Material Safety Data Sheet

Transcription

1 Material Safety Data Sheet Issuing Date 5/21/2012 Revision Number 0 1. PRODUCT AND COMPANY IDENTIFICATION Product Name Product Code(s) Synonyms Recommended Use Company Manufactured by: Emergency Telephone Number Appearance Side One, Buff to Gold, Side Two, Tan to Brown BioPaddle with Nutrient-TTC and MacConkeys 5553 none / ninguno / aucun Culture medium. LaMotte Company, Inc. 802 Washington Avenue P.O. Box 329 Chestertown, MD USA Precision Labs Inc. Cottonwood, AZ Hour Emergency Number (CHEM-TEL): USA, Canada, Puerto Rico Outside rth American Continent (Call collect) HAZARDS IDENTIFICATION Emergency Overview May cause skin and eye irritation May be harmful if swallowed Physical State BioPaddle - a paddle with two sides of agar within a vial Odor Characteristic OSHA Regulatory Status Potential Health Effects Principle Routes of Exposure Acute Toxicity Eyes Skin Inhalation Ingestion Chronic Effects Aggravated Medical Conditions Environmental Hazard This material is not considered hazardous by the OSHA Hazard Communication Standard (29 CFR ). Ingestion adverse effects expected from eye contact, but may cause irritation and redness. t expected to be a health hazard from skin contact. May cause slight irritation. t an expected route of exposure. May cause irritation. May be harmful if swallowed. May cause gastrointestinal discomfort if consumed in large amounts. ne known. information available. Page 1 / 9

2 3. COMPOSITION/INFORMATION ON INGREDIENTS The product contains no substances which at their given concentration, are considered to be hazardous to health. CAS- Weight % <1% to 100% 4. FIRST AID MEASURES General Advice Eye Contact Skin Contact Inhalation Ingestion Protection of First-aiders Do not get in eyes, on skin, or on clothing. Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. If irritation persists or develops, contact a physician. Wash off with soap and plenty of water removing all contaminated clothes and shoes. If irritation develops or persists, consult physician. Move to fresh air. Rinse mouth. Drink plenty of water. If symptoms persist or develop contact physician. Do not induce vomiting without medical advice. Use personal protective equipment. See Section 8 for more detail. Do not use mouth-to-mouth method if victim ingested or inhaled the substance; induce artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device. 5. FIRE-FIGHTING MEASURES Flammable Properties Flash Point Suitable Extinguishing Media Explosion Data NFPA Health Hazard 0 HMIS Health Hazard 0 Flammability 0 Flammability 0 t a fire hazard. t applicable spray, dry chemical, carbon dioxide (CO 2 ), or foam. Stability 0 Stability 0 Physical and Chemical Hazards N/A Personal Precautions Refer to Section ACCIDENTAL RELEASE MEASURES Methods for Containment Methods for Cleaning Up Contain and collect spillage with non-combustible absorbent material, (e.g. sand, earth, diatomaceous earth, vermiculite) and place in container for disposal according to local / national regulations (see Section 13). Keep in suitable and closed containers for disposal. After cleaning, flush away traces with water. Page 2 / 9

3 7. HANDLING AND STORAGE Handling Storage Handle in accordance with good industrial hygiene and safety practice. Prevent contact with skin, eyes, and clothing. Do not ingest. Do not eat, drink, or smoke when using this product. Keep containers tightly closed in a dry, cool, and well-ventilated place. Protect from moisture. Keep out of the reach of children. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Engineering Measures Personal Protective Equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Hygiene Measures ACGIH TLV OSHA PEL NIOSH IDLH Showers. Eyewash stations. Safety glasses with side-shields. Gloves & Lab Coat. ne required under normal usage. Avoid contact with skin, eyes and clothing. Handle in accordance with good industrial hygiene and safety practice. Wash hands and face before breaks and immediately after handling the product. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance Physical State Flash Point Boiling Point/Range Side One Buff to Gold Side Two Tan to Brown BioPaddle - a paddle with two sides of agar within a vial t applicable t applicable Odor ph Autoignition Temperature Characteristic Approximately neutral t applicable Molecular Weight Vapor Pressure data available information available Solubility Vapor Density Soluble information available 10. STABILITY AND REACTIVITY Stability Stable. Page 3 / 9

4 BioPaddle with Nutrient-TTC and MacConkeys Product Code(s) 5553 Incompatible Products Strong oxidizing agents. Acids. Alkalis. Conditions to Avoid Exposure to air or moisture over prolonged periods. Excessive heat. Hazardous Decomposition Products Carbon oxides (COx). Hazardous Reactions Hazardous polymerization does not occur. 11. TOXICOLOGICAL INFORMATION Acute Toxicity LD50 Oral LD50 Dermal LC50 Inhalation 10 g/kg ( Rabbit ) 42 g/m 3 ( Rat ) 1 h 10 g/kg ( Rat ) 11 g/kg ( Rat ) 90 ml/kg ( Rat ) Chronic Toxicity ACGIH IARC NTP OSHA EU - Endocrine Disrupters Candidate List EU - Endocrine Disruptors - Evaluated Substances Japan - Endocrine Disruptor Information Page 4 / 9

5 12. ECOLOGICAL INFORMATION Ecotoxicity Toxicity to Algae Toxicity to Fish Microtox Daphnia Magna ( Flea) LC50= mg/l Lepomis EC50 = 1000 mg/l 48 h macrochirus 96 h LC50= 7650 mg/l Pimephales promelas 96 h LC50= 9675 mg/l Lepomis macrochirus 96 h Persistence and Degradability Bioaccumulation/Accumulation information available. information available. Log Pow 13. DISPOSAL CONSIDERATIONS Waste Disposal Method Twist to remove paddle from vial. Fill vial to 40 ml fill line with 1:9 dilution of household bleach (5.25% sodium hypochlorite solution). Replace paddle in vial. Allow 15 minute contact time. Remove paddle. Discard bleach solution. Replace paddle in vial and dispose. Dispose of in accordance with local regulations. Contaminated Packaging Dispose of in accordance with local regulations. RCRA - Halogenated RCRA - P Series Wastes RCRA - F Series Wastes RCRA - K Series Wastes Organic Compounds Page 5 / 9

6 14. TRANSPORT INFORMATION DOT IATA IMDG/IMO t regulated t regulated t regulated 15. REGULATORY INFORMATION International Inventories Component ( 0.25 ) ( 0.5 ) ( <1% ) ( 3 ) ( 3 ) ( 4 ) ( 6 ) ( to 100% ) TSCA DSL EINECS/ELIN ENCS IECSC KECL PICCS AICS CS Present DSL X ENCS IECSC KECL PICCS AICS Present X X ENCS X KE X X Present X X X KE X X TSCA DSL EINECS/ELIN ENCS IECSC KECL X X CS TSCA DSL X ENCS X KECL X AICS XU X X X KE X X XU X X ENCS X KE X X Present X X ENCS X KE X X U.S. Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and Title 40 of the Code of Federal Regulations, Part 372. CAS- Weight % SARA Threshold Values % <1% to 100% SARA 311/312 Hazard Categories Acute Health Hazard Chronic Health Hazard Fire Hazard Sudden Release of Pressure Hazard Reactive Hazard Clean Act This product does not contain any substances regulated as pollutants pursuant to the Clean Act (40 CFR and 40 CFR ). Page 6 / 9

7 Component CWA - Reportable CWA - Toxic Pollutants CWA - Priority Pollutants CWA - Hazardous Quantities Substances ( 0.25 ) ( 0.5 ) ( <1% ) ( 3 ) ( 3 ) ( 4 ) ( 6 ) ( to 100% ) Clean Air Act, Section 112 Hazardous Air Pollutants (HAPs) (see 40 CFR 61) This product does not contain any substances regulated as hazardous air pollutants (HAPS) under Section 112 of the Clean Air Act Amendments of CAS- Weight % HAPS data VOC Chemicals Class 1 Ozone Class 2 Ozone Depletors Depletors <1% to 100% CERCLA U.S. State Regulations Hazardous Substances RQs Extremely Hazardous Substances RQs California Proposition 65 This product does not contain any Proposition 65 chemicals CAS- California Prop Page 7 / 9

8 Massachusetts New Jersey Pennsylvania Illinois Rhode Island International Regulations Mexico - Grade Canada Carcinogen Status Exposure Limits This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all the information required by the CPR Component ( 0.25 ) ( 0.5 ) ( <1% ) ( 3 ) ( 3 ) ( 4 ) ( 6 ) ( to 100% ) WHMIS Hazard Class t determined t determined Uncontrolled product according to WHMIS classification criteria Uncontrolled product according to WHMIS classification criteria t determined t determined t determined Uncontrolled product according to WHMIS classification criteria 16. OTHER INFORMATION Page 8 / 9

9 NFPA HMIS PPE Transport Symbol Prepared By Regulatory Affairs Department Issuing Date 5/21/2012 Revision Date 24-Jul-2012 Revision te Initial Release Disclaimer The information provided on this MSDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of MSDS Page 9 / 9