Safety Data Sheet ASSEMBLY FLUID #1. 1. Identification of the substance/mixture and of the company/undertaking

Transcription

1 Safety Data Sheet ASSEMBLY FLUID #1 SDS Revision Date: 05/22/ Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier Product Identity ASSEMBLY FLUID #1 Alternate Names NATIONAL STOCK # Relevant identified uses of the substance or mixture and uses advised against Intended use Application Method See Technical Data Sheet. See Technical Data Sheet Details of the supplier of the safety data sheet Company Name Emergency Ultrachem Inc. 900 Centerpoint Blvd. New Castle, Delaware USA CHEMTREC (USA) (800) Customer Service: Ultrachem Inc. Phone:(302) Fax: (302) Hazard identification of the product 2.1. Classification of the substance or mixture No applicable GHS categories Label elements Using the Toxicity Data listed in section 11 and 12 the product is labeled as follows. No applicable GHS categories. [Prevention]: No GHS prevention statements Page 1 of 10

2 [Response]: No GHS response statements [Storage]: No GHS storage statements [Disposal]: No GHS disposal statements 3. Composition/information on ingredients This product contains the following substances that present a hazard within the meaning of the relevant State and Federal Hazardous Substances regulations. Ingredient/Chemical Designations Weight % GHS Classification Notes acrylic copolymer CAS Number: Proprietary Distillates (petroleum), solvent refined heavy paraffinic CAS Number: Distillates (petroleum), solvent-refined light paraffinic Baseoil - unspecified CAS Number: Distillates (petroleum), solvent-dewaxed heavy paraffinic CAS Number: Mineral Oil = 100 %w/w approximately.nonionic surface active agent CAS Number: [1] [1] [1] [1] [1] [1] Substance classified with a health or environmental hazard. [2] Substance with a workplace exposure limit. [3] PBT-substance or vpvb-substance. *The full texts of the phrases are shown in Section First aid measures 4.1. Description of first aid measures General In all cases of doubt, or when symptoms persist, seek medical attention. Inhalation Eyes Skin Ingestion Never give anything by mouth to an unconscious person. Note to Physician: Product is soluble in medical white oil (BP) and/or paraffin oil. Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give artificial respiration. If unconscious place in the recovery position and obtain immediate medical attention. Give nothing by mouth. Irrigate copiously with clean fresh water for at least 15 minutes, holding the eyelids apart and seek medical attention. Remove contaminated clothing. Wash skin thoroughly with soap and water or use a recognized skin cleanser. If accidentally swallowed obtain immediate medical attention. Keep at rest. Do NOT induce vomiting Most important symptoms and effects, both acute and delayed Overview No specific symptom data. See section 2 for further details. Page 2 of 10

3 5. Fire-fighting measures 5.1. Extinguishing media Dry chemical, foam, carbon dioxide or water spray Special hazards arising from the substance or mixture Methacrylates (in case of thermal decomposition) 5.3. Advice for fire-fighters In the event of fire, wear full protective clothing and NIOSH Approved Self-contained breathing apparatus with full face piece operated in the pressure demand or other positive pressure mode. Move container from fire area if it can be done without risk. Use water to keep fire exposed containers cool and disperse vapors. ERG Guide No Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures Evacuate personnel to safe areas. Use personal protective equipment Environmental precautions Do not allow spills to enter drains or watercourses. Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse Methods and material for containment and cleaning up Use a non-combustible material like vermiculite, sand or earth to soak up product and place in a container for later disposal. Dike for disposal and cover with wet sand or earth. 7. Handling and storage 7.1. Precautions for safe handling See section 2 for further details. - [Prevention]: 7.2. Conditions for safe storage, including any incompatibilities Handle containers carefully to prevent damage and spillage. Store in a cool dry place. Keep containers tightly closed. Incompatible materials: Strong acids and oxidizing materials See section 2 for further details. - [Storage]: 7.3. Specific end use(s). Page 3 of 10

4 8. Exposure controls and personal protection 8.1. Control parameters Exposure CAS No. Ingredient Source Value Distillates (petroleum), solvent refined heavy paraffinic Distillates (petroleum), solvent-refined light paraffinic Baseoil - unspecified Mineral Oil = 100 %w/w approximately.nonionic surface active agent Distillates (petroleum), solvent-dewaxed heavy paraffinic ACGIH NIOSH Supplier ACGIH NIOSH Supplier ACGIH NIOSH Supplier ACGIH NIOSH Supplier Proprietary acrylic copolymer ACGIH NIOSH Supplier Contains mineral oil. The exposure limits for oil mist are 5 mg/m3 PEL and 10 mg/m3 ACGIH. Carcinogen Data CAS No. Ingredient Source Value Distillates (petroleum), solvent refined heavy paraffinic NTP IARC Select Carcinogen: No Known: No; Suspected: No Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; Page 4 of 10

5 Distillates (petroleum), solventrefined light paraffinic Baseoil - unspecified Mineral Oil = 100 %w/w approximately.nonionic surface active agent Distillates (petroleum), solventdewaxed heavy paraffinic NTP IARC NTP IARC NTP IARC Select Carcinogen: No Known: No; Suspected: No Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; Select Carcinogen: No Known: No; Suspected: No Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; Select Carcinogen: No Known: No; Suspected: No Proprietary acrylic copolymer Select Carcinogen: No NTP IARC Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; Known: No; Suspected: No Group 1: No; Group 2a: No; Group 2b: No; Group 3: No; Group 4: No; 8.2. Exposure controls Respiratory Eyes Skin Engineering Controls Other Work Practices If workers are exposed to concentrations above the exposure limit they must use the appropriate, certified respirators. Safety glasses with side shields Overalls which cover the body, arms and legs should be worn. Skin should not be exposed. All parts of the body should be washed after contact. Nitrile rubber gloves should be worn. Provide adequate ventilation. Where reasonably practicable this should be achieved by the use of local exhaust ventilation and good general extraction. If these are not sufficient to maintain concentrations of particulates and any vapor below occupational exposure limits suitable respiratory protection must be worn. Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove soiled clothing and wash thoroughly before reuse. See section 2 for further details. - [Prevention]: 9. Physical and chemical properties Appearance Odor Odor threshold Amber Liquid Sweet Page 5 of 10

6 ph Melting point / freezing point Initial boiling point and boiling range Flash Point Evaporation rate (Ether = 1) Flammability (solid, gas) Upper/lower flammability or explosive limits Vapor pressure (Pa) Vapor Density Specific Gravity Solubility in Water Partition coefficient n-octanol/water (Log Kow) Auto-ignition temperature Decomposition temperature Viscosity (cst) Pour Point -4 C / 25 F 120 C / 248 F Not Applicable Lower Explosive Limit: Upper Explosive Limit: 0.91 (7.59 lbs/gal) 1,500 cst 9.2. Other information DMSO extract by IP346: Less than 3.0 wt % (mineral oil component only) 10. Stability and reactivity Reactivity Hazardous Polymerization will not occur Chemical stability Stable under recommended storage and handling conditions (see section 7). When exposed to high temperatures may produce hazardous decomposition products such as carbon monoxide, carbon dioxide, oxides of nitrogen and smoke. Keep away from oxidizing agents, strongly alkaline and strongly acid materials in order to avoid possible exothermic reactions Possibility of hazardous reactions Conditions to avoid None known Incompatible materials Strong acids and oxidizing materials Hazardous decomposition products Methacrylates (in case of thermal decomposition) 11. Toxicological information Acute toxicity Page 6 of 10

7 Product is safe for intended use based on the formulation, testing results and the long history of safe consumer use. Ingredient Oral LD50, mg/kg Skin LD50, mg/kg Inhalation Vapor LD50, mg/l/4hr Inhalation Dust/Mist LD50, mg/l/4hr Inhalation Gas LD50, ppm acrylic copolymer - (Proprietary) Distillates (petroleum), solvent refined heavy paraffinic - ( ) 5,000.00, Rat - Category: 5 5,000.00, Rabbit - Category: , Rat - Category: NA Distillates (petroleum), solvent-refined light paraffinic Baseoil - unspecified - ( ) Distillates (petroleum), solvent-dewaxed heavy paraffinic - ( ) 5,000.00, Rat - Category: 5 2,000.00, Rabbit - Category: 4 Mineral Oil = 100 %w/w approximately.nonionic surface active agent - ( ) Note: When no route specific LD50 data is for an acute toxin, the converted acute toxicity point estimate was used in the calculation of the product's ATE (Acute Toxicity Estimate). Classification Category Hazard Description Acute toxicity (oral) --- Not Applicable Acute toxicity (dermal) --- Not Applicable Acute toxicity (inhalation) --- Not Applicable Skin corrosion/irritation --- Not Applicable Serious eye damage/irritation --- Not Applicable Respiratory sensitization --- Not Applicable Skin sensitization --- Not Applicable Germ cell mutagenicity --- Not Applicable Carcinogenicity --- Not Applicable Reproductive toxicity --- Not Applicable STOT-single exposure --- Not Applicable STOT-repeated exposure --- Not Applicable Aspiration hazard --- Not Applicable 12. Ecological information Toxicity No additional information provided for this product. See Section 3 for chemical specific data. Aquatic Ecotoxicity Page 7 of 10

8 Ingredient 96 hr LC50 fish, mg/l 48 hr EC50 crustacea, mg/l ErC50 algae, mg/l acrylic copolymer - (Proprietary) Not Available Not Available Not Available Distillates (petroleum), solvent refined heavy paraffinic - ( ) Distillates (petroleum), solvent-refined light paraffinic Baseoil - unspecified - ( ) Distillates (petroleum), solvent-dewaxed heavy paraffinic - ( ) Mineral Oil = 100 %w/w approximately.nonionic surface active agent - ( ) Not Available Not Available Not Available Not Available Not Available Not Available 5,000.00, Oncorhynchus mykiss 1,000.00, Daphnia magna 1, (96 hr), Scenedesmus subspicatus Not Available Not Available Not Available Persistence and degradability There is no data on the preparation itself Bioaccumulative potential Mobility in soil Results of PBT and vpvb assessment This product contains no PBT/vPvB chemicals Other adverse effects. 13. Disposal considerations Waste treatment methods Do not allow into drains or water courses. Wastes and emptied containers should be disposed of in accordance with regulations made under the Control of Pollution Act and the Environmental Protection Act. Using information provided in this data sheet advice should be obtained from the Waste Regulation Authority, whether the special waste regulations apply. 14. Transport information UN number Not Applicable UN proper shipping name Not Regulated Transport hazard class(es) DOT (Domestic Surface Transportation) IMO / IMDG (Ocean Transportation) / ICAO/IATA DOT Proper Shipping Name Not Regulated Page 8 of 10 IMDG Proper Shipping Name Not Regulated DOT Hazard Class Not Applicable IMDG Hazard Class Not Applicable

9 DOT Label --- Sub Class Not Applicable UN / NA Number Not Applicable IMDG Packing Group Not Applicable DOT Packing Group Not Applicable CERCLA/DOT RQ NA gal. / NA lbs. ICAO/IATA Proper Shipping Name Not Regulated Air Class Not Applicable Packing group Not Applicable Environmental hazards IMDG Marine Pollutant: No Special precautions for user Not Applicable Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Not Applicable 15. Regulatory information Regulatory Overview WHMIS Classification US EPA Tier II Hazards The regulatory data in Section 15 is not intended to be all-inclusive, only selected regulations are represented. All ingredients of this product are listed on the TSCA (Toxic Substance Control Act) Inventory or are not required to be listed on the TSCA Inventory. Not Regulated Fire: No Sudden Release of Pressure: No Reactive: No Immediate (Acute): No Delayed (Chronic): No EPCRA 311/312 Chemicals and RQs: EPCRA 302 Extremely Hazardous : EPCRA 313 Toxic Chemicals: Proposition 65 - Carcinogens (>0.0%): Page 9 of 10

10 Proposition 65 - Developmental Toxins (>0.0%): Proposition 65 - Female Repro Toxins (>0.0%): Proposition 65 - Male Repro Toxins (>0.0%): N.J. RTK Substances (>1%) : Penn RTK Substances (>1%) : 16. Other information The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or warranty of any kind, expressed or implied, is made with respect to the information contained herein. We accept no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to our products. Customers/users of this product must comply with all applicable health and safety laws, regulations, and orders. The full text of the phrases appearing in section 3 is: This is the first version in the GHS SDS format. Listings of changes from previous versions in other formats are not applicable. The information provided on the SDS is a correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text. End of Document Page 10 of 10