SAFETY DATA SHEET Cutan Complete Foaming Hand Sanitiser According to Regulation (EC) No 1907/2006, Annex II, as amended by Regulation (EU) No 453/2010

Transcription

1 SAFETY DATA SHEET According to Regulation (EC) No 1907/2006, Annex II, as amended by Regulation (EU) No 453/2010 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product name Product number CFS39H, CFS400P, CFS47ML, CFS400PDM 1.2. Relevant identified uses of the substance or mixture and uses advised against Identified uses PT1 Human Hygiene Biocidal Product 1.3. Details of the supplier of the safety data sheet Supplier Deb Ltd Denby Hall Way Denby Derbyshire DE5 8JZ Main Tel Technical Tel Emergency telephone number Emergency telephone National Poisons Information Service (UK) (Health Professionals only) National Poisons Information Centre (Eire) / SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification (EC 1272/2008) Physical hazards Flam. Liq. 2 - H225 Health hazards Environmental hazards Eye Irrit. 2 - H319 Not Classified 2.2. Label elements Pictogram Signal word Hazard statements Danger H225 Highly flammable liquid and vapour. H319 Causes serious eye irritation. 1/10

2 Precautionary statements Supplemental label information Supplementary precautionary statements P210 Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No smoking. P233 Keep container tightly closed. P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P337+P313 If eye irritation persists: Get medical advice/ attention. P404 Store in a closed container. P501 Dispose of contents/ container in accordance with local regulations. BPR001 Use biocides safely. Always read the label and product information before use. P240 Ground/ bond container and receiving equipment. P241 Use explosion-proof electrical equipment. P242 Use only non-sparking tools. P243 Take precautionary measures against static discharge. P264 Wash contaminated skin thoroughly after handling. P280 Wear eye protection. P303+P361+P353 IF ON SKIN (or hair): Take off immediately all contaminated clothing. Rinse skin with water/ shower. P370+P378 In case of fire: Use foam, carbon dioxide, dry powder or water fog to extinguish Other hazards This product does not contain any substances classified as PBT or vpvb. SECTION 3: Composition/information on ingredients 3.2. Mixtures ETHANOL 80.0% CAS number: EC number: REACH registration number: XXXX Classification Flam. Liq. 2 - H225 Eye Irrit. 2 - H319 Classification (67/548/EEC or 1999/45/EC) F;R11 The Full Text for all R-Phrases and Hazard Statements are Displayed in Section 16. SECTION 4: First aid measures 4.1. Description of first aid measures General information Inhalation Ingestion Skin contact Get medical attention if any discomfort continues. Move affected person to fresh air and keep warm and at rest in a position comfortable for breathing. Rinse mouth. Promptly get affected person to drink large volumes of water to dilute the swallowed chemical. Never give anything by mouth to an unconscious person. Do not induce vomiting. Get medical attention if any discomfort continues. Not relevant. Eye contact Remove any contact lenses and open eyelids wide apart. Continue to rinse for at least 15 minutes. Get medical attention promptly if symptoms occur after washing Most important symptoms and effects, both acute and delayed Inhalation No specific symptoms known. 2/10

3 Ingestion Skin contact Eye contact May cause nausea, headache, dizziness and intoxication. None known. May cause severe eye irritation Indication of any immediate medical attention and special treatment needed Notes for the doctor No specific recommendations. SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media Extinguish with the following media: Water spray, fog or mist. Foam, carbon dioxide or dry powder. Dry chemicals, sand, dolomite etc Special hazards arising from the substance or mixture Specific hazards Hazardous combustion products The product is highly flammable. Oxides of carbon Advice for firefighters Protective actions during firefighting Special protective equipment for firefighters Fight fire from safe distance or protected location. Wear positive-pressure self-contained breathing apparatus (SCBA) and appropriate protective clothing. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Personal precautions Wear protective clothing as described in Section 8 of this safety data sheet Environmental precautions Environmental precautions Do not discharge into drains or watercourses or onto the ground. Contain spillage with sand, earth or other suitable non-combustible material Methods and material for containment and cleaning up Methods for cleaning up Eliminate all sources of ignition. No smoking, sparks, flames or other sources of ignition near spillage. Use explosion-proof electrical equipment. Provide adequate ventilation. Absorb in vermiculite, dry sand or earth and place into containers. Wash thoroughly after dealing with a spillage Reference to other sections Reference to other sections For personal protection, see Section 8. SECTION 7: Handling and storage 7.1. Precautions for safe handling Usage precautions Advice on general occupational hygiene Keep away from heat, sparks and open flame. Avoid contact with eyes. Good general ventilation should be adequate to control worker exposure to airborne contaminants. Do not smoke in work area Conditions for safe storage, including any incompatibilities 3/10

4 Storage precautions Storage class Store in tightly-closed, original container in a dry, cool and well-ventilated place. Keep away from heat, sparks and open flame. Store at temperatures not exceeding 40 C. Take precautionary measures against static discharges. Flammable liquid storage Specific end use(s) Specific end use(s) The identified uses for this product are detailed in Section 1.2. SECTION 8: Exposure Controls/personal protection 8.1. Control parameters Occupational exposure limits ETHANOL Long-term exposure limit (8-hour TWA): WEL 1000 ppm 1920 mg/m³ WEL = Workplace Exposure Limit Ingredient comments WEL = Workplace Exposure Limits ETHANOL (CAS: ) DNEL PNEC Professional - Inhalation; local effects: 1900 mg/m³ Professional - Dermal; Long term systemic effects: 343 mg/kg/day Professional - Inhalation; Long term systemic effects: 950 mg/m³ Consumer - Inhalation; local effects: 950 mg/m³ Consumer - Dermal; Long term systemic effects: 206 mg/kg/day Consumer - Inhalation; Long term systemic effects: 114 mg/m³ Consumer - Oral; Long term systemic effects: 87 mg/kg/day - Marine water; 0.79 mg/l - Fresh water; 0.96 mg/l - Intermittent release; 2.75 mg/l - STP; 580 mg/l - Sediment (Freshwater); 3.46 mg/kg - Sediment (Marinewater); 2.9 mg/l - Soil; 0.63 mg/kg COCOGLUCOSIDE (CAS: ) DNEL PNEC Workers - Inhalation; Long term systemic effects: 420 mg/m³ Workers - Dermal; Long term systemic effects: mg/kg/day General population - Inhalation; Long term systemic effects: 124 mg/m³ General population - Dermal; Long term systemic effects: mg/kg/day General population - Oral; Long term systemic effects: 35.7 mg/kg/day - Fresh water; mg/l - Marine water; mg/l - Intermittent release; 0.27 mg/l - STP; 560 mg/l - Sediment (Freshwater); mg/kg - Sediment (Marinewater); mg/kg - Soil; mg/kg 8.2. Exposure controls 4/10

5 Protective equipment Appropriate engineering controls Eye/face protection Hand protection Other skin and body protection Hygiene measures Respiratory protection Not relevant. Eyewear complying with an approved standard should be worn if a risk assessment indicates eye contact is possible. Personal protective equipment for eye and face protection should comply with European Standard EN166. Not applicable. Not relevant. Do not smoke in work area. Promptly remove any clothing that becomes contaminated. Not relevant. SECTION 9: Physical and Chemical Properties 9.1. Information on basic physical and chemical properties Appearance Colour Odour Odour threshold Clear liquid. Colourless. Alcoholic. ph ph (concentrated solution): Melting point Initial boiling point and range Flash point 15.5 C C A.9 Evaporation rate Upper/lower flammability or explosive limits Vapour pressure Vapour density Relative density ~ 20 C Solubility(ies) Partition coefficient Auto-ignition temperature Decomposition Temperature Soluble in water. Viscosity 2.67 mpa 20 C Explosive properties Oxidising properties Does not meet the criteria for classification as oxidising Other information 5/10

6 Other information No information required. SECTION 10: Stability and reactivity Reactivity Reactivity There are no known reactivity hazards associated with this product Chemical stability Stability No particular stability concerns Possibility of hazardous reactions Possibility of hazardous reactions Not known Conditions to avoid Conditions to avoid Avoid heat, flames and other sources of ignition Incompatible materials Materials to avoid No specific material or group of materials is likely to react with the product to produce a hazardous situation Hazardous decomposition products Hazardous decomposition products Oxides of carbon. SECTION 11: Toxicological information Information on toxicological effects Acute toxicity - oral Notes (oral LD₅₀) Acute toxicity - dermal Notes (dermal LD₅₀) Acute toxicity - inhalation Notes (inhalation LC₅₀) Skin corrosion/irritation Animal data Respiratory sensitisation Respiratory sensitisation Skin sensitisation Skin sensitisation Germ cell mutagenicity Genotoxicity - in vivo Carcinogenicity Carcinogenicity Reproductive toxicity Reproductive toxicity - development Does not contain any substances known to be mutagenic. Does not contain any substances known to be toxic to reproduction. Specific target organ toxicity - single exposure 6/10

7 STOT - single exposure No information available. Specific target organ toxicity - repeated exposure STOT - repeated exposure No information available. Aspiration hazard Aspiration hazard General information Inhalation Ingestion Skin contact Eye contact No specific health hazards known. No specific health hazards known. May cause nausea, headache, dizziness and intoxication. Skin irritation should not occur when used as recommended. Irritating to eyes. Symptoms following overexposure may include the following: Redness. Pain. ETHANOL Acute toxicity - oral Acute toxicity oral (LD₅₀ mg/kg) Species 10,470.0 Rat ATE oral (mg/kg) 10,470.0 Acute toxicity - dermal Acute toxicity dermal (LD₅₀ mg/kg) Species 20,000.0 Rabbit Acute toxicity - inhalation Acute toxicity inhalation (LC₅₀ vapours mg/l) Species ATE inhalation (vapours mg/l) Rat Skin corrosion/irritation Animal data Oedema score: Very slight oedema - barely perceptible (1). Carcinogenicity Carcinogenicity SECTION 12: Ecological Information Ecotoxicity The product is not expected to be hazardous to the environment Toxicity Toxicity The product is not expected to be toxic to aquatic organisms. ETHANOL 7/10

8 Acute toxicity - fish Acute toxicity - aquatic invertebrates Acute toxicity - aquatic plants LC50, 96 hours: mg/l, Pimephales promelas (Fat-head Minnow) LC₅₀, 96 hours: mg/l, Algae EC₅₀, : H mg/l, Marinewater invertebrates EC₅₀, 48 hours: mg/l, Daphnia magna EC₅₀, > 48 hours: mg/l, Daphnia magna EC₅₀, 72 hours: 275 mg/l, Freshwater algae IC₅₀, 72 hours: 5000 mg/l, Fish Persistence and degradability Persistence and degradability The product is expected to be biodegradable Bioaccumulative potential Bioaccumulative potential Partition coefficient No data available on bioaccumulation Mobility in soil Mobility The product is soluble in water Results of PBT and vpvb assessment Results of PBT and vpvb assessment This product does not contain any substances classified as PBT or vpvb Other adverse effects Other adverse effects None known. SECTION 13: Disposal considerations Waste treatment methods General information Disposal methods Dispose of waste to licensed waste disposal site in accordance with the requirements of the local Waste Disposal Authority. Reuse or recycle products wherever possible. Dispose of waste to licensed waste disposal site in accordance with the requirements of the local Waste Disposal Authority. SECTION 14: Transport information UN number UN No. (ADR/RID) 1170 UN No. (IMDG) 1170 UN No. (ICAO) 1170 UN No. (ADN) UN proper shipping name Proper shipping name (ADR/RID) ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) Proper shipping name (IMDG) ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) Proper shipping name (ICAO) Proper shipping name (ADN) ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) ETHANOL (ETHYL ALCOHOL) or ETHANOL SOLUTION (ETHYL ALCOHOL SOLUTION) Transport hazard class(es) 8/10

9 ADR/RID class 3 ADR/RID classification code F1 ADR/RID label 3 IMDG class 3 ICAO class/division 3 ADN class 3 Transport labels Packing group ADR/RID packing group IMDG packing group ADN packing group ICAO packing group II II II II Environmental hazards Environmentally hazardous substance/marine pollutant No Special precautions for user EmS F-E, S-D ADR transport category 2 Emergency Action Code Hazard Identification Number (ADR/RID) Tunnel restriction code 2YE 33 (D/E) Transport in bulk according to Annex II of MARPOL and the IBC Code SECTION 15: Regulatory information Safety, health and environmental regulations/legislation specific for the substance or mixture 9/10

10 EU legislation Regulation (EC) No 1907/2006 of the European Parliament and of the Council of 18 December 2006 concerning the Registration, Evaluation, Authorisation and Restriction of Chemicals (REACH) (as amended). Regulation (EC) No 1272/2008 of the European Parliament and of the Council of 16 December 2008 on classification, labelling and packaging of substances and mixtures (as amended). Commission Directive 91/322/EEC of 29 May 1991 on establishing indicative limit values by implementing Council Directive 80/1107/EEC on the protection of workers from the risks related to exposure to chemical, physical and biological agents at work. Commission Directive 2000/39/EC of 8 June 2000 establishing a first list of indicative occupational exposure limit values in implementation of Council Directive 98/24/EC on the protection of the health and safety of workers from the risks related to chemical agents at work (as amended). REGULATION (EU) No 528/2012 (as amended) concerning the making available on the market and use of biocidal products Chemical safety assessment No chemical safety assessment has been carried out. SECTION 16: Other information General information Key literature references and sources for data Revision comments Use biocides safely. Always read the label and product information before use. Where Exposure Scenarios for the substances listed in Section 3 are available they have been assessed for the uses identified in this data sheet or on the product label and the appropriate relevant information is incorporated into this Safety Data Sheet. Revision of information Revision date 18/10/2016 Revision 7 Supersedes date 11/08/2016 Hazard statements in full Notes for Risk Phrases and Hazard Statements in Full H225 Highly flammable liquid and vapour. H319 Causes serious eye irritation. The full text for Risk Phrases and Hazard Statements in section 16 relates to the reference numbers in sections 2 and 3 and not necessarily the finished product classification. This information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process. Such information is, to the best of the company's knowledge and belief, accurate and reliable as of the date indicated. However, no warranty, guarantee or representation is made to its accuracy, reliability or completeness. It is the user's responsibility to satisfy himself as to the suitability of such information for his own particular use. 10/10