2. HAZARDS IDENTIFICATION

Transcription

1 Safety Data Sheet Issue Date: 27-Aug-2015 Revision Date: 08-Sep-2015 Version 1 1. IDENTIFICATION Product Identifier Product Name Auto Car Wash & TTW Other means of identification SDS # E-015 Recommended use of the chemical and restrictions on use Recommended Use Cleaning agent. Details of the supplier of the safety data sheet Supplier Address NOCO Distribution LLC 2440 Sheridan Drive Tonawanda, NY Emergency Telephone Number Company Phone Number Phone: Emergency Telephone (24 hr) CHEM-TEL ( ) 2. HAZARDS IDENTIFICATION Appearance According to product specification Physical State Liquid Classification Carcinogenicity Category 1A Signal Word Danger Hazard Statements May cause cancer Precautionary Statements - Prevention Obtain special instructions before use Do not handle until all safety precautions have been read and understood Use personal protective equipment as required Precautionary Statements - Response If exposed or concerned: Get medical advice/attention Precautionary Statements - Storage Store locked up Page 1 / 8

2 Precautionary Statements - Disposal Dispose of contents/container to an approved waste disposal plant Other Hazards Toxic to aquatic life with long lasting effects 3. COMPOSITION/INFORMATION ON INGREDIENTS Chemical Name CAS No Weight-% Alkyl Benzene Sulfonic Acid <1 Cocomide DEA <1 <1 **If Chemical Name/CAS No is "proprietary" and/or Weight-% is listed as a range, the specific chemical identity and/or percentage of composition has been withheld as a trade secret.** First Aid Measures 4. FIRST-AID MEASURES General Advice Eye Contact Skin Contact Inhalation Ingestion Provide this SDS to medical personnel for treatment. Rinse thoroughly with plenty of water for at least 15 minutes, lifting lower and upper eyelids. Consult a physician. Wash off immediately with plenty of water for at least 15 minutes. Remove to fresh air. Clean mouth with water and drink afterwards plenty of water. Most important symptoms and effects Symptoms. Indication of any immediate medical attention and special treatment needed Notes to Physician Treat symptomatically. 5. FIRE-FIGHTING MEASURES Suitable Extinguishing Media Use extinguishing measures that are appropriate to local circumstances and the surrounding environment. Unsuitable Extinguishing Media. Specific Hazards Arising from the Chemical. Protective equipment and precautions for firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. 6. ACCIDENTAL RELEASE MEASURES Page 2 / 8

3 Personal precautions, protective equipment and emergency procedures Personal Precautions Environmental Precautions Use personal protective equipment as required. See Section 12 for additional Ecological Information. Methods and material for containment and cleaning up Methods for Containment Methods for Clean-Up Prevent further leakage or spillage if safe to do so. Keep in suitable, closed containers for disposal. 7. HANDLING AND STORAGE Precautions for safe handling Advice on Safe Handling Handle in accordance with good industrial hygiene and safety practice. Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Use personal protective equipment as required. Conditions for safe storage, including any incompatibilities Storage Conditions Incompatible Materials Keep container tightly closed and store in a cool, dry and well-ventilated place. Store locked up. None known based on information supplied. 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Exposure Guidelines Chemical Name ACGIH TLV OSHA PEL NIOSH IDLH STEL: 1000 ppm Appropriate engineering controls TWA: 1 mg/m 3 inhalable fraction and vapor S* TWA: 1000 ppm TWA: 1900 mg/m 3 (vacated) TWA: 1000 ppm (vacated) TWA: 1900 mg/m 3 (vacated) TWA: 3 ppm (vacated) TWA: 15 mg/m 3 IDLH: 3300 ppm TWA: 1000 ppm TWA: 1900 mg/m 3 TWA: 3 ppm TWA: 15 mg/m 3 Engineering Controls Apply technical measures to comply with the occupational exposure limits. Individual protection measures, such as personal protective equipment Eye/Face Protection Skin and Body Protection Respiratory Protection Refer to 29 CFR for eye and face protection regulations. Refer to 29 CFR for appropriate skin and body protection. Refer to 29 CFR for respiratory protection requirements. General Hygiene Considerations Handle in accordance with good industrial hygiene and safety practice. 9. PHYSICAL AND CHEMICAL PROPERTIES Page 3 / 8

4 Information on basic physical and chemical properties Physical State Liquid Appearance According to product specification Odor Color Odor Threshold Property Values Remarks Method ph 9.69 Melting Point/Freezing Point Boiling Point/Boiling Range Flash Point Evaporation Rate Flammability (Solid, Gas) Liquid- Not Applicable Upper Flammability Limits Lower Flammability Limit Vapor Pressure Vapor Density Specific Gravity Water Solubility Solubility in other solvents Partition Coefficient Auto-ignition Temperature Decomposition Temperature Kinematic Viscosity Dynamic Viscosity Explosive Properties Oxidizing Properties Reactivity Not reactive under normal conditions. Chemical Stability Stable under recommended storage conditions. Possibility of Hazardous Reactions None under normal processing. Conditions to Avoid Keep out of reach of children. Incompatible Materials None known based on information supplied. Hazardous Decomposition Products None known based on information supplied. Information on likely routes of exposure Product Information 10. STABILITY AND REACTIVITY 11. TOXICOLOGICAL INFORMATION Eye Contact Skin Contact Inhalation Avoid contact with eyes. Avoid contact with skin. Do not inhale. Page 4 / 8

5 Ingestion Do not ingest. Component Information Chemical Name Oral LD50 Dermal LD50 Inhalation LC50 Alkyl Benzene Sulfonic Acid = 1219 mg/kg ( Rat ) = 7060 mg/kg ( Rat ) - = mg/l ( Rat ) 4 h Cocomide DEA = µl/kg ( Rat ) = 620 µl/kg ( Rat ) = 0.62 ml/kg ( Rat ) = 7640 µl/kg ( Rabbit ) - Information on physical, chemical and toxicological effects Symptoms Please see section 4 of this SDS for symptoms. Delayed and immediate effects as well as chronic effects from short and long-term exposure Carcinogenicity The table below indicates whether each agency has listed any ingredient as a carcinogen. However, the product as a whole has not been tested. Ethanol has been shown to be carcinogenic in long-term studies only when consumed as an alcoholic beverage. Chemical Name ACGIH IARC NTP OSHA A3 Group 1 Known X Cocomide DEA Group 2B X A3 Group 2B X Legend ACGIH (American Conference of Governmental Industrial Hygienists) A3 - Animal Carcinogen IARC (International Agency for Research on Cancer) Group 1 - Carcinogenic to Humans Group 2B - Possibly Carcinogenic to Humans NTP (National Toxicology Program) Known - Known Carcinogen OSHA (Occupational Safety and Health Administration of the US Department of Labor) X - Present Numerical measures of toxicity Ecotoxicity Toxic to aquatic life with long lasting effects. Component Information 12. ECOLOGICAL INFORMATION Chemical Name Algae/aquatic plants Fish Toxicity to microorganisms Alkyl Benzene Sulfonic Acid 36: 72 h Desmodesmus 5.6: 96 h Cyprinus carpio subspicatus mg/l EC50 mg/l LC50 flow-through Cocomide DEA 3.6: 96 h Brachydanio rerio mg/l LC50 semi-static Crustacea 5.2: 48 h Daphnia magna mg/l EC50 4.2: 24 h Daphnia magna mg/l EC50 Page 5 / 8

6 EC50 = mg/l 30 min EC50 = mg/l 5 min Persistence/Degradability. Bioaccumulation. Mobility 7.8: 72 h Desmodesmus subspicatus mg/l EC : 96 h Pseudokirchneriella subcapitata mg/l EC : 96 h Oncorhynchus mykiss ml/l LC50 static : 96 h Pimephales promelas mg/l LC50 flow-through 100: 96 h Pimephales promelas mg/l LC50 static : 96 h Pimephales promelas mg/l LC50 flow-through : 96 h Pimephales promelas mg/l LC50 static : 96 h Lepomis macrochirus mg/l LC50 static EC50 = 73 mg/l 5 min EC50 > 16 mg/l 16 h : 48 h Daphnia magna mg/l LC50 2: 48 h Daphnia magna mg/l EC50 Static 10800: 24 h Daphnia magna mg/l EC50 55: 48 h Daphnia magna mg/l EC50 Chemical Name Alkyl Benzene Sulfonic Acid Partition Coefficient Other Adverse Effects 13. DISPOSAL CONSIDERATIONS Waste Treatment Methods Disposal of Wastes Contaminated Packaging Disposal should be in accordance with applicable regional, national and local laws and regulations. Disposal should be in accordance with applicable regional, national and local laws and regulations. California Hazardous Waste Status Chemical Name California Hazardous Waste Status Toxic Ignitable 14. TRANSPORT INFORMATION Note DOT IATA IMDG Marine Pollutant Please see current shipping paper for most up to date shipping information, including exemptions and special circumstances. Not regulated Not regulated This material may meet the definition of a marine pollutant Page 6 / 8

7 International Inventories 15. REGULATORY INFORMATION Chemical Name TSCA DSL NDSL EINECS ELINCS ENCS IECSC KECL PICCS AICS Alkyl Benzene Sulfonic Acid Present X Present X Present X X Present X Present Present X Present X X Cocomide DEA Present X Present Present X Present X X Present X Present Present X Present X X Legend: TSCA - United States Toxic Substances Control Act Section 8(b) Inventory DSL/NDSL - Canadian Domestic Substances List/Non-Domestic Substances List EINECS/ELINCS - European Inventory of Existing Chemical Substances/European List of Notified Chemical Substances ENCS - Japan Existing and New Chemical Substances IECSC - China Inventory of Existing Chemical Substances KECL - Korean Existing and Evaluated Chemical Substances PICCS - Philippines Inventory of Chemicals and Chemical Substances AICS - Australian Inventory of Chemical Substances US Federal Regulations CERCLA This material, as supplied, contains one or more substances regulated as a hazardous substance under the Comprehensive Environmental Response Compensation and Liability Act (CERCLA) (40 CFR 302) Chemical Name Hazardous Substances RQs CERCLA/SARA RQ Reportable Quantity (RQ) SARA lb RQ 100 lb final RQ RQ 45.4 kg final RQ CWA (Clean Water Act) This product contains the following substances which are regulated pollutants pursuant to the Clean Water Act (40 CFR and 40 CFR ) US State Regulations California Proposition 65 This product contains the following Proposition 65 chemicals. Chemical Name California Proposition 65 - Carcinogen Developmental Cocomide DEA Carcinogen - Carcinogen U.S. State Right-to-Know Regulations Chemical Name New Jersey Massachusetts Pennsylvania X X X X X X Page 7 / 8

8 16. OTHER INFORMATION NFPA HMIS Health Hazards Health Hazards Flammability Flammability Instability Physical Hazards Special Hazards Personal Protection Issue Date: Revision Date: Revision Note: 27-Aug Sep-2015 New format Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. End of Safety Data Sheet Page 8 / 8