SAFETY DATA SHEET. None. None. The mixture does not meet the criteria for classification.

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Other means of identification Product code Recommended use Recommended restrictions SW-1 OzzyJuice Degreasing Solution Solution for SmartWasher parts washing systems Manufacturer/Importer/Supplier/Distributor information Manufactured or sold by: Company name CRC Canada Co. Address Lorimar Dr. Mississauga, Ontario L5S 1R2 Canada Telephone Website Emergency phone number 24-Hour Emergency (Canada) (CHEMTREC) (International) 2. Hazard(s) identification Physical hazards Health hazards Environmental hazards Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Other hazards ne. ne. The mixture does not meet the criteria for classification. Use with adequate ventilation. Observe good industrial hygiene practices. Wash hands after handling. Store away from incompatible materials. Dispose of contents/container in accordance with local/regional/national regulations. 3. Composition/information on ingredients Mixtures Chemical name Common name and synonyms CAS number % water Surfactant blend tetrasodium ethylenediaminetetraacetate The exact percentage (concentration) of composition has been withheld as a trade secret. All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. 4. First-aid measures Inhalation Skin contact Eye contact Ingestion If breathing is difficult, remove to fresh air and keep at rest in a position comfortable for breathing. Call a physician if symptoms develop or persist. Rinse skin with water/shower. Get medical attention if irritation develops and persists. Rinse with plenty of water. Get medical attention if irritation develops and persists. Rinse mouth. If ingestion of a large amount does occur, call a poison control center immediately. 1 / 6

2 Most important symptoms/effects, acute and delayed Indication of immediate medical attention and special treatment needed General information 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment/instructions General fire hazards 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Treat symptomatically. Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2). Self-contained breathing apparatus and full protective clothing must be worn in case of fire. Cool containers with water spray. 8. Exposure controls/personal protection Occupational exposure limits Biological limit values Appropriate engineering controls unusual fire or explosion hazards noted. Keep unnecessary personnel away. Wear appropriate protective equipment and clothing during clean-up. Ensure adequate ventilation. For personal protection, see section 8 of the SDS. Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is possible. Absorb in vermiculite, dry sand or earth and place into containers. Following product recovery, flush area with water. Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to remove residual contamination. Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Avoid discharge into drains, water courses or onto the ground. Provide adequate ventilation. Wear appropriate personal protective equipment. Observe good industrial hygiene practices. For product usage instructions, see the product label. Store in a cool, dry place out of direct sunlight. Store away from incompatible materials (see Section 10 of the SDS). exposure limits noted for ingredient(s). biological exposure limits noted for the ingredient(s). special precautions are necessary beyond normal good hygiene practices. See Section 8 of the SDS for additional personal protection advice when handling this product. Individual protection measures, such as personal protective equipment Wear safety glasses with side shields (or goggles). Eye/face protection Skin protection Hand protection Other Respiratory protection Thermal hazards General hygiene considerations Wear protective gloves, if needed: Nitrile. Neoprene. Rubber. Wear suitable protective clothing. personal respiratory protective equipment normally required. Use a self-contained breathing apparatus in confined spaces and for emergencies. Air monitoring is needed to determine actual employee exposure levels. Wear appropriate thermal protective clothing, when necessary. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. 2 / 6

3 9. Physical and chemical properties Appearance Odor Physical state Form Color Odor threshold Liquid. Liquid. Clear. Mild. ph Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) 212 F (100 C) estimated ne Upper/lower flammability or explosive limits Flammability limit - lower (%) Flammability limit - upper (%) Vapor pressure Vapor density Relative density 1.02 Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity Other information Percent volatile 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products 11. Toxicological information 22 hpa estimated Soluble % estimated The product is stable and non-reactive under normal conditions of use, storage and transport. Material is stable under normal conditions. dangerous reaction known under conditions of normal use. Contact with incompatible materials. hazardous decomposition products are known. Information on likely routes of exposure Inhalation Under normal conditions of intended use, this material is not expected to be an inhalation hazard. Skin contact Eye contact Ingestion Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Prolonged skin contact may cause temporary irritation. Health injuries are not known or expected under normal use. 3 / 6

4 Acute toxicity Components Surfactant blend (CAS ) Acute Species Test Results Dermal LD50 Rabbit > 2000 mg/kg Oral LD50 Rat > 2000 mg/kg tetrasodium ethylenediaminetetraacetate (CAS ) Acute Oral LD50 Rat > 2000 mg/kg * Estimates for product may be based on additional component data not shown. Skin corrosion/irritation Serious eye damage/eye irritation Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard Further information 12. Ecological information Ecotoxicity Components Surfactant blend (CAS ) Aquatic Acute Crustacea Prolonged skin contact may cause temporary irritation. t a respiratory sensitizer. This product is not expected to cause skin sensitization. data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. This product is not expected to cause reproductive or developmental effects. t an aspiration hazard. This product has no known adverse effect on human health. The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. EC50 Species tetrasodium ethylenediaminetetraacetate (CAS ) Aquatic Fish Water flea (Daphnia magna) * Estimates for product may be based on additional component data not shown. Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects LC Disposal considerations Disposal of waste from residues / unused products Hazardous waste code Biodegradable. data available. data available. Bluegill (Lepomis macrochirus) Test Results 5.3 mg/l, 48 hours mg/l, 96 hours other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. Do not allow this material to drain into sewers/water supplies. Dispose in accordance with all applicable regulations. t regulated. 4 / 6

5 Contaminated packaging 14. Transport information TDG t regulated as dangerous goods. IATA t regulated as dangerous goods. IMDG t regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code 15. Regulatory information Canadian regulations Since emptied containers may retain product residue, follow label warnings even after container is emptied. Empty containers should be taken to an approved waste handling site for recycling or disposal. Controlled Drugs and Substances Act t regulated. Export Control List (CEPA 1999, Schedule 3) t listed. Greenhouse Gases t listed. Precursor Control Regulations t regulated. International regulations Stockholm Convention Rotterdam Convention Kyoto protocol Montreal Protocol Basel Convention International Inventories Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Canada China Europe Europe Japan Korea New Zealand Philippines Domestic Substances List (DSL) n-domestic Substances List (NDSL) Inventory of Existing Chemical Substances in China (IECSC) European Inventory of Existing Commercial Chemical Substances (EINECS) European List of tified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances (PICCS) United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory *A "" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information Issue date / 6

6 Version # 01 Further information Disclaimer Chemfree # SW-1 The information contained in this document applies to this specific material as supplied. It may not be valid for this material if it is used in combination with any other materials. This information is accurate to the best of CRC's knowledge or obtained from sources believed by CRC to be accurate. Before using any product, read all warnings and directions on the label. For further clarification of any information contained on this (M)SDS consult your supervisor, a health & safety professional, or CRC Canada Co.. 6 / 6