Revision Number: Issue date: 03/14/ PRODUCT AND COMPANY IDENTIFICATION 2. HAZARDS IDENTIFICATION

Transcription

1 Safety Data Sheet Revision Number: Issue date: 03/14/ PRODUCT AND COMPANY IDENTIFICATION Product name: BONDERITE C-AK 412 ALKALINE IDH number: CLEANER known as RIDOLINE 412 Product type: Alkaline Cleaner for Industrial Application Restriction of Use: None identified Region: United States Company address: Contact information: Henkel Corporation One Henkel Way Rocky Hill, Connecticut Telephone: +1 (860) MEDICAL EMERGENCY Phone: Poison Control Center (toll free) or TRANSPORT EMERGENCY Phone: CHEMTREC (toll free) or Internet: 2. HAZARDS IDENTIFICATION DANGER: EMERGENCY OVERVIEW CAUSES SEVERE SKIN BURNS AND EYE DAMAGE. SUSPECTED OF DAMAGING FERTILITY OR THE UNBORN CHILD. HAZARD CLASS HAZARD CATEGORY SKIN CORROSION 1C SERIOUS EYE DAMAGE 1 REPRODUCTIVE TOXICITY 2 PICTOGRAM(S) Precautionary Statements Prevention: Response: Storage: Disposal: Obtain special instructions before use. Do not handle until all safety precautions have been read and understood. Wash affected area thoroughly after handling. Wear protective gloves, clothing, eye and face protection. IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately all contaminated clothing. IF INHALED: Remove victim to fresh air and keep at rest in a position comfortable for breathing. Immediately call a POISON CENTER or physician. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. IF exposed or concerned: Get medical attention. Wash contaminated clothing before reuse. Store locked up. Dispose of contents and/or container according to Federal, State/Provincial and local governmental regulations. Classification complies with OSHA Hazard Communication Standard (29 CFR ) and is consistent with the provisions of the United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Page 1 of 6

2 Hazardous Component(s) CAS Number Percentage* Dipropylene glycol monomethyl ether Borax Tripotassium orthophosphate Nonylphenol, branched Potassium hydroxide * Exact percentages may vary or are trade secret. Concentration range is provided to assist users in providing appropriate protections. 4. FIRST AID MEASURES Inhalation: Skin contact: If mist or vapor of this product is inhaled, remove person immediately to fresh air. Seek medical attention if symptoms develop or persist. Remove contaminated clothing and footwear. For skin contact, flush with large amounts of water. Seek immediate medical attention. Eye contact: In case of contact with the eyes, rinse immediately with plenty of water for 15 minutes, and seek immediate medical attention. Ingestion: DO NOT induce vomiting unless directed to do so by medical personnel. Symptoms: See Section 11. Notes to physician: Treat symptomatically and supportively. 5. FIRE FIGHTING MEASURES Extinguishing media: Special firefighting procedures: Unusual fire or explosion hazards: Hazardous combustion products: Use media appropriate for surrounding material. Wear self-contained breathing apparatus. Wear full protective clothing. This product is an aqueous mixture which will not burn. Irritating and toxic gases or fumes may be released during a fire. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Clean-up methods: Prevent further leakage or spillage if safe to do so. Wear appropriate personal protective equipment. Absorb spill with inert material. Shovel material into appropriate container for disposal. Dispose of according to Federal, State and local governmental regulations. 7. HANDLING AND STORAGE Handling: Storage: Avoid contact with eyes, skin and clothing. Wash thoroughly after handling. Avoid breathing mists or aerosols of this product. For industrial use only. For safe storage, store between 40 F (4.4 C) and 100 F (37.8 C) Keep container tightly closed and in a cool, well-ventilated place away from incompatible materials. Thaw and mix thoroughly if frozen. For information on product shelf life, please review labels on container or check the Technical Data Sheet. Page 2 of 6

3 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER Dipropylene glycol monomethyl ether Borax 150 ppm STEL (SKIN) 100 ppm TWA 2 mg/m3 TWA Inhalable fraction. 6 mg/m3 STEL Inhalable fraction. (SKIN) 100 ppm (600 mg/m3) PEL None None None None None Tripotassium orthophosphate None None None None 4-Nonylphenol, branched None None None None Potassium hydroxide 2 mg/m3 Ceiling None None None Engineering controls: Respiratory protection: Eye/face protection: Skin protection: Provide local and general exhaust ventilation to effectively remove and prevent buildup of any vapors or mists generated from the handling of this product. If ventilation is not sufficient to effectively prevent buildup of aerosols, mists or vapors, appropriate NIOSH/MSHA respiratory protection must be provided. Wear chemical goggles; face shield (if splashing is possible). Chemical resistant, impermeable gloves. Gloves should be tested to determine suitability for prolonged contact. Use of impervious apron and boots are recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Liquid Color: Colorless Odor: Mild Odor threshold: Not available. ph: > 11 Vapor pressure: Boiling point/range: > 100 C (> 212 F)calculated Melting point/ range: Specific gravity: at 16 C (60.8 F) Vapor density: Flash point: Flammable/Explosive limits - lower: Flammable/Explosive limits - upper: Autoignition temperature: Flammability: Evaporation rate: Solubility in water: Complete Partition coefficient (n-octanol/water): VOC content: 7.0 % Viscosity: Not available. Decomposition temperature: Not available. Page 3 of 6

4 10. STABILITY AND REACTIVITY Stability: Hazardous reactions: Hazardous decomposition products: Incompatible materials: Reactivity: Conditions to avoid: Stable at normal conditions. Will not occur. None expected. Acids. This product reacts with acids. Store away from incompatible materials. 11. TOXICOLOGICAL INFORMATION Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion Potential Health Effects/Symptoms Inhalation: Skin contact: Eye contact: Ingestion: Mists, vapors or liquid may cause severe irritation or burns. Excessive inhalation of this material causes headache, dizziness, nausea and incoordination. May cause severe skin irritation. Possible burns to skin. This product is severely irritating to the eyes and may cause eye burns. Causes serious eye damage. This product may produce corrosive damage to the gastrointestinal tract if it is swallowed. Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects Oral LD50 (Rat) = 5.35 g/kg Dipropylene glycol monomethyl ether Irritant Dermal LD50 (Rabbit) = 9.5 g/kg Oral LD50 (Rat) = 2,660 mg/kg Irritant, Skin, Less weight gain and food Borax Dermal LD50 (Rabbit) = > 1,055 mg/kg intake. Inhalation LC50 (Rat, 4 h) = > mg/l Tripotassium orthophosphate None Irritant 4-Nonylphenol, branched None No Target Organs Oral LD50 (Rat) = 273 mg/kg Potassium hydroxide Corrosive, Irritant Oral LD50 (Rat) = 1.23 g/kg Hazardous Component(s) NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) Dipropylene glycol monomethyl ether No No No Borax No No No Tripotassium orthophosphate No No No 4-Nonylphenol, branched No No No Potassium hydroxide No No No 12. ECOLOGICAL INFORMATION Ecological information: No data available. Page 4 of 6

5 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Hazardous waste number: Follow all local, state, federal and provincial regulations for disposal. Wastes must be tested using methods described in 40 CFR Part 261 to determine if it meets applicable definitions of hazardous wastes. 14. TRANSPORT INFORMATION The transport information provided in this section only applies to the material/formulation itself, and is not specific to any package/configuration. U.S. Department of Transportation Ground (49 CFR) Proper shipping name: Corrosive liquid, basic, inorganic, n.o.s. (Potassium hydroxide, Tetrapotassium pyrophosphate) Hazard class or division: 8 Identification number: UN 3266 Packing group: III International Air Transportation (ICAO/IATA) Proper shipping name: Corrosive liquid, basic, inorganic, n.o.s. (Potassium hydroxide, Tetrapotassium pyrophosphate) Hazard class or division: 8 Identification number: UN 3266 Packing group: III Water Transportation (IMO/IMDG) Proper shipping name: CORROSIVE LIQUID, BASIC, INORGANIC, N.O.S. (Potassium hydroxide, Tetrapotassium pyrophosphate) Hazard class or division: 8 Identification number: UN 3266 Packing group: III United States Regulatory Information 15. REGULATORY INFORMATION TSCA 8 (b) Inventory Status: TSCA 12 (b) Export Notification: CERCLA/SARA Section 302 EHS: CERCLA/SARA Section 311/312: CERCLA/SARA Section 313: California Proposition 65: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. None above reporting de minimis None above reporting de minimis. Immediate Health, Delayed Health None above reporting de minimis. This product contains a chemical known in the State of California to cause cancer. This product contains a chemical known to the State of California to cause birth defects or other reproductive harm. Canada Regulatory Information CEPA DSL/NDSL Status: Contains one or more components listed on the Non-Domestic Substances List. All other components are listed on or are exempt from listing on the Domestic Substances List. Components listed on the NDSL must be tracked by all Canadian Importers of Record as required by Environment Canada. They may be imported into Canada in limited quantities. Please contact Regulatory Affairs for additional details. 16. OTHER INFORMATION This safety data sheet contains changes from the previous version in sections: New Safety Data Sheet format. Page 5 of 6

6 Prepared by: Regulatory Affairs Issue date: 03/14/2018 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its affiliates ( Henkel ) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user s responsibility to determine the suitability of Henkel s products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any Henkel s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel s products. Henkel further disclaims any liability for consequential or incidental damages of any kind, including lost profits. Page 6 of 6