SAFETY DATA SHEET. Creation Date 14-Aug-2009 Revision Date 17-Jan-2018 Revision Number Identification

Transcription

1 SAFETY DATA SHEET Creation Date 14-Aug-2009 Revision Number 4 Product Name 1. Identification Calcium chloride dihydrate Cat No. : C69-50; C69-500; C69-500LC; C70-500; C79-3; C79-3LC; C CAS-No Synonyms (Crystals/Powder/Granules/USP/FCC/EP/Certified ACS) Recommended Use Uses advised against Laboratory chemicals. Not for food, drug, pesticide or biocidal product use Details of the supplier of the safety data sheet Company Fisher Scientific One Reagent Lane Fair Lawn, NJ Tel: (201) Emergency Telephone Number CHEMTRECÒ, Inside the USA: CHEMTRECÒ, Outside the USA: Hazard(s) identification Classification This chemical is considered hazardous by the 2012 OSHA Hazard Communication Standard (29 CFR ) Serious Eye Damage/Eye Irritation Category 2 Label Elements Signal Word Warning Hazard Statements Causes serious eye irritation Precautionary Statements Prevention Wash face, hands and any exposed skin thoroughly after handling Wear eye/face protection Page 1 / 6

2 Eyes IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing If eye irritation persists: Get medical advice/attention Hazards not otherwise classified (HNOC) None identified 3. Composition/Information on Ingredients Component CAS-No Weight % Calcium chloride, dihydrate >95 Calcium chloride First-aid measures Eye Contact Skin Contact Inhalation Ingestion Most important symptoms and effects Notes to Physician Suitable Extinguishing Media Unsuitable Extinguishing Media Flash Point Method - Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Get medical attention. Wash off immediately with plenty of water for at least 15 minutes. Obtain medical attention. Move to fresh air. Do not use mouth-to-mouth method if victim ingested or inhaled the substance; give artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device. Obtain medical attention. If not breathing, give artificial respiration. Do not induce vomiting. Obtain medical attention.. Treat symptomatically 5. Fire-fighting measures Substance is nonflammable; use agent most appropriate to extinguish surrounding fire. Autoignition Temperature Explosion Limits Upper Lower Sensitivity to Mechanical Impact Sensitivity to Static Discharge Specific Hazards Arising from the Chemical Non-combustible, substance itself does not burn but may decompose upon heating to produce corrosive and/or toxic fumes. Hazardous Combustion Products Hydrogen chloride gas Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. NFPA Health 2 Flammability 0 Instability 1 Physical hazards N/A Page 2 / 6

3 Personal Precautions Environmental Precautions 6. Accidental release measures Ensure adequate ventilation. Use personal protective equipment. Avoid dust formation. Should not be released into the environment. See Section 12 for additional ecological information. Methods for Containment and Clean Sweep up or vacuum up spillage and collect in suitable container for disposal. Avoid dust Up formation. Use spark-proof tools and explosion-proof equipment. Handling Storage Exposure Guidelines 7. Handling and storage Wear personal protective equipment. Ensure adequate ventilation. Do not get in eyes, on skin, or on clothing. Avoid ingestion and inhalation. Avoid dust formation. Wash hands before breaks and immediately after handling the product. Keep containers tightly closed in a dry, cool and well-ventilated place. 8. Exposure controls / personal protection Engineering Measures Ensure that eyewash stations and safety showers are close to the workstation location. Ensure adequate ventilation, especially in confined areas. Personal Protective Equipment Eye/face Protection Skin and body protection Respiratory Protection Hygiene Measures Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR or European Standard EN166. Wear appropriate protective gloves and clothing to prevent skin exposure. No protective equipment is needed under normal use conditions. Handle in accordance with good industrial hygiene and safety practice. 9. Physical and chemical properties Physical State Solid Appearance Beige - White Odor Odorless Odor Threshold ph g/l aq. sol Melting Point/Range 175 C / 347 F Boiling Point/Range Flash Point Evaporation Rate Flammability (solid,gas) Flammability or explosive limits Upper Lower Vapor Pressure Vapor Density Specific Gravity Solubility C Partition coefficient; n-octanol/water Autoignition Temperature Decomposition Temperature Page 3 / 6

4 Viscosity Molecular Formula Ca Cl2. 2 H2 O Molecular Weight Stability and reactivity Reactive Hazard Stability Conditions to Avoid Incompatible Materials None known, based on information available Hygroscopic. Incompatible products. Excess heat. Avoid dust formation. Exposure to moist air or water. Strong oxidizing agents Hazardous Decomposition Products Hydrogen chloride gas Hazardous Polymerization Hazardous Reactions Acute Toxicity Hazardous polymerization does not occur. None under normal processing. 11. Toxicological information Product Information Component Information Component LD50 Oral LD50 Dermal LC50 Inhalation Calcium chloride 2301 mg/kg ( Rat ) LD50 > 5000 mg/kg ( Rabbit ) Not listed Toxicologically Synergistic Products Delayed and immediate effects as well as chronic effects from short and long-term exposure Irritation Sensitization Carcinogenicity Irritating to eyes The table below indicates whether each agency has listed any ingredient as a carcinogen. Component CAS-No IARC NTP ACGIH OSHA Mexico Calcium chloride, Not listed Not listed Not listed Not listed Not listed dihydrate Calcium chloride Not listed Not listed Not listed Not listed Not listed Mutagenic Effects Reproductive Effects Developmental Effects Teratogenicity STOT - single exposure STOT - repeated exposure Aspiration hazard Symptoms / effects,both acute and delayed Endocrine Disruptor Information... None known None known Page 4 / 6

5 Other Adverse Effects Ecotoxicity Do not empty into drains. The toxicological properties have not been fully investigated. 12. Ecological information Component Freshwater Algae Freshwater Fish Microtox Water Flea Calcium chloride, dihydrate - Lepomis macrochirus: LC50: - EC50: 3005 mg/l/48h mg/l/96h Calcium chloride Not listed Lepomis macrochirus: LC50: mg/l/96h Not listed EC50: 52 mg/l/48h Persistence and Degradability Soluble in water Persistence is unlikely based on information available. Bioaccumulation/ Accumulation Mobility.. Will likely be mobile in the environment due to its water solubility. Component log Pow Calcium chloride, dihydrate 0.05 Waste Disposal Methods DOT TDG IATA IMDG/IMO 13. Disposal considerations Chemical waste generators must determine whether a discarded chemical is classified as a hazardous waste. Chemical waste generators must also consult local, regional, and national hazardous waste regulations to ensure complete and accurate classification. 14. Transport information 15. Regulatory information All of the components in the product are on the following Inventory lists: X = listed International Inventories Component TSCA DSL NDSL EINECS ELINCS NLP PICCS ENCS AICS IECSC KECL Calcium chloride, dihydrate X X X X - Calcium chloride X X X X X X X Legend: X - Listed E - Indicates a substance that is the subject of a Section 5(e) Consent order under TSCA. F - Indicates a substance that is the subject of a Section 5(f) Rule under TSCA. N - Indicates a polymeric substance containing no free-radical initiator in its inventory name but is considered to cover the designated polymer made with any free-radical initiator regardless of the amount used. P - Indicates a commenced PMN substance R - Indicates a substance that is the subject of a Section 6 risk management rule under TSCA. S - Indicates a substance that is identified in a proposed or final Significant New Use Rule T - Indicates a substance that is the subject of a Section 4 test rule under TSCA. XU - Indicates a substance exempt from reporting under the Inventory Update Rule, i.e. Partial Updating of the TSCA Inventory Data Base Production and Site Reports (40 CFR 710(B). Y1 - Indicates an exempt polymer that has a number-average molecular weight of 1,000 or greater. Y2 - Indicates an exempt polymer that is a polyester and is made only from reactants included in a specified list of low concern reactants that comprises one of the eligibility criteria for the exemption rule. U.S. Federal Regulations TSCA 12(b) Page 5 / 6

6 SARA 313 SARA 311/312 Hazard Categories CWA (Clean Water Act) Clean Air Act See section 2 for more information OSHA Occupational Safety and Health Administration CERCLA California Proposition 65 U.S. State Right-to-Know Regulations This product does not contain any Proposition 65 chemicals U.S. Department of Transportation Reportable Quantity (RQ): DOT Marine Pollutant DOT Severe Marine Pollutant N N N U.S. Department of Homeland Security This product does not contain any DHS chemicals. Other International Regulations Mexico - Grade Prepared By Creation Date Revision Date Print Date Revision Summary 16. Other information Regulatory Affairs Thermo Fisher Scientific EMSDS.RA@thermofisher.com 14-Aug Jan Jan-2018 This document has been updated to comply with the US OSHA HazCom 2012 Standard replacing the current legislation under 29 CFR to align with the Globally Harmonized System of Classification and Labeling of Chemicals (GHS). Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text End of SDS Page 6 / 6