DOAS CONSTRUCTION BR SERIES CA SERIES INTEGRAL ENERGY RECOVERY PA SERIES EV SERIES SUPPLY & EXHAUST RD SERIES CONTROLS OPTIONS & ACCESSORIES

Transcription

1 O A S F E AT U R E S A N D O P T I O N ww Indoor and otdoor models ww 2 0-gage galvanized steel for inner and oter ww D oble-wall, foamin-place panels ww 1 " or 2" doble-wall constrction ww 1" R6.5 foam inslation for 1" doble-wall nits ww 2" thermally broken R13 inslation for 2" doblewall nits ww S tainless steel doblesloped drain pan ww 0% Cross-contamination ww No freeze concerns ww No condensate concerns ww No microbial growth ww Can handle higher ESP ww N eoprene or spring ww F an control via factoryinstalled R esidential and light commercial for-dct design 500-4,400 CFM Stackable to 20,000 CFM Applied modlar panels 1,500-nlimited CFM CFM ww F actory-preprogrammed seqence of operations ww Optional remote interface ww Airflow monitoring C ommercial packaged soltions ,950 CFM LE SERIES Commercial large capacity 1,500-11,000 ww Optional modlating air systems CFM 500-4,250 CFM OPTIONS & ACCESSORIES C ommercial Dedicated otdoor Otdoor Air System (DOAS) HE SERIES ww Hot water coil ww Steam coil ww Heat pmp DOAS dedicated ww Split DX coil, chilled water coil, heat pmp ww Spacing between DX and modlar cabinets RD SERIES ww E lectric heat with ww Indirect gas-fired frnace with electronic modlation A pplied PA SERIES EV SERIES ww Energy-efficient, directdrive, backward-crved plenm fans ww Premim highefficiency motors CFM ww F actory-monted, wired ww N ight-setback and recirclation-mode controls CA SERIES two-dct design ww RenewAire s Enthalpic ww H igh sensible and latent ww Low pressre drop BR SERIES R esidential ECM motors Variable freqency drives Motorized isolation dampers Combo crbs Bypass economizers Electric dct heaters I ndirect gas-fired dct frnaces Filter alarms I ntegrated programmable controls ww 2 " MERV 8 / 13 / 14 filters, ww AMCA Class I low-leakage actator ww Internal enthalpy-based modlating bypass that will allow fll economizer bypass of ERV spply air F O R C E R T I F I C AT I O N D E TA I L S, S E E U N I T S U B M I T TA L S O N R E N E WA I R E. C O M R ENE WA I R E E V E RY WHE RE E V E R Y G E O G R A P H Y, E V E R Y C L I M A T E, E V E R Y H O M E, E V E R Y B U I L D I N G A N D E V E R Y A P P L I C A T I O N CONDITION OUTDOOR AIR E F F I C I E N T LY A N D S U S T A I N A B LY

2 DOAS WITH ENERGY RECOVERY RenewAire s DOAS EFFECTIVELY CONDITIONS OUTDOOR AIR with efficient and sstainable technology. By enabling HVAC UNITS TO OPERATE INDEPENDENTLY, depending on bilding load, or DOAS nit with fixedplate, innovative cooling and heating featres and hot-gas reheat will optimize yor ventilation strategy, downsize eqipment, decrease capital costs and realize significant operating savings. DOUBLE-WALL, FOAM-IN-PLACE PANELS INTEGRATED PROGRAMMABLE DIRECT-DRIVE FANS WITH EC MOTORS ENERGY RECOVERY CORE LOW-LEAKAGE ISOLATION DAMPERS HEATING SECTION ELECTRIC, GAS OR HOT WATER/STEAM COIL HOT-GAS REHEAT COOLING COIL INTERNAL MODULATING BYPASS ECONOMIZER AND DEFROST RECIRCULATION DAMPER (BEHIND CORE) FILTRATION KEY BENEFITS Enhanced IAQ Improved hmidity control Simplified ventilation design Decreased ventilation operation Redced energy consmption Downsized HVAC eqipment Increased system flexibility and control and installation costs

3 FEATURES EXHAUST FAN SUPPLY FAN CABINET UNIT COOLING/ OTHER HEATING SMALL MEDIUM LARGE Airflow Range 375-1,650 CFM 750-3,300 CFM 1,125-4,950 CFM Installation Location Indoor / Otdoor Airflow Orientation Vertical / Horizontal Available Voltages V 1P (EC small only) / 3P (all); 460V 3P (all); 575V (VFD only) Unit Disconnect Energy Recovery Enthalpic fixed plate Internal Bypass of Energy Recovery, modlating bypass sing face and bypass dampers Wall Constrction 1" or 2" doble-wall, foam-in-place panels Inslation 1" R / 2" R Panels with Thermal Break, all 2" doble-wall nits Painted Cabinets (optional) Salt Spray Rated Paint (optional) Spply Blower High-efficiency plenm fans Spply Fan Type Direct-drive Spply Fan Speed Control Spply Fan Vibration Isolation Neoprene / spring (VFD only) Spply Fan Motor HP (kw) V 1P 1.35 kw N / A N / A V 3P 2.70 kw 2.70 kw 2.70 kw x V 3P 3.70 kw 3.70 kw 3.70 kw x2 VFD 3 HP 5 HP 5 HP x2 Spply Fan ESP 2" WC at 1,500 CFM 2.5" WC at 3,000 CFM 3" WC at 4,500 CFM Exhast Blower High-efficiency plenm fans Exhast Fan Type Direct-drive Neoprene / spring (VFD only) V 1P 1.35 kw N / A N / A V 3P 2.70 kw 2.70 kw 2.70 kw x V 3P 3.70 kw 3.70 kw 3.70 kw x2 VFD 3 HP 5 HP 5 HP x2 Exhast Fan ESP 2" WC at 1,500 CFM 2.5" WC at 3,000 CFM 3.0" WC at 4,500 CFM Cooling Coil Direct expansion, chilled water, heat pmp (optional) Heating Section Electric heat, indirect gas frnace, hot water, heat pmp, steam (optional) Hot Gas Reheat, modlating (optional) Defrost Capability, modlating, RenewAire s Premim Integrated Programmable Controls Control Hardware Carel c.pco Mini BACnet MS / TP or IP, Modbs RTU, IP Airflow Monitoring Recirclation Mode Exhast Fan Speed Control Exhast Fan Vibration Isolation Exhast Fan Motor HP (kw) Microprocessor Controller Optional Commnications GFCI Convenience Otlet Filtration MERV 8 / 13 / 14 Isolation Dampers AMCA Class I dampers

4 O A S F E AT U R E S A N D O P T I O N ww Indoor and otdoor models ww 2 0-gage galvanized steel for inner and oter ww D oble-wall, foamin-place panels ww 1 " or 2" doble-wall constrction ww 1" R6.5 foam inslation for 1" doble-wall nits ww 2" thermally broken R13 inslation for 2" doblewall nits ww S tainless steel doblesloped drain pan ww 0% Cross-contamination ww No freeze concerns ww No condensate concerns ww No microbial growth ww Can handle higher ESP ww N eoprene or spring ww F an control via factoryinstalled R esidential and light commercial for-dct design 500-4,400 CFM Stackable to 20,000 CFM Applied modlar panels 1,500-nlimited CFM CFM ww F actory-preprogrammed seqence of operations ww Optional remote interface ww Airflow monitoring C ommercial packaged soltions ,950 CFM LE SERIES Commercial large capacity 1,500-11,000 ww Optional modlating air systems CFM 500-4,250 CFM OPTIONS & ACCESSORIES C ommercial Dedicated otdoor Otdoor Air System (DOAS) HE SERIES ww Hot water coil ww Steam coil ww Heat pmp DOAS dedicated ww Split DX coil, chilled water coil, heat pmp ww Spacing between DX and modlar cabinets RD SERIES ww E lectric heat with ww Indirect gas-fired frnace with electronic modlation A pplied PA SERIES EV SERIES ww Energy-efficient, directdrive, backward-crved plenm fans ww Premim highefficiency motors CFM ww F actory-monted, wired ww N ight-setback and recirclation-mode controls CA SERIES two-dct design ww RenewAire s Enthalpic ww H igh sensible and latent ww Low pressre drop BR SERIES R esidential ECM motors Variable freqency drives Motorized isolation dampers Combo crbs Bypass economizers Electric dct heaters I ndirect gas-fired dct frnaces Filter alarms I ntegrated programmable controls ww 2 " MERV 8 / 13 / 14 filters, ww AMCA Class I low-leakage actator ww Internal enthalpy-based modlating bypass that will allow fll economizer bypass of ERV spply air F O R C E R T I F I C AT I O N D E TA I L S, S E E U N I T S U B M I T TA L S O N R E N E WA I R E. C O M R ENE WA I R E E V E RY WHE RE E V E R Y G E O G R A P H Y, E V E R Y C L I M A T E, E V E R Y H O M E, E V E R Y B U I L D I N G A N D E V E R Y A P P L I C A T I O N CONDITION OUTDOOR AIR E F F I C I E N T LY A N D S U S T A I N A B LY

5 OAS FEATURES AND OPTIONS w Indoor and otdoor models w 20-gage galvanized steel for inner and oter w Doble-wall, foamin-place panels w 1" or 2" doble-wall constrction w 1" R6.5 foam inslation for 1" doble-wall nits w 2" thermally broken R13 inslation for 2" doblewall nits w Stainless steel doblesloped drain pan w RenewAire s Enthalpic w 0% Cross-contamination w High sensible and latent w No freeze concerns w No condensate concerns w Low pressre drop w No microbial growth w Can handle higher ESP w Neoprene or spring w Fan control via factoryinstalled w Factory-monted, wired w Night-setback and recirclation-mode controls w Split DX coil, chilled water coil, heat pmp w Electric heat with w Indirect gas-fired frnace with electronic modlation w Spacing between DX and w Energy-efficient, directdrive, backward-crved plenm fans w Premim highefficiency motors w Factory-preprogrammed seqence of operations w Optional remote interface w Airflow monitoring w Hot water coil w Steam coil w Heat pmp w Optional modlating w 2" MERV 8 / 13 / 14 filters, w Internal enthalpy-based modlating bypass that will w AMCA Class I low-leakage allow fll economizer bypass of ERV spply air actator