquet Pattern: Meter Species Correction: Seams Overlapped and Taped: Basement Finished/Unfinished: Add tl. Info. on Flooring Container: High Reading: Low Reading: If Finished, Date Completed: Comparison Readings (trim, door, cabinets, etc.): Plastic Taped up Foundation Walls: Wall Cracks Present: Lot Number: SqFt. per Container: Unknown Total Job SqFt.: Total SqFt. Necessary: Areas of Concern: Percentage of Ground Covered: % If, Location: Installation Method: Nail Glue Float Temperature: Relative Humidity: Insulation Present: Transition Pieces Needed: Average Reading (sum of readings/40): Sump Pump: Quantity of Transitions: linear feet High Readings (% of total boards): Insulation on Foundation Walls: Type of Underlayment Required by Manufacturer: >> 40 Readings per 1,000 Square Feet << Operating: Vents Present: Unknown Quantity of Underlayment Necessary: HVAC Vents Open to Basement: Fastener Type Required by Manufacturer: Number of Vents: Open/Closed: Length: Gauge: Schedule: Square Feet of Crawl Space: Temperature: Relative Humidity: Adhesive System Required by Manufacturer: Humidistat Installed: Moisture Content of Exposed Joists: Trowel Required: Flooring Manufacturer Acclimation Requirements: Temperature: Relative Humidity: Signs of Moisture Damage: Distance from Ground to Underside of Joists: inches Peeling Paint: Temperature: Relative Humidity: Moisture Content of Exposed Joists: Specific Installation Requirements: Moisture Content Underside Exposed Subfloor: Floor Stains: Condensation Present: Rusty Nails: FINISH INFORMATION Standing Water Present: Mold Present: Alkali/Discoloration on Foundation Walls: : Finish Used: Lot Number: Sheen: Total SqFt.: Coverage Rate: Number of Gallons: Number of Coats: Application Method/Tool: Sealer: Color: Product: Mixture/Ratio: Process/System: Lot Number: Total SqFt.: Dry Time Requirements: Coverage Rate: Number of Gallons: Number of Coats: Airflow Obstacles: Application Method/Tool:

4 SPECIAL CONSIDERATIONS ROOMS TO RECEIVE WOOD Power: Art/Fixtures: Entry: SqFt. Kitchen: SqFt. Bath 3: SqFt. Bath 4: SqFt Removed Cover Hall(s): SqFt. Great Room: SqFt. Bath 5: SqFt. Bath 6: SqFt. Location of Breaker Box: Gas and Water Lines Disconnected: Living Room: SqFt. Dining Room: SqFt. Master Bed: SqFt. Bed 1: SqFt. ok: SqFt. Pantry: SqFt. Bed 2: SqFt. Bed 3: SqFt. Location of Temp Pole: Toilets/Pedestals/Plumbing Fixtures: Formal: SqFt. Study: SqFt. Bed 4: SqFt. Bed 5: SqFt. Library: SqFt. Powder Bath: SqFt. Bed 6: SqFt. Bed 7: SqFt. Booster Necessary: Plumber Information: Bath 1: SqFt. Bath 2: SqFt. Rooms: SqFt. Rooms: SqFt. Time Schedule Considerations: Existing Floor Covering Removal and Disposal: Arrival: Carpet Glued: Departure: Vinyl Underlayment: Trades: Tile Underlayment: Schedules: Wet Work Complete: Wood Nailed/Glued: Expected Traffic Use: High Low Average Disposal: Any Special or Unique Use: Trim and Moldings Removal: Office Restaurant Retail Store Re-Use Trim: Bar High Rise: New Trim: Style: Amount Necessary: Elevator: Lead (pre-1978): Certified: Passenger Freight ne Stairways: Number of Flights: Asbestos (pre-1986): Remediation: Hours of Access: Age of Facility:

5 NOTES