NATIONAL CHEMICAL LABORATORIES, INC.

Transcription

1 NATIONAL CHEMICAL LABORATORIES, INC. Product Identifier Other means of identification 2522 Recommended use Recommended restrictions For commercial and industrial use only. Manufacturer / Importer / Supplier / Distributor Information Company Name National Chemical Laboratories of PA, Inc. Address 401 N. 10th Street - Philadelphia, PA Telephone 1 (215) Supplier info@nclonline.com Contact CHEM-TEL Emergency Phone 1 (800) Section 1 - Identification Section 2 - Hazard(s) Identification SDS Hazards and Warnings are based on the undiluted product. Refer to diluted SDS for Ready-To-Use Hazards and Warnings. Physical Hazards Health Hazards OSHA defined hazards t Classified t Classified t Classified. Category Target Organ Label Elements Hazard Symbol Signal Word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) Mixture Hazardous Components Composition Comments Harmful if swallowed. Harmful in contact with skin. Causes severe skin burns and eye damage. Do not breathe mist or vapor. Wash thoroughly after handling. Do not eat, drink or smoke when using this product. Wear protective gloves/protective clothing/eye protection/face protection. If swallowed: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately all contaminated clothing. Rinse skin with water/shower. If inhaled: Remove person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinising. Immediately call a poison center/doctor. Take off contaminated clothing and wash before reuse. Store in a well-ventilated place. Keep container tightly closed. Store locked up. Dispose of contents/container in accordance with local/regional/national/international regulations. ne known. Section 3 - Composition/Information on ingredients Ingredient Name CAS # % Oxalic Acid All concentrations are in percent by weight unless ingredient is a gas. Gas concentrations are in percent by volume. Section 4 - First-aid Measures Inhalation Skin contact Eye contact Ingestion Most Important symptoms /effects, acute and delayed 2522 Page 1 of 5

2 Indication of immediate medical attention and special treatment General Information Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire-fighting equipment /instructions General fire hazards Specific Methods Personal precautions, protective equipment and emergency procedures. Methods and materials for containment and cleaning up Treat symptomatically. Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Section 5 - Fire-fighting measures Section 6 - Accidental release measures SMALL SPILLAGE: Absorb spillage with suitable absorbent material. Absorb spill with vermiculite or other inert material, then place in a container for chemical waste. After removal flush contaminated area thoroughly with water. LARGE SPILLS: Absorb spill with vermiculite or other inert material, then place in a container for chemical waste. After removal flush contaminated area thoroughly with water. Environmental precautions Precautions for safe handling Conditions for safe storage, including any incompatibilities Occupational exposure limits Avoid discharge into drains, water courses or onto the ground. Section 7 - Handling and storage Avoid contact with eyes, skin, and clothing. Avoid breathing mist or vapor. Do not taste or swallow. Use with adequate ventilation. Wash thoroughly after handling. Use Personal Protective Equipment recommended in section 8 of the SDS. Store away from incompatible materials. Keep container closed. Section 8 - Exposure control/personal protection Biological limit values Exposure guidelines Appropriate engineering controls Individual protection measures, such as personal protective equipment Eye/face protection Goggles or safety glasses with side shields. Skin protection Hand protection Other Respiratory protection Thermal hazards General hygiene considerations Appearance Odor Physical state Form Color Odor threshold ph (Concentrate) Melting point/freezing point Initial boinging point and boiling range Flash point Rubber or Latex. t required. White slurry. Liquid. Liquid. White. ne. 212 F (100 C) Section 9 - Physical and chemical properties > F (> C) 2522 Page 2 of 5

3 Evaporation rate = To Water Flammability (solid, gas) Upper/lower flammability or explosive limits Flammability limit - lower (%) Flammability limit - upper (%) Explosive limit - lower (%) Explosive limit - upper (%) Vapor pressure Vapor density Relative density 1.38 Relative density temperature Solubilities Partition Coefficient n- octanol/water Auto-ignition temperature Decomposition temperature Viscosity Viscosity Temperature Similar to water. Similar to water. 75 F (23.89 C) 100 % Soluble. t available t Available t Available 75 F (23.89 C) Reactivity Chemical stability Possiblity of hazardous reactions Conditions to Avoid Incompatible materials Hazardous Decomposition Products Information on likely routes of exposure Ingestion Inhalation Skin contact Eye contact Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects. Acute toxicity Skin corrosion/irritation Serious eye damage/ eye irritation Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity The product is non-reactive under normal conditions of use, storage and transport. Stable at normal conditions. Hazardous polymerization does not occur. Contact with incompatible materials. Avoid contact with strong acids and oxidizers. Carbon Oxides Section 10 - Stability and reactivity Section 11 - Toxicological information Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard Chronic effects Further information Ecotoxicity Components Aquatic Aquatic Persistence and degradability Section 12 - Ecological Information The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. Species The product is expected to be biodegradable. Test Results 2522 Page 3 of 5

4 Bioaccumulative potential t known. Mobility in soil Mobility in general Other adverse effects Disposal instructions Local disposal regulations Hazardous waste code Waste from residues / unused products Contaminated packaging The product is water soluble and may spread in water systems. ne known. Section 13 - Disposal considerations Dispose in accordance with applicable federal, state, and local regulations. Dispose of in accordance with local regulations. Dispose in accordance with all applicable regulations. Since emptied containers may retain product residue, follow label warnings even after container is emptied. DOT Packing group Special precautions for users Special provisions Packaging exemption Packaging non bulk Packaging bulk IATA Packaging group Environmental hazards ERG Code Special precautions for user IMDG Packaging goup Environmental hazards Marine pollutant EmS Special precautions for user Transportation in bulk according to Annex II of MARPOL 73/78 and IBC Code General Information not regulated Section 14 - Transport information US federal regulations TSCA Section 12(b) Export tification (40 CFR707, Subpt. D) US. OSHA Specifically Regulated Substances (29 CFR ) CERCLA Hazardous Substance List (40 CFR Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard Categories Immediate Hazard Delayed Hazard Fire Hazard Section 15 - Regulatory Information 2522 Page 4 of 5

5 Pressure Hazard Reactivity Hazard SARA 302 Extremely hazardous substance SARA 311/312 Hazardous chemical SARA 313 (TRI reporting) Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HSPs) List Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) Safe Drinking Water Act (SDWA) Food and Drug Administration (FDA) t regulated. US state regulations US.Massachusetts RTK - Substance List US.New Jersey Worker and Community Right-to-Know Act US.Pennsylvania RTK - Hazardous Substances US.Rhode Island RTK US - California Propsition 65 - Carcinogens Reproductive Toxicity (CRT): Listed substance International Inventories Country(s) or region Australia Canada Canada China Europe Europe Japan Korea New Zealand Philippines Unites States Puerto Rico Inventory Name Australian Inventory of Chemical Substances (AICS) Domestic Substances List (DSL) n-domestic Substances List (NDSL) Inventory of Existing Chemical Substances in China (IECSC) European Inventory of Existing Commercial Chemical Substances (EINECS) European List of tifed Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances Toxic Substances Control Act (TSCA) Inventory On Inventory (yes/no)* *A "Yes" indicates this product complies with the inventory requirements administered by the governing country(s). *A "" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). Section 16 - Other information, including date of preparation or last version Issue date 5/30/2002 Revision date Version # Further information List of abbreviations References Disclaimer The information contained herein was obtained from current and reliable sources. However, the data is provided without any warranty, expressed or implied, regarding its correctness or accuracy. Since the conditions for use, handling, storage and disposal of this product are beyond the manufacturer's control, it is the user's responsibility both to determine safe conditions for use of this product and to assume liability for loss, injury, damage or expense arising from the product's improper use. warranty, expressed or implied, regarding the product described herein shall be created by or inferred from any statement or omission in this SDS. Various government agencies may have specific regulations concerning the transportation, handling, storage, use or disposal of this product which may not be reflected in this SDS. The user should review these regulations to ensure full compliance Page 5 of 5