MODULAR VARIABLE SPEED BLOWER CABINET 2, 3, 4, and 5 TONS FEATURES Variable Speed modular blower Supports two-stage outdoor units Dehumidification Speed: 80% Airflow Efficient low continuous fan selection: 50% Airflow Upflow, horizontal right or left applications Downflow requires sub-base accessory Electronic fan control board Adjustable Blower time delay Accepts accessory two stage outdoor thermostats Matches with AC and HP cased coils (Hot water coil may be used, but doesn t match case size) /-- supply voltage Requires a NO HEAT KIT if installed without electric heat. Field installed electric heater packages from 5kW- 25kW, single or three phase available separately SERVICE Direct drive slide-out blower assembly QUALITY Internally lined with ½ inch Tuf-Skin insulation Thermosetting powder coated steel cabinet WARRANTY 5 year parts limited warranty Product Specifications Model Nominal Tons Nominal CFM Motor HP 08004C 2 800 /2 2007C 3 200 /2 02C 4 0 3/4 200024C 5 2000 3/4 Dimensions H x W x D in (mm) 24 x 4-3/6 x 20-/2 ( x 3 x 52) 24 x 7-/2 x 20-/2 ( x 445 x 52) 25 x 2 x 20-/2 (635 x 533 x 52) 25 x 24-/2 x 20-/2 (635 x 622 x 52) Unit Weight lbs/kg Ship Weight lbs/kg 54/25 58/26 58/26 62/28 70/32 75/34 73/33 79/36 Specifications subject to change without notice. X00746 Rev.A May 202
UNIT SPECIFICATIONS - BLOWER COILS Model Number 08004C 2007C 02C 200024C Application Electrical Volt - Phase - Hz. Upflow / Downflow / Horizontal * / - - Data** Minimum Circuit Ampacity 6.3 6.3 9. 9. Blower Data Size DD0-7 DD0-8 DD0-9 DD0-9 Transformer Time Delay Fuse (Amps) Maximum Fuse or Breaker Size Horsepower - Speed /2 - VAR /2 - VAR 3/4 - VAR 3/4 - VAR Full Load Amps 5.0 5.0 7.3 7.3 Primary / Secondary - VA (- / 24 - VAC) 40 VA Weight Unit / Shipping Lbs. (Kg.) 54/58 (25/26) 58/62 (26/28) 70/75 (32/34) 73/79 (33/36) * Accessory subbase kit required for downflow application. ** Disregard if electric heat is added. Refer to Electric Heat table Dimensions and Clearances in (mm) 2-7/6 (36) 08-3/4 (400) 2 9-/4 (489) 6 22-3/4 (578) 20 CLEARANCES NO HEATERS ALL Sides 0 From Supply Duct. 0 Recommended Service From Front.. 20 (508mm) (Service for blower, filter if installed) 4-3/6 (3) 08 7-/2 (445) 2 2 (533) 6 24-/2 (622) 20 24 () 08 & 2 25 (635) 6 & 20 WITH HEATERS ALL Sides 0 From First Three Feet of Supply Duct to Combustibles. (26mm) From Duct after Three Feet... 0 Recommended Service From Front.. 20 (508mm) (Service for blower, heaters if installed) ALL DIMENSIONS IN (MM) MODEL NUMBER IDENTIFICATION GUIDE 2 3,4 5,6 7,8 9 0 M V 08 00 4 C M = Cased Modular Blower V = Variable Speed ECM Motor - /-- F = PSC Motor - /-- B = PSC Motor - -- TYPE 08 = 800 2 = 200 6 = 0 20 = 2000 NOMINAL MAX CFM 00 = No Electric Heat FACTORY INSTALLED ELECTRIC HEAT 4 = 4.5'' 7 = 7.5'' 2 = 2'' 24 = 24.5'' CABINET WIDTH Sales Digit (Major Revision) Engineering Digit (Minor Revision) 2 Specifications subject to change without notice. X00746 Rev.A
AIRFLOW DELIVERY (CFM) IN COOLING (EITHER A/C HP) Modular Outdoor -Stage Two-Stage Cooling Unit Unit A/C Cooling A/C Cooling - High A/C Cooling - Low Fan Only Size Size Nominal Dehum Nominal Dehum Nominal Dehum LOW MED HI 8 525 420 -- -- -- -- 350 420 525 08** 24 700 5 700 5 5 450 350 5 700 30 875 700 -- -- -- -- 440 700 875 36 050 840 050 840 840 670 525 840 050 24 700 5 700 5 5 450 4 5 700 2** 30 875 700 -- -- -- -- 440 700 875 36 050 840 050 840 840 670 525 840 050 42 225 980 -- -- -- -- 6 980 225 30 050 840 050 840 840 670 540 840 050 6** 36 225 980 -- -- -- -- 6 980 225 42 400 20 400 20 20 900 700 20 400 48 750 400 750 400 400 20 875 400 750 36 050 840 050 840 840 670 540 840 050 20** 42 225 980 -- -- -- -- 6 980 225 48 400 20 400 20 20 900 700 20 400 750 400 750 400 400 20 875 400 750 NOTES:. The above airflows result with the AC/HP CFM ADJUST select jumper set on NOM. 2. Airflow can be adjusted +% or -0% by selecting Hi or Lo respectively for all modes except fan only. 3. Dry coil at volts and with 0 kw heater and filter installed. 4. Airflows shown are valid for systems with total static pressure between 0. and 0.7 in. wc. ** Unit without electric heat installed X00746 Rev.A Specifications subject to change without notice. 3
No Heat Kit Model EHIA00KN0* UNIT SPECIFICATIONS No Heat Kit Cabinet 08** 2** 6** 20** Volts * No Heat Kit ** Unit without electric heat installed Phase Hertz Supply circuit No. H.P. /2 /2 3/4 3/4 Maximum Motor Amps 5.0 5.0 7.3 7.3 MCA Branch Circuit Ampacity 6.3 6.3 9. 9. Maximum Overcurrent Protection (Amps) Recommended Supply Wire 75ºC copper Ground Wire No. of Max. Ft. No. of Wire Size Wires Length Wires Wire Size 2 4 8 (36 m) 4 2 4 8 (36 m) 4 2 4 82 (25 m) 4 2 4 82 (25 m) 4 AIRFLOW DELIVERY (CFM) IN HEAT PUMP HEATING MODE ONLY Modular Outdoor -Stage Two-Stage Heating Unit Unit Tap HP Heating HP Heating - High HP Heating - Low Fan Only Size Size Comfort Eff Comfort Eff Comfort Eff LOW MED HI 8 D 475 525 -- -- -- -- 350 380 475 08** 24 C 630 700 630 700 505 5 350 505 630 30 B 785 875 -- -- -- -- 440 630 785 36 A 945 050 945 050 755 840 525 755 945 24 D 630 700 630 700 505 5 4 505 630 2** 30 C 785 875 -- -- -- -- 440 630 785 36 B 945 050 945 050 755 840 525 755 945 42 A 00 225 -- -- -- -- 6 880 00 30 D 945 050 945 050 755 840 540 755 945 6** 36 C 00 225 -- -- -- -- 6 880 00 42 B 2 400 2 400 00 20 700 00 2 48 A 75 750 75 750 2 400 875 2 75 36 D 945 050 945 050 755 840 540 755 945 20** 42 C 00 225 -- -- -- -- 6 880 00 48 B 2 400 2 400 00 20 700 00 2 A 75 750 75 750 2 400 875 2 75 NOTES:. The above airflows result with the AC/HP CFM ADJUST select jumper set on NOM. 2. Airflow can be adjusted +% or -0% by selecting Hi or Lo respectively for all modes except fan only. 3. Dry coil at volts and with 0 kw heater and filter installed. 4. Airflows shown are valid for systems with total static pressure between 0. and 0.7 in. wc. ** Unit without electric heat installed 4 Specifications subject to change without notice. X00746 Rev.A
ELECTRIC HEATER STATIC DROP IN. W.C. -Phase CFM EHIA05 EHIA07 EHIA0 EHIA EHIA20 EHIA25 0 0.0 0.0 0.0 -- -- -- -- -- -- 700 0.0 0.0 0.0 -- -- -- -- -- -- 800 0.0 0.0 0.0 0.0 -- -- -- -- 900 0.0 0.0 0.0 0.0 -- -- -- -- 000 0.0 0.0 0.0 0.0 0.02 -- -- 00 0.0 0.0 0.0 0.02 0.02 -- -- 200 0.0 0.0 0.0 0.02 0.02 -- -- 300 0.0 0.02 0.02 0.02 0.02 -- -- 400 0.0 0.02 0.02 0.02 0.03 0.03 00 0.0 0.02 0.02 0.02 0.03 0.04 0 0.0 0.02 0.02 0.03 0.03 0.04 700 0.0 0.02 0.02 0.03 0.03 0.04 800 0.0 0.02 0.02 0.03 0.04 0.04 900 0.0 0.02 0.02 0.03 0.04 0.05 2000 0.0 0.02 0.02 0.03 0.04 0.05 Three-Phase CFM -- -- -- -- EHIA0 EHIA EHIA20 EHIA25 0 -- -- -- -- 0.0 -- -- -- -- -- -- 700 -- -- -- -- 0.0 -- -- -- -- -- -- 800 -- -- -- -- 0.0 0.0 -- -- -- -- 900 -- -- -- -- 0.0 0.0 -- -- -- -- 000 -- -- -- -- 0.0 0.0 0.02 -- -- 00 -- -- -- -- 0.0 0.02 0.02 -- -- 200 -- -- -- -- 0.0 0.02 0.02 -- -- 300 -- -- -- -- 0.02 0.02 0.02 -- -- 400 -- -- -- -- 0.02 0.02 0.03 0.03 00 -- -- -- -- 0.02 0.02 0.03 0.04 0 -- -- -- -- 0.02 0.03 0.03 0.04 700 -- -- -- -- 0.02 0.03 0.03 0.04 800 -- -- -- -- 0.02 0.03 0.04 0.04 900 -- -- -- -- 0.02 0.03 0.04 0.05 2000 -- -- -- -- 0.02 0.03 0.04 0.05 -- -- DO NOT OPERATE IN THIS AREA CFM / KW LIMIT EXCEEDED X00746 Rev.A Specifications subject to change without notice. 5
6 Specifications subject to change without notice. X00746 Rev.A
International Comfort Products, LLC Lewisburg, Tennessee 3709 U.S.A. X00746 Rev.A Specifications subject to change without notice. 7