: Adhesive Side Developer - Dark

Transcription

1 Revision date:01/10/2013 Supersedes:05/07/2012 Version: SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product form Product name. Product code : Mixture : Adhesive Side Developer - Dark : ASD7D 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of the substance/preparation 1.3. Details of the supplier of the safety data sheet : Latent fingerprint developer SIRCHIE Finger Print Laboratories 100 Hunter Place Youngsville, NC - USA T ; F ; Emergency telephone number Emergency number : SECTION 2: Hazards identification 2.1. Classification of the substance or mixture Classification (GHS-US) Eye Dam. 1 H Label elements GHS-US labeling Hazard pictograms (GHS-US) : Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) 2.3. Other hazards 2.4. Unknown acute toxicity (GHS US) No data available GHS05 : Warning GHS07 : H318 - Causes serious eye damage SECTION 3: Composition/information on ingredients 3.1. Substances Not applicable 3.2. Mixtures : P280 - Wear eye protection, protective gloves. P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310 - Immediately call a POISON CENTER/doctor/ P102 - Keep out of reach of children P202 - Do not handle until all safety precautions have been read and understood P301+P330+P331 - IF SWALLOWED: Rinse mouth. Do NOT induce vomiting Name Product identifier % Classification (GHS-US) AQUA (CAS No.) < 50.5 Not classified iron(ii,iii)oxide (CAS No.) > 28.5 Not classified ethylene glycol (CAS No.) >= 11 Acute Tox. 4 (Oral), H302 TRITON X-100 (CAS No.) >= 10 Acute Tox. 4 (Oral), H302 Eye Dam. 1, H318 14/01/2013 EN (English US) 1/6

2 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). : Assure fresh air breathing. Allow the victim to rest. : Remove affected clothing and wash all exposed skin area with mild soap and water, followed by warm water rinse. : Rinse immediately with plenty of water. Obtain medical attention if pain, blinking or redness persist. : Rinse mouth. Do NOT induce vomiting. Obtain emergency medical attention Most important symptoms and effects, both acute and delayed Symptoms/injuries : Not expected to present a significant hazard under anticipated conditions of normal use Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media : Foam. Dry powder. Carbon dioxide. Water spray. Sand. Unsuitable extinguishing media : Do not use a heavy water stream Special hazards arising from the substance or mixture Reactivity Advice for firefighters Firefighting instructions Protection during firefighting : Use water spray or fog for cooling exposed containers. Exercise caution when fighting any chemical fire. Avoid (reject) fire-fighting water to enter environment. : Do not enter fire area without proper protective equipment, including respiratory protection. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures For non-emergency personnel Emergency procedures For emergency responders Protective equipment Emergency procedures : Evacuate unnecessary personnel. : Equip cleanup crew with proper protection. : Ventilate area Environmental precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters Methods and material for containment and cleaning up Methods for cleaning up 6.4. Reference to other sections See Heading 8. Exposure controls and personal protection. SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling 7.2. Conditions for safe storage, including any incompatibilities Storage conditions Incompatible products Incompatible materials 7.3. Specific end use(s) : Soak up spills with inert solids, such as clay or diatomaceous earth as soon as possible. Collect spillage. Store away from other materials. : Wash hands and other exposed areas with mild soap and water before eat, drink or smoke and when leaving work. Provide good ventilation in process area to prevent formation of vapor. : Keep only in the original container in a cool, well ventilated place away from : Keep container closed when not in use. : Strong bases. strong acids. SECTION 8: Exposure controls/personal protection 8.1. Control parameters : Sources of ignition. Direct sunlight. 14/01/2013 EN (English US) 2/6

3 8.2. Exposure controls Personal protective equipment : Gas mask. Gloves. Safety glasses. Hand protection Eye protection Respiratory protection : Wear protective gloves. : Chemical goggles or safety glasses. : Wear approved mask. : When using, do not eat, drink or smoke. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Liquid Appearance : Liquid. Color : black. Odor : odorless. Odor threshold ph Relative evaporation rate (butyl acetate=1) Melting point Freezing point Boiling point Flash point Self ignition temperature Decomposition temperature Flammability (solid, gas) Vapor pressure Relative vapor density at 20 C Relative density Solubility : Soluble in water. Log Pow Log Kow Viscosity, kinematic Viscosity, dynamic Explosive properties Oxidizing properties Explosive limits 9.2. SECTION 10: Stability and reactivity Reactivity No data available Chemical stability Stable under recommended handling and storage conditions (see section 7) Possibility of hazardous reactions Not established Conditions to avoid Direct sunlight. Extremely high or low temperatures Incompatible materials strong acids. Strong bases Hazardous decomposition products fume. Carbon monoxide. Carbon dioxide. 14/01/2013 EN (English US) 3/6

4 SECTION 11: Toxicological information Information on toxicological effects Acute toxicity LD50 oral rat LD50 oral rat LD50 dermal rabbit Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Potential Adverse human health effects and symptoms > 5000 mg/kg (Rat) 1800 mg/kg (Rat) > 3000 mg/kg (Rabbit) : Causes serious eye damage. Based on available data, the classification criteria are not met Based on available data, the classification criteria are not met Based on available data, the classification criteria are not met Based on available data, the classification criteria are not met : Based on available data, the classification criteria are not met. SECTION 12: Ecological information Toxicity LC50 fish 1 EC50 Daphnia 1 LC50 fish 2 Threshold limit algae 1 Threshold limit algae 2 LC50 fish 1 EC50 Daphnia 1 EC50 other aquatic organisms 1 LC50 fish mg/l (96 h; Pimephales promelas; Static system) > mg/l (24 h; Daphnia magna) mg/l (96 h; Salmo gairdneri (Oncorhynchus mykiss); Static system) > mg/l (168 h; Scenedesmus quadricauda) 2000 mg/l (192 h; Microcystis aeruginosa) > 10 mg/l (96 h; Lepomis macrochirus; TOXICITY TEST) 26 mg/l (48 h; Daphnia magna) 10 mg/l (336 h; Lemna sp.; BIOMASS) 8.9 mg/l (96 h; Pimephales promelas) Persistence and degradability Adhesive Side Developer - Dark Persistence and degradability Persistence and degradability Biochemical oxygen demand (BOD) Chemical oxygen demand (COD) ThOD BOD (% of ThOD) Persistence and degradability ThOD Not established. Readily biodegradable in water. Biodegradable in the soil g O²/g substance 1.24 g O²/g substance 1.29 g O²/g substance 0.36 % ThOD Biodegradable in water g O²/g substance Bioaccumulative potential Adhesive Side Developer - Dark Bioaccumulative potential BCF fish 1 BCF other aquatic organisms 1 BCF other aquatic organisms 2 Not established. 10 (72 h; Leuciscus idus) (Procambarus sp.; CHRONIC) 190 (24 h; Algae) 14/01/2013 EN (English US) 4/6

5 Log Pow (Experimental value) Bioaccumulative potential Low potential for bioaccumulation (BCF < 500). Log Pow 4.86 (Estimated value) Mobility in soil Surface tension Other adverse effects N/m (20 C) : Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations : Dispose in a safe manner in accordance with local/national regulations. Ecology - waste materials : Avoid release to the environment. SECTION 14: Transport information In accordance with ADR / RID / ADNR / IMDG / ICAO / IATA UN number Not applicable UN proper shipping name Not applicable Additional information : No supplementary information available. Overland transport Transport by sea Air transport SECTION 15: Regulatory information US Federal regulations International regulations CANADA EU-Regulations Classification according to Regulation (EC) No. 1272/2008 [CLP] Classification according to Directive 67/548/EEC or 1999/45/EC Not classified National regulations US State regulations 14/01/2013 EN (English US) 5/6

6 SECTION 16: Indication of changes : Revision - See : *. Data sources Training advice : REGULATION (EC) No 1272/2008 OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL of 16 December 2008 on classification, labeling and packaging of substances and mixtures, amending and repealing Directives 67/548/EEC and 1999/45/EC, and amending Regulation (EC) No 1907/2006. : Normal use of this product shall imply use in accordance with the instructions on the packaging. Keep in tightly closed container. Keep cool and dry. Avoid all ignition sources - heat, open flame, sparks. Avoid incompatible materials. Avoid dust creation and accumulation. Avoid inhalation and ingestion. Avoid contact with eyes. Wash thoroughly after handling. : None. Full text of H-phrases: see section 16: Acute Tox. 4 (Oral) Acute toxicity (oral) Category Eye Dam. 1 Serious eye damage/eye irritation Category H302 Harmful if swallowed H318 Causes serious eye damage NFPA health hazard NFPA fire hazard NFPA reactivity : 1 - Exposure could cause irritation but only minor residual injury even if no treatment is given. : 1 - Must be preheated before ignition can occur. : 0 - Normally stable, even under fire exposure conditions, and are not reactive with water. HMIS III Rating Health Flammability Physical Personal Protection : 1 Slight Hazard - Irritation or minor reversible injury possible : 1 Slight Hazard : 0 Minimal Hazard : G SDS US (GHS HazCom 2012) The information above is believed to be accurate and represents the best information currently available to us. However, we make no warranty of merchantability or any other warranty, expressed or implied, with respect to such information, and we assume no liability resulting from its use. Users should make their own investigation to determine the suitability of the information for their particular purposes. 14/01/2013 EN (English US) 6/6