Enviro Alcohol Gel HAND SANITIZER (Not hazardous according to criteria of Worksafe Australia)

Transcription

1 ENVIRO CHEMICALS AUST Pty Ltd ABN: ACN: Tel: (02) Fax: (02) Products That Don t Cost The Earth Enviro Alcohol Gel HAND SANITIZER (Not hazardous according to criteria of Worksafe Australia) Enviro Alcohol Gel is a waterless, alcohol based hand-rub that uses natural Oil to replenish the skin. Human skin lipids contain approximately 22% of cishexadec-6-enoic acid which along with palmitic acid comprise around half the skin lipid content. It s action is thought to be a combination of lubrication, softening and protection of the protein structures and prevention of moisture loss from the skin. Natural Oil contains up to 22% of an isomer, palmitoleic acid which is the highest known actual concentration of this unique material. Enviro Alcohol Gel uses Natural Oils to replace the skin s lipids which are removed by alcohol leaving your hands hygienic, soft and replenished. DIRECTIONS: Apply to hands, cover all skin surfaces and allow to dry. Water not required. You don't have to settle for second best to save money when cleaning. Step-up to the new level in Cleaning Soaps & Detergents. Use Enviro Chemicals and you will never settle for second best again. We trust this product will be of interest to you and for more info visit our Web site. Please do not hesitate to contact us if we can be of further assistance.

2 MATERIAL SAFETY DATA SHEET 1: IDENTIFICATION Product Name: Manufacturers Product Code: ENVIRO ALCOHOL GEL EC-ALGEL Recommended Use: Antibacterial Hand rub. COMPANY DETAILS: Company : Enviro Chemicals (Aust.) Pty Ltd. (A.C.N : ). Address : Woodville Road Fairfield East NSW 2165 Emergency: PH: (02) (Business hour ) or Poisons Information centre : : HAZARDS Classified as hazardous by the criteria of Safe W ork Australia. R11 S7 S16 Highly Flammable Keep Container Tightly Closed Keep Away From Sources of Ignition 3: COMPOSITION INFORMATION Ingredient CAS No Proportion Ethanol % v/ Ingredients deemed not to be hazardous Not applicable To 100% 4: FIRST AID Eye (Contact) Skin (Contact) Inhalation(Breathing) Hold eyelids apart and flush the eye continuously with running water. Continue flushing until advised to stop by the Poisons Information Centre or a doctor, or for at least 15 minutes. Not normally required. Not normally required. If patient is overcome by vapours, move to fresh air. Ingestion (Swallowing) DO NOT induce vomiting. For advice, contact a Poisons Information Centre (Phone ) or a doctor. Advice to Doctor First Aid Facilities Additional Information Treat symptomatically. Ensure an eye bath and safety shower are available and ready for use. No aggravated medical conditions are known to be caused by exposure to this product. Page 1 of 5

3 5: FIREFIGHTING MEASURE Suitable Extinguishing Media Hazards From Combustion Products Precautions For Fire Fighters and Special Protective Equipment Additional Information Use dry chemical, alcohol stable foam, carbon dioxide or fog type extinguishers. Toxic and/or irritating fumes including carbon monoxide and carbon dioxide may be emitted. Fire-fighters should wear self-contained breathing apparatus (SCBA) and complete protective clothing. Vapours from combustion products are heavier than air and may travel to low-level areas and/or spread fires. Water may be used to cool containers. Hazchem Code 3[Y]E 6: ACCIDENTAL RELEASE MEASURES Emergency Procedure Spills / Clean up SAA/SNZ HB76: Dangerous Goods Initial Emergency Response Guide Guide 14. Slippery when spilled. Personal protective equipment should be worn when cleaning up spills. Restrict access to area until completion of cleanup. Stop leak if safe to do so. Contain spill with absorbent material, such as toweling, sand, vermiculite or other inert material. Prevent spill entering sewers or waterways. Collect and dispose of spilled material according to local regulations. Wash away remnants with copious amounts of cold water. 7: HANDLING AND STORAGE Precautions for Safe Handling Contact W hiteley Corporation Pty Ltd sales representative for advice when using this product for any application other than that outlined on the label or technical bulletin. Any non-intended or non-authorised use of this product may result in personal injury or damage to equipment. Store product in original container. Conditions for Safe Storage Store in a cool, dry, well ventilated area away from direct sunlight, incompatible materials and sources of ignition. Keep container tightly sealed. 8: EXPOSURE CONTROL/PERSONAL PROTECTION National Exposure Standards Source: National Exposure Standards for Atmospheric Contaminants in the Occupational Environment [NOHSC:1003]. Ingredient CAS No ES-TWA ES-STEL Ethanol ppm 1880mg/m Biological Limit Values Engineering Controls Not normally required. Page 2 of 5

4 Personal Protective Equipment Eye/face protection Not required under normal circumstances. Should a splash risk exist then safety glasses or chemical resistant goggles should be worn to prevent eye contact. Skin protection Not required under normal circumstances. Respiratory protection Not required under normal circumstances. 9: PHYSICAL AND CHEMICAL PROPERTIES Appearance Thick blue opaque liquid Odour Ethanol odour ph approx. 7.0 Boiling Point o C Freezing Point Not available Solubility Moderately soluble in water. Specific Gravity 0.9 Flash Point 23.5 o C (ASTM D6450) Vapour Pressure Not Available. Vapour Density Not Available. Upper and Lower Flammability limits (in air) Not Available. Ignition Temperature Not Available. 10: STABILITY AND REACTIVITY Chemical Stability Stable under normal ambient storage conditions. Conditions to avoid Avoid heat, sparks, high temperatures (store below 30 o C) and direct sunlight. Protect against physical damage. Incompatible materials Hazardous decomposition products Hazardous reactions Strong oxidizing agents. Burning can produce carbon monoxide and/or carbon dioxide. None known. 11: TOXICOLOGICAL INFORMATION HEALTH EFFECTS Acute Swallowed Eye Skin Inhaled Chronic Swallowed Eye Skin Inhalation Considered an unlikely route of entry in commercial / industrial environments. May be irritating to gastro-intestinal tract. May cause headache, dizziness or fatigue. Methanol is used in this product as a denaturant which may cause optical nerve damage if ingested. May irritate or damage the eye. None known. Moderately irritating to the respiratory tract. May cause degenerative changes in the liver and kidneys. Permanent damage may result. No effect known. No effect known. TOXICITY DATA Ethanol LD mg/kg (oral, rat) RTECS KQ Page 3 of 5

5 12: ECOLOGICAL INFORMATION Ecotoxicity Persistence and degradability Mobility 13: DISPOSAL CONSIDERATIONS Disposal method Special precautions Refer to State/Territory Land Waste Management Authority. Dispose of material through a licensed waste contractor. Rinse empty containers thoroughly before recycling or disposing to an authorised landfill. Suitable for incineration by approved agent. 14: TRANSPORT INFORMATION Classified as Dangerous Goods by the criteria of the Australian Dangerous Goods Code (ADG Code). UN Number 1993 UN Proper Shipping Name FLAMMABLE LIQUID, N.O.S. Class and subsidiary risk 3 Flammable. Packing Group III Special precautions for user Not applicable. Hazchem Code 3[Y]E 15: REGULATORY INFORMATION Poisons Schedule (SUSDP): Not applicable. All ingredients are listed in the Australia Inventory of Chemical Substances (AICS). 16: OTHER INFORMATION Date of Preparation: Key to Abbreviations & Acronyms Used in MSDS: < Less Than > Greater Than AICS Australian Inventory of Chemical Substances CAS Chemical Abstracts Service (Registry Number) LC50 LC stands for lethal Concentration. LC50 is the concentration of a material in air which causes death of 50% (one half ) of a group of test animals. LD50 LD stands for Lethal Dose. LD50 is the amount of a material, given all at once, which causes the death of 50% (one half) of a group of test animals. NOHSC National Occupational Health and Safety Commission. OECD Organisation for Economic Co-operation and Development. PEL Permissible Exposure Limit. STEL Short Term Exposure Limit TLV Threshold Limit Value TWA Time Weighted Average Page 4 of 5

6 UN United Nations (Number) deg C ( C) Degrees Celsius g Gram g/cm3 Grams per cubic centimetre g/l Grams per litre Immiscible Liquids are insoluble in each other kg Kilogram kg/m3 Kilograms per cubic metre ltr Litre m3 Cubic metre mg Milligra m mg/24h Milligrams per 24 hours mg/kg Milligrams per kilogram mg/m3 Milligrams per cubic metre miscible Liquids form one homogeneous liquid ppm Parts per million wt Weight Literature References: Supplies MSDS The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. END OF MSDS Page 5 of 5