TransAT for Multiphase Flow in Pipes & Risers
|
|
- Cassandra Brooks
- 5 years ago
- Views:
Transcription
1 TransAT for Multiphase Flow in Pipes & Risers Djamel Lakehal (July, 2013) ASCOMP GmbH, Zurich
2 Outline Multiphase flow in pipelines Slug flow in horizontal pipes Slug flow in inclined pipes Slug flow with sand Slug/churn/annular flow in risers
3 Multiphase flow in pipes
4 Flow regime map Vertical pipe flow Horizontal pipe flow
5 Slug capturing and separation
6 Validation of base LS approach for interfacial (wavy) flows
7 The Thorpe experiment Experiment by Thorpe (J Fluid Mech., vol 39, 25-48, 1969) Interesting because purely hydrodynamic, simple geometry and Bc s Limited results to most amplified wave length, critical velocity difference
8 The refurbished experiment (UCL, Belgium: J-M. Seynhaeve, Y. Bartosiewicz) Calculated acceleration ramp to minimize initial perturbations High speed camera PIV (2D and stereoscopic) Fluids fully characterized in house (surface tensions, densities, viscosities)
9 Flow visualization
10 Comparison CLICK ON MOVIE
11 Comparison
12 The HAWAC setup (FZD Germany, C. Vallé)
13
14 Comparison Picture sequences at JL = 1.0 m/s and JG = 5.0 m/s with t = 50 ms (depicted part of the channel: 0 to 3.2 m after the inlet)
15
16 Slug formation in horizontal pipes
17 Slug formation: 1- ASHRAE case (Exp. Martin) Slug formation in an air-water flow. Important features : flow pattern: e.g. from stratified to slug (Kelvin-Helmholtz instabilities) Slug formation threshold Pressure drop and slug speed
18 Exp. of Martin (2005) -BFC grid & parallel blocks - L = 6.3m; D=0.14m - J L =0.5m/s & J G = 14m/s. - Void fraction 50% - V-LES & LES for turbulence
19 3D slug formation CLICK ON MOVIE
20 Time (Seconds) Slug speed Nicklin et al. (1962) Collins et al. (1978) Exp. Martin et al. (2005) U 1.2U Dg / s m l g l 0.8 Liquid Temperature : -45 C; Liquid Depth : 76.2 mm PACE1 PACE2 PACE3 PACE4 PACE5 Gas Liquid Slug Gas Liquid V Liquid PCB4 PCB1 PCB2 PCB U = dx/dt = 10.8 m/sec (dm/dt = kg/sec) U = dx/dt = 9.4 m/sec (dm/dt = kg/sec) U = dx/dt = 7.1 m/sec (dm/dt = kg/sec) Location x (Meters)
21 Slug formation: 2- Imperial College WASP case Air Water Physical Parm. Air water Density(kg/m³) Viscosity(Pa s) ( at 25 C) (at 25 C) Surface tension(n/m) (at 20 C)
22 Experimental vs. CMFD of water holdup Exp. (top) vs. CMFD water holdup results for U sl = 0.611m/s and U sg = 4.64m/s. inlet pressure= 1atm (Probe location from 0.76m to 3.56m)
23 CMFD 3D results: Slug forms & shapes (16m) Initial slugs: at x < 5m large slugs, or better, operating slugs Scale ~ 2-4 D Hold-up = 1
24 CMFD 3D results: Slug forms & shapes (16m) Next slugs: at x > 5m disturbance slugs Scale ~ 1 D Hold-up ~
25 CMFD 3D results: Slug signal (16m)
26 Sand Transport in pipes
27 Sand Transport & Corrosion Gas Water/Sand CLICK ON MOVIES
28 Slug formation in inclined pipes
29 Slug flow up an incline (for CHEVRON USA) Objective: Simulate slug flow up an incline for 3 different size pipes (2, 4 and 26 ), and estimate the reentrainment criteria for removing a settled solids bed.
30 Surface deformation
31 Level Sets method with V-LES CLICK ON MOVIES
32 Droplet Entrainment in stratified twophase pipe flows
33 LEIS of the flow in a periodic pipe Flow conditions: - Domain: 3D x 1D - Grid: 46x96x96 - Re_b = Air mass flowrate = 600 kg/hr - Water mass flowrate = kg/hr - Volume flow rate of water is 1/50 of that of air. Click on movie to play
34 The practical context Air-water flow Wetting mechanism Uair=20 m/s ; Uwater=0.02 m/s; Pipe diameter = m Courtesy: Badie & Hewitt Imperial College London
35 LEIS of a space evolving flow in a pipe Click on movie to play Flow conditions: - L = 5m; D = 0.5 m - Splitter plate at inlet: l = 16cm - Water and air - U G = 20 m/s; U L = 0.2 m/s. - Water cut: h/d = Ref = 7050 Computational parameters - IST Grid 1: cells - CPU: 39H on a Dell PC (16 cores) - BFC Grid 2: 1.6 million cells (580x 58x54) - High order schemes: 2nd order time; Quick scheme for convection
36 LEIS of droplet entrainment in a pipe
37 Hydrocarbon flow in vertical pipes & risers
38 Riser flow: The issues The main Issues: flow regime map, pressure drop & heat transients Reality: Subsea flow analysis
39 Two-phase flow in a pipe (Szalinski et al. 2010) Dispersed flow in a pipe, experiment of Szalinski et al., Chem. Eng. Sce, (2010) 2D axisymmetric steady & unsteady grid cells Mixture Algebraic Slip Model Tomiyama lift & drag coeff. correlations Turbulence: URANS (results shown)
40 Case 1 & 2: bubbly flow
41 Case 3: Slug-bubbly flow Click on movie to play
42 Slug-bubbly flow structures Evolution of slug flow at different instants.
43 Normalized SGS viscosity in the Taylor bubble wake
44 Pressure drop and frictional velocity Instantaneous pressure drop along the pipe (left panel), and mean pressure drop (right panel): single-phase vs. slug flow Instantaneous wall frictional velocities along the pipe
45 Annular Flow Regime (very thin film) Annular film flow experiment of Zhao and Hewitt (2012, Imperial College London).
46 Annular flow case Flow measurement conditions V G (L/min) Re G (10 4 ) Re L V L (L/min) Visualized ripple wavy and disturbance waves flow regimes
47 Thick-film annular flow (VLES + LS) Flow conditions: - D = m - L = 4 m - Water and air - V G = 2000 L/m (instead of 1650 L/min), Re G = 8.55 x V L = 70 L/m (instead of 1 L/min), Re L = 4.22 x Initial film: h/d = 0.04 Computational parameters & model - IST Grid : (still medium) - Comp. Time: 49H on 64 proc. (MPI parallel) local cluster - Level Set - V-LES for turbulence - Filter width =0.1D
48 Flow structures development CLICK ON MOVIE
49 Film thickness Film thickness varies with height and circumferentially, With a radial correlation for the most unstable modes Entrainment in the core flow
50 Film thickness (normalized by initial value) Film thickness could vary as much as 5 times the initial value
51 Coherent/disturbance waves Entrainment in the core flow Disturbance waves
52 Thin-film annular flow (LES/MILES + LS) Flow conditions: - D = m - L = 0.2 m (shorter length for periodicity) - Water and air - V G = 1950 L/m, Re G = 8.09 x V L = 0.5 L/m, Re L = Initial film thickness: h/d = 0.01, then h adjusts itself to the flow to an average of 1-3 x 10-4 Computational parameters & modelling - Periodic domain in flow direction to sustain turbulence - BFC Grid : 937,000 cells, with 12,500 covering cross section - Comp. Time: 763 CPU H on 15 proc. (MPI parallel) local cluster - Level Set - Under-resolved DNS of turbulence; (diffusion effects left to discretization MILES approach)
53 Thin Film: interfacial instabilities
54 Thin Film: transition to turbulence
55 Thin Film: transition to turbulence CLICK ON MOVIE
56 Two-phase flow in vertical pipe (FZD) Bubbly & churn flow experiment of Prasser et al. (2006). TOPFLOW D = 194mm - OpenMP 3D computation: 8h on a PC grid cells - Homogeneous Algebraic Slip Model - Tomiyama lift & drag coeff. correlations - Turbulence: - LES with Smagorinsky model, - V-LES (only results shown) - URANS
57 Churn flow case (TOPFLOW 118) churn flow case. TOPFLOW-128 Click on movie to play
58 Entrainment Modelling: Annular flow
59 Annular Flow (full domain) Jg = 20 m/s, Jl = 1.5 m/s, Domain Spans 1 full wavelength
60 Annular Flow (full domain) Ligament formation, droplet detachment, formation of large disturbance wave clearly visible in these simulations Flow for full domain still developing
61 Annular Flow (full domain) Cross Sectional View of Full Domain Simulation at (a) t = 5.8 ms, (b) t=33.1 ms, (c) t=78.9 ms, (d) t=133.4 ms
62 Thank you! For more information please contact us at ASCOMP GmbH, Technoparkstrasse 1, 8005 Zurich Switzerland Copyright ASCOMP
Flow assurance with ANSYS CFD
Flow assurance with ANSYS CFD Lubeena, R Muralikrishnan, R Mohan Srinivasa 2010 ANSYS, Inc. All rights reserved. 1 ANSYS, Inc. Proprietary Agenda Introduction Flow assurance with ANSYS Risk avoidance Hydrates
More informationAgenda. Background Validation studies. 3D application. Co-simulation. Summary. Espedal stratified flow. StatOil wavy-slug flow.
www.cd-adapco.com Computational Flow Assurance Recent progress in modelling of multiphase flows in long pipelines Simon Lo, Abderrahmane Fiala (presented by Demetris Clerides) Subsea Asia 2010 Agenda Background
More informationEffects of flow behavior on the design of transient operation scenarios
Effects of flow behavior on the design of transient operation scenarios *Jakyung Kim 1) and Yutaek Seo 2) 1), 2) Division of Ocean Systems Engineering, KAIST, Daejeon 305-600, Korea 1) kjkwkrud@kaist.ac.kr
More informationEVALUATE THE RISK OF HYDRATE BLOCKAGE INBEND FLOWLINES
EVALUATE THE RISK OF HYDRATE BLOCKAGE INBEND FLOWLINES H. Kh. Ben Mahmud Department of Petroleum Engineering, Curtin University, Sarawak, Malaysia E-Mail: hisham@curtin.edu.my ABSTRACT As oil and gas developments
More informationComputational Fluid Dynamics (CFD) Simulations of Dispersed Flow of Viscous Oil in Water in a Horizontal Pipe
Computational Fluid Dynamics (CFD) Simulations of Dispersed Flow of Viscous Oil in Water in a Horizontal Pipe *Robin Yap Miao Sin, Cary K Turangan Institute of High Performance Computing, 1 Fusionopolis
More informationFlow visualization at suction of a twin screw compressor
Flow visualization at suction of a twin screw compressor A. Kovacevic, M. Arjeneh, S. Rane, N. Stosic, M. Gavaises, City University London Abstract Rotary twin screw machines are commonly used for handling
More informationF l u i d F l o w a n d H e a t T r a n s f e r i n S t e a m G e n e r a t o r s
Report Series - Applications TransAT for Nuclear Science & Technology F l u i d F l o w a n d H e a t T r a n s f e r i n S t e a m G e n e r a t o r s ASCOMP GmbH Edited by: Dr D. Lakehal Release Date:
More informationMultiphase flows appear in various industrial processes
ADVANCED SIMULATION OF TRANSIENT MULTIPHASE FLOW &FLOW ASSURANCE IN THE OIL &GAS INDUSTRY Djamel Lakehal 1,2 * 1. ASCOMP GmbH Zurich, Zurich, Switzerland 2. ASCOMP Inc., Cambridge, Massachusetts We discuss
More informationAn overview of CFD applications in flow assurance From well head to the platform. Simon Lo
An overview of CFD applications in flow assurance From well head to the platform Simon Lo Contents From well head to the platform Heat transfer in Christmas tree Multiphase flow in long pipe Severe slugging
More informationErosion and Corrosion for Oil & Gas Equipment
OIL & GAS Erosion and Corrosion for Oil & Gas Equipment (Application of CFD) Mazdak Parsi 1 SAFER, SMARTER, GREENER Outline Erosion in Oil and Gas Equipment Erosion Equation Development Erosion in Choke
More informationFlow Patterns and Water Wetting in Gas-Oil-Water Three-phase Flow A Flow Loop Study ABSTRACT Keywords INTRODUCTION
Paper No. 6113 Flow Patterns and Water Wetting in Gas-Oil-Water Three-phase Flow A Flow Loop Study Kok Eng Kee*, Marijan Babic, Sonja Richter, Luciano Paolinelli, Wei Li, Srdjan Nesic Institute for Corrosion
More informationSpray Characteristics of Prefilming Type of Airblast Atomizer
ICLASS 1, 1 th Triennial International Conference on Liquid Atomization and Spray Systems, Heidelberg, Germany, September 6, 1 Spray Characteristics of Prefilming Type of Airblast Atomizer T. Inamura*,
More informationEffect of air flowrate on particle velocity profile in a circulating fluidized bed
Korean J. Chem. Eng., 24(5), 851-855 (2007) SHORT COMMUNICATION Effect of air flowrate on particle velocity profile in a circulating fluidized bed Sansanee Kumthanasup and Suchaya Nitivattananon Fuel Research
More informationReducing the Cost of Hydrate Management by Under-Dosing Thermodynamic Inhibitors
Reducing the Cost of Hydrate Management by Under-Dosing Thermodynamic Inhibitors Professor Eric F. May The University of Western Australia Australasian Oil & Gas Conference: New Trends in Flow Assurance
More informationx. ZHOU AND W. P. JEPSON
CORROSION IN THREE-PHASE OILjWATER/GAS SLUG FLOW IN HORIZONTAL PIPES. x. ZHOU AND W. P. JEPSON NSF, IfUCRC CORROSION IN KOLTIPHASE SYSTEMS CENTER DEPARTMENT OF CHEMICAL ENGINEERING OHIO UNIVERSITY ATHENS,
More informationPRESSURE MAINTENANCE IN OIL PRODUCTION PIPELINES: EQUIPMENT AND SIMULATION
PRESSURE MAINTENANCE IN OIL PRODUCTION PIPELINES: EQUIPMENT AND SIMULATION A Thesis By Dalamagka Dimitra Presented to The Faculty of the Department of Mineral Resources Engineering Technical University
More informationExperimental Investigations of Two-Phase Liquid-Liquid Horizontal Flows Through Orifice Plates
HEFAT2012 9 th International Conference on Heat Transfer, Fluid Mechanics and Thermodynamics 16 18 July 2012 Malta Experimental Investigations of Two-Phase Liquid-Liquid Horizontal Flows Through Orifice
More informationDr. J. Wolters. FZJ-ZAT-379 January Forschungszentrum Jülich GmbH, FZJ
Forschungszentrum Jülich GmbH, FZJ ZAT-Report FZJ-ZAT-379 January 2003 Benchmark Activity on Natural Convection Heat Transfer Enhancement in Mercury with Gas Injection authors Dr. J. Wolters abstract A
More informationSlugging in Pipelines: What You NEED to Know
Slugging in Pipelines: What You NEED to Know Mona Trick Advisor Flow Software Schlumberger mtrick@slb.com 1 Outline Why Worry? Hydrodynamic Slugs Terrain Induced Slugs Turn Up Slugs Pigging Slugs Slug
More informationCFD Simulation of Fisher-Tropsch Synthesis in Slurry Bubble Column
CFD Simulation of Fisher-Tropsch Synthesis in Slurry Bubble Column By Andrey Troshko Prepared by Peter Spicka Fluent Inc. 10 Cavendish Court Lebanon, NH,03766 www.fluent.com 1 Motivation & Objectives Internal
More informationStudy of Phase Wetting in Three-Phase Oil-Water-Gas Horizontal Pipe Flow - Recommendations for Corrosion Risk Assessment
Study of Phase Wetting in Three-Phase Oil-Water-Gas Horizontal Pipe Flow - Recommendations for Corrosion Risk Assessment L.D. Paolinelli Institute for Corrosion and Multiphase Technology Department of
More informationVI.3 Application of Computational Fluid Dynamics to Simulate the Behaviour of Fluids inside Vertical Stack of Building Drainage System
VI.3 Application of Computational Fluid Dynamics to Simulate the Behaviour of Fluids inside Vertical Stack of Building Drainage System Eric Wai Ming Lee ericlee@cityu.edu.hk Department of Building and
More information2009 PFC Meeting. Two-phase CFD Analysis of ITER FW Hypervapotrons
2009 PFC Meeting Two-phase CFD Analysis of ITER FW Hypervapotrons D.L. Youchison, M.A. Ulrickson, J.H. Bullock Sandia National Laboratories Boston, MA July 9, 2009 Sandia is a multiprogram laboratory operated
More informationFlow Induced Vibration A Review of Current Assessment Methods
Flow Induced Vibration A Review of Current Assessment Methods David Fielding, Matt Straw (Norton Straw Consultants) Alex Graham, Phil Shorter (CD-adapco) Introduction Presenting a joint study into flow-induced
More informationMitja Uršič, Matjaž Leskovar, Renaud Meignen, Stephane Picchi, Julie-Anne Zambaux. Fuel coolant interaction modelling in sodium cooled fast reactors
Mitja Uršič, Matjaž Leskovar, Renaud Meignen, Stephane Picchi, Julie-Anne Zambaux Fuel coolant interaction modelling in sodium cooled fast reactors Outline Introduction Premixing phase Explosion phase
More informationThe effect of surfactants on low water cut oil-water flows in large diameter pipelines
The effect of surfactants on low water cut oil-water flows in large diameter pipelines H SHI, J Y CAl, M GOPAL, and W P JEPSON NSF I/UCRC, Institutefor Corrosion and MultiphaseTechnology, Department of
More informationOPERATING PARAMETER EFFECTS ON THE SOLID CIRCULATION RATE IN A DUAL FLUIDIZED-BED GASIFICATION SYSTEM
Eleventh International Conference on Computational Fluid Dynamics in the Minerals and Process Industries MCEC, Melbourne, Australia 7-9 December 2015 CFD2015 OPERATING PARAMETER EFFECTS ON THE SOLID CIRCULATION
More informationCRANFIELD UNIVERSITY. Mohamed Essid El-Alej. Monitoring Sand Particle Concentration in Multiphase Flow Using Acoustic Emission Technology
CRANFIELD UNIVERSITY Mohamed Essid El-Alej Monitoring Sand Particle Concentration in Multiphase Flow Using Acoustic Emission Technology SCHOOL OF ENGINEERING PhD THESIS Academic Year: 2013-2014 Supervisor:
More informationStudy of the effect of water and gas injection on the total pressure gradient in upward-vertical viscous oil flow
Study of the effect of water and gas injection on the total pressure gradient in upward-vertical viscous oil flow Douglas Martins Rocha Advisor: Prof. Assoc. Oscar M. H. Rodriguez Context Feasibility $Production
More informationimedpub Journals Severe Slugging Control: Simulation of Real Case Study Abstract Introduction 2018 Vol.2 No.
Research Article imedpub Journals www.imedpub.com Journal of Environmental Research Severe Slugging Control: Simulation of Real Case Study Muhammad Ali Theyab * Ministry of Higher Education and Scientific
More informationOffshore Equipment. Yutaek Seo
Offshore Equipment Yutaek Seo Pipeline design procedures Subsea pipeline: Material selection Subsea pipelines burst Pipe material selection Pipe material type, i.e. rigid, flexible, or composite, should
More informationA Numerical Investigation on bubble formation in Coolant channel with various Ethylene Glycol and water compositions and change in contact angle
2016 IEEE 23rd International Conference on High Performance Computing Workshops A Numerical Investigation on bubble formation in Coolant channel with various Ethylene Glycol and water compositions and
More informationTwo-phase swirling flow in the barrel of a steam separator
MIKA Takeshi, MATSUBAYASHI Toshiki, HOSOKAWA Shigeo, and TOMIYAMA Akio Department of Mechanical Engineering, Faculty of Engineering, Kobe University, 1-1 Rokkodai, Nada, Kobe, 657-8501 Japan (tomiyama@mech.kobe-u.ac.jp)
More informationMonitoring Sand Transport Characteristics in Multiphase Flow in Horizontal Pipelines Using Acoustic Emission Technology
Monitoring Sand Transport Characteristics in Multiphase Flow in Horizontal Pipelines Using Acoustic Emission Technology M. El-Alej, D. Mba, T. Yan, and M. Elforgani Abstract This paper presents an experimental
More informationA Comparison between. commercial Pipeline Fluid-dynamic Codes. OLGA vs. LEDAFLOW
A Comparison between commercial Pipeline Fluid-dynamic Codes OLGA vs. LEDAFLOW Presentation Content Scope Analyzed Pipeline System and Basic Data Steady State Simulation Results and Summary Transient Simulation
More informationComparison of RANS, URANS and LES in the Prediction of Airflow and Pollutant Dispersion
Comparison of RANS, URANS and LES in the Prediction of Airflow and Pollutant Dispersion S. M. Salim, K. C. Ong, S. C. Cheah Abstract The performance of three different numerical techniques, i.e. RANS,
More informationOptimization of abrasive waterjet nozzle design for precision and reduced wear using compressible multiphase CFD modelling
Optimization of abrasive waterjet nozzle design for precision and reduced wear using compressible multiphase CFD modelling C. Narayanan, D. Caviezel, D. Lakehal ASCOMP AG Technoparkstrasse 1, 8005 Zurich,
More informationPrediction of Gas Hydrates Formation in Flow lines
ICCPGE 2016, 1, 25-30 Prediction of Gas Hydrates Formation in Flow lines M.G. Mounis 1, B. A. Hussien 1, F. E. Galoul 1, Dr. Hasan M. Asharif 1 and Mahmoud Said 2 1 Chemical Eng. Department, Faculty of
More information2008 International ANSYS Conference
2008 International ANSYS Conference Computational Modeling of Industrial Biofuel Reactors Jaydeep Kulkarni Presenter: Genong Li Technical Account Manager ANSYS, Inc. 2008 ANSYS, Inc. All rights reserved.
More informationAN INTRODUCTION TO FLUIDIZATION BY MILAN CARSKY UNIVERSITY OF KWAZULU-NATAL
AN INTRODUCTION TO FLUIDIZATION BY MILAN CARSKY UNIVERSITY OF KWAZULU-NATAL AN INTRODUCTION TO FLUIDIZATION SUMMARY Principle of fluidization (gas-solid fluidization, liquid-solid fluidization, properties
More informationIntegrity of Corrosion Inhibitor Films in Multiphase Flow
Paper No. 11238 2011 Integrity of Corrosion Inhibitor Films in Multiphase Flow Christian Canto, Bruce Brown, and Srdjan Nešić Institute for Corrosion and Multiphase Technology Department of Chemical &
More informationVisualization experiments on the influence of wall wettability on the liquid loading in
Visualization experiments on the influence of wall wettability on the liquid loading in wells V. Khosla, L.M. Portela, R.A.W.M. Henkes (Delft Univ. of Technology) G.J.N. Alberts, S.P.C. Belfroid (TNO)
More informationANSYS Combustion Analysis Solutions - Overview and Update
ANSYS Combustion Analysis Solutions - Overview and Update Gilles Eggenspieler ANSYS, Inc. 1 Agenda Overview of Combustion Analysis Solution Reduced Order Models Finite Rate Models Pollutant Models Examples
More informationCFD SIMULATION AND EXPERIMENTAL VALIDATION OF FLUID FLOW IN LIQUID DISTRIBUTORS
CFD SIMULATION AND EXPERIMENTAL VALIDATION OF FLUID FLOW IN LIQUID DISTRIBUTORS Marc Heggemann 1, Sebastian Hirschberg 1, Lothar Spiegel 2, Christian Bachmann 2 1 Sulzer Innotec, Sulzer Markets & Technology
More informationDetailed modelling of FBC fluid dynamics and combustion
Detailed modelling of FBC fluid dynamics and combustion Norberto Fueyo, Ana Cubero, Alberto Sánchez-Insa, Ramón Chordá Numerical Fluid dynamics Group University of Zaragoza gfn.unizar.es IEA - Fluidized
More informationSCHOOL OF COMPUTING, ENGINEERING AND MATHEMATICS SEMESTER 1 EXAMINATIONS 2015/2016 ME257. Fluid Dynamics
s SCHOOL OF COMPUTING, ENGINEERING AND MATHEMATICS SEMESTER 1 EXAMINATIONS 2015/2016 ME257 Fluid Dynamics Time allowed: TWO hours Answer: Answer TWO from THREE questions in section A and TWO from THREE
More informationA Fundamental Study of Refrigerant Line Transients
A Fundamental Study of Refrigerant Line Transients J. C. Shelton and A. M. Jacobi ACRCCR-4 March 1995 For additional information: Air Conditioning and Refrigeration Center University of Illinois Mechanical
More informationFlow Assurance in a subsea system perspective DAY 1 part 1
Flow Assurance in a subsea system perspective DAY 1 part 1 Tine Bauck Irmann-Jacobsen Week 39, 24th September 2013 10/3/2013 Footer Agenda Day 1-1.Oct 2013 B1036 (10 th floor) 13:15-16:00 Operability and
More informationCFD ANALYSIS OF CONVECTIVE FLOW IN A SOLAR DOMESTIC HOT WATER STORAGE TANK
International Journal of Scientific & Engineering Research Volume 4, Issue 1, January-2013 1 CFD ANALYSIS OF CONVECTIVE FLOW IN A SOLAR DOMESTIC HOT WATER STORAGE TANK Mr. Mainak Bhaumik M.E. (Thermal
More informationNumerical simulation of heavy oil flows in pipes using the core-annular flow technique
Computational Methods in Multiphase Flow V 93 Numerical simulation of heavy oil flows in pipes using the core-annular flow technique K. C. O. Crivelaro, Y. T. Damacena, T. H. F. Andrade, A. G. B. Lima
More informationNumerical Simulation of Foam Flow in Annulus With Wellbore Heat Transfer
Advances in Petroleum Exploration and Development Vol. 8, No. 1, 2014, pp. 43-48 DOI:10.3968/5383 ISSN 1925-542X [Print] ISSN 1925-5438 [Online] www.cscanada.net www.cscanada.org Numerical Simulation of
More informationPerformance Analysis for Natural Draught Cooling Tower & Chimney through Numerical Simulation
Performance Analysis for Natural Draught Cooling Tower & Chimney through Numerical Simulation Kanteyya A 1, Kiran Kumar Rokhade 2 Assistant Professor, Department of Mechanical Engineering, HKESSLN College
More informationSimulation of Fatigue relevant thermal Loads of Components in Piping Networks
Simulation of Fatigue relevant thermal Loads of Components in Piping Networks Dr. Jan Leilich Dr. Gerhard Schlicht NSSS Primary Circuit and Ageing Management Dresden, Oct. 15 th, 2014 Thermal Loads in
More informationExperimental Investigation of Hydrodynamic Slug Flow in Pipeline-Riser Systems
Experimental Investigation of Hydrodynamic Slug Flow in Pipeline-Riser Systems Adegboyega B Ehinmowo 1,2 *, Ajibola T Ogunbiyi 1,3, Oyinkepreye D Orodu 2, D S Aribike 4 and Adetokunbo O Denloye 4 1 Oil
More informationCCC Annual Report Transient Turbulent Multiphase Flow and Level Fluctuation Defects in Slab Casting
CCC Annual Report 00 UIUC, August, 00 Transient Turbulent Multiphase Flow and Level Fluctuation Defects in Slab Casting R. Liu *, J. Sengupta **, D. Crosbie **, and B. Thomas * *Department of Mechanical
More informationCCC Annual Report Quantitative Measurement of Molten Steel Surface Velocity with Nail Boards and SVC Sensor in CC Molds
CCC Annual Report 010 UIUC, August 1, 010 Quantitative Measurement of Molten Steel Surface Velocity with Nail Boards and SVC Sensor in CC Molds R. Liu *, J. Sengupta **, D. Crosbie **, S. Chung ***, M.
More informationOil Film Behavior Near The Onset Of Flow Reversal In Immiscible Gas/Liquid Vertical Annular Flow
Purdue University Purdue e-pubs International Refrigeration and Air Conditioning Conference School of Mechanical Engineering 2002 Oil Film Behavior Near The Onset Of Flow Reversal In Immiscible Gas/Liquid
More information3D Simulation of a fire inside a river tunnel and optimisation of the ventilation using Computational Fluid Dynamics
3D Simulation of a fire inside a river tunnel and optimisation of the ventilation using Computational Fluid Dynamics Authors: B. TRUCHOT, A. TRIPATHI Fluidyn-France Abstract CFD simulation is used to predict
More informationStudy on Severe Slugging in an S-Shaped Riser: Small-Scale Experiments Compared With Simulations
Study on Severe Slugging in an S-Shaped Riser: Small-Scale Experiments Compared With Simulations Sangmin Park, Hyundai Heavy Industries, and Ole Jørgen Nydal, Norwegian University of Science and Technology
More informationCFD investigation of coal gasification: Effect of particle size
CFD investigation of coal gasification: Effect of particle size Sonal Bhadauria #%, Sreepriya Vedantam *, Shriram Prasad $1, Anish P. Jacob $2 # PG scholar, Madhav Institute of Science and Technology,
More informationCFD Analysis of Oil Flooded Twin Screw Compressors
CFD Analysis of Oil Flooded Twin Screw Compressors Sham RANE, Ahmed KOVACEVIC, Nikola STOSIC City University London, Centre for Compressor Technology, London, EC1V 0HB, UK sham.rane@city.ac.uk July 11-14,
More informationStudy of water falling film over horizontal drop shaped and inverted drop shaped tubes
Study of water falling film over horizontal drop shaped and inverted drop shaped tubes Vipul Kumar Sharma, Nirmal Kant Singh 2 Dept. of Mechanical Engineering, GLBITM, Greater Noida, U.P, 236, India 2
More informationMultiphase Flow Dynamics 4
Multiphase Flow Dynamics 4 Nuclear Thermal Hydraulics von Nikolay I Kolev 1. Auflage Multiphase Flow Dynamics 4 Kolev schnell und portofrei erhältlich bei beck-shop.de DIE FACHBUCHHANDLUNG Thematische
More informationMEASURMENT OF THE FILM THICKNESS, FILM VELOCITY AND ENTRAINMENT FRACTION IN A LIQUID-AIR ANNULAR FLOW USING A CONDUCTANCE FLOWMETER
MEASURMENT OF THE FILM THICKNESS, FILM VELOCITY AND ENTRAINMENT FRACTION IN A LIUID-AIR ANNULAR FLOW USING A CONDUCTANCE FLOWMETER. Al-Yarubi 1 and Prof. G.Lucas 1 1 School of Department of School of Computing
More informationTesting System Optimization and Design for Slurry Pipeline Transportation
Research Journal of Applied Sciences, Engineering and Technology 5(5): 1646-1651, 2013 ISSN: 2040-7459; e-issn: 2040-7467 Maxwell Scientific Organization, 2013 Submitted: July 17, 2012 Accepted: August
More informationDetermination of Flow Patterns in Vertical Upward Two- Phase Flow Channel via Void Fraction Profile
Journal of Applied Fluid Mechanics, Vol. 2, No. 2, pp. 477-483, 209. Available online at www.jafmonline.net, ISSN 735-3572, EISSN 735-3645. DOI: 0.29252/jafm.2.02.2835 Determination of Flow Patterns in
More informationProject Background (long term goals)
ANNUAL REPORT 2012 UIUC, August 16, 2012 Modeling Heat Transfer in SEN during Preheating & Cool-down Yonghui Li (Ph.D. Student) Department of Mechanical Science and Engineering University of Illinois at
More informationA Comparative Analysis of Interfacial Friction Factor Correlations for Adiabatic Co-Current Gas Liquid Annular Two-Phase Flow in Large Diameter Pipes
Proceedings of the World Congress on Mechanical, Chemical, and Material Engineering (MCM 2015) Barcelona, Spain July 20-21, 2015 Paper No. 280 A Comparative Analysis of Interfacial Friction Factor Correlations
More informationARTICLE IN PRESS Chemical Engineering and Processing xxx (2010) xxx xxx
Chemical Engineering and Processing xxx (2010) xxx xxx Contents lists available at ScienceDirect Chemical Engineering and Processing: Process Intensification journal homepage: www.elsevier.com/locate/cep
More informationTheoretical and Experimental Analysis of Fluidisation Phenomena in a Rectangular Multiphase Bed
International Journal of Applied Engineering Research ISSN 097-456 Volume 1, Number 4 (017) pp. 554-560 Theoretical and Experimental Analysis of Fluidisation Phenomena in a Rectangular Multiphase Bed Massimiliana
More informationMultiphase flow modeling and simulation: HPC-enabled capabilities today and tomorrow
Multiphase flow modeling and simulation: HPC-enabled capabilities today and tomorrow Igor A. Bolotnov, Assistant Professor Department of Nuclear Engineering North Carolina State University Joint Faculty
More informationControl of Gas Bubbles and Slag Layer in a Ladle Furnace by Electromagnetic
Control of Gas Bubbles and Slag Layer in a Ladle Furnace by Electromagnetic Stirring The demands on flow control in the ladle vary from different functions and stages in a ladle refining cycle. With the
More informationFluidised bed for stripping sand casting process. Guido Belforte, Massimiliana Carello, Vladimir Viktorov
Fluidised bed for stripping sand casting process Guido Belforte, Massimiliana Carello, Vladimir Viktorov Dipartimento di Meccanica - Politecnico di Torino C.so Duca degli Abruzzi, 24 10129 Torino Italy
More informationHeat transfer enhancement in fire tube boiler using hellically ribbed tubes
Heat transfer enhancement in fire tube boiler using hellically ribbed tubes Miss Simantini Balasaheb Kute --------------------------------------------------------***-------------------------------------------------------------
More informationDETERMINATION OF DROP BREAKAGE MECHANISMS BY EXPERIMENTAL AND NUMERICAL INVESTIGATIONS OF SINGLE DROP BREAKAGES
14 th European Conference on Mixing Warszawa, 1-13 September 212 DETERMINATION OF DROP BREAKAGE MECHANISMS BY EXPERIMENTAL AND NUMERICAL INVESTIGATIONS OF SINGLE DROP BREAKAGES S. Nachtigall a, D. Zedel
More informationHigh-Resolution Simulations of Gas-Solids Jet Penetration Into a High- Density Riser Flow
Engineering Conferences International ECI Digital Archives 10th International Conference on Circulating Fluidized Beds and Fluidization Technology - CFB-10 Refereed Proceedings Spring 5-2-2011 High-Resolution
More informationTitle Using Neutron Radiography and Liqui. Author(s) Ito, Daisuke; Saito, Yasushi; Kawab. Citation Physics Procedia (2015), 69:
Title Hybrid Two-phase Flow Measurements Using Neutron Radiography and Liqui Author(s) Ito, Daisuke; Saito, Yasushi; Kawab Citation Physics Procedia (2015), 69: 570-57 Issue Date 2015 URL http://hdl.handle.net/2433/215123
More informationA CFD MODELLING STUDY OF MULTI-PHASE FLOW BEHAVIOUR OF BIOMASS AND BIOCHAR PARTICLES IN A BUBBLING FLUIDIZED BED
Ninth International Conference on CFD in the Minerals and Process Industries CSIRO, Melbourne, Australia 1-1 December 1 A CFD MODELLING STUDY OF MULTI-PHASE FLOW BEHAVIOUR OF BIOMASS AND BIOCHAR PARTICLES
More informationNumerical CFD Simulations for Understanding and Optimizing a Biomass Gasifier Reactor Set-Up
Numerical CFD Simulations for Understanding and Optimizing a Biomass Gasifier Reactor Set-Up E. George 1, J. Nguyen 1,Y. Kara, B 1. Marchand 1, A. Galnares 1 & 1 O. Guerrini 1 1. GDF SUEZ, R&D Division
More informationCFD SIMULATION OF BED VOIDAGE BEHAVIOUR OF A LIQUID-SOLID FLUIDIZED BED
Paper presented in the National Seminar on Recent Advances in Chemical Engineering, 30th - 31st January 2010 (RACE-2010), Department of Chemical Engineering, Gandhi Institute of Engineering and Technology,
More informationCFD in Ventilation, case studies from REHVA CFD guidebook
CFD in Ventilation, case studies from REHVA CFD guidebook by Peter V. Nielsen Aalborg University Peter V. Nielsen, Aalborg University pvn@civil.auc.dk 1 Outline of Lecture Study of ideas behind the air
More informationCharacterization of liquid-liquid flows in horizontal pipes
Characterization of liquid-liquid flows in horizontal pipes Jing Shi and Hoi Yeung Oil and Gas Engineering Centre, School of Energy, Environment and Agrifood, Cranfield University, Cranfield MK43 0AL,
More informationINVESTIGATION OF SUPERHEATED LIQUID CARBON DIOXIDE JETS FOR CUTTING APPLICATIONS
INVESTIGATION OF SUPERHEATED LIQUID CARBON DIOXIDE JETS FOR CUTTING APPLICATIONS L. Engelmeier, S. Pollak*, E. Weidner Chair of Particle Technology, Ruhr-University Bochum Universitätsstraße 150, 44801
More informationResearch Projects VI. RESEARCH APPROACH
RESEARCH APPROACH VI- VI. RESEARCH APPROACH Research at the Erosion/Corrosion Research Center (E/CRC) at The University of Tulsa is guided by member companies through planning sessions at the Advisory
More informationANSYS, Inc. March 31, Phase Change Models in FLUENT
1 2016 ANSYS, Inc. March 31, 2016 Phase Change Models in FLUENT Phase Change Models in ANSYS FLUENT In ANSYS Fluent the following are available for modeling phase change Boiling models RPI Non equilibrium
More informationNODALIZATION SCHEMES FOR LUMPED-PARAMETER CALCULATIONS OF REPRESENTATIVE NUCLEAR REACTOR SEVERE ACCIDENT TESTS IN THE MISTRA FACILITY
NODALIZATION SCHEMES FOR LUMPED-PARAMETER CALCULATIONS OF REPRESENTATIVE NUCLEAR REACTOR SEVERE ACCIDENT TESTS IN THE MISTRA FACILITY S. Benteboula & F. Dabbene CEA, DEN, DANS/DM2S/SFME/LATF - F-91191
More informationNumerical Simulation of the Aerodynamic Performance of a H-type Wind Turbine during Self-Starting
Numerical Simulation of the Aerodynamic Performance of a H-type Wind Turbine during Self-Starting Wei Zuo a, Shun Kang b Key Laboratory of Condition Monitoring and Control for Power Plant Equipment, Ministry
More informationPerformance of a Vertical Axis Wind Turbine under Accelerating and Decelerating Flows
Performance of a Vertical Axis Wind Turbine under Accelerating and Decelerating Flows Atif Shahzad, Taimoor Asim*, Rakesh Mishra, Achilleos Paris School of Computing & Engineering, University of Huddersfield,
More informationVisualization Study of Flow Stability in Reverse Roll Coating
ISIJ International, Vol. 55 (015), No. 4, pp. 863 869 Visualization Study of Flow Stability in Reverse Roll Coating Masato SASAKI, 1) * Masaru MIYAKE ) and Naoki NAKATA ) 1) JFE Steel Corporation, 1-1,
More informationHOLE CLEANING IN DIRECTIONAL WELLS
HOLE CLEANING IN DIRECTIONAL WELLS 1 ❶ Welcome to this presentation about Hole Cleaning in Directional Wells. It has been prepared by Sedco Forex, to give you a better understanding of the cuttings-transport
More informationGEYSERING IN RAPIDLY FILLING STORMWATER TUNNELS
GEYSERING IN RAPIDLY FILLING STORMWATER TUNNELS Steven J. Wright, P.E., M.ASCE 1, James W. Lewis, S.M.ASCE 2, and Jose G. Vasconcelos 3 ABSTRACT Events that are referred to as geysers have been observed
More informationDesign and Simulation of a Hybrid Entrained-Flow and Fluidized Bed Mild Gasifier Part 2 Case Study and Analysis
Proceedings of the ASME 2011 International Mechanical Engineering Congress & Exposition IMECE2011 November 11-17, 2011, Denver, Colorado, USA IMECE2011-64485 Design and Simulation of a Hybrid Entrained-Flow
More informationModeling Fast Biomass Pyrolysis in a Gas/Solid Vortex Reactor
Modeling Fast Biomass Pyrolysis in a Gas/Solid Vortex Reactor Robert W. Ashcraft, Jelena Kovacevic, Geraldine J. Heynderickx, Guy B. Marin Laboratory for Chemical Technology, Ghent University http://www.lct.ugent.be
More informationRecent Issues in Reactor Thermalhydraulics and Safety
Recent Issues in Reactor Thermalhydraulics and Safety Sanjoy Banerjee Distinguished Professor and Director, The Energy Institute The City College of New York, New York banerjee@che.ccny.cuny.edu June 2012,
More informationEstimation of the Air-Demand, Flame Height, and Radiation Load from Low-Profile Flare using ISIS-3D
Estimation of the Air-Demand, Flame Height, and Radiation Load from Low-Profile Flare using ISIS-3D J.D. Smith, Ph.D. and A. Suo-Ahttila, Ph.D., Alion Science and Technology, Owasso, Oklahoma, USA and
More informationCFD Modelling and Analysis of Different Plate Heat Exchangers
CFD Modelling and Analysis of Different Plate Heat Exchangers Ahmed Y Taha Al-Zubaydi a *, Guang Hong b and W. John Dartnall c Faculty of Engineering and Information Technology, UTS, Sydney, Australia
More informationH POLLUTANT DISPERSION OVER TWO-DIMENSIONAL IDEALIZED STREET CANYONS: A LARGE-EDDY SIMULATION APPROACH. Colman C.C. Wong and Chun-Ho Liu*
H14-117 POLLUTANT DISPERSION OVER TWO-DIMENSIONAL IDEALIZED STREET CANYONS: A LARGE-EDDY SIMULATION APPROACH Colman C.C. Wong and Chun-Ho Liu* Department of Mechanical Engineering, The University of Hong
More informationHydraulic performance of a low specific speed centrifugal pump with Spanwise-Slotted Blades
IOP Conference Series: Materials Science and Engineering OPEN ACCESS Hydraulic performance of a low specific speed centrifugal pump with Spanwise-Slotted Blades To cite this article: D X Ye et al 2013
More information*Corresponding author
2016 International Conference on Applied Mechanics, Mechanical and Materials Engineering (AMMME 2016) ISBN: 978-1-60595-409-7 Vibration Analysis of High Pressure Cylinder Steam Inlet Pipes During Turbine
More informationGas hydrate crystallisation: from laboratory to pilot plant tests. A. Sinquin Institut Français du Pétrole
Gas hydrate crystallisation: from laboratory to pilot plant tests A. Sinquin Institut Français du Pétrole HYDRATES Water salted or not Production lines + Hydrocarbon phase(s) 2 High pressure and /or low
More information