EuroSept Max Impression powder

Transcription

1 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1 identifier Trade name Article-No. : Relevant identified uses of the substance or mixture and uses advised against Use of the Substance/Mixture : Disinfectants Recommended restrictions on use : Restricted to professional users. 1.3 Details of the supplier of the safety data sheet Manufacturer/ Supplier : Henry Schein, Inc. 135 Duryea Road Melville, NY USA Henry Schein UK Holdings Ltd. MEDCARE HOUSE, CENTURION CLOSE, GILLINGHAM BUSINESS PARK Gillingham ME8 OSB U.K. Contact person : Information: Tel: International: Tel: UK TEL: +44 (0) 1634/ UK FAX: +44 (0) 1634/ Contact person : cbdeurope@henryschein.de 1.4 Emergency telephone number Emergency telephone number : Chemtrec US (800) SECTION 2: Hazards identification 2.1 Classification of the substance or mixture Classification (REGULATION (EC) No 1272/2008) Skin corrosion, Sub-category 1B Classification (67/548/EEC, 1999/45/EC) Irritant H314: Causes severe skin burns and eye damage. R36/38: Irritating to eyes and skin. R52: Harmful to aquatic organisms. 2.2 Label elements Labelling (REGULATION (EC) No 1272/2008) Z11223_05 ZSDB_P_ALL EN Page 1/12

2 Hazard pictograms : Signal word : Danger Hazard statements : H314 Causes severe skin burns and eye damage. Precautionary statements : P280 Wear protective gloves (e.g. butyl rubber) /eye protection/face protection. P301+P310+P330 IF SWALLOWED: Immediately call a POISON CENTER or doctor/ physician. Rinse mouth. P303+P361+P353 IF ON SKIN (or hair): Remove/ Take off immediately all contaminated clothing. Rinse skin with water/ shower. P305+P351+P338+P310 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or doctor/ physician. P501 Dispose of contents/ container to an approved waste disposal plant. Special labelling of certain mixtures 2.3 Other hazards : Labelling according to Regulation (EC) No. 648/2004: (5-15% anionic surfactants, < 5 % non-ionic surfactants,, < 5% soap,, < 5 % Phosphonates, perfumes) This mixture contains no substance considered to be persistent, bioaccumulating and toxic (PBT). The product itself does not burn, but it is oxidising. SECTION 3: Composition/information on ingredients 3.2 Mixtures Chemical nature : Mixture with the following substances and non dangerous additives. Hazardous components Chemical Name Pentapotassium bis(peroxymonosulphat e) bis(sulphate) Sodium dodecyl sulphate Index-Number CAS-No. EC-No. Registration number Classification (67/548/EEC) Xn; R22 C; R34 R52 F; R11 Xn; R20/22 Xi; R37/38 Xi; R41 Classification (REGULATION (EC) No 1272/2008) Acute Tox. 4; H302 Skin Corr. 1B; H314 Flam. Sol. 2; H228 Acute Tox. 4; H302 Acute Tox. 4; H332 Skin Irrit. 2; H315 Eye Dam. 1; H318 Concentration (%) 45 % 5-15 % Z11223_05 ZSDB_P_ALL EN Page 2/12

3 Isodecanpolyethyleneglycol(11)ether Polymer Xn; R22 Xi; R41 STOT SE 3; H335 Aquatic Chronic 3; H412 Acute Tox. 4; H302 Eye Dam. 1; H318 < 5 % Sodium carbonate XXXX Xi; R36 Eye Irrit. 2; H319 < 5 % For explanation of abbreviations see section 16. SECTION 4: First aid measures 4.1 Description of first aid measures General advice : If symptoms persist, call a physician. In case of skin contact : Wash off immediately with plenty of water. In case of eye contact : In the case of contact with eyes, rinse immediately with plenty of water and seek medical advice. If swallowed : Obtain medical attention. 4.2 Most important symptoms and effects, both acute and delayed Symptoms : Treat symptomatically. 4.3 Indication of any immediate medical attention and special treatment needed Treatment : For specialist advice physicians should contact the Poisons Information Service. SECTION 5: Firefighting measures 5.1 Extinguishing media Suitable extinguishing media Unsuitable extinguishing media : Dry powder, Foam, Carbon dioxide (CO2), Water spray jet : High volume water jet 5.2 Special hazards arising from the substance or mixture Specific hazards during firefighting : The product itself does not burn, but it is oxidising. Specific risk from the substance or the product itself, its combustion products or evolved gases : Formation of oxygen and mildly acidic benzoic acid vapour., Fire may cause evolution of:, Carbon monoxide, Carbon dioxide (CO2), Sulphur compounds Z11223_05 ZSDB_P_ALL EN Page 3/12

4 5.3 Advice for firefighters Special protective equipment for firefighters : In the event of fire, wear self-contained breathing apparatus. SECTION 6: Accidental release measures 6.1 Personal precautions, protective equipment and emergency procedures Personal precautions : Avoid dust formation. 6.2 Environmental precautions Environmental precautions : Do not flush into surface water. 6.3 Methods and material for containment and cleaning up Methods for cleaning up : Use mechanical handling equipment. 6.4 Reference to other sections see Section SECTION 7: Handling and storage 7.1 Precautions for safe handling Advice on safe handling Advice on protection against fire and explosion Hygiene measures : Avoid dust formation. : The product itself does not burn, but it is slightly oxidising (active oxygen content ca. 2%). The product has been shown not to be oxidising in a test following Directive 67/548/EEC (Method A17, oxidising properties). : Keep away from food and drink. 7.2 Conditions for safe storage, including any incompatibilities Requirements for storage areas and containers Further information on storage conditions : Store at room temperature in the original container. : Keep container tightly closed. Store in a dry place. Do not store at temperatures above 30 C. Recommended storage temperature: C Advice on common storage : No materials to be especially mentioned. 7.3 Specific end use(s) Specific use(s) : none SECTION 8: Exposure controls/personal protection 8.1 Control parameters none Derived No Effect Level (DNEL) : Z11223_05 ZSDB_P_ALL EN Page 4/12

5 Sodium dodecyl sulphate Sodium carbonate : End Use: Workers, Exposure routes: Skin contact, Potential health effects: Long-term systemic effects, Value: 4060 mg/kg End Use: Workers, Exposure routes: Inhalation, Potential health effects: Long-term systemic effects, Value: 285 mg/m3 : End Use: Workers, Exposure routes: Inhalation, Potential health effects: Long-term exposure, Value: 10 mg/m3 Predicted No Effect Concentration (PNEC) : Sodium dodecyl sulphate 8.2 Exposure controls Personal protective equipment Eye protection : Fresh water, Value: 0,137 mg/l Marine water, Value: 0,0137 mg/l Fresh water sediment, Value: 4,82 mg/kg Marine sediment, Value: 0,482 mg/kg Soil, Value: 0,882 mg/kg Intermittent use/release, Value: 0,055 mg/l : Safety glasses with side-shields conforming to EN166 Hand protection : Prolonged contact: Nitrile rubber gloves e.g. Camatril (>480 Min., layer thickness: 0,40 mm) or butyl rubber gloves e.g. Butoject (>480 Min., layer thickness: 0,70 mm) made by KCL or gloves from other manufacturers offering the same protection. Respiratory protection Protective measures : Breathing apparatus only if aerosol or dust is formed. ABEK-filter : Avoid contact with skin and eyes. Environmental exposure controls General advice : Do not flush into surface water. SECTION 9: Physical and chemical properties 9.1 Information on basic physical and chemical properties Appearance Colour Odour Odour Threshold Flash point Auto-ignition temperature Lower explosion limit Upper explosion limit Flammability Explosive properties Oxidizing properties ph Melting point/freezing point Decomposition temperature Boiling point/boiling range Z11223_05 ZSDB_P_ALL EN Page 5/12 : granular : white : pleasant : not determined : Not applicable : Not applicable : The product itself does not burn, but it is oxidising. : Not explosive : The product has been shown not to be oxidising in a test following Directive 67/548/EEC (Method A17, oxidising properties). : ca. 4, Concentration: 5,00 g/l, 20 C, in water : Not applicable

6 Vapour pressure, Relative vapour density : Not applicable Bulk density : ca. 775 kg/m³ Water solubility : ca. 20 g/l, 20 C Partition coefficient: n- : Not applicable octanol/water Viscosity, dynamic : Not applicable Evaporation rate : Not applicable 9.2 Other information SECTION 10: Stability and reactivity 10.1 Reactivity No dangerous reaction known under conditions of normal use Chemical stability The product is chemically stable Possibility of hazardous reactions Slightly exothermic autodecomposition (> 130 C) if strongly heated 10.4 Conditions to avoid Protect from frost, heat and sunlight Incompatible materials Do not mix with other products Hazardous decomposition products Oxygen SECTION 11: Toxicological information 11.1 Information on toxicological effects Acute toxicity Acute oral toxicity Acute inhalation toxicity Acute dermal toxicity Skin corrosion/irritation Z11223_05 ZSDB_P_ALL EN Page 6/12 : LD50: 2430 mg/kg, Rat : Acute toxicity estimate: 16,1 mg/l, in accordance with the calculation methode presented in the GHS (Globally Harmonized System), Part 3, Chapter 3.1) : Acute toxicity estimate: > mg/kg, in accordance with the calculation methode presented in the GHS (Globally Harmonized System), Part 3, Chapter 3.1) Causes severe skin burns and eye damage., Calculation method Serious eye damage/eye irritation

7 Causes severe skin burns and eye damage., Calculation method Respiratory or skin sensitisation Did not cause sensitisation on laboratory animals. Maximisation Test (GPMT), Guinea pig Did not cause sensitisation on laboratory animals. Germ cell mutagenicity Genotoxicity in vitro : Not mutagenic in Ames Test Germ cell mutagenicity- Assessment : Not mutagenic in Ames Test Genotoxicity in vitro : not mutagenic OECD Test Guideline 471 Germ cell mutagenicity- Assessment : not mutagenic Germ cell mutagenicity- Assessment Germ cell mutagenicity- Assessment : Contains no ingredient listed as a mutagen Carcinogenicity Carcinogenicity - Assessment Carcinogenicity - Assessment : Not classifiable as a human carcinogen. Carcinogenicity - Assessment Carcinogenicity - Assessment : No evidence of carcinogenicity in animal studies. Reproductive toxicity Reproductive toxicity - Assessment Teratogenicity - Assessment Reproductive toxicity - Assessment : No toxicity to reproduction Z11223_05 ZSDB_P_ALL EN Page 7/12

8 Teratogenicity - Assessment : According to experience not expected Reproductive toxicity - Assessment Teratogenicity - Assessment Reproductive toxicity - Assessment : Contains no ingredient listed as toxic to reproduction Teratogenicity - Assessment : Did not show carcinogenic or teratogenic effects in animal experiments. STOT - single exposure STOT - repeated exposure Aspiration toxicity Further information SECTION 12: Ecological information 12.1 Toxicity Toxicity to fish Toxicity to daphnia and other aquatic invertebrates Toxicity to bacteria Z11223_05 ZSDB_P_ALL EN Page 8/12 : LC50 (Oncorhynchus mykiss (rainbow trout)): 53 mg/l, 96 h : EC50 (Daphnia magna (Water flea)): 3,5 mg/l, 48 h : EC50 (Bacteria): 179 mg/l, 18 h Toxicity to fish : LC50: > 10 - < 100 mg/l, OECD Test Guideline 203 Toxicity to daphnia and other : EC50: > 1 - < 10 mg/l aquatic invertebrates Toxicity to algae : EC50: > 100 mg/l Toxicity to fish (Chronic toxicity) : NOEC: > 1 - < 10 mg/l Toxicity to fish Toxicity to daphnia and other aquatic invertebrates Toxicity to algae Toxicity to fish Toxicity to daphnia and other aquatic invertebrates Toxicity to algae 12.2 Persistence and degradability : LC50 (Leuciscus idus): > 100 mg/l, 96 h : EC50: > 100 mg/l, 48 h : EC50: > 100 mg/l, 72 h : LC50 (Lepomis macrochirus (Bluegill sunfish)): 300 mg/l, 96 h : EC50 (Daphnia magna): mg/l, 48 h

9 Biodegradability : Readily biodegradable OECD 301D / EEC 84/449 C6 Chemical Oxygen Demand : mg/l, 1% solution (COD) Biodegradability : The methods for determining biodegradability are not applicable to inorganic substances. Biodegradability : Readily biodegradable, according to appropriate OECD test. Biodegradability : Readily biodegradable, according to appropriate OECD test. Biodegradability : The methods for determining the biological degradability are not applicable to inorganic substances Bioaccumulative potential Partition coefficient: n- : Not applicable octanol/water Bioaccumulation Bioaccumulation : Bioaccumulation is unlikely. Bioaccumulation : According to experience not expected Bioaccumulation : Does not bioaccumulate Mobility in soil Mobility Mobility Mobility : Adsorbs on soil. Mobility 12.5 Results of PBT and vpvb assessment This mixture contains no substance considered to be persistent, bioaccumulating and toxic (PBT) Other adverse effects Additional ecological information : Harmful to aquatic organisms. SECTION 13: Disposal considerations 13.1 Waste treatment methods Z11223_05 ZSDB_P_ALL EN Page 9/12

10 Contaminated packaging Waste key for the unused product(group) : Can be incinerated or landfilled together with household waste in compliance with the regulations, and after consultation with the waste disposal services. : Take empty packaging to the recycling plant. : The waste producer itself must, in consultation with the appropriate authorities and a waste disposal company, obtain a waste code from the EWC (European Waste Catalogue) SECTION 14: Transport information 14.1 UN number ADR : UN 3260 IMDG : UN 3260 IATA : UN UN proper shipping name ADR IMDG IATA 14.3 Transport hazard class(es) : CORROSIVE SOLID, ACIDIC, INORGANIC, N.O.S. (Pentapotassium bis(peroxymonosulphate) bis(sulphate)) : CORROSIVE SOLID, ACIDIC, INORGANIC, N.O.S. (Pentapotassium bis(peroxymonosulphate) bis(sulphate)) : Corrosive solid, acidic, inorganic, n.o.s. (Pentapotassium bis(peroxymonosulphate) bis(sulphate)) ADR : 8 IMDG : 8 IATA : Packing group ADR Packing group : III Classification Code : C2 Hazard Identification Number : 80 Labels : 8 Tunnel restriction code : E IMDG Packing group : III Labels : 8 EmS Code : F-A, S-B IATA Packing instruction (cargo : 864 aircraft) Packing group : III Labels : Environmental hazards Z11223_05 ZSDB_P_ALL EN Page 10/12

11 ADR Environmentally hazardous IMDG Marine pollutant 14.6 Special precautions for user : no : no For personal protection see section Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code Not applicable for product as supplied. SECTION 15: Regulatory information 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture Legislation on the control of major-accident hazards involving dangerous substances : Directive 96/82/EC does not apply Volatile organic compounds : none, Directive 2010/75/EU on the limitation of emissions of volatile organic compounds 15.2 Chemical Safety Assessment Exempt SECTION 16: Other information Full text of R-Phrases R11 : Highly flammable. R20/22 : Harmful by inhalation and if swallowed. R22 : Harmful if swallowed. R34 : Causes burns. R36 : Irritating to eyes. R37/38 : Irritating to respiratory system and skin. R41 : Risk of serious damage to eyes. R52 : Harmful to aquatic organisms. Full text of H-Statements H228 : Flammable solid. H302 : Harmful if swallowed. H314 : Causes severe skin burns and eye damage. H315 : Causes skin irritation. H318 : Causes serious eye damage. H319 : Causes serious eye irritation. H332 : Harmful if inhaled. H335 : May cause respiratory irritation. H412 : Harmful to aquatic life with long lasting effects. Full text of other abbreviations Acute Tox. Acute toxicity Z11223_05 ZSDB_P_ALL EN Page 11/12

12 Aquatic Chronic Eye Dam. Eye Irrit. Flam. Sol. Skin Corr. Skin Irrit. STOT SE Further information Chronic aquatic toxicity Serious eye damage Eye irritation Flammable solids Skin corrosion Skin irritation Specific target organ toxicity - single exposure Changes compared with the previous edition!!! The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. Z11223_05 ZSDB_P_ALL EN Page 12/12