SAFETY DATA SHEET EXSPOR ACTIVATOR

Transcription

1 SECTION 1. PRODUCT AND COMPANY IDENTIFICATION Product name : Other means of identification : Not applicable Recommended use : Additive Restrictions on use : Reserved for industrial and professional use. Product dilution information :. % -.33 % 4 WATER: 1 BASE: 1 ACTIVATOR Company : Ecolab Inc. 37 N. Wabasha Street St. Paul, Minnesota USA Emergency telephone : (US/Canada), (outside US) Issuing date : 12/3/214 SECTION 2. HAZARDS IDENTIFICATION GHS Classification Skin corrosion : Category 1A Serious eye damage : Category 1 Not a hazardous substance or mixture. GHS Label element Hazard pictograms : Signal Word Hazard Statements Precautionary Statements : Danger : Causes severe skin burns and eye damage. : Prevention: Wash skin thoroughly after handling. Wear protective gloves/ protective clothing/ eye protection/ face protection. Do not mix with bleach or other chlorinated products will cause chlorine gas. Response: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. IF ON SKIN (or hair): Remove/ Take off immediately all contaminated clothing. Rinse skin with water/ shower. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Immediately call a POISON CENTER or doctor/ physician. Wash contaminated clothing before reuse. Storage: / 1

2 Store locked up. Disposal: Dispose of contents/ container to an approved waste disposal plant. Precautionary Statements : Prevention: Wash hands thoroughly after handling. Response: Get medical advice/ attention if you feel unwell. Storage: Store in accordance with local regulations. Other hazards : None known. SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS Pure substance/mixture : Mixture Chemical Name CAS-No. Concentration (%) Lactic acid No hazardous ingredients SECTION 4. FIRST AID MEASURES In case of eye contact In case of skin contact If swallowed If inhaled Protection of first-aiders Notes to physician Most important symptoms and effects, both acute and delayed In case of eye contact In case of skin contact : Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medical attention immediately. : Wash off immediately with plenty of water for at least 15 minutes. Use a mild soap if available. Wash clothing before reuse. Thoroughly clean shoes before reuse. Get medical attention immediately. : Rinse mouth with water. Do NOT induce vomiting. Never give anything by mouth to an unconscious person. Get medical attention immediately. : Remove to fresh air. Treat symptomatically. Get medical attention if symptoms occur. : If potential for exposure exists refer to Section 8 for specific personal protective equipment. : Treat symptomatically. : See Section 11 for more detailed information on health effects and symptoms. : Rinse with plenty of water. : Rinse with plenty of water / 1

3 If swallowed If inhaled : Rinse mouth. Get medical attention if symptoms occur. : Get medical attention if symptoms occur. SECTION 5. FIRE-FIGHTING MEASURES Suitable extinguishing media Unsuitable extinguishing media Specific hazards during fire fighting Hazardous combustion products Special protective equipment for fire-fighters Specific extinguishing methods : Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. : None known. : Not flammable or combustible. : Decomposition products may include the following materials: Carbon oxides Nitrogen oxides (NOx) Sulfur oxides Oxides of phosphorus : Use personal protective equipment. : Fire residues and contaminated fire extinguishing water must be disposed of in accordance with local regulations. In the event of fire and/or explosion do not breathe fumes. SECTION 6. ACCIDENTAL RELEASE MEASURES Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up Personal precautions, protective equipment and emergency procedures Environmental precautions Methods and materials for containment and cleaning up : Ensure adequate ventilation. Keep people away from and upwind of spill/leak. Avoid inhalation, ingestion and contact with skin and eyes. When workers are facing concentrations above the exposure limit they must use appropriate certified respirators. Ensure clean-up is conducted by trained personnel only. Refer to protective measures listed in sections 7 and 8. : Do not allow contact with soil, surface or ground water. : Stop leak if safe to do so. Contain spillage, and then collect with noncombustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and place in container for disposal according to local / national regulations (see section 13). Flush away traces with water. For large spills, dike spilled material or otherwise contain material to ensure runoff does not reach a waterway. : Refer to protective measures listed in sections 7 and 8. : No special environmental precautions required. : Stop leak if safe to do so. Contain spillage, and then collect with noncombustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and place in container for disposal according to / 1

4 SECTION 7. HANDLING AND STORAGE local / national regulations (see section 13). Flush away traces with water. For large spills, dike spilled material or otherwise contain material to ensure runoff does not reach a waterway. Advice on safe handling Conditions for safe storage : Do not ingest. Do not get in eyes, on skin, or on clothing. Do not breathe dust/ fume/ gas/ mist/ vapors/ spray. Use only with adequate ventilation. Wash hands thoroughly after handling. Do not mix with bleach or other chlorinated products will cause chlorine gas. : Keep away from strong bases. Keep out of reach of children. Store in suitable labeled containers. Storage temperature : -1 C to 4 C Advice on safe handling : Wash hands after handling. For personal protection see section 8. Conditions for safe storage : Keep out of reach of children. Store in suitable labeled containers. SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Ingredients with workplace control parameters Contains no substances with occupational exposure limit values. Engineering measures : Effective exhaust ventilation system. Maintain air concentrations below occupational exposure standards. Personal protective equipment Eye protection Hand protection Skin protection Respiratory protection Hygiene measures Engineering measures : Safety goggles Face-shield : Wear the following personal protective equipment: Standard glove type. Gloves should be discarded and replaced if there is any indication of degradation or chemical breakthrough. : Personal protective equipment comprising: suitable protective gloves, safety goggles and protective clothing : When workers are facing concentrations above the exposure limit they must use appropriate certified respirators. : Handle in accordance with good industrial hygiene and safety practice. Remove and wash contaminated clothing before re-use. Wash face, hands and any exposed skin thoroughly after handling. Provide suitable facilities for quick drenching or flushing of the eyes and body in case of contact or splash hazard. : Good general ventilation should be sufficient to control worker exposure to airborne contaminants / 1

5 Personal protective equipment Eye protection Hand protection Skin protection Respiratory protection : No special protective equipment required. : No special protective equipment required. : No special protective equipment required. : No personal respiratory protective equipment normally required. SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance : liquid liquid Color : light yellow light yellow Odor : slight slight ph : 1.8, 1 % Flash point Odor Threshold Melting point/freezing point Initial boiling point and boiling range Evaporation rate Flammability (solid, gas) Upper explosion limit Lower explosion limit Vapor pressure Relative vapor density : Not applicable, Does not sustain combustion. : > 1 C Relative density : 1.23 Water solubility Solubility in other solvents Partition coefficient: n- octanol/water Autoignition temperature Thermal decomposition Viscosity, kinematic Explosive properties Oxidizing properties Molecular weight VOC : soluble SECTION 1. STABILITY AND REACTIVITY Chemical stability : Stable under normal conditions / 1

6 Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products : Do not mix with bleach or other chlorinated products will cause chlorine gas. : None known. : Bases : Decomposition products may include the following materials: Carbon oxides Nitrogen oxides (NOx) Sulfur oxides Oxides of phosphorus SECTION 11. TOXICOLOGICAL INFORMATION Information on likely routes of exposure : Inhalation, Eye contact, Skin contact Potential Health Effects Eyes Skin Ingestion Inhalation Chronic Exposure Eyes Skin Ingestion Inhalation Chronic Exposure : Causes serious eye damage. : Causes severe skin burns. : Causes digestive tract burns. : May cause nose, throat, and lung irritation. Experience with human exposure Eye contact Skin contact Ingestion Inhalation Eye contact Skin contact Ingestion : Redness, Pain, Corrosion : Redness, Pain, Corrosion : Corrosion, Abdominal pain : Respiratory irritation, Cough : No symptoms known or expected. : No symptoms known or expected. : No symptoms known or expected / 1

7 Inhalation : No symptoms known or expected. Toxicity Acute oral toxicity Acute inhalation toxicity Acute dermal toxicity Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization Carcinogenicity Reproductive effects Germ cell mutagenicity Teratogenicity STOT-single exposure STOT-repeated exposure Aspiration toxicity Ingredients Acute inhalation toxicity Ingredients Acute dermal toxicity : Acute toxicity estimate : > 5, mg/kg : Lactic acid 4 h LC5 Rat: > 7.94 mg/l : Lactic acid LD5 Rabbit: > 2, mg/kg SECTION 12. ECOLOGICAL INFORMATION Ecotoxicity Environmental Effects Product Toxicity to fish Toxicity to daphnia and other aquatic invertebrates Toxicity to algae Ingredients Toxicity to fish : This product has no known ecotoxicological effects. : Lactic acid 96 h LC5 Fish: 13 mg/l Persistence and degradability No data available / 1

8 Bioaccumulative potential No data available Mobility in soil No data available Other adverse effects No data available SECTION 13. DISPOSAL CONSIDERATIONS Disposal methods Disposal considerations RCRA - Resource Conservation and Recovery Authorization Act Hazardous waste Disposal methods Disposal considerations : Where possible recycling is preferred to disposal or incineration. If recycling is not practicable, dispose of in compliance with local regulations. Dispose of wastes in an approved waste disposal facility. : Dispose of as unused product. Empty containers should be taken to an approved waste handling site for recycling or disposal. Do not reuse empty containers. : D2 (Corrosive) : Where possible recycling is preferred to disposal or incineration. If recycling is not practicable, dispose of in compliance with local regulations. Dispose of wastes in an approved waste disposal facility. : Dispose of as unused product. Empty containers should be taken to an approved waste handling site for recycling or disposal. Do not reuse empty containers. SECTION 14. TRANSPORT INFORMATION The shipper/consignor/sender is responsible to ensure that the packaging, labeling, and markings are in compliance with the selected mode of transport. Land transport (DOT) UN number : 3265 Description of the goods : Corrosive liquid, acidic, organic, n.o.s. (Lactic acid) Class : 8 Packing group : III Environmentally hazardous : no Sea transport (IMDG/IMO) UN number : 3265 Description of the goods : CORROSIVE LIQUID, ACIDIC, ORGANIC, N.O.S. (Lactic acid) Class : 8 Packing group : III Marine pollutant : no / 1

9 Not intended for transport. SECTION 15. REGULATORY INFORMATION EPA Registration number : ADJUVANT EPCRA - Emergency Planning and Community Right-to-Know CERCLA Reportable Quantity This material does not contain any components with a CERCLA RQ. SARA 34 Extremely Hazardous Substances Reportable Quantity This material does not contain any components with a section 34 EHS RQ. SARA 311/312 Hazards SARA 32 SARA 313 : Acute Health Hazard : No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 32. : This material does not contain any chemical components with known CAS numbers that exceed the threshold (De Minimis) reporting levels established by SARA Title III, Section 313. California Prop 65 This product does not contain any chemicals known to the State of California to cause cancer, birth, or any other reproductive defects. The ingredients of this product are reported in the following inventories: United States TSCA Inventory : On TSCA Inventory Canadian Domestic Substances List (DSL) : All components of this product are on the Canadian DSL. Australia Inventory of Chemical Substances (AICS) : New Zealand. Inventory of Chemical Substances : Japan. ENCS - Existing and New Chemical Substances Inventory : Japan. ISHL - Inventory of Chemical Substances (METI) : Korea. Korean Existing Chemicals Inventory (KECI) : Philippines Inventory of Chemicals and Chemical Substances (PICCS) : China. Inventory of Existing Chemical Substances in China (IECSC) : / 1

10 Health Health Instability Instability SAFETY DATA SHEET SECTION 16. OTHER INFORMATION NFPA: Flammability HMIS III: HEALTH 3 3 FLAMMABILITY PHYSICAL HAZARD Special hazard. = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic NFPA: Flammability HMIS III: HEALTH FLAMMABILITY PHYSICAL HAZARD Special hazard. = not significant, 1 =Slight, 2 = Moderate, 3 = High 4 = Extreme, * = Chronic Issuing date : 12/3/214 Version : 1.1 Prepared by : Regulatory Affairs REVISED INFORMATION: Significant changes to regulatory or health information for this revision is indicated by a bar in the left-hand margin of the SDS. The information provided in this Material Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text / 1