UC-A Safety Data Sheet according to Federal Register / Vol. 77, No. 58 / Monday, March 26, 2012 / Rules and Regulations Date of issue: 09/01/2015

Transcription

1 Date of issue: 09/01/2015 SECTION 1: Identification 1.1. Identification Product form Product name Product code : Mixture : : 1.2. Relevant identified uses of the substance or mixture and uses advised against 1.3. Details of the supplier of the safety data sheet Protective Industrial Polymers 7875 Bliss Parkway North Ridgeville, Ohio USA-Ohio T Emergency telephone number Emergency number : Chemtrec: (Outside USA) SECTION 2: Hazard(s) identification 2.1. Classification of the substance or mixture GHS-US classification Not classified 2.2. Label elements GHS-US labelling No labelling applicable 2.3. Other hazards Other hazards not contributing to the classification 2.4. Unknown acute toxicity (GHS US) : None under normal conditions. SECTION 3: Composition/information on ingredients 3.1. Substance 3.2. Mixture Name Product identifier % GHS-US classification Castor oil (CAS No) Not classified Solvent naphtha (petroleum), light aromatic (CAS No) < 0.55 Flam. Liq. 2, H225 Resp. Sens. 1B, H334 2-n-butyl-benzo[d]isothiazol-3-one (CAS No) < 0.1 Not classified Full text of H-statements: see section 16 SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general First-aid measures after inhalation First-aid measures after skin contact First-aid measures after eye contact First-aid measures after ingestion : If you feel unwell, seek medical advice. : Remove the victim into fresh air. : Wash with plenty of soap and water. : Rinse immediately with plenty of water. : Give nothing or a little water to drink. Get medical advice/attention if you feel unwell Most important symptoms and effects, both acute and delayed Symptoms/injuries : Skin rash/inflammation. Symptoms/injuries after inhalation : Irritation of respiratory tract. Symptoms/injuries after skin contact : Causes skin irritation. 01/20/2016 EN (English) Page 1

2 Symptoms/injuries after eye contact Symptoms/injuries after ingestion : Causes eye irritation. : Irritation of the gastric/intestinal mucosa Indication of any immediate medical attention and special treatment needed Treat symptomatically. SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media : Alcohol resistant foam, water, water fog, CO2, dry chemical, dry sand, limestone powder Special hazards arising from the substance or mixture Fire hazard on direct fire hazard Advice for firefighters Firefighting instructions : Eliminate all ignition sources if safe to do so. Exercise caution when fighting any chemical fire. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures General measures For non-emergency personnel For emergency responders 6.2. Environmental precautions Avoid release to the environment Methods and material for containment and cleaning up For containment Methods for cleaning up 6.4. Reference to other sections SECTION 7: Handling and storage 7.1. Precautions for safe handling : Absorb spillage to prevent material damage. Evacuate area. : Collect spillage. Dam up the liquid spill Conditions for safe storage, including any incompatibilities SECTION 8: Exposure controls/personal protection 8.1. Control parameters Solvent naphtha (petroleum), light aromatic ( ) : Absorb spillage to prevent material damage. Cover the solid spill with dry sand/earth/vermiculite soda ash or powdered limestone Exposure controls SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Liquid Colour : brown 01/20/2016 EN (English) 2/6

3 Odour Odour threshold ph : 7.7 Melting point Freezing point : 98 C Boiling point Flash point Relative evaporation rate (butylacetate=1) Flammability (solid, gas) Explosive limits Explosive properties Oxidising properties Vapour pressure Relative density Relative vapour density at 20 C : slight musty smell Solubility : Water: Solubility in water of component(s) of the mixture : 2-n-butyl-benzo[d]isothiazol-3-one: < g/100ml Solvent naphtha (petroleum), light aromatic: < 0.01 g/100ml Castor oil: insoluble Log Pow Auto-ignition temperature Decomposition temperature Viscosity Viscosity, kinematic Viscosity, dynamic 9.2. Other information SECTION 10: Stability and reactivity Reactivity Chemical stability Stable under normal conditions Possibility of hazardous reactions Will not occur Conditions to avoid Incompatible materials Strong acids, strong bases and oxidation agents Hazardous decomposition products SECTION 11: Toxicological information Information on toxicological effects Acute toxicity LD50 oral rat LD50 dermal rat > 2000 mg/kg (Rat) > 2000 mg/kg (Rat) Skin corrosion/irritation Serious eye damage/irritation. ph: 7.7 ph: /20/2016 EN (English) 3/6

4 Respiratory or skin sensitisation Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity (single exposure) Specific target organ toxicity (repeated exposure) Aspiration hazard Symptoms/injuries after inhalation Symptoms/injuries after skin contact Symptoms/injuries after eye contact Symptoms/injuries after ingestion SECTION 12: Ecological information Toxicity Ecology - general : Irritation of respiratory tract. : Causes skin irritation. : Causes eye irritation. : Irritation of the gastric/intestinal mucosa. due to lack of data. LC50 fish mg/l (LC50; 96 h; Salmo gairdneri) EC50 Daphnia mg/l (EC50; 48 h) LC50 fish 1 > 1000 ppm (LC50; 96 h) Persistence and degradability Persistence and degradability Persistence and degradability Biochemical oxygen demand (BOD) Chemical oxygen demand (COD) BOD (% of ThOD) Persistence and degradability Not established. Not readily biodegradable in water. 0 g O₂/g substance 2.6 g O₂/g substance 0 (28 days) Readily biodegradable in water. No (test)data on mobility of the substance available Bioaccumulative potential Bioaccumulative potential Not established. Log Pow 2.86 Bioaccumulative potential Low potential for bioaccumulation (Log Kow < 4). Solvent naphtha (petroleum), light aromatic ( ) Log Pow Bioaccumulative potential No bioaccumulation data available Mobility in soil Ecology - soil Surface tension No Data Available N/m 01/20/2016 EN (English) 4/6

5 12.5. Other adverse effects Effect on the global warming : No known ecological damage caused by this product. SECTION 13: Disposal considerations Waste treatment methods Waste treatment methods : Contain and dispose of waste according to local regulations. Waste disposal recommendations : Dispose in a safe manner in accordance with local/national regulations. SECTION 14: Transport information Department of Transportation (DOT) In accordance with DOT Not regulated for transport TDG Transport by sea Air transport Proper Shipping Name (IATA) : Not Regulated SECTION 15: Regulatory information US Federal regulations Listed on the United States TSCA (Toxic Substances Control Act) inventory All components of this product are listed, or excluded from listing, on the United States Environmental Protection Agency Toxic Substances Control Act (TSCA) inventory except for: 2-n-butyl-benzo[d]isothiazol-3-one CAS No < 0.1% This product or mixture does not contain a toxic chemical or chemicals in excess of the applicable de minimis concentration as specified in 40 CFR (a) subject to the reporting requirements of section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part International regulations CANADA EU-Regulations National regulations US State regulations California Proposition 65 - This product does not contain any substances known to the state of California to cause cancer, developmental and/or reproductive harm SECTION 16: Other information Other information : Disclaimer: This SDS to the best of our knowledge conforms to the requirements of OSHA 20 CFR and summarizes the health and safety hazard information and general guidance on how to safely handle the material at the date of issue. Each user must review the SDS in the context of how the product will be handled and used in the workplace. 01/20/2016 EN (English) 5/6

6 Full text of H-statements: H225 Highly flammable liquid and vapour H334 May cause allergy or asthma symptoms or breathing difficulties if inhaled NFPA health hazard NFPA fire hazard NFPA reactivity : 1 - Exposure could cause irritation but only minor residual injury even if no treatment is given. : 1 - Must be preheated before ignition can occur. : 0 - Normally stable, even under fire exposure conditions, and are not reactive with water. HMIS III Rating Health Flammability Physical : 1 Slight Hazard - Irritation or minor reversible injury possible : 1 Slight Hazard - Materials that must be preheated before ignition will occur. Includes liquids, solids and semi solids having a flash point above 200 F. (Class IIIB) : 0 Minimal Hazard - Materials that are normally stable, even under fire conditions, and will NOT react with water, polymerize, decompose, condense, or self-react. Non-Explosives. SDS US (GHS HazCom 2012) This information is based on our current knowledge and is intended to describe the product for the purposes of health, safety and environmental requirements only. It should not therefore be construed as guaranteeing any specific property of the product 01/20/2016 EN (English) 6/6