UF PRO ULTRAFILTRATION UNIT Safe, clean drinking water on tap anywhere, anytime with UF-PRO Ultrafiltration Units... LONG TERM, HIGH PERFORMANCE FILTERS SIMPLIFIED CLEANING PROCESS Low cost, safe potable water with minimal operator attendance, stand-alone capability and low power consumption is now available... The unique range of UF-PRO ultrafiltration units provide sustainable safe clean water solutions for numerous applications using simple plug-in connections. This makes for quick & easy set up and user-friendly operation. Non-technical operators find the UF-PRO a breeze to use particularly with intuitive controller inputs and no hard wiring required to get started. What s more with low energy consumption the UF-PRO saves money on power and can even run on solar if needed. And, when gravity feed is available the need for a supply pump can be eliminated. Long-Life High Performance Ultrafilters At the heart of the UF-PRO are the proven MEMCOR high permeability, low fouling PVDF hollow fiber membranes used by thousands of membrane plants globally. These membranes have stood the test of time effectively disinfecting primary water by removing pathogens and particulates and supplying safe drinking water from the majority of non-saline surface and ground waters. Patented ECO-FLUSH TM Self-Cleaning Process The key feature for successful operation of the UF-PRO is the effectiveness of its patented backwash process, which uses low-pressure aeration to maintain a clean membrane surface even with highly turbid, feed waters. This unique process replaces the old conventional inside-outside reverse flush backwash operation and instead relies on an aggressive shell-scour protocol to scrub clean the filter membrane during cleaning cycles. Not only are filter membranes refreshes but also the system lasts longer particularly when the process is augmented periodically with a chemical clean or CIP (Clean In Place) to remove residual fouling. www.aquasolutions.com.au TM UFP200DUAL (40-50 kl/day) High volume output Lightweight and portable Pathogen-free low cost water Patented self-cleaning/backwash process High performance long-life ultrafilters Fully automated operation by system controller Minimal operator attendance by non-technical persons Stand-alone capability Low power consumption Simple plug-in connections - no hard wiring Quick & easy setup and hassle-free operation
IDEAL SOLUTION FOR COMMERCIAL & DOMESTIC CLEAN DRINKING AND RO PRE-TREATMENT MULTI-MODULE AUTOMATED ULTRA FILTRATION UNITS TYPICAL APPLICATIONS Decentralised water treatment systems Community and rural small scale systems Remote mining and resource communities Point-of-entry filtration Emergency and temporary water supplies Hotels / restaurants / resorts Bottled water production RO (reverse osmosis) pre-treatment UFP100MONO (20-25 kl/day) Single (1) module automated UFP200DUAL (40-50 kl/day) Dual (2) module automated UFP300TRI (60-70 kl/day) Triple (3) module automated UFP400QUAD (80-100 kl/day) Quad (4) module automated
SPECIFICATIONS UFPRO100MONO Single (1) module automated (20-25 kl/day) 18 20 20,000 5,200 Height: 161 cm Depth: 34 cm Width: 51 cm Weight: 57 kg UFPRO200DUAL Dual (2) module automated (40-50 kl/day) 36 40 40,000 10,400 Height: 161 cm Depth: 34 cm Width: 71 cm Weight: 78 kg UFPRO300TRI Tri (3) module automated (60-70 kl/day) 54 60 60,000 15,654 Height: 161 cm Depth: 34 cm Width: 91 cm Weight: 100 kg UFPRO400QUAD Quad (4) module automated (80-100 kl/day) 72 80 80,000 20,872 Height: 161 cm Depth: 34 cm Width: 111 cm Weight: 145 kg
TECHNICAL DATA Specifications Filtration of potable surface water, groundwater or seawater. Note: Not suitable for use with Typical Application water sources containing chemical or mineral contaminants such as heavy metals. surface water (per module housing) 1 Model Number UFPRO-100-MONO Single Module Unit UFPRO-200-DUAL UFPRO-300-TRI UFPRO-400-QUAD Dual Module Unit Triple Module Unit Quad Module Unit 18 36 54 20 40 60 20,000 40,000 60,000 5,200 10,400 15,654 72 80 80,000 20,872 Membrane Module Details Materials of Construction: Module Housing Assmbly Valves Seals and Gaskets Pipe andffittings Filter Mode Operation Standard Flow Control Device MEMCOR S10V membrane filtration module polyvinylidene fluoride (PVDF) hollow fibre ultrafiltration membrane with nominal pore size 0.04 μm Food grade polyethylene (PE) Various including PVC and PP EPDM typical Various including PE, ABS, Nylon and PVC Pressurised outside to inside filtration. Automatic standby on feed and filtrate storage levels via level switch inputs (where fitted). Automatic backwash at preset filtration intervals. Fixed flow rate flexible orifice flow control valve (FCV) (nominal instantaneous flow rate approx 18 litres per minute) ELECTRICAL AND PLUMBING CONNECTIONS GUIDELINE PRO UF ULTRAFILTRATION UNIT 240 VOLT MAINS POWER SUPPLY RAW VALVE LOW FLOAT SWITCH 24 VOLT DC INPUT FROM FLOAT SWITCH 240 VOLT AC POWER TO PUMP VALVE ELECTRICAL CONTROLLER BOX AIR VENT 25MM 24 VOLT DC INPUT FROM FLOAT SWITCH HIGH FLOAT SWITCH VALVE RAW SUPPLY TANK ELECTRIC PUMP PRE-FILTER PRE-FILTER BACKWASH DRAIN 25MM FILTRATION UNIT SV1 FEED SUPPLY (DIRTY IN) SV2 FILTRATE CLEAN TO CLEAN TANK SV3 BACKWASH TO DRAINAGE OUTLET PLUS AIR VENT SV5 FILTRATE FLUSH TO DRAINAGE MV1 HOUSING FLUSH TO DRAINAGE BACKWASH DRAIN 25MM FILTRATE - CLEAN TANK FILTRATE
ULTRAFILTRATION REMOVAL CRITERIA: (to 0.04um nominal) PATHOGENS (disease causing organisms) removed (to log reduction value > 4) by ultrafiltration include: Bacteria Protozoa Cysts Helminths Ultrafiltration WILL REMOVE: Total coliform TC Total coliform TC Ecoli Virus TURBIDITY (DIRT) TOTAL SUSPENDED SOLIDS (TSS) IRON & MANGANESE ARSENIC MANGANESE The World Health Organisation (WHO) reports that ultrafiltration provides complete removal of bacteria and viruses (disease causing pathogens) as outlined in WHO document GUIDELINES FOR DRINKG QUALITY under Treatment Process as referenced in the WHO website. Ultrafiltration WILL NOT REMOVE: CHEMICALS: Arsenic (unless first oxidised), Cadmium, Chromium, Copper, Cyanide, Fluoride, Lead, Mercury, Nickel, Nitrate, Nitrite, Sulphate MINERALS (hardness) SALINITY AND SALTS TOTAL DISSOLVED SOLIDS (TDS) UNPLEASANT TASTES UF-PRO ultrafiltration Pathogen-free water at low cost and minimal operator attendance is just the start of the UF-PRO range of ultrafiltation units and stand-alone capability requiring no additional equipment to operate other than a water tank and pump. Connections are plug-in requiring no hard-wiring making for quick and easy setup and with low power consumption, solar power or gravity flow is optional. Patented self-cleaning ECO-FLUSH Process The effectiveness of the UF-PRO relies on its patented self-cleaning ECO-FLUSH process using low pressure aeration to maintain a clean membrane surface. The patented shell-scour protocol does not reply on conventional inside-outside reverse flush backwash operation. Neither air or water reverse flow is engaged during the backwash cycle. The low energy source for the intermittent purge of contaminants. The system controller fully automates operation of the filtration and backwash cycles backwash are typically cycled very 15, 30 to 60 minutes during filtration (as preset by operator) and periodically the unit requires a chemical clean or CIP (Clean in Place) to remove residual fouling. Provision is made for a level switch input from a feed supply tank and a level switch from a filtrate storage tank. These inputs may be used to pause the filtration operation as the liquid levels in the feed or filtrate storage systems change. Long-life high performance ultrafilters The membrane filtration modules uses MEMCOR high permeability, low fouling PVDF follow fibre membranes for optimum performance and long life. The modules are simple in design, easy to install and maintain. Thousands of membrane plants globally rely on MEMCOR membrane modules for their water filtration requirements. Choose the simple, affordable solution for safe, clean drinking water, wherever you need it.. UF PRO c 2015 AquaSynergy Solutions Pty Ltd ULTRAFILTRATION UNIT
ULTRAFILTRATION SYSTEMS Designed & manufactured in Australia by: AquaSynergy Solutions Pty Ltd ABN: 32 134 373 676 5/23 Enterprise Ave, Tweed Heads South NSW 2486 Australia Telephone Tel: +61 7 55 233 888 Email info@aquasolutions.com.au Website www.aquasolutions.com.au The information provided in this literature contains merely general descriptions or characteristics of performance which in actual case of use do not always apply as described or which may change as a result of further development of the products. An obligation to provide the respective characteristics shall only exist if expressly agreed in the terms of the contract. SkyHydrant TM is a registered trademark of SkyJuice Foundation REGISTERED INTERNATIONAL PATENT c Copyright 2015 AquaSynergy Solutions Pty Ltd