SAFETY DATA SHEET. 1. Identification. 2. Hazard(s) identification. 3. Composition/information on ingredients

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Other means of identification Recommended use Recommended restrictions Royston Rosphalt 50-LT ne. ne known. Manufacturer/Importer/Supplier/Distributor information Manufacturer Company name CHASE CORPORATION Blawnox Plant Address 128 1st Street Blawnox, PA United States Telephone Emergency phone number Chemtrec, US Chemtrec, outside of US 2. Hazard(s) identification Physical hazards Health hazards OSHA defined hazards t classified. Germ cell mutagenicity Hazardous to the aquatic environment, acute hazard Hazardous to the aquatic environment, long-term hazard t classified. Category 1B Category 2 Category 2 Label elements Hazard symbol Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) Supplemental information ne. ne. ne known. ne. 3. Composition/information on ingredients Mixtures Chemical name Common name and synonyms CAS number % Coal, bituminous N/A 20 - < 30 1 / 7

2 Chemical name Distillates, Petroleum, Hydrotreated Heavy Naphthenic Common name and synonyms CAS number % *Designates that a specific chemical identity and/or percentage of composition has been withheld as a trade secret. 4. First-aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms/effects, acute and delayed 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Environmental precautions 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities t applicable < 30 This material is classified as a water pollutant under the Clean Water Act and should be prevented from contaminating soil or from entering sewage and drainage systems which lead to waterways. 8. Exposure controls/personal protection Occupational exposure limits The following constituents are the only constituents of the product which have a PEL, TLV or other recommended exposure limit. At this time, the other constituents have no known exposure limits. U.S. - OSHA Coal, bituminous US. OSHA Table Z-1 Limits for Air Contaminants (2 CFR ) PEL 2.4 mg/m3 Respirable Fraction Distillates, Petroleum, Hydrotreated Heavy Naphthenic (CAS ) PEL 5 mg/m3 Mist mg/m3 500 ppm US. ACGIH Threshold Limit s Distillates, Petroleum, Hydrotreated Heavy Naphthenic (CAS ) TWA 5 mg/m3 Inhalable fraction. 2 / 7

3 US. NIOSH: Pocket Guide to Chemical Hazards Distillates, Petroleum, Hydrotreated Heavy Naphthenic (CAS ) Biological limit values Appropriate engineering controls Ceiling 1800 mg/m3 STEL 10 mg/m3 Mist. biological exposure limits noted for the ingredient(s). Individual protection measures, such as personal protective equipment Eye/face protection Skin protection Hand protection Other Respiratory protection Thermal hazards. Physical and chemical properties Appearance Odor Physical state Color Odor threshold ph Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) Solid. Granular. Black Aromatic 680 F (360 C) estimated F (135.0 C) estimated Upper/lower flammability or explosive limits Flammability limit - lower (%) Flammability limit - upper (%) Explosive limit - lower (%) Explosive limit - upper (%) Vapor pressure Vapor density Relative density Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity Other information Density Percent volatile 0 % Specific gravity 500 F (260 C) estimated 8.30 lb/gal estimated 1 estimated 3 / 7

4 VOC 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products 0 g/l 11. Toxicological information Information on likely routes of exposure Inhalation Skin contact Eye contact Ingestion Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Acute toxicity Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization Respiratory sensitization Skin sensitization Germ cell mutagenicity Carcinogenicity IARC Monographs. Overall Evaluation of Carcinogenicity t listed. OSHA Specifically Regulated Substances (2 CFR ) t regulated. US. National Toxicology Program (NTP) Report on Carcinogens Distillates, Petroleum, Hydrotreated Heavy Naphthenic (CAS ) Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard 12. Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects 13. Disposal considerations Disposal instructions ecotoxicity data noted for the ingredient(s). Known To Be Human Carcinogen. 4 / 7

5 Waste from residues / unused products Contaminated packaging 14. Transport information DOT UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Label(s) Packing group Marine pollutant Special precautions for user Special provisions Packaging exceptions Packaging non bulk Packaging bulk IATA UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Packing group ERG Code Special precautions for user Other information Passenger and cargo aircraft Cargo aircraft only IMDG UN number UN proper shipping name Transport hazard class(es) Class Subsidiary risk Packing group Marine pollutant EmS Special precautions for user Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code UN3082 Environmentally hazardous substances, liquid, n.o.s. (Distillates, Petroleum, Hydrotreated Heavy Naphthenic), MARINE POLLUTANT - III 8, 146, 335, IB3, T4, TP1, TP UN3082 Environmentally hazardous substance, liquid, n.o.s. (Distillates, Petroleum, Hydrotreated Heavy Naphthenic) - III L Allowed with restrictions. Allowed with restrictions. UN3082 ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S. (Distillates, Petroleum, Hydrotreated Heavy Naphthenic), MARINE POLLUTANT - III F-A, S-F 5 / 7

6 DOT; IATA; IMDG Marine pollutant General information 15. Regulatory information US federal regulations DOT Regulated Marine Pollutant. TSCA Section 12(b) Export tification (40 CFR 707, Subpt. D) t regulated. CERCLA Hazardous Substance List (40 CFR 302.4) t listed. SARA 304 Emergency release notification t regulated. OSHA Specifically Regulated Substances (2 CFR ) t regulated. Superfund Amendments and Reauthorization Act of 186 (SARA) SARA 302 Extremely hazardous substance t listed. SARA 311/312 Hazardous chemical Classified hazard categories SARA 313 (TRI reporting) t regulated. Other federal regulations Germ cell mutagenicity Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List t regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) t regulated. Safe Drinking Water Act (SDWA) US state regulations t regulated. California Proposition 65 California Safe Drinking Water and Toxic Enforcement Act of 2016 (Proposition 65): This material is not known to contain any chemicals currently listed as carcinogens or reproductive toxins. For more information go to US. California. Candidate Chemicals List. Safer Consumer Products Regulations (Cal. Code Regs, tit. 22, , subd. (a)) Distillates, Petroleum, Hydrotreated Heavy Naphthenic (CAS ) 6 / 7

7 International Inventories Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Canada China Europe Europe Japan Korea New Zealand Philippines Taiwan Domestic Substances List (DSL) n-domestic Substances List (NDSL) Inventory of Existing Chemical Substances in China (IECSC) European Inventory of Existing Commercial Chemical Substances (EINECS) European List of tified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances (PICCS) Taiwan Chemical Substance Inventory (TCSI) United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory *A "" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision Issue date Revision date Version # 02 HMIS ratings NFPA ratings Disclaimer Revision information Health: 2 Flammability: 1 Physical hazard: 0 Health: 2 Flammability: 1 Instability: 0 This document has undergone significant changes and should be reviewed in its entirety. 7 / 7