SUMMARY OF ASBESTOS LOCATIONS HAMILTON HEALTH SCIENCES, MCMASTER SITE

Transcription

1 Page 1 of 19 SUMMARY OF ASBESTOS LOCATIONS HAMILTON HEALTH SCIENCES, MCMASTER SITE Material For Full Asbestos Management Program Document See Engineering Supervisor or Project Manager Revised 09 March 2012 IF AREA OR MATERIALS ARE NOT IN THIS INVENTORY WE ASSUME IT HAS ASBESTOS MATERIAL UNLESS TESTING PROVES OTHERWISE MM Level Locations Approx. Quantity Sample Number(s) Tar insulation Chilled water, domestic water lines 004a Parging cement Drywall joint compound Pipe fittings Chilled water storage tanks (purple) 200 sf 002a & 005a 008a Quadrant dividing walls, storage rooms, corridors and miscellaneous 100% various Result (if ACM) Material ACM fireproofing Shafts Locations shafts 36, 43, 45, 48, 56, 63 and 68 (and above 4M in all other shafts) -Interface with interstitial spaces: where some beams exit the interstitial spaces (testing of suspect material is required) Removals in Clean shafts (33, 34, 35, 37, 38, 44, 46, 47, 53, 54, 55, 57, 58, 64, 67, 73, 74, 75, 76, 77 & 78) have some residual ACM Approx. Quantity Sample Number(s) Parging cement the majority of pipe fittings Drywall joint compound Walls Result (if ACM)

2 Page 2 of 19 Material Glass shafts Locations Approx. Quantity Sample Number(s) Parging cement Roof drains and misc fittings Sprayed Fireproofing Non-asbestos Cementitious (hard coat) Non-asbestos Except: -Structural steel in shaft 26 on level 1 and 1M levels -Structural steel in -shafts 65 and 89 at 5M & 6 levels -Interface with interstitial spaces: where some beams exit the interstitial spaces (analysis of suspect material is required) -Structural steel in shaft 66 on level 5 and 5M -Structural steel in 44, 47, 74 & 77 had removals of spray-on above level 6 & are bare steel; levels 5, 5M & 6 of these glass towers contain ACM 021 a-c Result (if ACM)

3 Material Exterior Stairwells Locations Approx. Quantity Sample Number(s) Parging cement Roof drains and misc fittings Sprayed Fireproofiing Non-asbestos Cementitious (hard coat), Page 3 of 19 Result (if ACM) Non-asbestos Except: -Interface with interstitial spaces: where some beams exit the interstitial spaces (testing of suspect material is required) 021 a-c Drywall joint compound Walls Parking Garages Material Locations Approx. Quantity Sample Number(s) Result (if ACM) Texture finish Blue area corridor to morgue Yellow area-south/east corner 1,000 sf 1,500 sf 056a 012a Parging cement -Hearse loading area -mechanical rooms 20 fittings

4 Material Interstitial Spaces 1M to 4M Locations Approx. Quantity Sample Number(s) Parging cement The majority of pipe fittings Sprayed fireproofing All areas, encased Page 4 of 19 Result (if ACM) Except: The underside of the beams where the beam abuts the double drywall See Appendix W MUMC AMP For details Material Level 5M Locations Approx. Quantity Sample Number(s) Parging cement all pipe fittings Sprayed fireproofing All areas-not encased, debris on all surfaces Access restricted to Type 2 PPE Result (if ACM)

5 Material Level 6 Locations Approx. Quantity Sample Number(s) Parging cement all pipe fittings Sprayed fireproofing All areas-not encased, except approx. 5-6% Page 5 of 19 Material Level 1 to 4 Locations Approx. Quantity Floor tiles Refer to Appendix IV - Attached Vinyl sheet flooring Refer to Appendix V - Attached Carpet Assume all Carpet adhesive contains Asbestos Sample Number(s) Acoustic ceiling tiles Throughout entire building Except: Fumehoods, lab cabinets fumehood exhausts Any doubt as to the makeup of the hood lining it is to be considered as Asbestos until testing proves otherwise Level 1-Cafeteria, 1M Shipping/Receiving Offices (IT), Garbage Dock (IT), Stores (IT/IE), & Pharmacy (IE) Level 2 Main Entrance Red Elevators to Yellow Elevators straight through Main Lobby - 1P8 FH#1 & #2-2N49 FH#1, #2 & #3-2N13 FH # HLMP1941-3N38 FH#1, #2 & #5-4H3 FH #74-6F - 4N71 FH#2-4N75 FH#2 & #3-4N76 FH#1-4N68 FH#1-4H8 FH#1-4H9 FH#1 Transite Result (if ACM)

6 Page 6 of 19 Material Locations Result (if ACM) Under sink chase pipes, conduit, etc Any service pipe or conduit through the floor not listed or labeled as Asbestos free is to be considered as Asbestos until testing proves otherwise Window boxes systems are to be considered as Asbestos containing until Testing proves otherwise 2V8-2, 2V8-3 2N49-1, 2N49-3, 2N49-5, 2N49-6 2N22-1, 2N22-2, 2N22-4, 2N22-6 Under workbench #5 2N22 2N13-1, 2N13-3, 2N13-4, 2N13-5, 2N13-6, 2N13-7 2N28-5, 2N38-8 3H45-1,3H45-2, 3H45-3, 3H45-5 All outer / exterior wall offices and patient rooms that contain a window box system

7 Page 7 of 19 APPENDIX IV - Vinyl floor tiles Twenty-one visually distinct types of vinyl floor tiles were sampled throughout the building, as follows: Tile Size (inches) Colour/Pattern Locations Sample Numbers Asbestos 12 x 12 Green with white fleck Purple Rooms Purple L1 Corridor, Blue Rooms 2N39, 2N45, 2N47, 2N52-56, 2T1E-1G, 2TC4, Room 3U10, Red Rooms L1 corridors, 3D1, 3D5, 4B1A-21, Yellow Rooms 1S1A, 2Q32-36, 2Q38-41, 2R29, 2RC1 013a 12 x 12 Red with white fleck Purple Rooms 1H1, 1H3, 1H4, 1H5, Blue Rooms, 4N53, 4N55, 4N63-67, 4N68, 4N70, 4N71-71B, Yellow Rooms 4Z1A, 4Z2-23, 4Y a 12 x 12 White with brown fleck Purple Rooms Room 1A1, 1A1B, 1A6, 1J12 Blue Rooms 1R9-10, 2S13-41A, 3U11B, 3U14, 3U16-18C, 3U24-27, 3V25-36, 3V38-42 and Corridor at Room 3V40, Rooms 4U17-20, 4N29-42, 3N43-44B, 4N46, 4N48-52, 4N55, Corridor adjacent to Room 4N44, Red Rooms shaft 43 first floor, 1F13-15, 2G4B, 2G23-25, 2G34-40, 3F7-32, 3FW1-W2, Yellow Rooms 2L5, 2S43-46A, 2SW25, 2SW4, 2S71-72, 2S7-7A, 2S9, 2S70, 2s48-53, 2R26-26A, 2R25A, 3V6-23, 3V44-51, 3E25-27F, 3X30D, Corridors 3VC1 and adjacent to Room 3V51, 4NC14, 4VC1, 4V22E, 4V21, 4V a 12 x 12 Black Purple Room 1A1B 019a 12 x 12 Beige with brown line Red Rooms MM Red-server/phone room, 1D37, 1DC5 Purple Rooms 1A2, 1J6-10, 1P2, 1P3, 1P5, 1P10-13, 1P23B, 1P24, 1P25, 1N1-8 Blue Rooms 1U20-29, 1V2 & 10, 1P16-19, 1P26-27, 1PW2-3,1P6-8, 3N1A, 3N45, 3N49A, 3N29-42, Corridor 3NC1, Corridor adjacent to 3N52 and 3N26, Rooms 3UW1, 3U a 12 x 12 Grey with white Purple Rooms 1J2, 1J5-9, Purple Corridor 2AC1 Yellow 022a

8 Page 8 of 19 Tile Size (inches) Colour/Pattern Locations Sample Numbers Asbestos line Rooms corridor ITC1, 1RC3 (and blue) Blue Rooms 1R17 12 x 12 Light gray Red Rooms Eng. Room 1D19, 1CC2 Yellow Rooms 1T1-6 (and sub rooms) 023a 12 x 12 Red with black fleck Yellow Rooms 3Y1-21 and adjacent Corridors, Blue Rooms 1R1-5, 1RC3, 4NC3, Purple Rooms 2J24, 2J14, and Corridor adjacent to 2J14, Corridors 4NC3, 4HC6-9, Rooms 4H6-7, 4H9-10A, 4H29-29A, 4H39-41C 025a 12 x 12 Yellow Blue Room 1V4-9 & a 12 x 12 Dark gray with black fleck Blue Rooms Nuclear Medicine Room 1PC1, 1P1B, 2P3-7B, 2P7C, 2N49A, 2N38, 2T13-16, 2T11, 2T10, 2U2-7, 2JW3 and Corridor 2UC1 027a 12 x 12 Dark brown with brown fleck Room 2EW4 and all Stairwells, Blue Rooms 3U5-9, 3N14-20, Blue Corridor 4NC6, Red Rooms 3B33A, 4D4, Yellow Rooms 3X26, 3U a 12 x 12 Brown with white fleck Hallway adjacent to Red Room 2E16 030a 12 x 12 Gray/green with brown fleck Room 2J33, Blue Rooms, 4U7-16, Purple Rooms 2J26-33, 2J16-25 and adjacent Corridor, Purple Rooms 3H6, 3H8C-G, 3H21, 3H24, Corridor 3HC2 and Corridor adjacent to 3H7, 4H13-21, 4H24-25B, 4H31-37, 4H1-5, 4HW1-2, 4H42-45, Red Corridor 3FC8, Red Rooms 4C1-22, 4GB1,4F11-21B, 4B26, 4C1-4C22, Yellow Rooms 2Pw3, 3W10C-10F, 3WC3, 3W11-15, 4U1-64V23-32, Corridors 4VC4, 4VC5 033a 12 x 12 Beige with white/brown line Corridor at Room 2CC3, Blue Rooms 2N32, 2N22A, 2N22B, 2N22C, 2N22, 22D, 22E, 22F, 2NW1,2NW2, 36A, 2N36, 2N13A, 2N14, 2N19, 2V11-16, 2VW1-2, 2NW5 2V3-8, 2V1 A-B, 2N4A, 2N49, 2N38, 2T8-9, Corridors 2NC3, 2NC6, 034a

9 Page 9 of 19 Tile Size (inches) Colour/Pattern Locations Sample Numbers Asbestos Rooms 3N5, 3N5D-J, 3U29-30, 3N49, 3N49B-D, 3N3, 3N2, 3N11, 3N11B, 3N25A-G, 3N26A-J, 3N27A-H, 3N28A-H, 3N52A-G, 4N3-6, 4N8-25, Corridor 4NC12A, Purple Rooms 2C12-13 and Corridor 2CC3, Purple Rooms 3H31, 3H35-35A, 3H39, 3H42-43A, 3H44-45, 3H51-57, 3H58-58B, Corridor adjacent to 4G40, Red Rooms 3V43A-43E, 3E9B, 4E9, 4E11-14, 4E18-19, 4G36D, Yellow Rooms 3E21A, 3E17A, 4G42-44, Corridor 4GC5, Rooms 4E6-4E11 12 x 12 Yellow with white fleck Blue Room 2N33, 2N31, 2N30, 2N29, 2N27, 22N26, 2N24, 2N23, 4N77-83, Corridors 4Nc7, 4NC9, Corridors adjacent to Rooms 4N19, 4N37A and 4N36, Purple Corridors 3HC9, 3HC7, 3HC5, 3HC11, Yellow Rooms 2Q1-5, 2QJ2, 2Q7-13, 2QW7, 2Q24-28B, 3Z1-21A 036a 12 x 12 Orange Yellow Room 2Q30, Corridor at Blue Room 3U31, 041a 12 x 12 Pink Yellow Room 2S71A 043a 12 x 12 White Corridor adjacent to Blue Room 4N22 054a 12 x 12 Red Corridor adjacent to Blue Room 4N22 055a 12 x 12 Gray Centre Stair to Purple 010a-c None 12 x 12 Beige with brown fleck Corridor adjacent to Room 2G52, Blue Room 4N73, 4N75-75A, 4N84A-86, Purple Rooms 2BW3, 2BW4, 2B16-19, Corridor adjacent to Red Room 2G52, Red Room 3D1, 4D8, Yellow Rooms 4Y25-31, 4Z24-31, 4Z32B 031a-c None Vinyl floor tiles are non-friable and in good condition. ACM vinyl floor tiles may also be present in rooms not accessed during the original assessment. Remaining vinyl floor tiles within the building were not sampled due to the age of installation

10 Page 10 of 19 APPENDIX V - Vinyl Sheet Flooring Seven visually distinct types of vinyl sheet flooring are present in the building, as follows: Pattern and Colour Beige square pattern Locations Sample Numbers Asbestos Purple Rooms 1H2, Room 1A18, Red Rooms 2GW11-12, 016a White/ grey/ green square Room 2T7, Blue Rooms 2TW4, 2TC2, 2T1-2T7B, Red Room 4C31A, Yellow Rooms 2P1-2A, 2Q30ACorridor 2PC1, 037a Brown with white square Room 2SC9, Blue Room 3U10, 4N7, 4N28-28A, 4N74-76, Red Rooms 4G1-5, Yellow Rooms 2P2B-2E, 2P10-11, Corridor 2PC1, 2SC9, Rooms 2S4A, 2S5E, 2S8, 2S54-55A and adjacent Corridor, Rooms 2S68-69, 3X1-11E, 3X a Dark green square Yellow Emergency Area adjacent to Room 2R26B, Yellow Rooms 2R4A-4E 042a Dark green/white square Medical Corridors adjacent to Yellow Room 3X16, Rooms 3X18, 3X23-24, 3X31, 3X11A, 3X12 044a Red with green square Multi subdued colour pebble pattern Red Room 4B30-31, Yellow Rooms 4Z32, 4Z33, 047a Red Room 1D6, 1D5 sheet vinyl currently covered with carpet Gray square Surgical Yellow Room 4Z1, Corridor 4XC1 048a-c None Asbestos present in vinyl sheet flooring is present in the paper backing (underpad) only. Vinyl sheet flooring is a non-friable material and is in good condition. All remaining types of vinyl sheet flooring throughout the building are non-asbestos due to the nature of the material (rubber and no underpad).

11 Page 11 of 19 Appendix MUMC Asbestos Abated Area Survey Level 1-1K10D, 1K10E & Cafeteria flooring replacement Asbestos free materials. Interior partition walls ACM free. Ceiling tiles, flooring and interior partitions walls ACM free. All exterior perimeter walls to department contain ACM - 1D1 Engineering carpet replaced with Asbestos free floor tiles. (1D1 1D13) - 1R17/18, acoustic ceiling tiles, drywall, drywall compound and flooring replacement Asbestos free materials Flooring and ceiling tiles only, 1R6, 1R6A, 1R6B, 1R6C, 1R1, 1R2, 1R3, 1R4, 1R5, 1R7, 1R8, 1R.C1. All exterior perimeter walls to department contain ACM. - Ewart Angus Center level 1 and level 2 flooring replacement with asbestos free materials - Williams Coffee Shop 1A2/2B1A, acoustic ceiling tiles, drywall, and drywall compound and flooring replacement Asbestos free materials. - 1C area PAC ceiling tiles, flooring and new interior drywall all replaced. All exterior perimeter walls to department contain ACM - 1C7 - asbestos free flooring, and ceiling tiles - 1F renovation Flooring is new - 1D1 Volunteer Resources reception area and Volunteer lounge 1D4 carpet replaced with Asbestos free floor tiles. - 1P42, 1P46 and 1P43 flooring replacement Level 2 - Main ring corridor Level 2-2Q Clinic partial floor replacement (2Q1A and internal Clinic corridors only) - 2H sheet flooring and ceiling tile asbestos free and interior walls. All exterior perimeter walls to department contain ACM - School of Nursing main interior corridors sheet flooring and tile asbestos free - 2L9, 2L9A, 2L9B drywall removed. All exterior perimeter walls to department contain ACM - 2L2D, 2L2E, 2L2, 2L2B, 2L2A flooring replaced. - 2L8B, 2L8A flooring replacement. Interior walls ACM removed. All exterior perimeter walls to department contain ACM - 2S Registration to 2S10 staff station sheet flooring, ceiling tile and drywall asbestos free. All exterior perimeter walls to department contain ACM (this phase) - 2S52 Endo Procedure Room new drywall ceiling and flooring installed. Interior walls new All exterior perimeter walls to department contain ACM - 2S69 new interior walls and flooring new All exterior perimeter walls to department contain ACM - 2Q53, 2QW3, 2Q52 and 2SC12 new flooring - 2R6 new flooring and ceiling - 2R11 new flooring and ceiling. Interior walls new. All exterior perimeter walls to department contain ACM

12 Page 12 of 19-2RS1 new flooring. - Open concept Stairwells red and yellow quadrants level 2 to 3 asbestos free tiles. - 2F Phases 1 and 2 Ceilings, and flooring are new. All interior partitions new. All exterior perimeter walls to department contain ACM. including 2G3 and 2G54A hallways. - 2G Clinical areas, acoustic ceiling tiles, drywall, drywall compound and flooring replacement Asbestos free materials. All exterior perimeter walls to department contain ACM - 2E24 Administration floor tiles replaced with wood veneer - 2J24 acoustic ceiling tiles, drywall, drywall compound and flooring replacement Asbestos free materials. All exterior perimeter walls to department contain ACM - 2JC1 flooring only. Entire 2C suite, new flooring and ceiling tiles, Also 2D suite, new floor and ceiling tiles, 2CW1 and 2CW2. - Chapel/worship centre Flooring and ceilings are new - Ceiling tiles Level 2 Red elevators to Yellow elevators straight through main lobby. - 2C20, 2C19, 2C18, 2C17, 2C8A, 2C9A, 2C7 new flooring and ceiling tiles. - 2S57 to 2S72 new flooring and ceiling tiles and internal/interior walls. - 2S1, 2S1A, 2S1B, 2S1C, 2S1D, 2R18, 2S48, 2S49, 2S50, 2S51, 2S51A, 2S51B 2S52, 2S53A and 2S53B all ceiling tile, partitions and flooring removed and replaced. Level 3 - Main Ring Corridor Level 3 & Farncomb rear corridor (3H51 area) asbestos free sheet flooring - 3V3 Clinic flooring tile and ceiling tile asbestos free. All exterior perimeter walls to department contain ACM - 3H sheet flooring and ceiling tile asbestos free. - 3F Clinic sheet flooring asbestos free. (3F23B, 3F23A, 3F23C, 3FC5, 3FC4, 3F29A, 3F30) - 3F Clinic ceiling tiles asbestos free. - 3B sheet flooring and ceiling tile asbestos free. All interior partitions walls asbestos free. - All exterior perimeter walls to department contain ACM - 3D sheet flooring and ceiling tile asbestos free. All interior partitions walls asbestos free excluding 3D21, 3D14, 3D15, 3D17, 3D16, 3D6, 3D11. All exterior perimeter walls to department contain ACM - 3C sheet flooring asbestos free - Ronald McDonald Family Room flooring, ceiling tiles and inner walls asbestos free NOTE outer perimeter walls are still original and are to be considered as to contain asbestos joining compound. - 3V ENT Clinic Ceiling tiles, flooring and most walls are new. All exterior perimeter walls to department contain ACM - 3A GFT area Ceilings, and floors are new. All interior partitions walls ACM free. All exterior perimeter walls to department contain ACM - 3D Sedation clinic sheet flooring and ceiling tile, drywall and drywall compound ACM free. All exterior perimeter walls to department contain ACM

13 Page 13 of 19-3N5/Courtyoard 3, acoustic ceiling tiles, drywall, drywall compound and flooring replacement Asbestos free materials includes 3N5A, 3N5B, 3NW1, 3NW2, 3N51 suite, new flooring and ceiling tiles. All exterior perimeter walls to department contain ACM - Floor tile replacement with sheet flooring: corridor 3H31, - 3G Inpatient Ward, acoustic ceiling tiles, drywall, drywall compound and flooring replacement Asbestos free materials. All exterior perimeter walls to department contain ACM - main corridor ward 3Y ceiling tiles replaced with new. Level 4 - Floor tile replacement with sheet flooring: corridors 4HC1, 4NC2 and 4NC1. - Main Ring Corridor Level 4 asbestos free sheet flooring except: 4N48 to 4N43 original carpeting - 4H24 new flooring and ceiling tiles - 4N72 acoustic ceiling tiles, drywall, drywall compound and flooring replacement - 4A ceiling tiles, flooring and interior partitions walls ACM free. All exterior walls to department contain ACM. - 4X ceiling tiles, flooring and interior partitions walls ACM free. All exterior walls to department contain ACM. - 4H32 / 4H34 new vinyl floor tiles - 4G1 to 4G5 new flooring and ceiling tiles and internal/interior walls. - 4F1 to 4F9B new flooring and ceiling tiles and internal/interior walls.

14 Page 14 of 19

15 Page 15 of 19 END OF DOCUMENT

16 Page 16 of 19

17 Page 17 of 19

18 Page 18 of 19

19 Page 19 of 19 END OF DOCUMENT