P N : WET DISTILLERS GRAINS Page 1 of 6

Transcription

1 P N : WET DISTILLERS GRAINS Page 1 of 6 M B : GreenField Specialty Alcohols Inc. Bruce Energy Centre 275 Bloomfield Road 3300 boulevard Marie Victorin 2 Chelsea Lane 4th Concession Chatham, Varennes, Quebec Brampton, Ontario Tiverton, Ontario Ontario J3X 1P7 L6T 3Y4 N0G 2T0 N7M 5J5 E P N : C (613) T PRIMARY CLASS: NOT APPLICABLE CLASS NAME: NOT APPLICABLE UN#: NOT APPLICABLE SUBSIDIARY CLASS: SHIPPING NAME: NONE N OT APPLICABLE I. E F A P I It is unlikely that an acute hazard would be posed from inges on of this product. Never give anything by mouth if vic m is rapidly losing consciousness or is unconscious or convulsing. DO NOT INDUCE VOMITING. Have vic m drink about 250 ml (8 oz) of water to dilute material in stomach. If vomi ng occurs naturally, have vic m lean forward to reduce risk of aspira on. Seek medical a en on immediately. S Fibers may mildly irritate skin. Flush contaminated area with water for at least 20 minutes. Remove contaminated clothing under running water. Completely decontaminate clothing before re use, or discard. If irrita on occurs seek medical a en on. I Dust from this product is categorized as a nuisance par culate. May cause irrita on upon respira on. Remove vic m to fresh air. E Dust may cause eye irrita on. Immediately flush eyes with water for at least 10 minutes, holding the eyelids open. Seek medical a en on. N T P Wet dis llers grains are an animal feed product. Health effects upon exposure or inges on are expected to be minimal. THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA BELIEVED TO BE CORRECT. HOWEVER, NO GUARANTEE OR WARRANTY OF ANY KIND, EXPRESSED OR IMPLIED, IS MADE WITH RESPECT TO INFORMATION AND RECOMMEN DATIONS CONTAINED HEREIN.

2 P N : WET DISTILLERS GRAINS Page 2 of 6 II. F E H D F P, o C N A. O I D - COMPONENT % W/W VAPOUR PRESSURE VAPOUR DENSITY AUTOIGNI TION LOWER UPPER KPA AT 20 o C (AIR = 1) POINT, o C (1) Dis llers dried grains and solubles Water 30 approx. Balance E M S F F P U F E H flammable or combus ble. None. None III. I C N WET DISTILLERS GRAINS. C F F M W S WDG, WDGS, Dis llers Grains PROTEINS, CARBOHYDRATES FIBERS, U Animal feed.

3 P N : WET DISTILLERS GRAINS Page 3 of 6 IV. P D BOILING POINT, o C at 760mm Hg FREEZING POINT, o C. DENSITY, 20 o C COEFFICIENT OF WATER/OIL DISTRIBUTION ph Range 3 to 4 DISTILLATION RANGE, o C MISCIBILITY IN WATER % VOLATILES BY VOLUME 70 EVAPORATION RATE (butyl acetate = 1) 0.9 A A O Yellowish brown solid substance with cooked corn odour. V. I T D INGREDIENT % V/V CAS NO. TLV, ppm LC50, ppm/4h. LD50, mg/kg LD50, mg/kg (1) Dis llers dried grains and solubles Water 30 approx. Balance RAT, INHAL. RAT, ORAL RABBIT, SKIN VI. WHMIS C S M WHMIS C Dust from the product may be considered an eye irritant S M available

4 P N : WET DISTILLERS GRAINS Page 4 of 6 VII. H H D I It is unlikely that an acute hazard would be posed from inges on of this product. S A. I Dust from this product may cause irrita on upon respira on. S C EYE C EFFECT OF REPEATED OVEREXPOSURE M C A B O No evidence of significant adverse effects from available informa on. Fibres may cause minor skin irrita on. Airborne dust from this product may irritate eyes. Wear appropriate eye protec on. available. available.

5 P N : WET DISTILLERS GRAINS Page 5 of 6 VIII. R D S This product is suscep ble to degrada on by growth of micro organisms on exposed surfaces over me. C A None. I. H C D P H P Will not occur Burning can produce carbon monoxide and/or carbon dioxide. C A Over me, microbial growth on exposed surfaces may cause the oxygen content in confined spaces to be reduced. Do not enter confined spaces containing this product without first verifying that the oxygen content is safe. IX. S L P S Use conven onal cleanup methods. W D Waste material should be disposed of using conven onal methods, in compliance with all federal, provincial and local government regula ons. X. S P I R E V normally required. normally required. Over me, microbial growth on exposed surfaces may cause the oxygen content in confined spaces to be reduced. Do not enter confined spaces containing this product without first verifying that the oxygen content is safe. P G Generally not required. Neoprene, butyl or natural rubber. E P Safety glasses or monogoggles when exposed to flying par cles during handling. O P E Eye bath, safety shower and other protec ve equipment as required.

6 P N : WET DISTILLERS GRAINS Page 6 of 6 XI. SPECIAL PRECAUTIONS P T H S Wear eye protec on suitable to the hazard. Wash exposed skin thoroughly a er handling. O P Good personal hygiene prac ces are suggested, such as abstaining from ea ng, drinking and smoking in the workplace. XII. MSDS P PREPARED BY: Alcohol Quality Assurance, Technical Services, Regulatory Affairs Department PHONE NUMBER: (905) Date: February 1, 2014 GREENFIELD ETHANOL URGES EACH CUSTOMER OR RECIPIENT OF THIS MSDS TO STUDY IT CAREFULLY TO BECOME AWARE OF AND UNDERSTAND THE HAZARDS ASSOCIATED WITH THE PRODUCT. THE READER SHOULD CONSIDER CONSULTING REFERENCE WORKS OR INDIVIDUALS WHO ARE EXPERTS IN VENTILATION, TOXICOLOGY OR FIRE PREVENTION, AS NECESSARY OR APPROPRIATE TO USE AND UNDERSTAND THE DATA CONTAINED IN THIS MSDS. TO PROMOTE SAFE USE AND HANDLING OF THIS PRODUCT, EACH CUSTOMER OR RECIPIENT SHOULD (1) NOTIFY EMPLOYEES, AGENTS, CONTRACTORS AND OTHERS WHO MAY USE THIS MATERIAL, OF THE INFORMATION IN THIS MSDS AND ANY OTHER INFORMATION REGARDING HAZARDS OR SAFETY, (2) FURNISH THIS SAME INFORMATION TO EACH CUSTOMER FOR THE PRODUCT, AND (3) REQUEST CUSTOMERS TO NOTIFY THEIR EMPLOYEES, CUSTOMERS, AND OTHER USERS OF THE PRODUCT OF THIS INFORMATION.