Material Safety Data Sheet

Transcription

1 Material Safety Data Sheet 1. PRODUCT AND COMPANY IDENTIFICATION MICROPOSIT EC Solvent 11 Revision date: 01/01/2004 Supplier ROHM AND HAAS ELECTRONIC MATERIALS LLC A Subsidiary of The Dow Chemical Company 455 FOREST STREET MARLBOROUGH, MA United States For non-emergency information contact: For non-emergency information contact: Emergency telephone number Local emergency telephone number COMPOSITION/INFORMATION ON INGREDIENTS Component CAS-No. Concentration Ethyl lactate % 3. HAZARDS IDENTIFICATION Emergency Overview Appearance Form Colour Odour liquid clear sweet Hazard Summary WARNING! Combustible liquid and vapor. Causes irritation to eyes, nose, and respiratory tract. Prolonged, repeated contact, inhalation, ingestion, or absorption through the skin, may cause toxic effects to internal organ systems (liver, kidney, central nervous system). Page 1 of 6 Revision date 01/01/2004

2 Potential Health Effects Primary Routes of Entry: Inhalation, ingestion, eye and skin contact, absorption. Eyes: May cause pain, transient irritation and superficial corneal effects. Skin: Material may cause irritation. Prolonged or repeated exposure may have the following effects: central nervous system depression drowsiness defatting of skin leading to irritation and dermatitis Ingestion: Swallowing may have the following effects: irritation of mouth, throat and digestive tract Repeated doses may have the following effects: central nervous system depression drowsiness Inhalation: Inhalation may have the following effects: irritation of nose, throat and respiratory tract Higher concentrations may have the following effects: systemic effects similar to those resulting from ingestion Target Organs: Eye Respiratory System Skin nervous system Carcinogenicity Not considered carcinogenic by NTP, IARC, and OSHA 4. FIRST AID MEASURES Inhalation: Remove from exposure. If there is difficulty in breathing, give oxygen. Seek medical attention if symptoms persist. Skin contact: Wash skin with water. Continue washing for at least 15 minutes. Obtain medical attention if blistering occurs or redness persists. Eye contact: Immediately flush the eye with plenty of water for at least 15 minutes, holding the eye open. Obtain medical attention if soreness or redness persists. Ingestion: Wash out mouth with water. Have victim drink 1-3 glasses of water to dilute stomach contents. Induce vomiting if person is conscious. Immediate medical attention is required Never administer anything by mouth if a victim is losing conciousness, is unconcious or is convulsing. Notes to physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Flash point 48 C (119.8 F ) Lower explosion limit 1.6 %(V) Upper explosion limit no data available Suitable extinguishing media: Use water spray, foam, dry chemical or carbon dioxide. Keep containers and surroundings cool with water spray. Page 2 of 6 Revision date 01/01/2004

3 Specific hazards during fire fighting: This product may give rise to hazardous vapors in a fire. Vapors can travel a considerable distance to a source of ignition and result in flashback. Special protective equipment for fire-fighters: Wear full protective clothing and self-contained breathing apparatus. Further information: Pressure may build up in closed containers with possible liberation of combustible vapors. 6. ACCIDENTAL RELEASE MEASURES Personal precautions Wear suitable protective clothing. Wear respiratory protection. Eliminate all ignition sources. Environmental precautions Prevent the material from entering drains or water courses. Do not discharge directly to a water source. Advise Authorities if spillage has entered watercourse or sewer or has contaminated soil or vegetation. Methods for cleaning up Contain spills immediately with inert materials (e.g., sand, earth). Transfer into suitable containers for recovery or disposal. Finally flush area with plenty of water. 7. HANDLING AND STORAGE Handling Use local exhaust ventilation. Avoid contact with eyes, skin and clothing. Keep container tightly closed. Further information on storage conditions: Keep away from heat, sparks, flame, and other sources of ignition. Practice good personal hygiene to prevent accidental exposure. Storage Storage conditions: Store in original container. Keep away from heat and sources of ignition. Storage area should be: cool dry well ventilated out of direct sunlight 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Exposure limit(s) Exposure limits are listed below, if they exist. Component Regulation Type of listing Value Ethyl lactate Rohm and Haas TWA 5 ppm Rohm and Haas STEL 15 ppm Eye protection: goggles Hand protection: Butyl rubber gloves. Other chemical resistant gloves may be recommended by your safety professional. Skin and body protection: Normal work wear. Respiratory protection: Respiratory protection if there is a risk of exposure to high vapor concentrations. The specific respirator selected must be based on the airborne concentration found in the workplace and must not exceed the working limits of the respirator. Engineering measures: Engineering methods to prevent or control exposure are preferred. Methods include process or personnel enclosure, mechanical ventilation (local exhaust), and control of process conditions. Page 3 of 6 Revision date 01/01/2004

4 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Form Colour Odour ph Boiling point/range Flash point Lower explosion limit Upper explosion limit liquid clear sweet ca C (308.8 F) 48 C (119.8 F) 1.6 %(V) no data available Vapour pressure 1.7 mmhg at 20 C Relative vapour density Heavier than air. Water solubility completely soluble Relative density 1.04 Evaporation rate Slower than ether VOC s 1,042 g/l NOTE: The physical data presented above are typical values and should not be construed as a specification. 10. STABILITY AND REACTIVITY Hazardous reactions Stable under normal conditions. Conditions to avoid Materials to avoid Hazardous decomposition products polymerization High temperatures Static discharge Oxidizing agents bases acids Carbon monoxide, carbon dioxide, Will not occur. 11. TOXICOLOGICAL INFORMATION Toxicological information on this product or its components appear in this section when such data is available. Acute oral toxicity LD50 rat >2,000 mg/kg Acute inhalation toxicity LC50 rat >5,400 mg/m3 Acute dermal toxicity LD50 rat >5,000 mg/kg Page 4 of 6 Revision date 01/01/2004

5 Skin irritation Eye irritation A single application to rabbit skin produced mild irritation. Single application to the rabbit eye produced conjunctival irritation. Toxicity to reproduction Studies in laboratory animals have shown no teratogenic effects in the following species: 12. ECOLOGICAL INFORMATION Ecotoxicological information on this product or its components appear in this section when such data is available. Ethyl lactate Ecotoxicity effects Toxicity to aquatic invertebrates EC50 Daphnia magna 48 h 683 mg/l 13. DISPOSAL CONSIDERATIONS Environmental precautions: Prevent the material from entering drains or water courses. Do not discharge directly to a water source. Advise Authorities if spillage has entered watercourse or sewer or has contaminated soil or vegetation. Disposal Dispose in accordance with all local, state (provincial), and federal regulations. Incineration is the recommended method of disposal for containers. Under RCRA, it is the responsibility of the product s user to determine at the time of disposal, whether the product meets RCRA criteria for hazardous waste. This is because the product uses, transformations, mixtures, processes, etc. may render the resulting materials hazardous. Do not remove label until container is thoroughly cleaned. Empty containers may contain hazardous residues. This material and its container must be disposed of in a safe way. 14. TRANSPORT INFORMATION DOT Not regulated per 49CFR (f)(2) IMO/IMDG Proper shipping name ETHYL LACTATE UN-No UN 1192 Class 3 Packing group III 15. REGULATORY INFORMATION SARA TITLE III: Section 311/312 Categorizations (40CFR370): Immediate, delayed, flammability hazard SARA TITLE III: Section 313 Information (40CFR372) This product does not contain a chemical which is listed in Section 313 at or above de minimis concentrations. Page 5 of 6 Revision date 01/01/2004

6 U.S. Toxic Substances Control Act (TSCA) Section 12(b) Export Notification (40 CFR 707, Subpt D): U.S. Toxic Substances Control Act (TSCA) Section 12(b) Export Notification (40 CFR 707, Subpt D) This product does not contain any substances subject to Section 12(b) export notification. US. Toxic Substances Control Act (TSCA) All components of this product are in compliance with the inventory listing requirements of the U.S. Toxic Substances Control Act (TSCA) Chemical Substance Inventory. California (Proposition 65) This product does not contain materials which the State of California has found to cause cancer, birth defects or other reproductive harm. 16. OTHER INFORMATION Hazard Rating Health Fire Reactivity NFPA Legend ACGIH BAc OSHA PEL STEL TLV TWA American Conference of Governmental Industrial Hygienists Butyl acetate Occupational Safety and Health Administration Permissible Exposure Limit Short Term Exposure Limit (STEL): Threshold Limit Value Time Weighted Average (TWA): Bar denotes a revision from prior MSDS. The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. Version: 2.0 Print Date: 02/19/2014 Layout Page 6 of 6 Revision date 01/01/2004